2005 Toyota Tacoma Engine Problems

In May of 2018, I purchased a 2005 Toyota Tacoma. After arrival of new title, I received a safety recall notice from Toyota in regards to possible abnormal frame rust. I was instructed to take my Tacoma to nearest Toyota dealership for frame inspection. Prior to taking Tacoma in for frame inspection, I scoped the frame myself, and noticed abnormal rust forming throughout both sides of the frame. Therefore, I took my Tacoma to Berge Toyota in Mesa AZ. for further inspection and to have some other repairs done. Upon my arrival to Berge Toyota, l informed the service writer of the repairs that were needed done and showed him the request from Toyota for the frame inspection. My vehicle was taken to a lift, where a brief frame inspection was performed with a flashlight only and I was told the frame was fine, and the rust I had witnessed during my personal inspection was within a standard tolerance of "normal". On September 12, 2022 my frame cracked in a horseshoe formation around the driver side motor mount, causing the engine to shift and sink approx. 3/4" towards the driver side. This frame failure has caused numerous problems to occur, such as the fan to continuously rub against the shroud, abnormal shifting of the transmission, ramping up and down of RPM's, vehicle's steering locks up and cannot be safely driven, leaving me without transportation After detailed inspection was performed on my Tacoma, the horseshoe crack around the motor mount was found and it was determined this was the source of all the problems. I contacted Berge Toyota where I was informed by their service manager that Berge Toyota was not certified to do the frame inspection or repair, and further explained the safety recall had expired and instructed me to contact Toyota to see what could be done. The question I had for the Berge Toyota service manager, was if they were not certified to do the frame inspection, or repair why did they inspect my frame and inform me it was fine, when it wasn't?

NHTSA ID

11490424

Incident

Sep 12, 2022

The frame of my truck failed at the motor mount. The motor mount has sunk into the frame shifting the motor and effecting performance and other parts. This can be confirmed by anyone. I never received recall information, I can’t find evidence of one issued for this year or my state.

NHTSA ID

11440418

Incident

Nov 7, 2021

The frame caved in to the motor mounts. The motor mounts on the drive side are intact however the frame has broken and the motor mount has fallen into the frame.

NHTSA ID

11439984

Incident

Nov 10, 2021

THE HEAD GASKET HAS CAUSED COOLANT TO LEAK INTO THE CYLINDER. ACCORDING TO MANY OTHER OWNERS THIS IS A COMMON PROBLEM WITH THE 2005 AND 2006 TOYOTA TACOMA 4.0L V6 ENGINES AND THE HEAD GASKET WAS FINALLY REVISED IN 2007

NHTSA ID

11321755

Incident

Apr 1, 2020

Mileage

155,000 mi

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS A STRONG VIBRATION COMING FROM THE VEHICLE, THE SERVICE ENGINE INDICATOR ILLUMINATED, AND THE U-JOINTS HAD NOT BEEN PROPERLY LUBRICATED FROM THE MANUFACTURING PROCESS. THE DEALER (LEGACY TOYOTA, 3800 W TENNESSEE ST, TALLAHASSEE, FL 32304, (850) 688-9264) DIAGNOSED THAT THE TIRES WERE THE CAUSE OF THE FAILURES. THE DEALER DID NOT REPLACE THE DRIVETRAIN AND THE U-JOINTS. THE CONTACT CONSTANTLY HAD TO LUBE THE U-JOINTS TO PREVENT DRYNESS, WHICH WOULD HAVE CAUSED THE DRIVETRAIN TO FRACTURE. THE CONTACT, A MECHANIC, REPLACED THE U-JOINTS AND TOOK THE DRIVESHAFT TO THE DEALER TO INSPECT THE PART, BUT NO REMEDY WAS PROVIDED. THE MANUFACTURER ISSUED A SERVICE CAMPAIGN AND INDICATED THAT THE VEHICLE WAS EXCLUDED; THEREFORE, THE DEALER REFUSED TO REPLACE THE U-JOINTS AND THE DRIVESHAFT. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER FOR FURTHER DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11101115

Incident

May 1, 2015

FRAME CRACKED AT THE MOTOR MOUNT WELDS, SPECIFICALLY THE DRIVERS (RIGHT) SIDE MOTOR MOUNT. CAUSES THE MOTOR TO DROP DOWN LEADING TO A SERIOUS, AND DANGEROUS CONDITION OF HAVING THE MOTOR FALL OUT. THIS PROBLEM IS MOST NOTICEABLE DURING DRIVING CONDITIONS.

NHTSA ID

11093972

Incident

May 1, 2018

Mileage

160,000 mi

I HAVE HAD THE REAR END ON MY VEHICLE REPLACED 2X. NO HARD DRIVING. NO SIGNS OF ABUSE OR REGULAR WEAR BUT HAS COST ME OVER 2200 EACH TIME. THE HEAD GASKET HAVE NOW FAILED AND IN READING MANY ONLINE SITES THIS IS A COMMON PROBLEM. MY VEHICLE HAS BEEN SERVICED AND NEVER OVER HEATED. THIS JOB IS NOW GOING TO COST ME 2500. IT STARTED A GURGLING NOISE IN THE DASH AND GOT WARM ONE DAY. THE ENGINE THEN THREW A MISFIRE IN CYLINDER 4 A PRESSURE CHECK CONFIRMED THE HEAD GASKET. THE REAR END IS A CONCERN ALONG WITH THE HEAD GASKETS.

NHTSA ID

11081730

Incident

Mar 1, 2018

Mileage

200,000 mi

DRIVING DOWN THE ROAD AND HEAD GASKET APPARENTLY BLOWN AFTER OWNING FOR THREE MONTHS. NO WARNING JUST BLEW. 30 MILES AWAY FROM HIGHWAY AND NO CELL SERVICE.

NHTSA ID

11052644

Incident

Nov 30, 2017

Mileage

175,000 mi

MY FATHER HAS AN '05 TACOMA SR5 V6 WITH THE TRD OFF-ROAD PACKAGE. HIS TRUCK IS A 6-SPEED MANUAL. WHEN PRESSING THE GAS PEDAL 1/2 WAY, THE ENGINE RESPONDS WITH A SEMI-VIOLENT JERK, AND THEN GOES. THIS SCARES ME, AS I COULDN'T EVEN IMAGINE MY FATHER GOING FULLY DOWN ON THE PEDAL. THIS IS VERY UNSAFE. PLEASE FIX THIS TOYOTA. *TR

NHTSA ID

10704875

Incident

Feb 27, 2015

Mileage

140,500 mi

THE CATALYTIC CONVERTER SHIELD ON MY 2005 TACOMA FELL OFF WHILE DRIVING AND ALMOST CAUSED AN ACCIDENT. AFTER PICKING UP THE LARGE METAL PARTS AND INSPECTING UNDER THE VEHICLE, I NOTICED THAT NEAR TO WHERE THE CATALYTIC CONVERTER SITS, THAT THERE WAS EXTENSIVE CORROSION ON THE TRUCK'S FRAME AND EVEN A LARGE HOLE. I AM EXTREMELY WORRIED ABOUT THE SAFETY OF THE VEHICLE AND AM AFRAID THAT THE FRAME MAY CRUMPLE WHILE DRIVING CAUSING AN ACCIDENT OR DEATH. TOYOTA IS AWARE OF THE ISSUE. I CONTACTED THE CORPORATE OFFICES, BUT WAS TOLD THAT TOYOTA IS ONLY REPLACING THE FRAME ON VEHICLES REGISTERED IN WHAT THEY HAVE DESIGNATED AS A "SNOW STATE". I PURCHASED MY TOYOTA AT A DEALERSHIP IN ILLINOIS (A "SNOW STATE") AND HAVE DONE A LOT OF TRAVELING WITHIN THE "SNOW STATES", YET BECAUSE I LIVE 25 MILES AWAY ON THE MISSOURI SIDE, TOYOTA IS REFUSING TO COVER THE REPAIR. THE WOMAN FROM TOYOTA CORPORATE DID NOT SEEM TO CARE WHEN I TOLD HER THAT I WAS WORRIED ABOUT THE SAFETY OF THE VEHICLE AND THAT IT COULD RESULT IN AN ACCIDENT OR DEATH. I OFFERED TO EMAIL THE PHOTOS OF THE FRAME CORROSION, BUT WAS REJECTED. TOYOTA NEEDS TO COVER THIS REPAIR ON ALL VEHICLES WITH FRAME CORROSION REGARDLESS OF THE STATE THEY LIVE IN. *TR

NHTSA ID

10662411

Incident

Oct 15, 2014

Mileage

160,000 mi

FOR MY INFORMATION I WOULD LIKE TO KNOW IF WHAT I WAS READING IN THE INTERNET ABOUT MY TRUCK IS REAL. SO THIS IS MY QUESTION, I OWNED A 2005 TOYOTA TACOMA WITH A 4.0 V6 ENGINE THAT IS MAKING A KNOCKING SOUND WITH 60,186 MILES ON THE ENGINE. WHAT I FOUND IS THAT THOSE ENGINES IS, THAT THEY HAVE PROBLEMS WITH THE # 1AND 2 CYLINDERS AND WILL CREATE A HAZARDOUS SITUATION ON THE ROAD. I REED THAT IS A NON-PUBLIC RECALL ON THOSE ENGINES(VO-6) IS THE CODE FOR THAT. PLEASE WRITE (ASAP) BECAUSE IS DIFFICULT TO ENTER WITH A CONVERSATION WITH ANY TOYOTA DEALER ABOUT MY CONCERN. NOW THEY SAID THAT THEY DON'T HAVE ANY INFORMATION ABOUT THE RECALL. TO FIX MY TRUCK IS GOING TO TAKE ME TO SPEND THOUSANDS OF DOLLARS. IF THE RECALL IS TRUE WHAT IS MY RIGHT TO GET THE TOYOTA CORP. TO HONOR THIS ISSUE? *JS

NHTSA ID

10661485

Incident

Nov 19, 2014

Mileage

59,765 mi

MY VEHICLE WAS PARKED IN THE DRIVEWAY. I STARTED THE VEHICLE AND PUT THE GEAR IN DRIVE TO MOVE IT FORWARD. AS SOON AS I DROPPED IT INTO DRIVE, THE VEHICLE SUDDENLY ACCELERATED FORWARD WITH THE THROTTLE APPEARING TO BE WIDE OPEN. I HAD MY FEET FIRMLY ON THE BRAKE TO KEEP THE VEHICLE FROM MOVING, THE BACK WHEELS STARTED TO SLIP AND "CHIRP" SINCE THE REAR END IS LIGHT. WITH THE ACCELERATOR STILL WIDE OPEN, I PUT THE GEAR IN NEUTRAL AND WATCHED AS THE RPM'S SHOT OVER 4000. AFTER A FEW SECONDS, THE ACCELERATOR SHOWED NO SIGNS OF DISENGAGING, SO I TURNED THE VEHICLE OFF AND PUT THE GEAR IN PARK. THIS HAS HAPPENED BEFORE, SO I AM ALWAYS READY IN CASE IT HAPPENS AGAIN. I MUST CONSTANTLY DRIVE WITH ONE HAND ON THE GEAR SHIFT, READY TO PUSH IT INTO NEUTRAL AT THE FIRST SIGNS OF THIS SUDDEN UNINTENDED ACCELERATION. THIS IS THE FIFTH TIME THIS HAS OCCURRED IN THE PAST YEAR. TOYOTA CONTINUES TO CLAIM THERE IS NOTHING WRONG WITH THE VEHICLE, THAT I AM ACCIDENTLY HITTING THE GAS PEDAL MYSELF. *TR

NHTSA ID

10651292

Incident

Oct 25, 2014

Mileage

167,776 mi

ON MY OLD 1998 TOYOTA TACOMA I GOT THE DEAL ON BUYBACK WHEN THE FRAME RUSTED OUT SO BAD WITH HOLES IN IT.THEN I WENT OUT AND BOUGHT A 2005 TOYOTA TACOMA AND THIS TRUCK HAS RUST FROM END TO END ON THE FRAME AGAIN. WHEN I BOUGHT IT IN 2006 TOYOTA SAID THEY HAD THAT FIXED BUT THIS 2005 IS ALOT WORSE WITH ALOT MORE RUST THEN THE 1998.I ALSO TOOK IT TO THE GARAGE TO HAVE THE POWER STEERING PUMP AND ALTERNATOR AND AC PUMP REPLACED BECAUSE EVERYTHING WAS RUSTED UP ON THE ALTERNATOR AND AC PUMP AND POWER STEERING SO BAD THE MECHANIC TOLD ME TO KEEP THE PARTS AND SHOW THE TOYOTA DEALERSHIP AND NHTSA.I WAS LUCKY THAT EVERYTHING SHUT DOWN ON THE TRUCK WHEN I GOT IT TO THE BOTTOM OF MY DRIVEWAY AND THEN GOT IT TOWED TO THE MECHANIC AND 1790.00 DOLLARS LATER WITH LABOR AND PARTS LET ME TELL YOU NOT HAPPY WITH TOYOTA.PLEASE NHTSA LOOK AT THIS PROBLEM AND IF YOU NEED A TRUCK TO TAKE PICS OF MINE IS THE ONE I USED TO WORK AT A BODY SHOP SO I KNOW THIS TRUCK WOULD DO THE JOB FOR NHTSA MY TRUCK HAS 78000 MILES ON IT I WILL TAKE PICS OF IT FOR YOU IF YOU WISH. *TR

NHTSA ID

10641869

Incident

Sep 29, 2014

IN JUNE 2013 I WAS APPROACHING AN INTERSTATE ENTRANCE RAMP. AS I SLOWED DOWN (FOOT ON THE BRAKE) TO MAKE THE RIGHT TURN ONTO THE RAMP, THE VEHICLE SUDDENLY ACCELERATED, CAUSING THE REAR END TO "FISH TAIL" AROUND, JUMPING THE CURB ON THE RIGHT SIDE OF THE RAMP AND SENDING THE VEHICLE DOWN THE EMBANKMENT. I WAS ABLE TO GET THE VEHICLE TO STOP BEFORE HITTING THE FENCE AT THE BOTTOM OF THE HILL. SINCE THIS FIRST INCIDENT IN JUNE 2013, THE VEHICLE HAS HAD THREE MORE INCIDENTS IN JUNE, JULY AND AUGUST OF 2014. THE LAST INCIDENT IN AUGUST OCCURRED AS I WAS PULLING INTO A PARKING SPOT. AGAIN, I WAS SLOWING DOWN (FOOT ON THE BRAKE) WHEN THE VEHICLE SUDDENLY ACCELERATED CAUSING ME TO STRIKE THE PARKED VEHICLE IN FRONT OF ME. THE INCIDENTS IN JUNE AND JULY 2014 WERE ALSO SIMILAR PARKING LOT INCIDENTS WITH NO OTHER VEHICLES AROUND. AFTER THE AUGUST 2014 INCIDENT, I STARTED TO "CONNECT THE DOTS" AND TOOK THE VEHICLE TO THE TOYOTA DEALERSHIP. HOWEVER, THEY FOUND NO PROBLEM WITH THE VEHICLE. I FIND THIS VERY STRANGE GIVEN ALL OF THE KNOWN ISSUES TOYOTA HAS HAD WITH SUDDEN UNINTENDED ACCELERATION (SUA). *TR

NHTSA ID

10632642

Incident

Jun 5, 2013

Mileage

151,000 mi

AFTER REPAIR OF 2 RECALLS-SPIRAL CABLE AND SEAT BELT, A WHINING NOISE STARTED AFTER STARTING THE ENGINE. THE WHINE GETS LOUDER AS DURING ACCELERATION. THE WHINE WAS NOT THERE BEFORE THE REPAIR OF THE TWO RECALLS. *JS

NHTSA ID

10598040

Incident

May 30, 2014

Mileage

137,000 mi

THE FOLLOWING IS THE DEALER INSPECTION REPORT FOR MY TRUCK: "FOUND EXTREME CORROSION TO FRAME. TOW HOOK AND DRIVER SIDE SWAY BAR MOUNT UNABLE TO RE-ATTACH DUE TO FRAME PERFORATION FRONT CROSS MEMBER MISSING (RUSTED OFF) FOUND HOLE IN LEFT SIDE OF FRAME. STEERING RACK MOUNTS EXTREMELY PERFORATED, READY TO DETACH. DO NOT RECOMMEND DRIVING VEHICLE DUE TO EXTREME DAMAGE TO FRAME" TRUCK PURCHASED NEW, SINGLE OWNER, WELL MAINTAINED. ...UPDATED 06/10/14 *BF

NHTSA ID

10596419

Incident

Jun 5, 2014

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING IN REVERSE, HE NOTICED THE FRAME UNDER THE MOTOR MOUNT WAS DETERIORATED. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC, WHO DIAGNOSED THAT THE FRAME WAS RUSTED, DETERIORATED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. UPDATED 04/17/14*LJ *TR

NHTSA ID

10565785

Incident

Feb 17, 2014

Mileage

170,000 mi

ON MAY 27, 2013 MY WIFE [XXX] AND I WERE TOWING MY BASS BOAT AND I BLEW OUT THE REAR PASSENGER TIRE AND WAS ABLE TO SAFELY GET IT OFF OF THE ROAD TO CHANGE THE TIRE. IN THE PROCESS OF CHANGING THE TIRE IN MY TRUCK, THE FRAME BENT UNDER THE PRESSURE OF THE JACK AND THE TRUCK, CAME OFF OF THE JACK, LUCKILY I HAD THE TIRE PARTIALLY ON THAT THE LUG BOLTS CAUGHT THE TRUCK. THIS RUSTING AND UNSAFE FRAME ISSUE DATES BACK TO 1/16/13 AT APPROXIMATELY 7:30 AM I WAS CONTACTED BY THE TOYOTA DEALERSHIP THAT DURING A REPAIR TO MY CATALYTIC CONVERTER THEY NOTICED THAT I HAD A HOLE IN MY FRAME AND THAT IT WOULD NOT PASS INSPECTION. I FEEL TERRIBLE NOW, BUT I ALL BUT CALLED THE GIRL SERVICE MANAGER A LIAR AND ASKED THAT SHE TAKE ME A PHOTO OF THE HOLE AND SEND IT TO ME AT WORK. I WANT MY TACOMA FIXED, THE FRAME REPLACED AS I FEEL IT IS UNSAFE AND AFTER HAVING EXPERIENCED THE TRUCK FALLING OFF OF THE JACK AFTER THE FRAME BENT WHILE SIMPLY JACKING IT UP, I CAN'T IMAGINE THAT I AM THE ONLY ONE OUT THERE WITH THIS ISSUE. IN MY RESEARCH I AM FINDING VOLUMES OF COMPLAINTS TO TOYOTA IN KIND REGARDING FRAME ROT AND RUST. I HAVE ALSO NOTICED SOME INSTABILITY WHEN DRIVING, IT SEEMS TO HAVE A CONSTANT SHAKE IN THE STEERING. I HAVE PLACED NUMEROUS CALLS TO TOYOTA'S CUSTOMER SERVICE EXPLAINING IN DETAIL MY SAFETY CONCERN AND THE ANSWER I AM CONSTANTLY BEING GIVEN IS THAT MY VEHICLE IS NOT CURRENTLY PART OF THE RECALL PROGRAM. ANY WAY YOU SLICE IT, I FEEL THIS IS TERRIBLE ON TOYOTA'S BEHALF TO SUBJECT LOYAL CUSTOMERS TO SUCH POTENTIAL AND EMINENT SAFETY HAZARDS AS A WEEK AND INFERIOR FRAME! GOD HELP US IF WE ARE EVER INVOLVED IN AN AUTO ACCIDENT... HOW WELL WILL THESE FRAMES HOLD UP OR WILL WE BE CRUSHED LIKE A SODA CAN? SO MUCH FOR TOYOTA'S SAFETY RATING AT THAT POINT RIGHT? PLEASE HELP ME...PLEASE HELP ME. SINCERELY A CONCERNED TOYOTA OWNER, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10559798

Incident

May 27, 2013

Mileage

164,000 mi

FRAME AT PASSENGER SIDE MOTOR MOUNT IS CRACKED AND FAILED. BECAUSE IT'S VERY UNUSUAL FOR A TRUCK FRAME TO CRACK, NOTIFIED TOYOTA (HILO, HAWAII) OF THE PROBLEM AND ASKED IF THERE IS A RECALL TO ADDRESS IT. TOYOTA SAID IT'S NORMAL WEAR AND TEAR AND THERE IS NO RECALL. *TR

NHTSA ID

10556081

Incident

Dec 12, 2013

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE EXHIBITED A LOUD GRINDING NOISE. UPON INSPECTION, THE FRAME THAT HELD THE ENGINE WAS FOUND TO BE CRACKED. THE CONTACT WAS CONCERNED THAT THE ENGINE COULD FALL OUT FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 129,000.

NHTSA ID

10545017

Incident

May 27, 2013

Mileage

129,000 mi

I WAS DRIVING ON THE HIGHWAY AND THE CHECK ENGINE LIGHT CAME ON. I IMMEDIATELY TOOK IT TO THE TOYOTA DEALER AS I WAS RIGHT UP THE STREET FROM THEM. THEY SCANNED FOR THE SERVICE CODE AND IT TOLD THEM THERE WAS A MIS-FIRE IN THE #6 CYLINDER. THEY CHECKED THE SPARK PLUG COIL AND SAID IT WAS FAULTY AND REPLACED IT. WHEN I PICKED UP THE TRUCK FROM THE DEALER THE CHECK ENGINE WAS STILL ON. THEY TOOK IT BACK INTO THE SERVICE BAY AND AFTER 20 MINUTES CALLED ME OVER TO TELL ME THERE WAS COOLANT LEAKING INTO THE #6 CYLINDER AND WAS DETERMINED THAT THE ENGINE BLOCK WAS CRACKED. THIS TRUCK HAS NEVER OVER-HEATED AND THEY COULD NOT EXPLAIN IT. AFTER CHECKING THE INTERNET FOR OTHERS WITH THE SAME PROBLEM, I FOUND THERE WERE A FEW OTHERS AND THE MECHANIC TOLD ME THAT HE HAS SEEN IT BEFORE IN THIS ENGINE BLOCK. I CAN'T AFFORD A NEW TRUCK, SO I AM STUCK WITH PAYING FOR NOT ONLY THE COIL REPLACEMENT BUT ALSO THE NEW OR REFURBISHED ENGINE BLOCK ($5,000+). IT WOULD BE GREAT IF THE NHTSA COULD LOOK INTO THE INTEGRITY AND ENGINEERING OF THE ENGINE BLOCK IN THE 2005 4.0L V6 ENGINE IN THE TOYOTA TACOMA. *TR

NHTSA ID

10535519

Incident

Aug 8, 2013

Mileage

145,604 mi

TO WHO IT MAY CONCERN: WOULD YOU BE ABLE TO RESEARCH AND COVER A 2005 TOYOTA TACOMA PROBLEM PLAGUING TOYOTA CUSTOMER. THE ISSUES IS A PROBLEM WITH THE DESIGN OF THE FRAME. THE FRAMES ARE FAILING AT THE ENGINE MOTOR MOUNT(VERY VERY DANGEROUS) AND CAUSING THE CARS TO BE ALMOST BE IN-REPAIRABLE(TOYOTA ADVISE ME IT WOULD BE 10,000 FIX). TOYOTA IS OFFERING NO ASSISTANCE AND THERE ARE TONS OF CUSTOMER FEEDBACK ONLINE TO SHOW THERE IS A PROBLEM WITH THEIR FRAMES. FOR MY TRUCK I HEARD A NOISE COMING FROM THE ENGINE ON 12/24/2012 AND TOOK INTO A DEALER ON 12/26/2012. THEY SAID IT WAS THE FAN HITTING THE FAN SHROAD THEY SAID THEY FIXED IT. I STARTED HEARING THE NOISE AGAIN AND HAD TO TAKE IT IN ON 1/5/2013...THEY FIRST SAID IT WAS MY MOTOR MOUNTS AND WOULD NEED TO ORDER THE PART..WHEN THEY WERE GOING TO INSTALL THE PART THEY NOTICE A CRACK IN THE FRAME WHERE IT CONNECTS TO THE MOTOR MOUNT. THEY SAID THERE WAS NO OTHER SIGNS IF DAMAGE ANY WHERE AND DID NOT KNOW HOW THAT HAPPENED...MEANING THE FRAME FAILED FROM THE TORQUE OF THE ENGINE.. THEY ADVISE I WOULD NEED TO GET NEW FRAME ($10,000)...I CALLED TOYOTA AND ADVISE THEY WOULD NOT ASSIST. *TR

NHTSA ID

10492062

Incident

Dec 24, 2012

Mileage

134,000 mi

2005 TOYOTA TACOMA. CONSUMER STATES LOUD NOISE COMING FROM ENGINE AND THAT THE ENGINE WAS OFF KILTER *TGW THE CONSUMER STATED WHEN HE OPENED THE HOOD, HE DISCOVERED THE ENGINE WAS DRASTICALLY LEANING TOWARDS THE DRIVER'S SIDE OF THE VEHICLE. THE NOISE WAS THE ENGINE'S COOLING FAN HITTING THE SHROUD MEANT TO PROTECT IT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER. AN INSPECTION REVEALED THE MOTOR MOUNT WHICH WAS ATTACHED TO THE FRAME OF THE VEHICLE BROKEN FREE AND COLLAPSED INTO THE FRAME ITSELF. THERE WAS ALSO EXTENSIVE RUST ON THE FRAME ON THE REMAINDER OF THE FRAME. A TOYOTA SPECIALIST TOOK PICTURES OF THE FAILED MOTOR MOUNT AND RUSTED FRAME. THE CONSUMER STATED TOYOTA HAS A LONG HISTORY OF FRAME RUST ISSUES, AS A RECALL WAS ISSUED FOR PREVIOUS MODELS. *JB

NHTSA ID

10443035

Incident

Nov 1, 2011

TRUCK BEGAN MAKING LOUD NOISES IN ENGINE COMPARTMENT. TRUCK WAS DIAGNOSED AS HAVING BAD MOTOR MOUNTS. AT TIME OF REPAIR, MOTOR MOUNT ASSEMBLIES WERE NOTED BY MECHANIC TO HAVE BROKEN OFF THE FRAME DUE TO BAD/WEAKENED WELDS. MOTOR IS RUBBING ON FAN/RADIATOR SHROUD. OWNER HAS DONE INDEPENDENT RESEARCH, INCLUDING COMPLAINTS FILED ON THIS SITE, AND HAS NOTED THAT THIS HAS BEEN AN ON-GOING ISSUE WITH 2005 TACOMAS. *TR

NHTSA ID

10424436

Incident

Sep 1, 2011

Mileage

148,000 mi

I OWN A 2005 TOYOTA TACOMA. ON SEVERAL OCCASIONS THE VEHICLE HAS SHUT DOWN WHEN I ATTEMPT TO PROCEED FROM A STOP. THIS OCCURS WHILE I AM IN TRAFFIC. THE VEHICLE MAY OR MAY NOT START FOR SOME TIME AFTER THAT. IF IT DOES START, IT WILL IDLE OK BUT WHEN I STEP ON THE GAS PEDAL IT SHUTS DOWN. AFTER CONTINUALLY STARTING FOR A FEW TIMES IT MAY RUN OK FOR A WHILE. I HAD IT SERVICED AT A DEALER THE FIRST TIME AND THEY ENDED UP REPLACING THE COMPUTER SYSTEM. IT WORKED FINE FOR ABOUT 3-4 MONTHS BUT THEN BEGAN DOING IT AGAIN. I TOOK THE VEHICLE IN FOR SERVICE AT THE DEALER AGAIN AND THEY FIND NOTHING WRONG. IT HAS HAPPENED TO ME ABOUT 6 OR 7 TIMES NOW. *TR

NHTSA ID

10313764

Incident

Feb 18, 2010

Mileage

39,000 mi