2006 Toyota Tacoma Electrical Problems

THE CHECK ENGINE LIGHT WILL NOT GO OFF. A TOYOTA INDEPENDENT SERVICE/REPAIR FACILITY CHECKED EVERYTHING AND SAID IT IS ELECTRICAL BOARD PROBLEM. I REC'D A SAFETY RECALL LETTER FROM TOYOTA STATING THERE IS A MALFUNCTION INDICATOR LAMP CAUSING THE CHECK ENGINE LIGHT TO STAY ON. IT STATES I WILL RECEIVE A 2ND NOTIFICATION WHEN REMEDY IS AVAILABLE THAT I HAVE NOT REC'D. THEY WANT ME TO PAY THE DEALER (APPROX. 300-400 DOLLARS) THEN SEND DOCUMENTS OF REPAIR TO TOYOTA CORP FOR REIMBURSEMENT! I DO NOT HAVE THAT KIND OF MONEY TO WAIT AND SEE IF I WILL BE REIMBURSED. WHY ARE THEY DRAGGING THEIR FEET NOT SENDING AN ACTUAL RECALL THAT THEY WILL PAY THEIR DEALERS AFTER THEY PERFORM THE WORK? WHY IS THIS RECALL NOT NOTED ABOVE. ARE THEY TRYING TO NOT HAVE TO DO ANYTHING? IN RED, THE LETTER STATES "THIS IS AN IMPORTANT SAFETY RECALL:" BUT THE TOYOTA DEALER "TEAM TOYOTA" KNEW NOTHING ABOUT IT,SAID THEY COULD CHECK AND FIX, BUT WOULD HAVE TO PAY FOR IT THEN MAYBE BE REIMBURSED BY TOYOTA BUT THEY COULDN'T SAY I WOULD BE. CAN YOU HELP WITH THIS?? MY EMAIL IS [XXX] THANK YOU [XXX] (RETIRED DON'T HAVE ACCESS TO SEND DOCUMENTS,I COULD TAKE PICTURE WITH PHONE AND SEND TO PHONE #) INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11417472

Incident

May 17, 2021

THE ENTIRE FRAME OF THIS GARAGE KEPT TRUCK IS COMPLETELY RUSTED THOUGH. THIS TRUCK AS ONLY 61,000 MILES ON IT & IS UNSAFE TO DRIVE. THE REAR LEAF SPRING MOUNTS ARE BROKEN & HAVE PUNCTURED THE GAS TANK. THE ELECTRICAL WIRING TO DO WITH THE SAFETY NEUTRAL SWITCH, WHICH IS TIED INTO THE ENTIRE FROM WIRING HARNESS HAS CAUGHT FIRE TWICE. TOYOTA HAS BEEN NOTIFIED ABOUT ALL OF THIS, IN DETAIL, & THEY COULD CARE LESS ABOUT MY OWN OR ANYONE ELSE'S SAFETY. THERE ISN'T A SCRATCH ON THIS TRUCK & HAS REALLY LOW MILES YET IS SO UNSAFE TO USE BECAUSE OF POOR CONSTRUCTION ON TOYOTA'S PART.

NHTSA ID

11315970

Incident

Jan 2, 2020

Mileage

61,000 mi

THE AIRBAG LIGHT JUST TURNED ON. CRUISE CONTROL ON STEERING WHEEL IS NOT FUNCTIONING, AUDIO CONTROL ON STEERING NOT WORKING ALSO AND LASTLY THE HORN IS NOT WORKING ALSO. LOOKS LIKE A SPIRAL CABLE PROBLEM BASED ON THE SYMPTOM AND VALIDATION OF DISCUSSION GROUP ONLINE. CHECKED FOR RECALL HERE AND SEEN MY VIN NUMBER ON THE RANGE FOR RECALL. WHY DID I NOT RECEIVED ANY RECALL NOTICE ON THIS. NOT SURE IF THE VEHICLE IS UNSAFE TO DRIVE CONSIDERING THE AIRBAG DEPLOYED LIGHT IS ON OR IF THIS WILL AFFECT THE AIRBAG DELOYMENT IF NEEDED. THIS HAPPENED JUST RECENTLY AND THERE ARE ISSUES SIMILAR TO MY CASE. HOPE IT CAN BE FIXED BY TOYOTA.

NHTSA ID

11151633

Incident

Nov 12, 2018

Mileage

131,800 mi

AS THE WEATHER INCREASES ABOVE 85 TO 90 DEGREES THE DIRECTIONAL SIGNAL AND THE HAZARD FLASHERS CEASE WORKING. ONCE THE OPERATION OF THE VEHICLE HAS CEASED AND THE TEMPERATURE AND THE VEHICLE COOL DOWN NORMAL FUNCTION RETURNS. I BELIEVE THE PROBLEM IS IN THE ENGINE COMPARTMENT BECAUSE WHEN USING THE A/C IN THE CAB THE COOL AIR HAS NO EFFECT. THIS IS A SAFETY HAZARD BECAUSE I DO NOT KNOW WHEN IT WILL OCCUR. LEAVING ME WITHOUT SIGNALS WHILE DRIVING.

NHTSA ID

11123869

Incident

Aug 26, 2018

Mileage

67,000 mi

I DO NOT SEE THE RECALL FOR THE SPIRAL CABLE ASSEMBLY ON MY TACOMA. I READ THAT THIS VIN IS PART OF A RECALL FOR THE WIRING IN THE STEERING WHEEL THAT CONTROLS MY PASSENGER AIRBAG, CRUISE CONTROL AND SOME OTHER FUNCTIONS. IT HAS MALFUNCTIONED. WHY IS IT NOT LISTED ON YOUR WEBSITE? WHEN I CHECKED ON THE STATUS OF THIS RECALL, IT SHOWS THAT MY MODEL, ACCORDING TO THE VIN DOES QUALIFY FOR THIS. MY PASSENGER AIRBAG IS NOT WORKING, AND MY CRUISE CONTROL IS NO LONGER WORKING AT SPEED.

NHTSA ID

11119717

Incident

Jun 1, 2010

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE OFF POSITION, THE ENGINE DID NOT TURN OFF. THE CONTACT HAD TO DEPRESS THE REMOTE START IN ORDER FOR THE VEHICLE TO TURN OFF. THE CONTACT STATED THAT AFTER THE VEHICLE WAS REPAIRED UNDER A MANUFACTURER'S RECALL THE FAILURES OCCURRED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10787065

Incident

Jan 13, 2014

AIR BAG LIGHT ON, HORN NOT WORKING. DEALER SAID DEFECTIVE CLOCK SPRING IN STEERING COLUMN. *TR

NHTSA ID

10449586

Incident

Feb 22, 2012

Mileage

130,000 mi

THIS HAS BEEN GOING ON FOR FEW YEARS. THIS MONTH MY A/C STARTED WORKING INTERMITTENTLY AGAIN. I HAVE REPLACED THE RESISTOR BEFORE THINKING IT WAS BAD..THAT'S WHEN I FIRST NOTICED THE HOT SPOTS. THIS TIME I INVESTIGATED MORE. NOW ALL 4 CONDUCTORS ARE SHOWING SIGNS OF A HOTSPOTS AND THE PLUG ALSO IS SHOWING SIGNS OF OVERHEATING ON THE TWO MIDDLE CONNECTIONS. TOYOTA'S SERVICE MANAGE DIDN'T KNOW OF ANY SERVICE BULLETINS OR RECALLS ON THIS ISSUE. ALSO TOYOTA DOESN'T SELL A REPLACEMENT PLUG. THIS CAN, AND PROBABLY WILL START A FIRE. THE PARTS DEPARTMENT SAID I WILL FINE THAT MOST OF THE PLUGS WILL SHOW HEAT INDICATIONS AT A USED PARTS HOUSES. HAVING A FIRE INSIDE MY VEHICLE IS DEFINITELY A SAFETY ISSUE. FIRST RESISTOR CHANGED 11/10 @ 81500 MILES AND THERE WAS NOTHING WRONG WITH IT, JUST LOOSE CONNECTIONS. *TR

NHTSA ID

10441540

Incident

Dec 28, 2011

Mileage

81,500 mi

AT AROUND 48,000 MILES, AIRBAG LIGHT CAME ON. TOOK IT TO TOYOTA DEALER AND WAS DIAGNOSED AT BROKEN SPIRAL CABLE. TOTAL COST TO FIX WAS 460 DOLLARS WITH LABOR. SEEMS TO BE A COMMON PROBLEM WITH 06 TACOMA. *KB

NHTSA ID

10437596

Incident

Nov 28, 2011

Mileage

48,987 mi

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL ON A CONSISTENT BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THERE WAS A SHORT IN THE DRIVERS SIDE SQUIB AND THE VEHICLE NEEDED A SPIRAL CABLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.

NHTSA ID

10418496

Incident

Jul 11, 2011

Mileage

105,000 mi

USED MY 2006 TOYOTA TACOMA PRERUNNER TO TOW A VEHICLE A SHORT DISTANCE BEFORE A SHORT CIRCUIT IN TRAILER WIRING CAUSED WIRING FIRE IN PRERUNNER---30 AMP FUSE IN TOYOTA FAILED TO PROTECT CIRCUIT, LEADING TO TOTAL TRUCK WIRING MELTDOWN AND RUIN. FUSE WAS OF THE AMPACITY REQUIRED BY TOYOTA--30 AMPS. TRUCK WAS PURCHASED NEW, NEVER INVOLVED IN AN ACCIDENT, AND NO CHANGES HAD BEEN MADE TO WIRING OR FUSE SYSTEMS. AUTO ELECTRIC REPAIR SHOP REQUIRED $2800 IN PARTS AND $2000 FOR LABOR TO REPAIR MELTED WIRING LOOMS AND FUSE BOX; THEY SUGGESTED THAT FAILURE COULD HAVE RESULTED BECAUSE TOYOTA USES A 30 AMP FUSE ON A #12 WIRE CIRCUIT THAT WILL MELT AND BURN BEFORE THE FUSE BLOWS. (12 GAUGE WIRE TYPICALLY MUST BE PROTECTED BY A 20-AMP FUSE.) TOYOTA (CORPORATE) REFUSES TO DEAL WITH MY ISSUE OR TALK TO ME ABOUT WHETHER THE FAILED FUSE AND MELTDOWN COULD HAVE BEEN CAUSED BY THEIR INSTALLING A FUSE WITH TOO HIGH AN AMPACITY RATING BECAUSE I DID NOT HAVE THE REPAIR DONE BY A TOYOTA DEALERSHIP. IS THERE A DANGEROUS DESIGN FLAW WITH THE PRERUNNER? I AM CERTAIN THAT I DID NOTHING TO MY PRERUNNER (AS ITS ONLY OWNER) TO EXPLAIN WHY THE TRUCK NEARLY BURNED UP AND THE WIRING SYSTEM MELTED DOWN (AND WAS COMPLETELY RUINED) SIMPLY BECAUSE OF A SIMPLE SHORT CIRCUIT IN THE TRAILER I TOWED FOR LESS THAN ONE MILE (BEFORE MELTDOWN OCCURRED). I AM HOPEFUL THAT NHTSA MAY BE ABLE TO USE MY INFORMATION TO APPROACH TOYOTA ON THE POTENTIAL DESIGN DEFECT ISSUE AND, CERTAINLY, TO COLLECT MY COMPLAINT WITH ANY OTHER SIMILAR COMPLAINTS THAT COULD DENOTE A TREND OR SERIOUS SAFETY RISKS WITH THE TOYOTA TRUCK'S WIRING SYSTEM. *TR

NHTSA ID

10404306

Incident

May 1, 2011

Mileage

97,000 mi

COPY OF LETTER TO TOYOTA CONCERNING A DEFECTIVE SPIRAL CABLE AND ELECTRONIC CIRCUIT; FEELS THIS PART SHOULD HAVE BEEN REPAIRED AND COVERED UNDER A SPECIAL SAFETY WARRANTY OR RECALL; ENCLOSED AUTOMOTIVE PART FWD TO NVS-200 *TGW THE CONSUMER STATED THE AIR BAG LIGHT ILLUMINATED 12 DAYS AFTER BEING AT THE DEALERSHIP TO HAVE A RECALL PROBLEM REPAIRED. THE DEALER INFORMED THE CONSUMER HE WOULD HAVE TO PAY $88 TO DIAGNOSE THE PROBLEM. THE DEALER STATED THE PROBLEM WAS DUE TO A BROKEN SPIRAL CABLE AND ELECTRONIC CIRCUIT UNDERNEATH THE HORN WHICH WOULD COST $ 496 IN ADDITION TO THE $ 88. *JB

NHTSA ID

10387868

Incident

Mar 1, 2011

I WAS DRIVING MY 2006 TOYOTA TACOMA WHEN AIRBAG WARNING LIGHT WENT ON. THIS WAS BROUGHT TO THE DEALER IMMEDIATELY THE NEXT DAY AND DIAGNOSIS IS FAILED SPIRAL CABLE. THE SPIRAL CABLE SENSES MORE THAN THE AIRBAG AND INCLUDES THE STEERING WHEEL, HORN, AND CRUISE CONTROL. COST OF REPLACEMENT IS $603.31. *TR

NHTSA ID

10362605

Incident

Oct 25, 2010

Mileage

112,700 mi

TL*THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE AIR BAG LIGHT ILLUMINATED. THE DEALER STATED THAT THE FAILURE WAS WITHIN THE SQUID CIRCUIT. THE VEHICLE WAS REPAIRED UNDER WARRANTY. THE FAILURE OCCURRED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS 14,685 AND THE CURRENT MILEAGE WAS APPROXIMATELY 149,000. UPDATED 12/29/10 *BF UPDATED 12/30/10*JB

NHTSA ID

10359428

Incident

Jan 3, 2007

Mileage

14,685 mi

WHEN I WAS COASTING TO PARK MY TRUCK AT MY PARKING SPACE OUTSIDE OF MY HOUSE PARKING GARAGE, MY P/U TRUCK SUDDENLY ACCELERATED VERY FAST AND THE TRUCK HIT THE FENCE AND STOPPED. I REMEMBER CLEARLY MY SENSE THAT I PUSHED THE BRAKE WHILE THE CAR ACCELERATING FOR A SPLIT SECOND BUT DO NOT REMEMBER IF THE ENGINE WAS STOPPED AFTER HITTING THE FENCE WITH STEEL POLE. I SOMEHOW REVERSED BACK ABOUT 8 FEET FROM THE FENCE AND STOPPED THE ENGINE. I CAME OUT OF THE CAR AND CHECKED IF THE ACCELERATING PEDAL WAS DEPRESSED. IT WAS NOT. I HAD EXPERIENCED THE TRUCK ENGINE RACING A LITTLE FAST AS I TRIED TO PARK AT WORK IN THE MORNINGS ALSO. I FELT SOMETHING UNUSUAL BUT IGNORED THE FEELING, SINCE MY CAR WAS RUNNING HIGH RPM SINCE NEW. I REMEMBER THAT I ASKED ABOUT THE HIGH RPM TO THE SALESMAN. HE MENTIONED SOME NEW DESIGN FEATURE THAT I COULD NOT UNDERSTAND. AFTER THIS INCIDENT WITHIN 30 MINUTES I WENT TO TOYOTA OF PLANO AND REPORTED MY INCIDENT, AND THEN I WENT TO MY CAR/HOME INSURANCE COMPANY (STATE FARM INSURANCE CO.) TO REPORT THE INCIDENT. MY CAR WAS TOWED TO TOYOTA OF PLANO. I HOPE SOME ONE CHECKS THE ENGINE ELECTRONICS, NOT JUST MECHANICAL PROBLEM OF MY CAR. THIS IS VERY ODD AND DANGEROUS. I ASKED MYSELF ABOUT THE STATE OF MY OWN MIND AND ATTITUDE AT THE MOMENT BUT I WAS VERY NORMAL. I AM AN ELECTRICAL ENGINEER AND HAVE DRIVEN THE CARS FOR LAST 50 YEARS AND HAVE LIVED AND PARKED AT THE SAME PARKING SPACE FOR LAST 17 YEARS. I HAVE HEARD ABOUT THE TOYOTA PROBLEMS BUT NOT ABOUT MY TRUCK MODEL. UPDATED 03/30/10

NHTSA ID

10319419

Incident

Mar 12, 2010

Mileage

38,000 mi

VEHICLE ENGINE REVVED WHILE STILL IN PARK IN THE PARKING LOT OF A LOCAL MEDICAL CENTER AND ONLY STOPPED WHEN THE KEY IN THE IGNITION WAS TURNED OFF. THIS IS THE THIRD TIME THIS HAS OCCURRED. ON JANUARY 1, 2009 AN ACCIDENT INVOLVING PROPERTY DAMAGE (THROUGH A CHAIN LINK FENCE) OCCURRED AS A RESULT. WE FILED A COMPLAINT (CONFIRMATION NUMBER 10253526). A TOYOTA TECHNICIAN "CHECKED OUT" THE VEHICLE AND FOUND NOTHING WRONG. THERE IS OBVIOUSLY SOMETHING WRONG. THE FIRST TIME THIS OCCURRED WE WERE IN THE PARKING LOT OF A LOCAL DEPARTMENT STORE, ASSUMED HUMAN ERROR, AND DID NOT REPORT THE INCIDENT. THIS IS STRIKE THREE. TOYOTA HAS BEEN CONTACTED. *TR

NHTSA ID

10284909

Incident

Sep 22, 2009

Mileage

23,000 mi

WE PURCHASED A 2006 TACOMA ON DEC. 23, 2008 FROM COMPETITION TOYOTA IN NEW YORK. WE DROVE THE TRUCK BACK TO WISCONSIN THAT DAY. TWO DAYS AFTER PURCHASE DATE (APPROX. 1500 MILES LATER), THE AIRBAG LIGHT CAME ON. HAVING A BUSY SCHEDULE, AND NOT USING THE TRUCK MUCH, WE BROUGHT THE TRUCK INTO MARQUART TOYOTA IN EAU CLAIRE, WI ON MARCH 18, 2009. THEY ASSURED ME THAT IT WOULD BE COVERED UNDER WARRANTY AS LONG AS IT WERE AN AIRBAG PROBLEM. TURNS OUT THEY CHARGED US WITH $94.95 FOR THE PROBLEM TO BE DIAGNOSED. A SPIRAL COIL THAT ALLOWS THE STEERING WHEEL TO TURN WHILE STILL KEEPING THE AIRBAG CONNECTED BROKE. THEY QUOTED ME $483.19 FOR THE REPAIR OF THIS COIL. DUE TO THIS BROKEN COIL, NONE OF THE AIRBAGS IN THE TRUCK WORK. I CALLED TOYOTA CUSTOMER SERVICE TO RESOLVE THIS ISSUE. AFTER TWO WEEKS OF DELIBERATING, TOYOTA TOLD ME THAT THIS WOULD NOT BE COVERED UNDER WARRANTY. I REMINDED THE REPRESENTATIVE WHOM I WAS SPEAKING WITH THAT ALL SAFETY RELATED DEFECTS ARE TO BE COVERED IN ENTIRETY BY THE MANUFACTURER. NONE OF THE AIRBAGS IN THIS TRUCK WORK BECAUSE OF THIS COIL, SOUNDS LIKE A SAFETY DEFECT TO ME. *TR

NHTSA ID

10263803

Incident

Mar 31, 2009

Mileage

85,000 mi

THE SPEEDOMETER IS NOT ACCURATE I TOOK IT TO THE DEALER ONCE WHEN STILL HAD WARRANTY THE BLAME ON THE TIRES THE OTHER DEALER SAID IT WAS ACCURATE BUT I CHANGE THE TIRES SIZE AND NOW IS BETTER IS COUNTING MORE MILES THAN IS USED TO. *TR

NHTSA ID

10243819

Incident

Jun 20, 2006

ON ALL 2005 AND 2006 TOYOTA TACOMAS THE FOURWHEEL DRIVE SELECTOR SWITCH DOES NOT LIGHT UP AND IS VERY DIFFICULT TO FIND WHEN DRIVING AT NIGHT. I NEEDED TO PUT THE TRUCK INTO FOURWHEEL DRIVE AND HAD TO FEEL AROUND THE DASHBOARD FOR A FEW SECONDS BEFORE I COULD GET IT INTO FOURWHEEL DRIVE. I FEEL THAT THIS IS A SAFETY ISSUE THAT COULD RESULT IN AN ACCIDENT AND SOMEONE GETTING HURT BECAUSE THEY CAN'T GET INTO FOURWHEEL DRIVE IN A HURRY IF THEY NEED TO. I CONTACTED MY LOCAL TOYOTA DEALER BUT THEY SAID THERE WAS NOTHING THEY COULD DO. I ALSO CONTACTED TOYOTA HEADQUARTERS AND TOLD THEM ABOUT THE PROBLEM BUT I DON'T THINK THEY WILL DO ANYTHING BASED ON THEIR RESPONSE. ALL OTHER TOYOTA FOURWHEEL DRIVE MODELS HAVE FOURWHEEL DRIVE SWITCHES THAT DO LIGHT UP. ALL TACOMA MODELS FROM ATLEAST 2001 TO 2004 HAVE SWITCHES THAT LIGHT UP. I DON'T KNOW IF THEY CHANGED THE SWITCH ON THE 2007 OR 2008 TACOMAS. THIS IS A VERY POPULAR TRUCK AND THERE ARE THOUSANDS OF THEM ON THE ROAD. I AM NOT THE ONLY PERSON WHO IS NOT HAPPY ABOUT THIS. THERE ARE A NUMBER TACOMA FORUMS ON THE INTERNET WHERE PEOPLE ARE COMPLAING ABOUT THIS PROBLEM.*CN

NHTSA ID

10213429

Incident

Dec 19, 2007

Mileage

1 mi

TL*-THE CONTACT STATED THAT THE 2006 TOYOTA TACOMA LOST POWER ON A NUMBER OF OCCASIONS. WHILE DRIVING 70 MPH OR AT 5 MPH THE VEHICLE WOULD STALL. THE CONTACT STATED THAT THIS USUALLY HAPPENED WHEN HE HAD TO SHIFT AND USE THE CLUTCH. HE CONTACTED THE MANUFACTURER ,AND WAS GIVEN CASE# 200701040167. HE HAD BEEN TOLD THAT THEY COULDN'T DUPLICATE THE FAILURE. ALSO, HE STATED THAT IN HIS STATE THE LEMON LAW WAS NOT WORTH ANYTHING AFTER 12,000 MILES ,AND HIS VEHICLE NOW HAD 26,000 MILES. THE CONTACT STATED THAT THE VEHICLE HAD THIS STALLING PROBLEM SINCE IT WAS BRAND NEW AT 800 MILES . *AK CONSUMER STATES THE TRUCK STOPS AND WILL NOT RESTART FOR APPROXIMATELY 10 MINUTES. UPDATE *4/23/07TR

NHTSA ID

10185665

Incident

Jan 25, 2006

Mileage

800 mi

WE HAVE HAD TWO INCIDENTS WITH OUR 2006 TOYOTA TACOMA TRUCK; I. MY WIFE, WAS DRIVING ROUTE 40 WHEN AFTER RED LIGHTS THE ENGINE SUDDENLY STARTED SPEEDING UP W/O ANY WARNING OR ALARM. HAVING HER FOOT OFF THE ACCELERATOR PEDAL DIDN'T HAVE ANY IMPACT. SHE HAD TO BRAKE AS MUCH SHE COULD TO CONTROL THE CAR. SHE WAS ABLE TO PULL TO PULL OFF BUT STILL COULDN'T CONTROL THE ENGINE. THE ENGINE DIDN'T EVEN SHUT DOWN WHEN TURNING THE KEY. CHANGING THE SELECTOR LEVER TO NEUTRAL WAS IMPOSSIBLE AS THE ENGINE TOOK FULL RPM. SOMEHOW AFTER SOME "TRIAL AND HORROR" SHE WAS ABLE TO SHUT AND RESTART THE ENGINE AND EVENTUALLY THE CAR WAS BACK IN CONTROL. THE SITUATION HAD BEEN REALLY SCARY. I WASN'T THERE SO I COULD NOT FULLY APPRECIATE WHAT HAD HAPPENED WHEN SHE DESCRIBED THE SITUATION. II. MY WIFE DIDN'T DARE TO USE THE CAR BEFORE I CAME BACK FROM A BUSINESS TRIP. YESTERDAY - SATURDAY 3/10 - I WAS DRIVING THE TRUCK THE FIRST TIME AFTER THE PREVIOUS INCIDENT. THERE WAS A SLOW DOWN IN THE TRAFFIC WHEN SUDDENLY THE ENGINE DID THE SAME AS ABOVE. I WAS ON A MIDDLE LANE AND COULDN'T DO ANYTHING BUT BRAKE AS HARD AS I COULD. HAVING HAZARD LIGHTS ON AND SLOWING THE SPEED CAREFULLY I WAS ABLE STOP ON THE HIGHWAY W/O ANYBODY DRIVING ON US. I SHUT AND RESTARTED THE ENGINE COUPLE OF TIMES W/O ANY IMPACT. EACH TIME ENGINE STARTED AS IF THE ACCELERATOR PEDAL WOULD BE PUSHED DOWN. I STARTED THE CAR AND PUSHING THE BRAKE PEDAL HARD I WAS ABLE TO CONTROL THE TRUCK AND DRIVE TO NEXT RED LIGHTS. AFTER SOME BRAKING AND RESTARTING THE CAR WAS AGAIN SUDDENLY BACK IN CONTROL. THE DEFECT DESCRIBED ABOVE COULD EASILY CAUSE A CRASH WITH SERIOUS INJURY OR EVEN DEATH WHEN HAPPENING IN A HEAVY TRAFFIC OR BAD WEATHER CONDITIONS. WE DON'T DARE TO DRIVE THE TRUCK BEFORE IT IS THE DEFECT IS IDENTIFIED AND FIXED. IT WILL BE IMPORTANT TO UNDERSTAND WHAT CAUSED THE PROBLEM AND HOW IT WAS FIXED. I HAVE NOTIFIED TOYOTA DEALER AND THEY WILL PICK UP THE TRUCK TOMORROW. *JB

NHTSA ID

10184759

Incident

Mar 10, 2007

MY CIGARETTE LIGHTER POPPED OUT OF ITS RECEPTACLE ON TO THE FLOOR OF MY BRAND NEW TRUCK (APPROX. 4,000 MILES) CAUSING A FIRE THAT DESTROYED 75% OF THE INTERIOR. TWENTY MINUTES AFTER THE FIRE WAS PUT OUT I CALLED THE DEALER THAT I BOUGHT THE TRUCK FROM. THEY TOLD ME IT WAS A MANUFACTURING ISSUE AND OFFERED NO HELP. TOYOTA SENT AN INVESTIGATOR TO INSPECT THE TRUCK AND HE DID JUST THAT, FOR ABOUT 4 HOURS. EVENTUALLY THEY SENT A LETTER TO ME (2 MONTHS LATER) THAT SUGGESTED AN OUTSIDE SOURCE COULD HAVE STARTED THE FIRE. *NM

NHTSA ID

10175431

Incident

May 5, 2006

Mileage

4,000 mi

DT*: THE CONTACT STATED WHEN ACCELERATING IN 1ST GEAR AT 15 MPH, THE VEHICLE STALLED ON 9 OCCASIONS. AT OTHER TIMES, THE SHIFTER WOULD NOT GO INTO REVERSE. THERE WAS A CLUNKING NOISE WHEN SHIFTING OCCURRED THAT BECAME CONSTANT AS THE PROBLEM WORSENED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER BUT THE PROBLEM WAS NOT CORRECTED. AN APPOINTMENT WAS SCHEDULED WITH ANOTHER SERVICE DEALER. THE FUEL WARNING LIGHT WAS NOT ACTIVATED AT THE PROPER VOLUME OF FUEL. THESE PROBLEMS HAPPENED SHORTLY AFTER THE CARPETING WAS REPLACED DUE TO WATER LEAKING THROUGH THE FIREWALL. THE MANUFACTURER WAS NOTIFIED. THE CONSUMER STATED THE VEHICLE JUMPED OUT OF PARK AND INTO REVERSE. ON NUMEROUS OCCASIONS THE TRUCK STALLED. UPDATED 12/18/06. *JB

NHTSA ID

10171093

Incident

Oct 16, 2006

Mileage

6,242 mi

DT*: THE CONTACT STATED WHILE DEPRESSING THE ACCELERATOR PEDAL, THE THROTTLE STICKS. AFTER THE THROTTLE STICKS, THE RPM'S RANGE HIGH AND DO NOT DECREASE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. ALTHOUGH, THE DEALER KNEW THE PROBLEM PERSISTED WITH THE SPEED CONTROL AND THE ELECTRICAL SYSTEM, THE PROBLEM COULD NOT BE REMEDIED BY THE DEALER. UPDATED 03/28/06. *JB

NHTSA ID

10152011

Incident

Mar 6, 2006

Mileage

12 mi

DT: THE CONTACT STATES WHEN STARTING THE VEHICLE IN THE MORNING THE IDLE WAS HIGH. IT TOOK APPROXIMATELY ONE TO ONE AND A HALF MILES OF DRIVING FOR THE IDLE TO RETURN TO NORMAL. THE ACCELERATOR PEDAL STUCK. WHEN SHIFTING FROM FOURTH GEAR TO FIFTH WITHOUT FOOT ON THE ACCELERATOR THE VEHICLE ACCELERATED ON ITS OWN. SHE STATED THAT FOURTH GEAR COULD NOT BE USED. THE VEHICLE MUST BE SHIFTED FROM THIRD GEAR TO FIFTH GEAR. THE VEHICLE HAS BEEN TO THE DEALERSHIP TWICE, AND THEY STATED THE COMPUTER WAS LEARNING. THE MANUFACTURER WAS CONTACTED, AND THEY AGREED WITH THE DEALERSHIP. THEREFORE, NO REPAIRS HAVE BEEN MADE . *AK UPDATED 01/25/06

NHTSA ID

10145889

Incident

Nov 18, 2005