2006 Toyota Tacoma Fuel system Problems

THE ENTIRE FRAME OF THIS GARAGE KEPT TRUCK IS COMPLETELY RUSTED THOUGH. THIS TRUCK AS ONLY 61,000 MILES ON IT & IS UNSAFE TO DRIVE. THE REAR LEAF SPRING MOUNTS ARE BROKEN & HAVE PUNCTURED THE GAS TANK. THE ELECTRICAL WIRING TO DO WITH THE SAFETY NEUTRAL SWITCH, WHICH IS TIED INTO THE ENTIRE FROM WIRING HARNESS HAS CAUGHT FIRE TWICE. TOYOTA HAS BEEN NOTIFIED ABOUT ALL OF THIS, IN DETAIL, & THEY COULD CARE LESS ABOUT MY OWN OR ANYONE ELSE'S SAFETY. THERE ISN'T A SCRATCH ON THIS TRUCK & HAS REALLY LOW MILES YET IS SO UNSAFE TO USE BECAUSE OF POOR CONSTRUCTION ON TOYOTA'S PART.

NHTSA ID

11315970

Incident

Jan 2, 2020

Mileage

61,000 mi

MY TACOMA IS A LEASURE/WORK VEHICLE, GARAGED AND MAINTAINED WITH 65K MILES. WITHIN THIS MONTH I HAD A MAIN EXHUAST HANGER THAT WAS WELDED TO THE FRAME BREAK AWAY AND TAKE A LARGE PART OF THE FRAME WITH IT, THEN THANKS TO MY WIFE SHE NOTICED AN ODDITY UNDER THE BED AND IT WAS THAT 2 OF MY GAS TANK STRAPS HAD BROKEN. I INFORMED THE LOCAL DEALER (KOLAR) AND TOYOTA, THEY RESPONDED BY SAYING THAT DUE TO ITS ADVANCED YEARS, THEY WOULD NOT HELP AND ARE NOT RESPONSIBLE. IF I HAD BEEN TRAVELING DOWN I35 TO THE CITIES AT 85 MPH AND THE TANK CAME OFF, AND IT STRUCK MY OR ANOTHER VEHICLE THIS NOTE WOULD BE WORDED VERY DIFFERENTLY. I WILL PROVIDE PHOTOS, BUT I AM YET TO GET MY VEHICLE RELEASED FROM TOYOTA, NOT SURE HOW THAT WORKS, THEY WILL NOT RELEASE IT TO ME UNTIL IT IS SAFE AND THEY WOULD NOT COVER THE COSTS.

NHTSA ID

11244168

Incident

Aug 1, 2019

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 35 MPH, A LOUD NOISE EMITTED FROM UNDERNEATH THE VEHICLE. AFTER REACHING THE DESTINATION, THE CONTACT NOTICED THAT THE REAR FUEL TANK STRAP FRACTURED DUE TO RUST CORROSSION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

NHTSA ID

10860069

Incident

Apr 17, 2016

Mileage

35,000 mi

CAR AT APPROXIMATELY 2 MPH AT INDOOR PARKING GARAGE. MY FOOT WAS NOT ON THE GAS PEDAL WHEN CAR ACCELERATED SUDDENLY. TURNED IGNITION OFF AND WAS ABLE TO STOP CAR BEFORE IMPACT WITH SEVERAL OTHER VEHICLES.

NHTSA ID

10785787

Incident

Oct 23, 2015

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 25 MPH, THE FUEL TANK STRAP FRACTURED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10630827

Incident

Aug 31, 2014

Mileage

230,000 mi

ON OCTOBER 2013 I APPROACHED A RED LIGHT (NO CAR IN FRONT OF ME) THE ROAD SURFACE WAS WET AND THE ABS KICKED IN. WHEN I APPLIED THE BRAKE HARD, THE ENGINE STARTED TO ACCELERATE AND I COULDN'T HOLD THE TRUCK BACK. I WENT THROUGH THE RED LIGHT AVOIDING AN ACCIDENT. I CALLED THE TOYOTA DEALER AND WAS TOLD THAT I PROBABLY DID NOT PRESS DOWN ON THE BRAKE HARD ENOUGH. ON JANUARY 2014 THE SAME THING OCCURRED. HERE AGAIN I WAS FORTUNATE THAT ANOTHER VEHICLE WAS NOT IN FRONT OF ME AND THIS TIME I WENT THROUGH A STOP SIGN. I CALLED THE DEALER AND HAD IT CHECKED OUT. THEY FOUND NOTHING WRONG. MARCH 15TH IT HAPPENED AGAIN. ONCE AGAIN I WAS LUCKY THAT NO VEHICLE WAS IN FRONT OF ME, BUT I NOW BRAKE WAY IN ADVANCE OF A LIGHT OR STOP SIGN BECAUSE OF FEAR. THIS TIME WHEN THE ENGINE STARTED TO ACCELERATE I GOT OFF THE BRAKE AND WENT RIGHT BACK ON AND THE ENGINE STOPPED ACCELERATING. I ONCE AGAIN PUT IT IN THE GARAGE AND THEY FOUND NOTHING WRONG. I THINK THAT THE UNINTENTIONAL ACCELERATION IS TRIGGERED WHEN HARD PRESSURE IS APPLIED TO THE BRAKES WHEN THE ABS KICKS IN. I'M NOT A ROOKIE DRIVER. I'VE BEEN DRIVING TACOMAS FOR OVER 30 YEARS. THIS IS MY 4TH ONE. AFTER HAPPENING THREE TIMES, IT IS DEFINITELY A PROBLEM WITH THE TRUCK. THIS IS A POSSIBLE SERIOUS ACCIDENT WAITING TO HAPPEN. WHAT CAN I DO TO GET TOYOTA TO CORRECT THIS PROBLEM? THANK YOU *TR

NHTSA ID

10574601

Incident

Oct 16, 2013

Mileage

75,000 mi

TOYOTA DEALER AVOIDING MANDATED ACCELERATOR PEDAL REPAIR TO 2006 TOYOTA TACOMA. ON THREE DIFFERENT OCCASIONS MY LOCAL TOYOTA DEALER HAS EITHER NOT RECEIVED PARTS, OUT OF PARTS OR WILL REQUIRE ME TO LEAVE THEM THE CAR FOR AN UNSPECIFIED TIME (WHILE PROVIDING ME WITH NO ALTERNATIVE TRANSPORTATION). I SUSPECT, BUT HAVE NO PROOF, THAT THIS TOYOTA DEALER ATTEMPTING TO AVOID PERFORMING THE MANDATED REPAIR. I AM READY TO RE-SELL THIS TRUCK BUT WOULD LIKE TO HAVE THIS MANDATED REPAIR PERFORMED. *TR

NHTSA ID

10421383

Incident

Aug 24, 2011

STUCK GAS PEDAL ON MY TACOMA TRUCK. *TR

NHTSA ID

10320969

Incident

Mar 14, 2009

Mileage

50,000 mi

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). I HAVE FILED A COMPLAINT WITH CONSUMER AFFAIRS AS WELL AS TOYOTA EXPERIENCE REGARDING THE GAS PEDAL / FLOOR MAT ISSUE. THIS HAS OCCURRED TWO TIMES TO MYSELF AS WELL AS THREE TIMES TO MY HUSBAND, THANKFULLY IT DID NOT RESULT IN ANY INJURIES. I WANT MY FLOOR MATS REPLACED AT THE LEAST, MY FLOOR IS DAMAGED BY NOT BEING ABLE TO USE MATS AND THE FEAR OF IT TALKING OFF REALLY PREVENTS ME FROM DRIVING IT WITHOUT EXTREME CAUTION AND CONSTANT WORRYING. I WAS GIVEN A CUSTOMER CASE # 1002131342 AND WAS TOLD TO SPEAK WITH MARISOL BETANCOURT BECAUSE THEY WERE UNDER THE IMPRESSION THAT THERE WERE SOME NEW MATS AVAILABLE BUT THIS WAS THE RESPONSE I RECEIVED FROM: ---- MARISOL BETANCOURT [XXX] WROTE: ============= [XXX] I SPOKE TO YOU ON THE PHONE REGARDING YOUR CONCERN ABOUT YOUR VEHICLE'S PEDAL AND FLOOR MATS. THE SERVICE WRITER NAMED KEVIN HOLLINGER PULLED YOUR VEHICLE'S VIN NUMBER TO SEE IF IT WAS UNDER RECALL AND HE INFORMED ME THAT YOUR VEHICLE IS NOT UNDER RECALL. IF YOU HAVE FURTHER QUESTIONS PLEASE FEEL FREE TO CONTACT KEVIN HOLLINGER OR MYSELF. THANK YOU, MARISOL BETANCOURT CUSTOMER RELATIONS MANAGER TOYOTA CHULA VISTA [XXX] ++++++++++++++++++++++++++++++++++++++++++++++++

NHTSA ID

10317240

Incident

Oct 31, 2008

IN LATE MAY 2009 WHILE ON HIGHWAY 50 IN SACRAMENTO JUST EAST OF THE 50/80 INTERCHANGE IN GOOD WEATHER (DRY AND CLEAR) MY 2006 TOYOTA TACOMA'S GAS PEDAL BURIED ITSELF TO THE FLOOR AND THE VEHICLE WENT TO MAXIMUM ACCELERATION. BRAKING ONLY HAD A SLIGHT INITIAL EFFECT AND THEN OVERHEATED AND FADED. AFTER A LUCKY 4 MILES I SHIFTED TO NEUTRAL AND THE PROBLEM RESOLVED. THIS BEGAN AROUND 60MPH AND MAXED AROUND 107. DURING THE 4 MILES I ACTIVATED AND DEACTIVATED MY CRUISE SEVERAL TIMES, TAPPED THE BRAKES, REACHED DOWN AND PULLED ON THE PEDAL AND THE MAT, THE RECENT TOYOTA EXPLANATIONS OF STICKING PEDAL AND MAT ISSUES DID NOT APPLY AND I FIND THEM LUDICROUS.. IT IS AN EERIE FEELING TO HAVE YOUR ACCELERATOR LEAVE YOUR FOOT ON ITS OWN. TRUCK HAD 36,500 MILES, NEVER IN AN ACCIDENT, WAS IN GOOD REPAIR WITH REGULAR MAINTENANCE AND WAS STOCK EXCEPT FOR A SHELL. WHILE OWNED THE TRUCK HAD EXPERIENCED THE AT STOP SURGE DESCRIBED BY MANY OTHERS WHERE IT FELT LIKE SOMEONE TAPPED THE BACK OF THE TRUCK WHILE WAITING IN AN INTERSECTION. LOVED THE TRUCK UNTIL THAT DAY, AND RESPECTED TOYOTA. HAD THIS HAPPENED ON ANOTHER ROAD OR WITH HEAVIER TRAFFIC IT WOULD HAVE HAD A DIFFERENT OUTCOME. TRADED THE VEHICLE TWO WEEKS LATER AT GREAT LOSS OF EQUITY. SOMEONE ELSE NOW OWNS THIS VEHICLE. *TR

NHTSA ID

10312361

Incident

May 18, 2009

Mileage

36,500 mi

TL*THE CONTACT OWNS A 2006 TOYOTA TACOMA PICKUP TRUCK. SINCE THE VEHICLE WAS PURCHASED HE SMELLED FUEL INSIDE OF THE VEHICLE AFTER STARTING IT. THE DEALER COULD NOT DUPLICATE THE FAILURES. THE VEHICLE WAS TAKEN BACK TO THE DEALER TO REPAIR THE VEHICLE; HOWEVER, THE CONTACT DOES NOT KNOW WHAT COMPONENT WAS REPAIRED. HE ALSO STATED THE DRIVER'S SIDE SEAT BELT SENSOR FAILED AND THE SEAT BELT OFF WARNING LIGHT ILLUMINATED ON THE WARNING PANEL. THE DEALER CONFIRMED THAT THE SENSOR HAD FAILED. NO REPAIRS WERE MADE TO THE SEAT BELT. THE FAILURE AND CURRENT MILEAGES WERE UNDER 65,000.

NHTSA ID

10306568

Incident

Jan 10, 2010

Mileage

65,000 mi

THE TRUCK ACCELERATED AND WOULD NOT STOP I HAD BOTH FEET ON THE BRAKES THEY WAS AS HARD AS A ROCK AND THE TRUCK KEPT ACCELERATING ,I WAS ON A TWO LANE ROAD. I WAS COMING QUICKLY UPON CARS IN FRONT OF ME AND I PUT THE GEAR SHIFT IN 3RD OUT OF DRIVE AND BACK IN ,AND TRUCK ENGINE CAME BACK UNDER MY CONTROL . ENGINE CAME DOWN BUT ,A LITTLE LATER THE BRAKES WOULD NOT STOP THE TRUCK. I MANAGED TO GET IT HOME AND I AM AFRAID TO DRIVE IT. I CALLED TOYOTA AND THEY SAID I HAD TO DRIVE IT TO ONE OF THEIR DEALERS OR THEY CAN NOT HELP ME.I AM AFRAID TO DRIVE IT WHAT SHOULD I DO I DO NOT WANT TO HURT MYSELF OR SOME ONE ELSE IT HAS NOTHING TO DO WITH THE FLOOR MAT. I ASK THE LADY IF SHE WOULD PROMISE ME IT WOULD NOT HAPPEN ON THE WAY TO THE DEALERS SHE WOULD NOT I ASK HER IF THEY WOULD TOW IT SHE SAID AT MY EXPENSE. I REFUSED AND SHE HUNG UP THE PHONE. SHE CALLED ME BACK ON DEC 21 AND SAID SHE HAD CONTACTED TOYOTA LAWYERS AND THEY CAN NOT HELP ME. I NEED MORE INFORMATION ON WHAT TO DO IF YOU CAN HELP ME . *TR

NHTSA ID

10296591

Incident

Dec 16, 2009

Mileage

64,902 mi

PROBLEM: THROTTLE HUNG IN A WIDE-OPEN POSITION WHILE DRIVING. NO CARPET PROBLEM WAS INVOLVED. THIS HAS HAPPENED TWICE TO ME IN A TWO WEEK SPAN!!! I WOULD LIKE TO REPORT A SERIOUS PROBLEM WITH MY 2006 TACOMA. ON 10/29/09 WHILE TOWING A TRAILER I EXPERIENCED THE FIRST OCCURRENCE. I HAD TWO PASSENGERS WITH ME THAT CAN ATTEST TO THE TRUTH OF MY SITUATION. I DEPRESSED THE THROTTLE AND THE MOTOR SUDDENLY WENT TO A WIDE-OPEN POSITION. FORTUNATELY, I WAS NOT IN HEAVY TRAFFIC. I ATTEMPTED TO SLOW THE TRUCK WITH BRAKES ALONE BUT THEY COULD NOT STOP THE ACCELERATION OF THE TRUCK. MY ONLY THOUGHT WAS TO TURN OFF THE IGNITION. I DID SO AND BROUGHT THE TRUCK AND TRAILER TO A SAFE STOP ALTHOUGH IT WAS VERY DIFFICULT WITHOUT THE POWER BRAKES BEING ACTIVE ALONG WITH THE FACT THAT I WAS ALSO TOWING A TRAILER. I CHECKED THE THROTTLE AND GAS PEDAL CONNECTIONS AND FOUND NO OBVIOUS PROBLEMS. I THEN ATTEMPTED TO RESTART THE TRUCK TO SEE IF POSSIBLY THE COMPUTER CLEARED ITSELF. WHEN I TURNED ON THE IGNITION, THE MOTOR STARTED AND INSTANTLY WENT INTO A FULL-OPEN THROTTLE MODE. I SHUT IT OFF BEFORE IT REACHED A VERY HIGH LEVEL. WE THEN CHECKED ALL THE SAME THINGS WE ALREADY CHECKED AND I DECIDED TO TRY STARTING THE TRUCK AGAIN. THIS TIME, IT STARTED AND RAN LIKE NOTHING EVER WAS WRONG. WE DROVE THE TRUCK HOME WITH NO OTHER PROBLEMS. I BROUGHT THE TRUCK TO MY LOCAL TOYOTA DEALER WHERE I HAD PURCHASED IT. THEY INSPECTED BOTH THE THROTTLE BODY, ENGINE CODES, AND TEST DROVE IT AND TOLD ME THAT THEY COULD FIND NOTHING WRONG. I WAS SENT ON MY WAY WITH NO CHARGE TO ME. THEY GAVE ME NO PAPERWORK AS I NORMALLY GET BUT I DID CONFIRM THAT THIS COMPLAINT WAS PUT INTO THEIR COMPUTER SYSTEM. THIS SAME PROBLEM HAPPENED TO ME ONCE MORE ON 11/02/09 WHICH ALSO HAPPENED TO BE MY BIRTHDAY. I FEEL EXTREMELY FORTUNATE TO NOT HAVE BEEN INVOLVED IN ANY ACCIDENT TO DATE BUT I MUST TELL YOU THAT I DO NOT FEEL SAFE DRIVING THIS VEHICLE AT THE PRESENT TIME. REF. TOYOTA NATIONAL HEADQUARTERS FILE #0911125974. *TR

NHTSA ID

10293928

Incident

Oct 29, 2009

Mileage

47,500 mi

2006 TOYOTA TACOMA 2.7 LITER ENGINE. PURCHASED AND @ 42K MILES FUEL SMELL ENTERS CABIN. I DOES NOT HAPPEN ALL THE TIME BUT SUSPECT THE AIR INJECTED EXHAUST SYSTEM A FAILURE. THE SMELL OF FUEL IS SO BAD I HAVE TO STOP AND REMOVE EVERYONE FROM VEHICLE DUE TO NAUSEA, AND LIGHT HEADED. *TR

NHTSA ID

10275839

Incident

Aug 16, 2008

Mileage

42,000 mi

TL*THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE VEHICLE CAUGHT FIRE DUE TO THE FUEL TANK AND FUEL LINE WHILE TRAVELING 65 MPH. THE VEHICLE WAS COMPLETELY DESTROYED. THE CONTACT WAS UNSURE IF THERE WAS PROPERTY DAMAGE. A FIRE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 3,000. THE CONSUMER PROVIDED AN INCIDENT REPORT. UPDATED 06/08/07 *TR

NHTSA ID

10190403

Incident

Mar 24, 2007

Mileage

3,000 mi

APPLIED BRAKE PEDAL AS I APPROACHED AN INTERSECTION WITH A RED LIGHT AND COULD NOT STOP, CAUSING MY VEHICLE TO REAR END A STOPPED VEHICLE. MY VEHICLE ALSO PICKED UP ACCELERATION WHEN I APPLIED THE BRAKE A SECOND TIME. I HAD TO SHUT THE VEHICLE OFF IN ORDER TO STOP IT FROM CLIMBING UP THE REAR OF THE VEHICLE AHEAD OF ME. POLICE OFFICER AT THE SCENE VERIFIED THIS OBSERVATION AFTERWARD INDICATING A MECHANICAL PROBLEM AND NOTED SAME ON THE POLICE REPORT. MY BRAND NEW VEHICLE WAS PURCHASED LESS THAN TWO WEEKS BEFORE THIS ACCIDENT, TOWED BACK TO THE DEALERSHIP AFTER THE ACCIDENT AND REMAINS THERE AWAITING AN INSPECTION BY THE MANUFACTURER. *JB

NHTSA ID

10165368

Incident

Jul 27, 2006