2000 Toyota Tundra Transmission Problems

TL* THE CONTACT OWNS 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT ALSO ATTEMPTED TO SHIFT INTO PARK AND THE GEAR SHIFTER FRACTURED IN HIS HAND. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE GEAR SHIFT SELECTOR WOULD NOT FULLY SHIFT INTO PARK. THE CONTACT STATED THE SHIFTER WAS RUSTED FROM THE INSIDE OF THE STEERING COLUMN. THE DEALER INSPECTED THE VEHICLE AND ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY TWO COMPONENTS THAT WOULD NEED REPAIRS. THE CONTACT WAS UNABLE TO RECALL THE NAME OF THE COMPONENTS. THE MANUFACTURER WAS CONTACTED BUT WOULD PROVIDE NO ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 180,000.

NHTSA ID

10365788

Incident

Sep 28, 2010

Mileage

180,000 mi

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 45-50 MPH HE HEARD A LOUD NOISE AND THE LEFT REAR SPRING BROKE WHICH CAUSED THE VEHICLE TO STOP IMMEDIATELY. HE ENGAGED THE ACCELERATOR PEDAL AND HEARD ANOTHER LOUD NOISE AND COASTED THE VEHICLE INTO A PARKING LOT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER ADVISED HIM THAT IT WOULD BE 3 MONTHS BEFORE THEY COULD REPAIR HIS VEHICLE BECAUSE OF THE BACK LOG OF RECALLS. THE DEALER PERFORMED THE RECALL WORK ON HIS VEHICLE ON AUGUST 23, 2010; RECALL 09V444000, STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS. AS HE WAS DRIVING FROM THE DEALERSHIP HE ENGAGED THE BRAKES AND THE BRAKE PEDAL WENT TO THE FLOOR; HE INFORMED THE SERVICE MANAGER OF THE FAILURE. THE SERVICE MANAGER ADVISED THE TECHNICIANS TO CLEAN, ADJUST THE REAR BRAKES AND RELIEVE SOME TENSION ON THE PARKING BRAKE CABLE. THE FOLLOWING DAY THE DEALER ADVISED HIM THAT THE TRANSMISSION WAS FAILING AND NEEDED TO BE REPLACED. THE VEHICLE REMAINED AT THE DEALER WAITING FOR THE PARTS TO BE AVAILABLE. THE FAILURE MILEAGE WAS 102,168 AND THE CURRENT MILEAGE WAS 102,192.

NHTSA ID

10353470

Incident

May 24, 2010

Mileage

102,168 mi

8/3/2009 - STEERING RACK LOST ALL FLUID WHILE DRIVING ON A HIGHWAY. ABLE TO MAINTAIN CONTROL, BROUGHT TO MECHANIC WHO REPLACED STEERING RACK. 09/08/2009 - FRONT BRAKE LINES CORRODED THRU AND LOST ALL BRAKE FLUID WHILE DRIVING,BROUGHT TO MECHANIC WHO REPLACED FRONT AND REAR BRAKE LINES AS ALL REQUIRED REPLACEMENT. 09/11/2009 - SHIFT CABLE FAILED (CORROSION) - ABLE TO GET OFF THE ROAD AND TOWED TO MECHANIC. FRAME AND UNDERBODY OF THIS TRUCK HAVE EXCESSIVE CORROSION WHICH LED TO THESE FAILURES. THE INTEGRITY AND SAFETY OF THIS VEHICLE IS QUESTIONABLE. *TR

NHTSA ID

10293725

Incident

Aug 3, 2009

Mileage

71,200 mi

AT 78,000 MILES THE TRANSMISSION BEGAN MAKING A NOISE AND VIBRATION THAT UPON FIRST IMPRESSION SOUNDED AND FELT LIKE RUNNING INTO A POTHOLE. THE TRUCK WOULD ALSO, INTERMITTENTLY FAIL TO GO INTO REVERSE GEAR. AFTER DROPPING THE TRANSMISSION PAN IT WAS DETERMINED THAT THE PAN HAD SEVERAL CLUMPS OF METAL SHAVINGS AND THE TRANSMISSION HAS TO BE REPLACED. THIS IS AN EGREGIOUS MECHANICAL FAILURE ON A VEHICLE WITH LOW MILEAGE AND WELL MAINTAINED. *TR

NHTSA ID

10283800

Incident

Sep 5, 2009

Mileage

38,600 mi

VEHICLE WOULD STUTTER OR JERK OCCASIONALLY OVER A THREE WEEK PERIOD OF TIME/APPROX 500 MILES OF DRIVING. WHILE TURNING INTO DRIVEWAY VEHICLE SHUT DOWN AND WOULD NOT SHIFT OUT OF DRIVE. TORQUE CONVERTER WAS LOCKED UP REQUIRING A NEW TRANSMISSION. *TR

NHTSA ID

10269438

Incident

May 1, 2002

Mileage

40,000 mi

AT 80,000 MILES MY TRANSMISSION NEEDS TO BE REPLACED . I HAVE NEVER ABUSED THIS VEHICLE IN ANY FORM AND FEEL THAT TOYOTA SHOULD REIMBURSE THE MANY THOUSANDS OF OWNERS WHO SEEM TO BE HAVING THE SAME PROBLEMS WITH THIS MODEL. FOR THE AMOUNT OF MONEY THESE VEHICLES COST IT ONLY SEEMS FAIR THAT TOYOTA SHOULD BE FORCED TO STAND BEHIND THEIR PRODUCTS. *TR

NHTSA ID

10261894

Incident

Oct 10, 2008

Mileage

80,000 mi

THE TRANSMISSION OCCASIONALLY MADE A CLUNKING NOISE AND FELT LIKE THE TIRE HIT A SMALL POTHOLE IN THE ROAD WHEN SHIFTING INTO OVERDRIVE. THIS STARTED AROUND 80,000 MILES. I HAD THE TRANSMISSION FLUID CHANGED AND THE TRANSMISSION PAN DROPPED. THE PAN MAGNETS HAD MOSTLY SMALL METAL SHAVINGS BUT ALSO A FEW LARGER PIECES AROUND 1/4" LONG. NOW AT 85,000 MILES THE TRANSMISSION MAKES A VERY LOUD THUD NOISE AND SHAKES THE TRUCK VIOLENTLY EVERY TIME IT SHIFTS INTO OVERDRIVE. I AM FORCED TO KEEP THE TRUCK IN 3RD GEAR UNTIL I REACH THE FREEWAY AND THEN MUST PRESS THE O/D SWITCH TO SHIFT INTO 4TH GEAR/OVERDRIVE. MY MECHANIC WILL BE REPLACING THE TRANSMISSION NEXT WEEK AS HE HAS BEEN ON VACATION. I CANNOT BELIEVE THAT THE TRANSMISSION MUST BE REPLACED AT ONLY 85,000 MILES! I AM A CAREFUL DRIVER AND CONSCIENTIOUS ABOUT MAINTENANCE. *TR

NHTSA ID

10260016

Incident

Nov 1, 2008

Mileage

85,000 mi

2000 TOYOTA TUNDRA 2WD 4.7L V8 AUTOMATIC SR5 EXTENDED CAB 1. TRANSMISSION NOISE AND TRANSMISSION "BUMP" WHEN STARTING OUT FROM STOP. IT OCCURRED FROM APPROX 10,000MI (CURRENTLY 93,000 MI) 2. EVENTUAL COMPLETE FAILURE OF THE DEFECTIVE TRANSMISSION OVERDRIVE GEAR AND TRANSMISSION LOCKUP, LEADING TO SKID AND NEAR CRASH. 3. TOYOTA SERVICE PACKED GREASE IN U JOINT. ONLY SOFTENS BUMP AND NOISE FOR 100MI THEN BACK TO SAME PROBLEMS. REPAIR ESTIMATED AT $5000.00+. *TR

NHTSA ID

10243053

Incident

Sep 19, 2008

Mileage

93,000 mi

MY TOYOTA TUNDRA'S PLANETARY GEAR EXPLODED WITHIN THE TRANSMISSION AND DISABLE THE VEHICLE COMPLETELY. THE TRANSMISSION WAS IN OTHERWISE PERFECT CONDITION. IT LEFT ME STRAND ON 2 SEPARATE OCCASIONS WITHOUT ANY PRE-NOTICE THAT THE TRANSMISSION WAS HAVING ANY ISSUES. *TR

NHTSA ID

10214085

Incident

Jan 5, 2008

Mileage

117,000 mi

2000 TOYTA TUNDRA AUTOMTIC TRANSMISSION FAILURE. *TR

NHTSA ID

10213006

Incident

Dec 24, 2007

Mileage

48,000 mi

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 55 MPH, THE GEAR SHIFT INDICATOR SLIPPED OUT OF GEAR AND INTO NEUTRAL. THE MECHANIC STATED THAT THE TRANSMISSION FAILED. AS OF OCTOBER 9, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CONTACT FELT THAT THE TRANSMISSION FAILED PREMATURELY. THE CURRENT AND FAILURE MILEAGES WERE 108,000. UPDATED 10/24/07.*JB

NHTSA ID

10205260

Incident

Oct 5, 2007

Mileage

108,000 mi

I BOUGHT MY TRUCK AND ABOUT THREE WEEKS AGO I WAS DRIVING ALONG WHEN IT DIED. ANYTIME I CAME TO A FULL STOP IT DIED. TURNS OUT IT'S THE TRANSMISSION AND A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM. TOYOTA REFUSES TO ISSUE A RECALL ON THEIR PLANETARY GEAR EVEN THOUGH IT MALFUNCTIONS. THIS FAILURE CAUSED MY TRUCK TO STOP IN A BUSY INTERSECTION AND ALMOST KILLED ME. *TR

NHTSA ID

10198770

Incident

Jul 18, 2006

Mileage

81,000 mi

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 5 MPH, THE VEHICLE STOPPED ACCELERATING. THE DEALER STATED THAT THE SHIFT SOLENOID COULD BE THE CAUSE OF FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE OVERDRIVE GEAR CLUSTER WAS NOT WORKING PROPERLY. AS OF JUNE 27, 2007, THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 145,000 AND FAILURE MILEAGE WAS 144,000.

NHTSA ID

10194742

Incident

Jun 13, 2007

Mileage

144,000 mi

2000 TOYOTA TUNDRA SHIFT ASSEMBLY FAILURE**CC THE CONSUMER STATED THE SHIFT LEVER BROKE. *JB

NHTSA ID

10181585

Incident

Nov 24, 2006

DT*: THE CONTACT STATED THE SHIFT LEVER DISINTEGRATED OFF THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THEY WOULD NEED TO REPLACE A BRACKET TO FIX THE SHIFT LEVER. THE VEHICLE WAS STILL AT THE DEALER AWAITING THE REPAIR WORK. THE CONSUMER STATED THE SHIFTER SHATTERED WITHOUT WARNING AND WAS UNABLE TO PLACE THE VEHICLE IN GEAR. UPDATED 12/18/06. *JB THE CONSUMER STATED THE PROBLEM WITH THE ACCELERATOR BEGAN IN SUMMER OF 2005. HE STARTED THE VEHICLE STEPPED ON THE ACCELERATOR AND NOTHING HAPPENED. HE THEN DEPRESSED THE ACCELERATOR PEDAL TO THE FLOOR AND THE TRUCK LUNGED FORWARD. ONLY BY CAREFULLY PUMPING THE GAS PEDAL UP AND DOWN WAS HE ABLE TO ATTAIN APPROXIMATELY 40 MPH. THE SEARCHED THE INTERNET TO SEE IF OTHERS HAD EXPERIENCED THE PROBLEM. WITHIN IN A SHORT PERIOD OF TIME, HE FOUND SOMEONE ELSE WHO EXPERIENCED THE SAME PROBLEM. IT WAS CAUSED BY A LOOSE CONNECTION WHERE THE ACCELERATOR PEDAL POSITION SENSOR WIRE CONNECTS TO ITS FEMALE CONNECTOR. WHICH WAS LOCATED ON TOP OF THE ENGINE. THE CONSUMER LOOKED AT THE CONNECTOR AND IT SEEMED CONNECTED. HE PUSHED THE CONNECTOR DOWN HARD AND TO HIS ASTONISHMENT IT CLICKED INTO PLACE. WHICH SOLVED THE PROBLEM. THE CONSUMER STATED TWO YEARS LATER, THE SAME PROBLEM PRESENTED ITSELF AGAIN. ONCE HE ARRIVED HOME, HE CLICKED THE ELECTRICAL CONNECTOR SECURELY IN PLACE. HE USED SOME COPPER ELECTRICAL WIRE AND WIRED THE CONNECTOR FIRMLY IN PLACE. THE CONSUMER STATED HIS BEST GUESS TO THE PROBLEM WITH THE CONNECTOR: WAS THE DESIGN OF THE PLASTIC WAS FAULTY. THE PLASTIC TAB WASN'T LARGE ENOUGH TO HOLD IT SECURELY IN THE SOCKET AND OVER TIME, ROAD VIBRATION CAUSED IT TO COME LOOSE. ALSO, THE STARTER FAILED. UPDATED 03/08/10

NHTSA ID

10174197

Incident

Nov 24, 2006

Mileage

90,000 mi

AUTOMATIC TRANSMISSION TRANSMISSION ON THE TUNDRA TRUCK IS A KNOWN PROBLEM, EXPERIENCED BY THOUSANDS OF TUNDRA OWNERS ACROSS THE COUNTRY, AND YET TOYOTA FAILS TO ADMIT THE PROBLEM AND HELP OWNERS WITH THE COST OF REPAIR. THE TRANSMISSION ON MY 2000 TUNDRA NEEDS TO BE REPLACED DUE TO ABRUPT GEAR SHIFTING WHICH CAUSE THE TRUCK TO LUNGE FORWARD. I'VE COMPLAINED TO TOYOTA AND THEIR ANSWER WAS " YOUR TRUCK IS OUT OF WARRANTY". I'VE BEEN A TOYOTA OWNER FOR 15 YEARS, BUT AFTER THIS EXPERIENCE I WILL NOT BUY ANOTHER TOYOTA. *NM

NHTSA ID

10168717

Incident

Aug 12, 2006

Mileage

102,000 mi

DT*: THE CONTACT STATED THE COLUMN GEAR SHIFT WAS PLACED INTO PARK ATOP A HILL WITH THE EMERGENCY BRAKE ENGAGED AND THE ENGINE RUNNING, THE VEHICLE ROLLED FORWARD AND CRASHED INTO A TREE. AFTER INITIAL PARKING OF THE VEHICLE, THE CONTACT EXITED THE VEHICLE. WHILE ATTEMPTING TO REENTER THE VEHICLE AND STOP THE FORWARD MOTION INJURIES WERE SUSTAINED. THE VEHICLE ROLLED DOWNHILL 60-70 YARDS AND TOTALED DUE TO THE EXTENSIVE DAMAGE. AFTER THE CRASH, THE CONTACT INSPECTED THE VEHICLE AND THE COLUMN GEAR SHIFT WAS IN PARK AND THE EMERGENCY BRAKE WAS STILL ENGAGED. THE VEHICLE WAS NOT SEEN BY AN AUTHORIZED DEALER OR REPAIR SHOP. UPDATED 03/28/06. *JB

NHTSA ID

10148560

Incident

Jan 19, 2006

Mileage

81,400 mi

2000 TOYOTA TUNDRA 65,000 MILES. OUT OF WARRANTY. THE ORBITAL GEAR IN THE TRANSMISSION BLEW UP. THIS GEAR HAS BEEN DISCONTINUED BY TOYOTA ,AND REPLACED WITH A MORE HEAVY DUTY GEAR. THIS IS A DEFECT OF THE TRANSMISSION. MANY TUNDRA OWNERS ACROSS THE COUNTRY ARE HAVING THE SAME PROBLEM. TOYOTA HAS TURNED THEIR BACKS TO THIS PROBLEM. THIS IS A $3000.00 REPAIR JOB. *AK

NHTSA ID

10118619

Incident

Dec 2, 2004

Mileage

65,000 mi

THE SHIFT LEVER BROKE OFF, DISCONNECTED FROM THE STEERING COLUMN AT ABOUT 21000 MILES. AFTER I PARKED THE TRUCK, I WAS NOT ABLE TO SHIFT IT TO REVERSE OR ANY OTHER GEAR. I HAD THE VEHICULE TOWED TO A DEALER AND THEY REPLACED THE SHIFT LEVER, TUBE STEERING, SUPPORT TILT MECHANISM, AND SHAFT CONTROL. (COVERED UNDER WARRANTY) AT 44, 000 MILES. THE EXACT SAME PROBLEM HAPPENED. I TALKED TO THE DEALER AND TO A TOYOTA CORPORATE REPRESENTATIVE, THEY STATED SINCE MY VEHICULE IS OUT OF WARRANTY, THERE WAS NOTHING THEY COULD DO FOR ME. I FEEL TOYOTA SHOULD COVER THE COST OF THE REPAIR SINCE THIS IS A RECCURING PROBLEM THAT IS PART OF THE DRIVE TRAIN. THE SHIFT LEVER IS A PART THAT SHOULD LAST THE LIVE CYCLE OF THE VEHICULE. THEY ARE WELL AWARE OF THE DEFFECT ; THEY SHOULD BEAR THE COST. *AK

NHTSA ID

10112586

Incident

Mar 3, 2005

Mileage

44,000 mi

TRUCK LURCHES AT TIMES WHEN STOPPING, DOWNSHIFTS ARE SOMETIMES HARD. I'VE HAD SEVERAL DEALERS LOOK AT IT, AND THEY HAVE SAID IT'S "FINE". THERE IS NO TRANSMITTION FILTER (STANDARD) SO I PAYED TO HAVE IT FLUSHED. IT WORKED GREAT FOR A COUPLE DAYS. I THINK THIS HAS TO DO WITH THE DRIVE SHAFT, AND THE REQUIREMENT FOR RE-TORQUING THAT IS SUPPOSED TO BE DONE TO IT ACCORDING TO THE USER MANUAL. I HAVE KEPT UP THE MAINTENANCE ON IT, BUT I THINK ITS SOME FLAW IN THE LINKAGE OR A CONTROL PROBLEM. TIRES ARE NOW NEW, BUT HAS HAD NO EFFECT. BASICALLY, IT SOMETIMES SHIFTS/JERKS LIKE IT HAS A BELT DRIVE, NOT A GEARED ONE.*AK

NHTSA ID

10056895

Incident

Jan 7, 2004

Mileage

50,000 mi

WHILE DRIVING 10 TO 15 MILES AN HOUR DRIVETRAIN LOCKS UP AND VEHICLE SKIDS TO A STOP. DEALER SAYS IT IS AN INTERMITTENT PROBLEM, AND CANNOT DUPLICATE. THEY HAVE HAD THE TRUCK FOR TWO WEEKS. IT HAS HAPPENED TWICE ON THE 19 OF SEPTEMBER AND THE 19TH OF OCTOBER. FROM AROUND 5:30 TO 6:00 PM. I WILL DROVE IT ON THE 19TH OF NOVEMBER HOPING IT WILL HAPPEN AGAIN. COMPUTER AND BACKUP COMPUTER CHECKS OKAY, NO METAL IN ANY OF THE DRIVETRAIN COMPONENTS. THIS IS A 4X4 SR5 2000 TUNDRA. *AK

NHTSA ID

10045548

Incident

Sep 19, 2003

Mileage

62,000 mi

WHILE DRIVING VEHICLE CAME TO A COMPLETE STOP, HIT ACCELERATOR AND VEHICLE STALLED. HAD VEHICLE SERVICED, TRANSMISSION WENT OUT.*AK

NHTSA ID

8018153

Incident

Sep 5, 2002

INITIAL SYMPTOM BEFORE FAILURE - DIFFICULTY PUTTING STEERING COLUMN SHIFTER INTO FORWARD GEARS AND "CLUNKY" ROUGH SHIFTING FROM DRIVE GEAR (3RD) INTO AUTOMATIC OVERDRIVE. OCCURRED PERIODICALLY FOR 1 WEEK PRIOR TO TOTAL FAILURE OF OD. TOYOTA SERVICE DEPARTMENT COULD NOT IDENTIFY PROBLEM ON 2 OCCASIONS IN THIS PERIOD. ONLY AFTER TOTAL FAILURE AND "IDIOT" LIGHT (CHECK ENGINE) CAME ON WAS TOYOTA SERVICE WILLING TO LOOK INTERNALLY, ONLY TO FIND METAL SHAVINGS IN THE PAN.*AK

NHTSA ID

756417

Incident

Dec 13, 2001

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK (DOT NUMBER: B7JC DC7X TIRESIZE: 265/70 R16)

NHTSA ID

747873

Incident

Nov 8, 2000

CONSUMER WAS TRAVELING ON HIGHWAY AN APPLIED BRAKES, TRANSMISSION MADE A CLUNKING NOISE. DEALERSHIP WAS AWARE OF PROBLEM.*AK CONSUMER STATES THE VEHICLE WILL LUNGE FOWARD, JUST ENOUGH TO HIT SOMEONE IF FOLLOWING A VEHICLE.*JB

NHTSA ID

887545

Incident

Mar 1, 2001