RoadVitals

2010 Van Hool TD925

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Nov 29, 2016
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2010 Van Hool TD925. 2 safety recalls have been issued covering this model year; and 37 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
16V857000

STEERING

Nov 29, 2016
1,612 units potentially affected
The defect: Van Hool N.V. (Van Hool) is recalling certain model year 2010-2014 C2045 and T2145; 2010 C3045; 2016 CX35; 2014-2016 CX45 and TX45; 2009-2016 TD925; 2015-2016 TDX25 and TX40 and 2010-2013 T2140 motorcoaches. In the affected vehicles, the front steering knuckle carriers may crack.
The risk: Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.
The remedy: Van Hool will notify owners, and dealers will replace the steering knuckle carriers that were produced from August 2009 through March 2011. Carriers that were produced from April 2011 to December 2014 will be inspected by ultrasonic measurement and replaced as necessary. These repairs will be performed free of charge. The recall began on January 19, 2017. Owners may contact ABC Bus, Inc. at 1-877-427-7278. Van Hool's number for this recall is P855. Note: This recall expands recalls 14V-569 and 15V-331.
Van Hool N.V.Manufacturer number P855View on NHTSA.gov
10V603000

VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

Dec 1, 2010
1,673 units potentially affected
The defect: VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2011 TRANSIT BUSES AND MOTORCOACHES MANUFACTURED FROM AUGUST 2002 THROUGH OCTOBER 2010, EQUIPPED WITH HADLEY REMOTE MIRROR SWITCHES, PART NUMBERS 509VH AND 509VH1F. THE REAR VIEW MIRROR SWITCH MAY OVERHEAT, CAUSING THE PLASTIC HOUSING TO MELT.
The risk: EXCESSIVE HEATING CAN CAUSE A FIRE RESULTING IN SMOKE, OPERATOR DISTRACTION, OR PERSONAL INJURY. AN OVERHEATED MIRROR SWITCH COULD CAUSE THE EXTERIOR REAR VIEW MIRRORS TO NOT OPERATE. THE MIRRORS MAY NOT ADJUST PROPERLY FROM THE INTERIOR SWITCH OR OPERATE POORLY. THEREFORE, THE DRIVER MAY NOT BE ABLE TO HAVE FULL USE OF THE REAR VIEW MIRROR, INCREASING THE RISK OF A CRASH.
The remedy: VAN HOOL WILL NOTIFY OWNERS VIA ITS DEALER ABC BUS INC. OWNERS WILL HAVE THE CHOICE TO PERFORM THE REPAIR THEMSELVES OR TO TAKE THE VEHICLE(S) TO AN ABC-LOCATION FOR REPAIR, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 10, 2011. OWNERS MAY CONTACT THE WARRANTY ADMINISTRATOR FOR ABC BUS, INC. TOLL FREE AT 1-877-427-7278.
VAN HOOL N.V.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

SB2492

STEERING

The purpose of this service bulletin is to inform you that VDL Van Hool will switch over to other components for the front axle steering system. This switch-over will be cut into production as from units 89249 (TDX25 Diesel) and 89558 (TDX25 E). Previous references may be used further, but for future orders only the new components will be supplied.

SB2509

VISIBILITY/WIPER

On the above-mentioned vehicles, it is possible that the installation of the FMCSA decal has been omitted. Verification is necessary in order that the decal is present in accordance with the requirements of FMCSA.

SB2506

This service bulletin is a reminder about rules, procedures and precautions that must be followed when a TD925 10-wheeler needs to be lifted.

SB2492

STEERING

The purpose of this service bulletin is to inform you that VDL Van Hool will switch over to other components for the front axle steering system. This switch-over will be cut into production as from units 89249 (TDX25 Diesel) and 89558 (TDX25 E). Previous references may be used further, but for future orders only the new components will be supplied.

SB2501

SUSPENSION

The control arms of the front and trailing axles are equipped with a flexible ball-joint at the chassis side. Van Hool has several suppliers for the repair kit of this flexible ball-joint. All of the repair kits contain a flexible ball-joint, a spacer and a snap ring. Due to not equal thickness of the spacer in the different kits, it is important to install all three the kit parts when replacing a flexible ball-joint. Do not mix parts of different repair kits!

SB2497

SUSPENSION

Mobile column lifts raise the vehicle under the wheels. This service bulletin is a reminder about the usage of mobile column lifts when lifting a complete vehicle.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Van Hool TD925 by model year
YearComplaintsRecallsInvestigationsIssue Index
2019000—
2018031—
2017022—
2016042—
2015082—
2014050—
2013040—
2012060—
2011060—
2010Viewing020—
2009020—
2008010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.