2022 Vanleigh Vilano Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Vanleigh Vilano, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical240.0%
- Body & structure120.0%
- Other / unspecified120.0%
- Tires & wheels120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2022 Vanleigh Vilano. The contact stated that the cabinets had separated from the wall and struck the rim, and the refrigerator separated and fell into the aisle while driving. The contact stated that the refrigerator power inverter had failed and almost caught on fire. The contact stated that the shelf separated and fractured the curtain valance. While in the process of replacing the water heater, the contact noticed that the frame was fractured and appeared smashed in. The contact stated that the RV was defective from the factory. The RV was taken to the dealer, to whom the contact provided photos of the failures. The dealer informed the contact that the failure would be reported to the manufacturer. The contact stated that the RV remained at the dealer unrepaired for a year and nine months. The manufacturer picked up the RV and performed unrelated minors repairs, and then the manufacturer returned the RV to the dealer with an unrepaired frame and other major reported failures. The RV was not repaired. The failure mileage was approximately 400. The VIN was not available.
Started getting messages that trailer brake gain was not recalled on the dash display. The NAV display continued to show no connection errors. The problem escalated to a turn signal failure. The left turn signal flashed and sounded an alarm when changing lanes. The nav display did indicate a turn signal connection error. I tried moving the 7 pin trailer cable to another connector and the brake gain warnings continued. My tow vehicle is a GMC Sierra 3500HD Denali. I remembered seeing this issue on an RV forum and the fix is spraying contact cleaner into the 7 pin plug. The contact cleaner did stop the warning messages. The Denali is equipped with a trailer package. The package includes a lamp test. The lamp test cycles the trailer brake and turn signals. We always perform the lamp test before traveling with the trailer and it has always passed. The turn signal failure did not cause an accident. My concern is that the cable and plug is a component common to other RV manufacturers. An electrical failure of the brakes or turn signals could result in a serious accident. Does the 7 pin plug require a design change to eliminate corrosion issues?
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2022 Vanleigh Vilano. The contact stated that the cabinets had separated from the wall and struck the rim, and the refrigerator separated and fell into the aisle while driving. The contact stated that the refrigerator power inverter had failed and almost caught on fire. The contact stated that the shelf separated and fractured the curtain valance. While in the process of replacing the water heater, the contact noticed that the frame was fractured and appeared smashed in. The contact stated that the RV was defective from the factory. The RV was taken to the dealer, to whom the contact provided photos of the failures. The dealer informed the contact that the failure would be reported to the manufacturer. The contact stated that the RV remained at the dealer unrepaired for a year and nine months. The manufacturer picked up the RV and performed unrelated minors repairs, and then the manufacturer returned the RV to the dealer with an unrepaired frame and other major reported failures. The RV was not repaired. The failure mileage was approximately 400. The VIN was not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 2022 Vanleigh Vilano. The contact stated that the cabinets had separated from the wall and struck the rim, and the refrigerator separated and fell into the aisle while driving. The contact stated that the refrigerator power inverter had failed and almost caught on fire. The contact stated that the shelf separated and fractured the curtain valance. While in the process of replacing the water heater, the contact noticed that the frame was fractured and appeared smashed in. The contact stated that the RV was defective from the factory. The RV was taken to the dealer, to whom the contact provided photos of the failures. The dealer informed the contact that the failure would be reported to the manufacturer. The contact stated that the RV remained at the dealer unrepaired for a year and nine months. The manufacturer picked up the RV and performed unrelated minors repairs, and then the manufacturer returned the RV to the dealer with an unrepaired frame and other major reported failures. The RV was not repaired. The failure mileage was approximately 400. The VIN was not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
Size: 215/75R17.5 Load Range: H 16 PR RV Weight: 14,380 Traveling north on [XXX] Hayden AL. Tread separated from tire casting causing $2500 damage to RV + $2000 to replace all tires minus Westlake refund of ~$130 for defective tire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .