2011 Volkswagen Golf Problems

The High-pressure Fuel pump failed during a routine drive at approximately 1500 RPMs. This caused an immediate loss of power while in traffic. Manage to limp the car to the nearest gas station in which the car finally died and would not start. Had to call for a tow truck. This immediate loss of power could have cause myself and my daughter to get into an accident. Luckily, we were not on a major highway doing 65+ MPH, which could have been a lot worse. The vehicle flashed a MIL light or flashing glow plug light at the time of the incident. The car did not show any signs of possible failure beforehand. This same issue has been recalled by Fiat-Chrysler on their Heavy-Duty Ram pickup trucks with 6.7L Cummins due to catastrophic failure of the CP4 fuel pump.

Driving on interstate at 70 mph with cruise control on when car suddenly slowed and warning lights began flashing. I slowed to 60 mph and within a minute the engine shut off and was almost rear ended by a semi truck before I could get to the shoulder of the highway. Engine would not restart and I was stranded on the highway. Had to have the vehicle towed by AAA back to my home. Used my Ross-Tech VCDS scanning tool to troubleshoot and found codes: P0087 (fuel rail system pressure too low), P020 (cylinders 1-4 injection timing), P1004-P1007 (torque difference cylinders 1-4). Examined fuel filter and fuel metering valve and found metal chips and particles in both places. Based on this evidence, the high pressure fuel pump has likely failed. My safety was put at risk when the failure occurred due to the sudden loss of power and subsequent near collision with a truck. Additionally I was in danger of being hit by other vehicles as I sat on the shoulder of the highway waiting for a tow truck. My vehicle is available for inspection by the local VW dealership, but will have to be towed at my expense to be examined.

Electrical Short caused catastrophic fire in engine compartment, suspected issue is a water leak due to faulty manufacturing. Leak was noted by Volkswagen repair facility and was to be inspected and repaired within 30 days

Driving on interstate at 70 mph with cruise control on when car suddenly slowed and warning lights began flashing. I slowed to 60 mph and within a minute the engine shut off and was almost rear ended by a semi truck before I could get to the shoulder of the highway. Engine would not restart and I was stranded on the highway. Had to have the vehicle towed by AAA back to my home. Used my Ross-Tech VCDS scanning tool to troubleshoot and found codes: P0087 (fuel rail system pressure too low), P020 (cylinders 1-4 injection timing), P1004-P1007 (torque difference cylinders 1-4). Examined fuel filter and fuel metering valve and found metal chips and particles in both places. Based on this evidence, the high pressure fuel pump has likely failed. My safety was put at risk when the failure occurred due to the sudden loss of power and subsequent near collision with a truck. Additionally I was in danger of being hit by other vehicles as I sat on the shoulder of the highway waiting for a tow truck. My vehicle is available for inspection by the local VW dealership, but will have to be towed at my expense to be examined.

Fuse F16 (30A) in the engine fuse plate, melted instead of breaking - causing half of the cars lights to stop functioning including turn signals and brake lights. Cannot be fixed with replacing the fuse as it was never tripped but instead the whole fuse plate needs to be replaced. No warning lights preceded the event, all lights went out while driving. VW dealership requires a new plate to be put in with no explanation of what caused the melt and no guarantee that it won’t happen again. Multiple online forums suggest a similar finding, and even other models have tickets for recalls (same problem, same part) but not the 2011 Golf TDI.

The wire from the alternator to the underhood fuse block is not thick enough to handle the current from the stock alternator. This causes the wire to get too hot melting the fuse block at the 30 amp fuse causing headlight issues.

WHILE IN MOTION AND UNDER POWER, CAR SUDDENLY LOSES DRIVE; ACTS AS IF SHIFTED INTO NEUTRAL. SOMETIMES A FLASHING WRENCH INDICATOR IS SEEN IN PLACE OF THE GEAR NUMBER IN THE INSTRUMENT DISPLAY. THIS IS HAPPENING INCREASINGLY OFTEN. AT LEAST ONCE PER DAY.

WHILE EXITING THE OFF RAMP OF THE HIGHWAY AT 1100 AT NIGHT THE CAR DIED AND I WAS LUCKY ENOUGH TO MAKE IT TO THE SIDE OF THE ROAD AS TRAFFIC BEHIND ME WAS LOCKING UP THEIR BRAKES AND SWERVING TO AVOID A COLLISION. AFTER AN EXPENSIVE TOW AND FINALLY GETTING THE VEHICLE TO THE DEALER I WAS TOLD THE HIGH PRESSURE FUEL PUMP HAD EXPLODED IN THE TANK SENDING METAL INTO THE WHOLE FUEL SYSTEM. I AM TOLD THE REPAIR BILL WILL COST AROUND $6500 TO FIX. THIS CAR HAS 54000 MILES AND I HAD RECEIVED A LETTER FROM VW STATING MY HIGH PRESSURE FUEL PUMP HAD AN EXTENDED WARRANTY A MONTH PRIOR HOWEVER VW WILL NOT PAY FOR THE REPAIR COSTS. THE VW DEALER TOLD ME THEY DID A FUEL SAMPLE TEST AND THE FUEL DID NOT HAVE ENOUGH LUBRICATION IN IT WHICH CAUSED THE FUEL PUMP TO FAIL. AS I HAVE RESEARCHED VW HAS HAD MORE THAN 3500 REPORTED CASES OF THESE FUEL PUMP FAILURES AND REFUSES TO STAND BEHIND THE BOSCH PRODUCTS THEY USE. I ALSO TALKED WITH THE SERVICE STATION WHERE I PURCHASED THE FUEL TO LET THEM KNOW THE PUMP FAILURE IS BEING BLAMED ON LACK OF LUBRICATION IN THEIR FUEL AND THEY HAVE NOT HAD ONE OTHER COMPLAINT OF FUEL ISSUES REPORTED. ON A SIDE NOT I FILLED MY DODGE DIESEL TRUCK WITH THE SAME PUMP AND FUEL AND HAVE HAD NO PROBLEMS. TO ME THIS IS A SERIOUS PROBLEM THAT VW IS NOT TAKING RESPONSIBILITY FOR AND IF THERE IS NOT A RECALL ON THESE FUEL PUMPS IT IS ONLY A MATTER OF TIME BEFORE SOMEONE GETS KILLED BECAUSE A KNOWN BAD PART THAT IS NOT GETTING REPLACED.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN GOLF. WITHIN LESS THAN TWO MONTHS OF OWNING THE VEHICLE, THE HORN FAILED TO WORK. THE DEALER (ANTHONY CARVONI VOLKSWAGEN, 12 MERIDEN PL, MELVILLEE, NY, 516-848-7315) DIAGNOSED THAT THE HORN NEEDED TO BE REPLACED AND STATED THAT IT WAS NOT RELATED TO THE AIR BAG BEING ELECTRICALLY CONNECTED TO THE HORN. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HORN AND THE DRIVER'S SIDE AIR BAG NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN OF WHAT AIR BAG RECALL REPAIRS WERE COMPLETED BEFORE THE VEHICLE WAS SOLD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I WAS IN A CAR ACCIDENT AND THE AIRBAG DIDN'T GO OFF.

I OWN A 2011 VW GTI 2-DOOR DSG. I HAVE EXPERIENCED A "FALSE NEUTRAL" ABOUT 7 TIMES IN THE 5+ WEEKS I HAVE OWNED THIS CAR. SPECIFICALLY, IT HAPPENED TWICE ON 08/27/2011. EACH TIME I HAVE BEEN IN MANUAL MODE...IT OCCURS WHEN I AM COASTING TO EITHER SLOW DOWN OR STOP...THEN ATTEMPT TO ACCELERATE...THOUGH THE CAR MFD TELLS ME IT IS IN GEAR (I.E. 3), THE CAR IS IN NEUTRAL...THE ACCELERATOR DOES NOTHING BUT REV THE ENGINE...THE CAR REMAINS COASTING. I HAVE TO TAKE THE SHIFTER OUT OF MANUAL MODE, AND PLACE IT INTO D...AND WAIT ABOUT A SECOND OR TWO WITHOUT TOUCHING THE ACCELERATOR IN ORDER FOR A CLUTCH TO ENGAGE A GEAR AND ALLOW ME TO MOVE. ON 8/27, BOTH TIMES IT HAPPENED WHEN TRYING TO COMPLETE A LEFT HAND TURN ON A GREEN...A DANGEROUS SITUATION TO FIND YOUR CAR BEING IN NEUTRAL. I HAVE BROUGHT MY CAR TO THE DEALERSHIP, THEY REFUSE TO HELP ME BECAUSE THEY WERE UNABLE TO REPLICATE THE ISSUE ON AN APPROXIMATE 5 MILE TEST DRIVE. I TALKED TO VW OF AMERICA, AND THEY WON'T HELP UNLESS A DEALER CAN REPLICATE IT...THEY SAID IT COSTS TOO MUCH MONEY. THIS IS A TERRIBLE SAFETY ISSUE...AND THEY ARE WORRIED ABOUT THE MONEY. I OFFERED TO SHOW THEM A VIDEO OF IT HAPPENING TO SOMEONE ELSE...IT IS POSTED ON YOUTUBE...AND THEY FLAT OUT REFUSED. THEY SAID IT WOULDN'T HELP IN MY CASE...AND THAT IT WOULD PROVE NOTHING. HERE IS A LINK TO THE YOUTUBE VIDEO: HTTP://WWW.YOUTUBE.COM/WATCH?V=8TQODOILKYK - EVEN IF I COULD TAKE A VIDEO OF IT HAPPENING TO ME IN MY CAR, THEY SAID THAT WOULDN'T HELP...AS IT WOULD HAVE TO HAPPEN IN FRONT OF A VW TECH FOR IT TO BE DIAGNOSED. I HAVE A SECOND APPOINTMENT WITH A DIFFERENT DEALERSHIP NEXT WEEK, THEY WILL KEEP MY CAR FOR A FEW DAYS AND TRY TO REPLICATE IT. I DON'T KNOW WHAT ELSE TO DO. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN GOLF. THE CONTACT WAS DRIVING 5 MPH WHEN THE FRONT PASSENGER SIDE TIRE BEGAN TO WOBBLE ABNORMALLY. THE VEHICLE THEN BEGAN TO DECELERATE DESPITE THE CONTACT APPLYING THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC WHICH ADVISED OF A TRANSMISSION FAILURE. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,800 AND THE CURRENT MILEAGE WAS 5,080.

LIGHTING CHECK ENGINE . I COULDN'T PASS INSPECTION ON MY VW DUE TO: CODE P0106. MANIFOLD ABSOLUTE/BAROMETRIC. PRESSURE CTRL. RANGE/PERFORMANCE

I WAS ENTERING AN INTERSECTION AT 10MPH AND HALFWAY INTO THE INTERSECTION, MY CAR STALLED AND STOPPED. IT SLOWLY BUMPED THE CAR IN MY REAR. NO INJURY OR DAMAGE NOTED. I PUT THE CAR IN PARK, TURNED OFF THE CAR AND RESTARTED IT AND DROP IT TO THE NEAREST PARKING LOT. THIS IS A VW GOLF TDI 2011! *TR

THE 2011 VW GOLF TDI SHUT OFF WHILE BEING DRIVEN. THE STEERING WHEEL LOCKED.

WHILE DRIVING AT APPROX 75 MPH IN THE FAST LANE OF AN INTERSTATE FREEWAY MY 2011 VW GOLF TDI SHUT OFF. WITHOUT WARNING, THE GLOW PLUG LAMP BEGAN FLASHING AND CHECK ENGINE NOTE CAME ON THE DASH. AT THE SAME TIME THE CAR LOST ALL POWER AND BEGAN RUNNING VERY ROUGH. WHILE NEGOTIATING TRAFFIC IN AN ATTEMPT TO PULL OVER (QUITE DANGEROUS WITHOUT POWER AND TRACTOR TRAILERS NOW PASSING MY SLOWING CAR) THE CAR SHUT OFF TAKING THE POWER BRAKES AND POWER STEERING WITH IT. I WAS ABLE TO SAFELY GET OFF THE HIGHWAY DUE TO THE WIDE SHOULDER IN THAT AREA BUT THIS WOULD HAVE BEEN ANOTHER STORY HAD THIS HAPPENED IN AN AREA WITH NO SHOULDER OR SAFE PULL OFF. MY CAR HAS BEEN PROPERLY MAINTAINED AT SERVICE INTERVALS AND FUELED FROM NAME BRAND, HIGH VOLUME FILLING STATIONS. VWS OWN TESTS OF MY CAR INDICATED NO FAULT OF MY OWN AND NOTHING AMISS IN THE FUEL BUT RATHER CATASTROPHIC FAILURE OF A HIGH PRESSURE PUMP WHICH DISPLACED METAL INTO THE FUEL SYSTEM. THIS SORT OF FAILURE IS COMMON ENOUGH (NOTED IN A SIMPLE INTERNET SEARCH) AND FLAT OUT DANGEROUS WHEN IT OCCURS AT SPEED SINCE THE CAR GAVE NO INDICATIONS THAT IT WAS GOING TO SHUT OFF AT SPEED (AND FAIL TO RESTART WITHOUT BEING TOWED TO THE DEALER). WORSE YET, VW IS AWARE OF THIS ISSUE WITH THE TDI DIESELS BUT HAS STOPPED SHORT OF ISSUING A RECALL TO INSTALL NEW PARTS THAT WILL NOT FAIL SO SOON AND WITHOUT WARNING. THE CAR WAS FIXED UNDER WARRANTY (CAR HAS ONLY 38,000 MILES) HOWEVER THEY REPLACED THE PARTS WITH THE SAME FAILURE PRONE PARTS. WEB ANECDOTES FROM OTHERS WITH SIMILAR FAILURES HAVE NOTED THAT IT HAPPENS IN HOTTER AREAS (90-100 DEGREE TEMPS). THIS WAS MY EXPERIENCE AS WELL AS I WAS IN THE MIDDLE OF A LONG DRIVE IN 100 DEGREE TEMPS. *TR

The wire from the alternator to the underhood fuse block is not thick enough to handle the current from the stock alternator. This causes the wire to get too hot melting the fuse block at the 30 amp fuse causing headlight issues.

LOW BEAM HEADLIGHT ELECTRICAL PROBLEM ONE SIDE OF VEHICLE LOW BEAM HEADLIGHT DOES NOT WORK. I NOTICED PASSATS AND JETTAS HAVE HAD THIS RECALLED AND IT IS DUE TO AN ELECTRICAL WIRING ISSUE. THIS IS NOT A BULB REPLACEMENT SINCE BULB HAS BEEN REPLACED SEVERAL TIMES AND STILL NOT WORKING. IT IS AN ISSUE WITH THE HOOD WHEN IT CLOSES KNOCKING THE ELECTRICAL CONNECTION OUT. SAME ISSUE AS THE PASSATS AND JETTAS. WHY WAS THIS NOT RECALLED FOR THE GOLF AS WELL?

I HAD PULLED INTO A PARKING SPACE READY TO SHIFT THE CAR INTO PARK POSITION WHEN IT LUNGED FORWARD AND HIT THE CAR PARKED IN FRONT OF MINE. WHEN PULLING INTO A PARKING SPACE, ONES FOOT IS ONE THE BRAKES, THEREFORE I BELIEVE THAT THIS MAY HAVE BEEN A CASE OF SPONTANEOUS ACCELERATION. THE OTHER CAR, NATURALLY, SUSTAINED DAMAGES, AS WELL

I BELIEVE MY CAR (2011 VW GOLF 2-DOOR 2.5) HAS A MANUFACTURING DEFECT - IMPROPER WELDING, MISSING STRUCTURAL COMPONENTS, ETC. - ON THE BODY IN THE AREA BENEATH THE REAR SEAT CUSHION. I THINK THAT THE DEFECT AFFECTS SAFETY. // I NOTICED IN MAY, 2011, THAT THE MID AND LEFT AREA OF THE REAR SEAT CUSHION MAKES CREAKING SOUND WHEN IT IS PRESSED. I COMPARED OTHER VEHICLES OF THE SAME MODEL (A 2011 VW GOLF 2-DOOR TDI AND A 2010 VW GOLF 4-DOOR 2.5) WITH MINE. THE OTHER VEHICLES DID NO MAKE THE CREAKING SOUND. // ON JULY 26, 2011, THE SERVICE MANGER JOHN AT THE VW DEALER IN DANVERS, MA, SHOWED ME THAT THE METAL BODY BENEATH THE SEAT CUSHION MADE THE CREAKING SOUND BY PRESSING THE AREA OF THE METAL BODY WHILE THE SEAT CUSHION WAS LIFTED UP. HOWEVER, HE DID NOT TRY TO FIX THE PROBLEM SAYING THAT THE HE DID NOT KNOW HOW TO FIX THE PROBLEM. // I THINK THAT THE DEFECT ON MY CAR'S BODY IN THE AREA BENEATH THE REAR SEAT CUSHION AFFECTS VEHICLE SAFETY IN THE FOLLOWING WAYS. IN CASE OF COLLISION, MY CAR'S BODY WILL NOT PROPERLY PROTECT THE PASSENGER COMPARTMENT. IN CASE OF EXPLOSION OF THE FUEL TANK WHICH IS RIGHT BELOW THE AREA OF THE ALLEGED DEFECT, MY CAR'S BODY WILL NOT PROPERLY PROTECT PASSENGERS FROM THE EXPLOSION. // LASTLY, I WOULD LIKE TO TELL YOU ABOUT A DIFFERENT SYMPTOM THAT MIGHT BE RELATED TO THE DEFECT ON THE BODY BENEATH THE REAR SEAT CUSHION. MY CAR FREQUENTLY MAKES CREAKING AND KNOCKING SOUND FROM AROUND THE DOORS WHEN THE ROAD IS SLIGHTLY UNEVEN OR WHEN I SUDDENLY LET OFF THE GAS PEDAL. THE VW DEALER IN WELLESLEY, MA, TRIED TO FIX IT MANY TIMES BUT FAILED. PERHAPS, THE DEFECT ON THE BODY BENEATH THE REAR SEAT CUSHION MAKES MY CAR'S BODY FLEX MUCH MORE THAN IT WAS DESIGNED, AND CAUSES THE CREAKING AND KNOCKING SOUND FROM AROUND THE DOORS. *TR

WHILE DRIVING AT APPROX 75 MPH IN THE FAST LANE OF AN INTERSTATE FREEWAY MY 2011 VW GOLF TDI SHUT OFF. WITHOUT WARNING, THE GLOW PLUG LAMP BEGAN FLASHING AND CHECK ENGINE NOTE CAME ON THE DASH. AT THE SAME TIME THE CAR LOST ALL POWER AND BEGAN RUNNING VERY ROUGH. WHILE NEGOTIATING TRAFFIC IN AN ATTEMPT TO PULL OVER (QUITE DANGEROUS WITHOUT POWER AND TRACTOR TRAILERS NOW PASSING MY SLOWING CAR) THE CAR SHUT OFF TAKING THE POWER BRAKES AND POWER STEERING WITH IT. I WAS ABLE TO SAFELY GET OFF THE HIGHWAY DUE TO THE WIDE SHOULDER IN THAT AREA BUT THIS WOULD HAVE BEEN ANOTHER STORY HAD THIS HAPPENED IN AN AREA WITH NO SHOULDER OR SAFE PULL OFF. MY CAR HAS BEEN PROPERLY MAINTAINED AT SERVICE INTERVALS AND FUELED FROM NAME BRAND, HIGH VOLUME FILLING STATIONS. VWS OWN TESTS OF MY CAR INDICATED NO FAULT OF MY OWN AND NOTHING AMISS IN THE FUEL BUT RATHER CATASTROPHIC FAILURE OF A HIGH PRESSURE PUMP WHICH DISPLACED METAL INTO THE FUEL SYSTEM. THIS SORT OF FAILURE IS COMMON ENOUGH (NOTED IN A SIMPLE INTERNET SEARCH) AND FLAT OUT DANGEROUS WHEN IT OCCURS AT SPEED SINCE THE CAR GAVE NO INDICATIONS THAT IT WAS GOING TO SHUT OFF AT SPEED (AND FAIL TO RESTART WITHOUT BEING TOWED TO THE DEALER). WORSE YET, VW IS AWARE OF THIS ISSUE WITH THE TDI DIESELS BUT HAS STOPPED SHORT OF ISSUING A RECALL TO INSTALL NEW PARTS THAT WILL NOT FAIL SO SOON AND WITHOUT WARNING. THE CAR WAS FIXED UNDER WARRANTY (CAR HAS ONLY 38,000 MILES) HOWEVER THEY REPLACED THE PARTS WITH THE SAME FAILURE PRONE PARTS. WEB ANECDOTES FROM OTHERS WITH SIMILAR FAILURES HAVE NOTED THAT IT HAPPENS IN HOTTER AREAS (90-100 DEGREE TEMPS). THIS WAS MY EXPERIENCE AS WELL AS I WAS IN THE MIDDLE OF A LONG DRIVE IN 100 DEGREE TEMPS. *TR

MY BRAND NEW 2011 VW GOLF TDI MANUAL CAR STALLS AT LAUNCH MUCH TOO EASILY. I HAVE DRIVEN MANUAL TRANSMISSION CARS FOR 40 YEARS AND HAVE FOUND IT MUCH WORSE THAN THE MAZDA MIATA WHICH WAS POOR. THIS IS A PROBLEM WITH ALL OF THIS MODEL, AS CONFIRMED BY MY TEST DRIVE, MAGAZINE REVIEWS, AND THE SALESPERSON. IT MAY BE DO TO THE "HILL CLIMBING" FEATURE WHICH LOCKS THE BRAKES UPON STOPPING SO THAT YOU HAVE TO OVERCOME THE BRAKES TO MOVE. I AM SCARED A CAR WILL HIT ME FROM BEHIND. *TR

THERE IS A VERY AUDIBLE "CLUNKING" SOUND THAT COMES FROM THE FRONT UNDERBODY OF THE VEHICLE. IT MOSTLY OCCURS WHEN MAKING LEFT HAND TURNS AT LOWER SPEEDS (1-25MPH) OR WHEN THERE IS A CHANGE IN ELEVATION (A BUMP).