2023 Volkswagen ID.4 Body & structure Problems

The failure involves the driver’s side door latch/lock assembly and emergency access system. Specifically, the mechanical emergency keys for the door did not function, and the door later did not fully close or seal due to two loose bolts near the lock. The vehicle is available for inspection upon request. This created a safety risk because I was unable to manually unlock the vehicle in an emergency when electronic systems could fail. Additionally, while driving, the driver’s door was not fully sealed and allowed wind into the cabin without triggering any warning alert, raising concern that the door was not securely latched. The issue was reproduced and confirmed by multiple authorized Volkswagen dealerships. In December 2025, a dealership confirmed that neither set of emergency keys worked. After replacement keys also failed, a faulty door lock cylinder was identified and replaced in March 2026. In April 2026, a new issue arose where the driver’s door was visibly not flush with the frame. A dealership technician identified and tightened two loose bolts in the door lock, which resolved the issue. The vehicle has been inspected by authorized Volkswagen service departments on multiple occasions. No inspection by police or insurance representatives occurred. There were no warning lights, alerts, or messages from the vehicle prior to or during either failure. The issues first appeared in December 2025 (emergency key failure) and again in April 2026 (door not properly sealing). Based on repeated failures and repairs involving the same door/lock, I believe there may be a defect related to the door latch/lock system or prior repair work that impacts safe operation and emergency access.

NHTSA ID

11735544

Incident

Apr 23, 2026

We took this vehicle in for a previous recall for defective exterior door handle. The previous one worked fine, but was replaced do the the recall. The new handle broke within days of being installed. We have requested to have it replaced numerous times by the dealer who says that parts aren't available. It has been more than six months. We are worried about it failing and being unable to enter or exit the vehicle.

NHTSA ID

11732232

Incident

Oct 13, 2025

Car is developing a paint chip even on the top of the hood since the car was purchased. According to google search, some of white and gray colored made in the USA Id4 card have the paint issues.

NHTSA ID

11730396

Incident

Oct 14, 2024

My 2023 VW ID4 has experienced multiple system failures/malfunctions (e.g., display, backup camera, climate controls, & speedometer failed) beginning in late November 2025. The following is a summary & an approximate timeline: Nov 4, 2025: “OUE7 – Software Update” email; dealer unable to complete (OTA update). Nov 7 & Nov 21, 2025: Weatherstrip repairs; maintenance inspections performed. Nov 30, 2025: Doors randomly unlocked; front, passenger door failed to latch; intermittent door popper issue. Door handles were previously replaced on Apr 2, 2025. Dec 14, 2025: Incorrect dynamic road signs/speed limits; vehicle mis‑positioned on maps; warnings: 1. “No data is available” 2. “Dynamic road sign display unavailable.” Dec 22, 2025: Major failures documented in photographs below: 1. Speedometer incorrect/no speed. 2. Brake/auto‑hold intermittent malfunction. 3. Multifunction display froze. 4. Defrost/climate controls unresponsive. 5. Backup camera failure. Dec 22, 2025 – Jan 15, 2026: Vehicle at dealer for ~24 days; dealer unable to replicate issues above. Dealer documented CarNet/connected vehicle issues. VW requested switching CarNet carriers (from Verizon to T‑Mobile), not possible for 2023 ID4. Jan 14–15, 2026: Dealer stated “safe to drive”; vehicle picked up. Dealer said VW would contact once they have a resolution for the CarNet. Jan 17, 2026: Same failures (display, backup camera, etc.) above reoccurred; documented by service advisor/manager. Jan 27, 2026: Notifications of open recalls: High‑voltage battery fire risk (NHTSA Recall IDs 26V028, 26V030). Jan 17 – Jan 30, 2026: Vehicle at dealer additional ~13 days; 5F modules replaced. CarNet issues & recalls still unresolved. OUE7 update still appears to be incomplete. Jan 30, 2026: Dealer stated “safe to drive” again; vehicle picked up. Today, the CarNet app / connected vehicle issues & open recall remain unresolved. Continues to show doors open, windows down, & incorrect charge, location, & mileage.

NHTSA ID

11715399

Incident

Dec 22, 2025

door-handle safety recall had previously been completed on this vehicle. While driving at normal city speed, the front passenger door opened unexpectedly while a passenger was seated inside, creating a serious safety risk. The passenger was restrained by a seat belt, preventing ejection. The vehicle was taken to a Volkswagen dealership, which inspected the vehicle and documented that multiple door latch bolts were missing and another bolt was loose following a Volkswagen-authorized door-handle repair. The dealership stated the condition was related to prior repair workmanship. There were no warning lamps or messages prior to the failure. Due to safety concerns, the vehicle was towed rather than driven after the incident. The vehicle remains available for inspection.

NHTSA ID

11712469

Incident

Jan 17, 2026

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

NHTSA ID

11691836

Incident

Oct 7, 2025

There has been an active recall on this vehicle for one year. The dealership has failed to repair the door handle recall in a timely manner. The dealerships I have called said they don’t have the parts in stock to repair the recall.

NHTSA ID

11681715

Incident

Aug 19, 2025

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (Structure). The contact stated that on several occasions after receiving a car wash, the driver’s side door failed to open as intended from the outside. The contact stated that the door needed to be opened from the inside. Additionally, the contact stated that on several occasions, while occupants were seated in the rear seat, the passengers were unable to exit the vehicle. The contact stated that during the failure, the rear seat occupants climbed over the seats to exit the vehicle. The vehicle was taken to a dealer, where it was determined that the driver’s side door handle was faulty, and the door handle needed to be replaced. The vehicle was repaired, but the failure reoccurred months later. The vehicle was taken to another dealer; however, the failure could not be duplicated. The manufacturer was notified of the failure. The failure was approximately 15,000.

NHTSA ID

11674971

Incident

Nov 27, 2024

Mileage

15,000 mi

The right rear passenger door has become completely inoperable. It cannot be opened from the inside or outside of the vehicle. This is a critical safety risk because two child car seats are installed in the back, and the right side is the only accessible exit for an adult passenger. In the event of an accident or emergency, that adult would not be able to exit the vehicle. Additionally, the rear trunk has also intermittently failed to open since purchase. Both issues have been reported to the dealership. The trunk issue was previously noted but not repaired, and the door issue, which was intermittent at first, has now become a full failure. The problem has been documented on video and reported to both the dealership and the vehicle manufacturer. There were no warning lights or error messages, and no physical impact caused the failure. The dealership has been unable to provide timely repair or transportation assistance, leaving the vehicle unsafe for use with children. These issues may be related to known or recalled door and latch failures on this vehicle model. The car is under warranty and has fewer than 8,000 miles on it. Manufacturer inspection has not yet occurred due to scheduling delays.

NHTSA ID

11668340

Incident

Jun 20, 2025

The contact owns a 2023 Volkswagen ID.4. The contact stated that after stopping the vehicle, the front driver’s side door erroneously opened, causing damage to the door stop and window. The contact stated that after the failure, the window failed to roll down completely. Additionally, whenever the door was opened, the door opened extremely wide. The vehicle was taken to the local dealer, who diagnosed that the doorstop was damaged, and the door needed to be replaced. The door was not repaired or replaced. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

NHTSA ID

11660646

Incident

May 1, 2025

Mileage

30,000 mi

I was driving my car and the door came unlocked and opened

NHTSA ID

11660509

Incident

Apr 26, 2025

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (STRUCTURE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that there was an electronic clicking sound coming the passenger’s side doors. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the issue. The failure mileage was 25,000. Parts distribution disconnect.

NHTSA ID

11653261

Incident

Feb 7, 2025

Mileage

25,000 mi

VW failed to perform the repairs associated with recall 24V651 because the necessary parts are not available despite months of leadtime. It costs me $80 each time I bring my car in. It is currently at the dealership and they have no eta for the parts.

NHTSA ID

11652607

Incident

Apr 3, 2025

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11651105

Incident

Sep 16, 2024

The contact owns a 2023 Volkswagen ID.4. The contact received notifications of NHTSA Campaign Numbers: 24V651000 (STRUCTURE) and 24V344000 (BACK OVER PREVENTION, EQUIPMENT, ELECTRICAL SYSTEM). The contact stated that while the vehicle was parked at the dealer, the driver's and front passenger's doors became difficult to open or close. There were no warning lights illuminated. The contact stated that the recall repair was performed incorrectly due to the failure. The dealer was informed of the failure, and the vehicle was taken to be diagnosed. The dealer informed the contact that parts would be ordered. The vehicle was repaired; however, the repair was not done correctly. The contact contacted another dealer to schedule an appointment and informed the contactthat parts would be ordered. The manufacturer was not made aware of the failure. The failure mileage was approximately 13,477. Parts distribution disconnect.

NHTSA ID

11650899

Incident

Mar 26, 2025

Mileage

13,477 mi

The contact owns a 2023 Volkswagen ID.4. The contact received notification of the NHTSA Campaign Number: 24V651000 (Structure); however, the part to do the recall repair was unavailable. The dealer was contacted and confirmed that the parts were not yet available. The dealer stated that parts were on backorder. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11650597

Incident

Mar 25, 2025

The contact owns a 2023 Volkswagen ID.4. The contact received notifications of NHTSA Campaign Numbers: 24V651000 (STRUCTURE) and 25V120000 (POWER TRAIN, SERVICE BRAKES, HYDRAULIC), 24V344000 (BACK OVER PREVENTION, EQUIPMENT, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact stated that while driving 5 MPH, the vehicle stalled, with unknown warning lights illuminated. The vehicle was taken to the dealer however, the dealer was unable to diagnose the vehicle. On another occasion, the vehicle started to make a grinding sound and jerked abnormally. Additionally, the contact stated that on another occasion, after shifting into reverse, the display screen turned off unintendedly. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,544. Parts distribution disconnect.

NHTSA ID

11649104

Incident

Dec 30, 2023

Mileage

10,544 mi

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11646094

Incident

Mar 3, 2025

I've had to replace the 12v battery in my ID.4 due to battery failure twice since I've owned it, and according to the service department at VW, the battery was replaced on delivery too. So that's a total of three batteries since it came off the production line. I'm also having issues with my doors handles not working properly and haven't been able to have the open recall performed on my vehicle due to backordered parts. It's been more than 6 months since the issue started and I still don't have any updates. The infotainment screen randomly blanks out while driving and is especially problematic when I'm backing the car up because the backup camera cuts out and is a huge safety issue. Lastly, the windows roll down when I press up on the switch which has caused a bunch of issues when driving in snow/rain. I was told it is due to an overly sensitive pinch monitor system and that there's no fix for it. All in all, I don't feel like I can trust the car and definitely don't feel safe driving it.

NHTSA ID

11641981

Incident

Nov 21, 2024

The contact owns a 2023 Volkswagen ID.4. The contact received notifications of NHTSA Campaign Numbers: 24V651000 (Structure) and 24V344000 (Back Over Prevention, Equipment, Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11640689

Incident

Feb 4, 2025

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 10 - 20 MPH, the passenger’s side rear door unlocked and became slightly opened. The door closed from the momentum while driving; however, the contact pulled over to the side of the road and inspected the door and found no visible defects. The door was automatically locked and secured. Additionally, the infotainment screen was black while reversing and activating the back-over prevention camera. The contact also stated that the back-over prevention camera erroneously activated and remained displayed for an additional 10 - 15 minutes after the vehicle had been shifted into drive(D). The contact stated that the mileage had decreased significantly from 220 to 150 miles and the vehicle failed to display the level of charge for the battery. The dealer was contacted and was unable to provide an estimate for when parts for the recall repair would be available. The manufacturer was made aware of the issue. The failure mileage was 12,800. Parts distribution disconnect.

NHTSA ID

11639878

Incident

Nov 30, 2024

Mileage

12,800 mi

The contact owns a 2023 Volkswagen ID.4. The contact received notification of NHTSA Campaign Number: 24V651000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, there was an audible unlocking sound coming from the vehicle. There was no warning light illuminated. The contact stated that on one occasion, the front driver’s side door independently opened while at a complete stop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue but was unable to schedule an immediate appointment. The manufacturer was notified of the failure and confirmed that parts were on backorder. The failure mileage was approximately 16,000. Parts distribution disconnect.

NHTSA ID

11635887

Incident

Dec 23, 2024

Mileage

16,000 mi

The vehicle’s door handle malfunctioned twice, causing a door to open unexpectedly while driving at normal speeds. Small children were present as passengers during one of these incidents, increasing the risk of injury had the door opened fully or had another driver reacted suddenly to the open door. There were no warning lamps, audible alerts, or error messages before these occurrences. The handles and related components remain installed and could be made available for inspection upon request. Additionally, the dashboard display occasionally goes blank or glitches, making it impossible to read speed, warning indicators, or other critical information while driving. This issue occurs intermittently and does not seem to follow any specific pattern. No visible warning lamps or messages appear before the display malfunctions. These problems have been reported to an authorized dealer, who acknowledged known defects but indicated that no repairs or remedies are currently available. To date, the issues have not been inspected by the manufacturer, police, insurance representatives, or other third parties, apart from the dealer’s acknowledgment. Without a functioning remedy, these malfunctions continue to present a safety concern, especially with young passengers onboard and limited access to essential driving information due to the dashboard failures.

NHTSA ID

11630430

Incident

Nov 2, 2024

The contact owns a 2023 Volkswagen ID.4. The contact received notifications of NHTSA Campaign Numbers: 24V651000 (Structure) and 24V344000 (Back Over Prevention, Equipment, Electrical System); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The dealer was contacted. The contact stated while driving approximately 60 MPH, the vehicle lost power. The main control panel blacked out and the contact was unable to accelerate. The contact coasted to the side of the road and the vehicle regained power and was able to continue driving. The vehicle was taken to the dealer who diagnosed that a software update was needed; however, update was unavailable. The failure occurred approximately 15 more times while driving at various speeds. There were no warning lights illuminated. Additionally, the front passenger’s door made a clicking sound and slightly opened while driving approximately 30 MPH and had to be manually closed. The contact also stated that the door ajar light illuminated and remained illuminated despite pulling over and properly closing the door. The vehicle was taken to the dealer who diagnosed that the software update needed to be performed. The software update was not performed. The manufacturer was made aware of the failure. The failure mileage was 4,000. VIN tool confirms parts not available.

NHTSA ID

11629216

Incident

Feb 6, 2024

Mileage

4,000 mi

I have a Manufacturer Compliance Recall and a Manufacturer Safety Recall outstanding, neither of which the manufacturer can fix. I have called the dealership multiple times to make an appointment to have them fixed, but they do not yet have the remedies available. I have had multiple problems with this car from the day I got it on November 6, 2023. I get errors that pop up constantly on the screen, but they come and go so quickly while I'm driving that I can barely read them, much less take a photo. One of them says maneuver braking is not available. My screen goes out and flashes constantly, but again, it happens so quickly that I can't get photos while I'm driving. I have tried many times, but I'm not going to risk my safety to get a photo of my failing software. This car has no TPMS sensors, so I never have any idea of the status of my tires or if they're low. The car brakes suddenly, going forward and in reverse, and it has happened going at a high speed on the tollway. It was very scary and thankfully no one was behind me. I have trouble getting the charger out of the port on a regular basis. I have to unlock the vehicle on the fob about 5 times before the charger will come out. When I plug in the charger, it is hit or miss whether it will actually charge. I always have to check it later to see if it actually did. It charges on the first try about 50% of the time, and this car has put me in a bind multiple times when I have a long drive the next day. I believe Volkswagen hired the least competent engineers to build this car. It is the most frighteningly terrible car I've ever driven, and I believe Volkswagen should buy this car back from me at the current market value.

NHTSA ID

11627441

Incident

Nov 6, 2023