1996 Volkswagen Jetta Owner Complaints

I OWN A 1996 VW JETTA GLS AND MY CAR SMOKES FROM MY STEERING WHEEL COLUMN. I WILL BE DRIVING AND OUT OF NO WHERE WHITE SMOKE POURS OUT OF THE COLUMN. I THOUGHT IT WAS BECAUSE OF MY HEADLIGHTS BEING ON BUT THEN NOTICED IT DOING IT WITHOUT THEM ON. IT EVEN DOES IT WHEN THE CAR IS OFF! THIS I FEEL AND MY FRIEND WHO HAS THE SAME PROBLEM IS A FIRE HAZARD AND COULD BE VERY DANGEROUS TO DRIVE. I CALLED A VW DEALERSHIP AND SPOKE TO THE MECHANIC AND HE TOLD ME HE FEARED FOR MY LIFE AND IT SOUNDS LIKE A FIRE HAZARD OR IT COULD CAUSE MY BREAKS AND OTHER THINGS ON MY CAR TO FAIL. I COULD BE DRIVING DOWN A HIGHWAY AT 65 AND MY CAR CAN JUST DIE. I HAVE BROUGHT MY CAR TO 3 DIFFERENT MECHANICS FOR THIS PROBLEM AND THEY ALL SAID THEY HAVE NO CLUE WHAT IT COULD BE . IN MY CASE NOTHING LEADS UP TO THIS HAPPENING IT JUST HAPPENS RANDOMLY AT ANYTIME WITH OR WITHOUT MY LIGHTS ON OR BLINKERS BEING ON. THIS IS STILL AN UNKNOWN CAUSE BUT VERY SCARY, EVEN SCARIER KNOWING ITS NOT JUST MY CAR. *TR

NHTSA ID

10364362

Incident

Sep 10, 2008

Mileage

102,000 mi

WHEN THE VDO ELECTRONIC INSTRUMENT CLUSTER "TOTAL" ODOMETER READING CROSSED FROM 299,999 MILES TO 300,000 MILES . . . THE WORD "TOTAL" DISAPPEARED AND MILEAGE DROPPED TO "0". THE "TRIP" SIDE OF THE ODOMETER WORKS OK. NOW (05/06/2010) THE JETTA IS ABOUT TO CROSS 350,000 MILES, BUT THE ODOMETER ONLY SHOWS 50,000 MILES. *TR

NHTSA ID

10329105

Incident

Aug 23, 2008

Mileage

300,000 mi

TL*THE CONTACT OWNS A 1996 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE EXPERIENCED A SUDDEN AGGRESSIVE AND FORCEFUL ACCELERATION. THE CONTACT IMMEDIATELY DEPRESSED THE BRAKE PEDAL, BUT THERE WAS NO RESPONSE AND THE VEHICLE FAILED TO SLOW DOWN. THE VEHICLE CRASHED INTO TWO PARKED VEHICLES. THE AMBULANCE AND POLICE WERE CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE DRIVER AND THE OCCUPANTS IN THE PARKED VEHICLES WERE TRANSPORTED TO THE HOSPITAL AND SUSTAINED MODERATE INJURIES. THE CAUSE OF THE FAILURE AND EXTENT OF THE VEHICLE DAMAGE HAVE NOT YET BEEN DETERMINED. THE MILEAGES WERE UNKNOWN.

NHTSA ID

10267226

Incident

Apr 23, 2009

DRIVING HOME FROM SCHOOL (12 MINUTE DRIVE) AT NIGHT AND THE AIR COMING FROM THE VENTS SMELLED FUNNY, LIKE COOLANT. I TURNED OFF THE FANS BUT STILL SMELLED FUNNY. I TURNED THE FANS BACK ON AND WHITE 'SMOKE' WAS COMING OUT OF THE VENTS AND IT SMELLED HEAVILY OF COOLANT. MY WINDSHIELD BEGAN TO FOG UP WHILE I WAS ON THE HIGHWAY. I ROLLED DOWN MY WINDOWS AND SUNROOF AND TRIED EVERYTHING I COULD TO GET THE WINDOW TO DEFOG, BUT IT ONLY GOT WORSE. I COULD BARELY SEE AND FELT LIKE I WAS IN A VERY DANGEROUS SITUATION SO I PULLED OFF ON THE NEAREST COUNTY ROAD. THE CAR BEGAN TO OVERHEAT AND I STILL COULDN'T SEE ANYTHING SO I OPENED THE DOOR AND DROVE TO A SAFE SPOT AND TURNED THE CAR OFF. FOUND OUT LATER THAT THERE WAS COOLANT ALL OVER ON THE FLOORBOARDS AND THAT THE HEATER CORE HAS FAILED. *JB

NHTSA ID

10198308

Incident

Jul 20, 2007

Mileage

125,000 mi

WELL, ITS AN OLD CAR YES AND HAVEN'T HAD ANY SEVERE MALFUNCTIONS EXCEPT ON PRETTY MUCH EVERY LATCH MECHANISM ON THE CAR. CURRENTLY, THE TRUNK DOES NOT OPEN. THE LATCH IS BROKE AND WILL NOT OPEN WITH KEY PLACED IN IT OR WITH RELEASE BUTTON. TO OPEN IT, I HAVE TO LAY THE BACK SEATS DOWN AND CRAWL INTO THE TRUNK AND ACTIVATE THE EMERGENCY RELEASE MANUALLY. TO ADD TO THE MESS, BOTH REAR DOORS WILL OPEN BUT UNDER NO CIRCUMSTANCES WILL CLOSE AGAIN. I'VE HAD TO RIG A WIRE TO PULL THE LATCH INTO ITS LOCKED POSITION TO KEEP BOTH DOORS CLOSED. (RESULTING IN THE ONLY 4 DOOR COUPE I KNOW OF!) *TR

NHTSA ID

10188837

Incident

May 1, 2004

DT*:THE CONTACT STATED WHILE DRIVING ON AN INTERSTATE HIGHWAY AT 70MPH, THERE WAS STINGING/BURNING SENSATION TO THE CONTACT'S FOOT. WHEN THE FOOT WAS REMOVED FROM THE GAS PEDAL, A STEAMING LIQUID WAS OBSERVED ON THE FOOT AND ON THE FLOOR AROUND THE PEDALS. THE LIQUID WAS SPEWING FROM AN AREA UNDER DASHBOARD ABOVE THE GAS, BREAK AND CLUTCH PEDALS. STEAM/VAPOR ALSO APPEARED TO BE COMING OUT OF THE DEFROSTER VENTS ON THE DASHBOARD. THE ACCESSORIES WERE IMMEDIATELY TURNED OFF AND THE VEHICLE WAS MOVED OVER AND OFF THE ROAD. THE HOT LIQUID CONTINUED TO SPEW AND BURN THE CONTACT'S FOOT AS THE BRAKES WERE BEING APPLIED. THE VAPOR OF THE LIQUID FILLED THE VEHICLE INTERFERRING WITH THE CONTACT'S VISION.

NHTSA ID

10160740

Incident

Jun 22, 2006

IN LATE FEB 2005 PURCHASED A 1996 VOLKSWAGEN JETTA (WHICH WAS A CERTIFIED USED VEHICLE) AND IN (APPOX) SEPT 2005 WHILE DRIVING DOWN A PACKED FREEWAY DURING RUSH HOUR, IN THE MIDDLE LANE, THE HOOD OF MY VEHICLE FLEW UP. I WAS TRAVELING ABOUT 60-65 MPH AND IT VISUALLY LOOKED LIKE A PIECE OF CARDBOARD CRUMPLING HOWEVER THE IMPACT WAS SO GREAT THAT IT CRACKED MY WINDSHIELD. I CONSIDER MYSELF AND THE PASSENGERS EXTREMELY LUCKY THAT WE WERE NOT INJURED AND/OR DID NOT CRASH. MY VEHICLE SUSTAINED TREMENDOUS BODY DAMAGE TO THE HOOD AND CAN NOT SHUT PROPERLY AND AS I MENTION PREVIOUSLY THE WINDSHIELD IS CRACKED ALL THE WAY ACROSS. I AM UNCERTAIN WHETHER OR NOT SIMILAR VEHICLES TO MINE HAVE HAD PROBLEMS BUT I FEEL THAT THIS WAS A MANUFACTURER DEFECT / FAILURE DUE TO THE FACT OF THE SAFETY LATCH MALFUNCTION. I AM NOT 100% SURE WHETHER OR NOT THE HOOD WAS NOT SHUT COMPLETELY BECAUSE I DID NOT PHYSICALLY CHECK IT BEFORE THE INCIDENT BUT REGARDLESS THAT IS WHY I THOUGHT SAFETY LATCHES WERE PUT INTO USE ON VEHICLE HOODS TO PREVENT SUCH DANGEROUS OCCURRENCES. *JB

NHTSA ID

10156592

Incident

Sep 1, 2005

Mileage

95,000 mi

ON JANUARY 12, 2006, AS I WAS DRIVING MY CAR AT 65 MPH ON THE HIGHWAY AN OPAQUE WHITE GAS WAS QUICKLY RELEASED FROM MY HEATER VENTS AND WITHIN SECONDS EFFECTIVELY TURNED THE PASSENGER COMPARTMENT OF MY CAR INTO A GAS CHAMBER. THE ENGINE TEMPERATURE INCREASED AFTER I WAS ABLE TO SAFELY REMOVE THE VEHICLE OF THE HIGHWAY. MY CAR WAS SOLD WITH A PERMANENT MAINTENANCE FREE PINK VW ANTIFREEZE. THE DOCUMENTATION THAT CAME WITH THE CAR INDICATED THAT OTHER THAN TOPPING OFF THE ANTIFREEZE PERIODICALLY THAT NO MAINTENANCE WAS NECESSARY. IT WAS DETERMINED THAT MY HEATER CORE FAILED; THE DEALER SAYS IT FAILED BECAUSE OF LACK OF MAINTENANCE. IF THE SYSTEM IS MAINTENANCE FREE THEN HOW CAN A COMPONENT FAIL BECAUSE OF LACK OF MAINTENANCE? I ORIGINALLY THOUGHT THE VEHICLE HAD BEEN VANDALIZED, BUT THE DEALER DIFFERED. I WAS UNABLE TO FIND ANY WARNINGS OF THE POSSIBILITY OF THIS OCCURRING IN SERVICE BULLETINS OR ANY OTHER VW LITERATURE. IF THE CATASTROPHIC FAILURE OF A HEATER CORE IS POSSIBLE DOESN'T THE MANUFACTURE HAVE A DUTY TO WARN THE PURCHASERS OF ITS PRODUCTS? *NM

NHTSA ID

10152770

Incident

Jan 12, 2006

Mileage

114,500 mi

ON SEPT 2, 2005 AND SEPT. 6, 2005, UNDER TWO CIRCUMSTANCES INVOLVING QUICK ACCELERATION WITH MODERATE LOAD (TWO ADULTS AND ONE KID. ABOUT 50 LB LOAD IN TRUNK), THE ENGINE KEPT HIGH REVVING AFTER THE GAS PADDLE HAD BEEN FULLY RELEASED, THUS PULLING FORWARD HARD UNINTENTIONALLY; IT KEPT SO DOING FOR SECONDS, EVEN AFTER BRAKING WAS APPLIED FOR THE FIRST FEW SECONDS, AND PUMPED. IT RECOVERED BACK TO NORMAL RESPONSIVENESS AFTER HARD BRAKING FOR AT LEAST FIVE SECONDS IN THE FIRST INCIDENT AND ABOUT THREE SECOND IN THE SECOND. ANOTHER PROBLEM IS THE CRUISE CONTROL NEVER WORKED SINCE THE PURCHASE IN 1996.

NHTSA ID

10136143

Incident

Sep 2, 2005

Mileage

78,000 mi

DT: THE CONSUMER OWNS A 1996 VOLKSWAGEN JETTA. SHE SAID THAT IN 2003 HER REAR TIRE BLEW OUT CAUSING AN ACCIDENT AND ALMOST TAKING THE LIFE OF HER DAUGHTER. WHEN THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS, DEALER HAD TO REPLACE THE WHEEL BEARINGS AND THE WHEEL STRUTS. ON MAY 15, 2005 HER HUSBAND CHECKS THE VEHICLE REGULARLY TO MAKE SURE IT IS SAFE. WHILE CHECKING THE VEHICLE HE NOTICED THE WHEEL WAS LOOSE. THEY TOOK THE VEHICLE BACK TO A TIRE CENTER AND THEY SAID THAT EVERYTHING WOULD HAVE TO BE REPLACED AGAIN. *TT

NHTSA ID

10121077

Incident

Apr 13, 2003

HEATER CORE RUPTURED, CAUSING THE COOLANT TO SPILL OVER THE DRIVER'S FEET. THIS EVENTUALLY CAUSED THE WINDSHIELD TO FOG UP, MAKING THE ABILITY TO SEE THE ROAD DIFFICULT.*AK WHILE CONSUMER WAS DRIVING THE VEHICLE, HE HIT A BUMP AND HOT COOLANT FELL ON HIS FEET. THE STEAM FROM THE HOT COOLANT FOGGED UP THE WINDOWS AND ESCAPED THROUGH THE VENTS. THE CONSUMER PULLED OVER TO PARKING LOT TO AVOID CRASHING BECAUSE OF THE STEAM ON THE WINDOW. VOLKSWAGEN AGREED TO REPAIR HEATING CORE.*SB

NHTSA ID

10117049

Incident

Mar 25, 2005

Mileage

164,493 mi

WINDSHIELD WIPERS AND HEAD LIGHTS WERE WORKING INTERMITTENTLY. CONSUMER TOOK VEHICLE TO DEALER FOR CHECK UP, AND RESULTS SHOWED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED.*AK

NHTSA ID

10106851

Incident

Dec 22, 2003

SMOKE FROM THE STEERING COLUMN. AFTER THE VEHICLE WAS STARTED, A PUFF OF SMOKE AROSE FROM THE STEERING COLUMN AND I LOST USE OF MY WINDSHIELD WIPERS. I HAVE BEEN ONLINE AND HAVE SEEN NUMEROUS SIMILAR COMPLAINTS TO THE SAME AFFECT. SHOULDN'T THIS BE A RECALL ITEM ? AVE HAD QUITE A FEW OTHERS PROBLEMS IN THE 6 MONTHS SINCE WE HAVE OWNED OUR 1996 JETTA. *AK

NHTSA ID

10105707

Incident

Dec 23, 2004

Mileage

106,500 mi

CONSUMER COMPLAINED THAT SIDE WINDOWS WERE NOT GOING UP AND DOWN AT WILL. CONSUMER TOOK THE VEHICLE TO A DEALER, AND WAS TOLD THAT THE MOTOR WINDOW REGULATOR WAS DEFECTIVE. TO HAVE THEM REPAIRED WOULD COST AT LEAST $500.00 PER WINDOW, WHICH CONSUMER DID NOT HAVE.*AK

NHTSA ID

10094117

Incident

Sep 22, 2004

THE REAR SIDE WINDOWS OF MY JETTA HAVE FALLEN INTO THE DOOR. *JB

NHTSA ID

10090456

Incident

Sep 3, 2004

THE STEERING IN THIS 1996 JETTA IS JUST HORRIBLE, NO MECHANIC HAS BEEN ABLE TO REPAIR IT. IM TOLD THERE IS SOMETHING ON THE WHEEL BASE TORN (REAR) AND ITS GOING TO COST ME 800 TO FIX. YET, THE STEERING HAS BEEN THIS WAY SINCE IVE HAD THE CAR AND I HARDLY NOTICED UNTIL I RENTED A CAR (BECAUSE THE CRANK SHAFT IN THE JETTA BROKE TOO). THIS CAR HAS NEVER BEEN IN A COLLISION OR ANY MAJOR TRAMA TO HAVE ANYTHING TORN, IT ONLY HAS 66,000 MILES ON IT, YET IVE HAD TO REPLACE THE CRANK SHAFT, LAST WEEK THE ENTIRE COMPUTER, 2 YEARS AGO THE ENTIRE ENGINE FELL TO THE GROUND (MY LAND LORD DISCOVERED) AND NOW THE STEERING. I THOUGHT VWS WERE SUPPOSED TO BE WELL BUILT CARS. *AK

NHTSA ID

10075256

Incident

Oct 9, 2002

Mileage

54,000 mi

JUST PURCHASED MY FIRST VW JETTA. MAY BE MY LAST VW PERIOD. MY WINDOWS WORK WHEN THEY FEEL LIKE IT. AFTER RESEARCHING THE PROBLEM, I FOUND OUT THIS IS A EXTREMELY COMMON PROBLEM THAT VW TAKES NO REPONSIBILITY FOR. FIXING IT MYSELF, IT COSTS ME $150 EVERY TIME IT HAPPENS. I SHOULD CHARGE VW $70 AN HOUR FOR LABOR!*AK

NHTSA ID

10074777

Incident

Jun 2, 2004

Mileage

90,000 mi

SINCE I HAVE HAD MY 1996 VW JETTA GLS, ALL FOUR WINDOW REGULATORS AND ALL FOUR WINDOW MOTORS HAVE BROKEN. I HAVE SPOKEN TO SEVERAL PEOPLE WHO HAVE HAD THE EXACT SAME PROBLEMS WITH THEIR JETTAS. *AK

NHTSA ID

10067915

Incident

Aug 15, 2002

ALL FOUR WINDOWS IN MY '96 JETTA HAVE MALFUNCTIONED. PROBLEMS INVOLVE THE WINDOW REGULATORS AND THE MOTORS. AS IT IS TODAY, MY VEHICLE HAS THREE OPERATING WINDOWS WITH DEFECTS (MAKES LOUD CRUNCH SOUND WHEN ROLLED ALL THE WAY DOWN) TO A STUCK-HALF-WAY WINDOW THAT WON'T GO UP OR DOWN. *JB

NHTSA ID

10058702

Incident

Mar 20, 2000

THE FRONT PASSENGER SIDE DOOR WAS DAMAGED DURING A COLLISION. THE DOOR WAS REPAIRED AND PAINTED. THE PAINT FUMES ARE VERY STRONG IN THE PASSENGER CABIN OF THE VEHICLE. *NM

NHTSA ID

10057312

Incident

Dec 12, 2003

1996 VW JETTA - DOOR LOCKS WOULD NOT OPERATE WHEN TEMPERATURE IS BELOW 0 C OR 32 F. THIS MATCHES TECHNICAL SERVICE BULLETIN # 57 9702 NHTSA ITEM NUMBER 53643. *LA

NHTSA ID

10052644

Incident

Jan 7, 2004

Mileage

108,000 mi

WHILE DRIVING MY CAR, 1996 VOLKSWAGEN JETTA GLS, FROM THE STORE, I NOTICE THAT THE CHECK ENGINE LIGHT CAME ON AND THEN MY THERMOSTAT STARTED TO GO BACK AND FORWARD LIKE IT WAS OUT OF CONTROL, THEN SMOKE CAME OUT OF MY VENTS INSIDE OF MY CAR. I THOUGHT THIS WAS STRANGE, THAT SMOKE(WHITE SMOKE) CAME FROM INSIDE MY CAR, SO I STOPPED THE CAR AND OPENED THE HOOD, BUT NOTHING WAS BURNING FROM UNDER THE HOOD. I TOLD MY HUSBAND ABOUT THIS AND WE TOOK IT TO OUR MECHANIC WHO DIAGNOSE THAT THE WIRING HARNESS WAS GONE OR WAS BURNED OUT. I THEN ASKED HIM HOW MUCH IT WOULD COST TO GET IT FIXED AND HE STATED THAT THIS COULD BE A COSTLY JOB. I NEEDED MY CAR FIXED SO I TOOK IT TO A EUROPEAN SPECIALIST AUTO SHOP AND THEY FIXED IT FOR A COST OF $800.00 PLUS TAX!!!!! THIS WAS OUTRAGEOUS, BUT I NEEDED TO GET IT FIXED. WHERE CAN I CALL TO GET MY REFUND??? THIS IS ENTIRELY A LOT OF MONEY!!!!! *NLM

NHTSA ID

10049230

Incident

Nov 15, 2003

CONSUMER PURCHASED A USED VEHICLE FROM DEALER AND VEHICLE NEEDED REAR WHEEL CYLINDERS AND BRAKE SHOES. THE WHEEL CYLINDERS WERE LEAKING, AND THE BRAKE SHOES CRUMBLED WHEN REMOVED FOR REPAIR DONE BY CONSUMER SINCE DEALER WAS NOT WILLING TO DO ANYTHING ABOUT IT.*AK

NHTSA ID

10042918

Incident

Mar 11, 2003

Mileage

69,500 mi

WHILE DRIVING AT 65 MPH DRIVER'S SIDE REAR WHEEL FELL OF WITHOUT WARNING. *AK

NHTSA ID

10037944

Incident

Jul 27, 2003

WHILE DRIVING REAR PASSENGER'S SIDE DOOR FLEW OPEN WITHOUT WARNING. DEALER NOTIFIED.*AK

NHTSA ID

10034281

Incident

May 21, 2003