2000 Volkswagen Passat Fuel system Problems

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE AFTER BEING PARKED OVERNIGHT, HE NOTICED A FUEL ODOR. THE CONTACT STATED THAT THE FUEL TANK WAS HALF EMPTY AFTER BEING REFILLED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AND WAS INFORMED THAT THE SEAM IN THE FUEL TANK WAS FRACTURED WHICH CAUSED THE FUEL LEAK. THE FUEL TANK WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

NHTSA ID

11384369

Incident

Nov 12, 2020

Mileage

45,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, SMOKE BILLOWED FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY LEAVE THE ROADWAY, THE HOOD WAS RAISED AND FLAMES APPEARED IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS NOT TOWED AND REMAINED AT THE SCENE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FIRE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT CONTACTED. THE INSURANCE COMPANY WAS NOT MADE AWARE OF THE FIRE. THE CONTACT WAS UNSURE IF THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

11230809

Incident

Jul 3, 2019

WHILE DRIVING ON THE HIGHWAY, WE STARTED SMELLING GASOLINE IN THE CABIN. WE PULLED OVER AND CHECKED UNDER THE HOOD. A FUEL LINE ATTACHED TO THE FIREWALL HAD A LEAK DIRECTLY ABOVE THE EXHAUST SYSTEM, AND WAS SPRAYING GASOLINE EVERYWHERE IN THE ENGINE BAY, INCLUDING THE CATALYTIC CONVERTER AND EXHAUST SYSTEM. WE WERE INFORMED BY TOW TRUCK DRIVER THAT WE WERE INCREDIBLY LUCKY NO FIRE GOT STARTED IN THE ENGINE BAY WHILE WE WERE DRIVING DOWN THE HIGHWAY.

NHTSA ID

10940191

Incident

Jan 5, 2017

Mileage

10 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED FUEL LEAKING UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 49,000. UPDATED 11/01/16*LJ

NHTSA ID

10897203

Incident

Aug 1, 2016

Mileage

49,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE TRANSMISSION WAS FRACTURED AND THERE WAS FUEL LEAKING. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE APPROXIMATE FAILURE MILEAGE WAS 149,000.

NHTSA ID

10766704

Incident

Jul 11, 2014

Mileage

149,000 mi

IN APPROXIMATELY JULY OF 2014 MY VOLKSWAGEN PASSAT STARTED EXPERIENCING ON AND OFF AGAIN PROBLEMS WITH THE ENGINE FIRING. I HAD RECENTLY RETIRED AND WAS NOT DRIVING THE CAR DAILY, AND SO I WAS UNABLE TO ASSOCIATE THE PROBLEM WITH ANY RECENT DRIVING EVENT. HOWEVER, ONE MORNING WHEN THE HESITATION WAS VERY PRONOUNCED I POPPED THE HOOD TO HAVE A LOOK. WATER WAS STANDING ALMOST LEVEL WITH THE TOP OF THE BATTERY IN THE AREA HOUSING THAT PART. I USED MY INDOOR/OUTDOOR VACUUM TO PUMP OUT AS MUCH WATER AS POSSIBLE. WHEN I THOUGHT THE AREA WAS THOROUGHLY DRIED OUT I TOOK THE CAR TO MY LOCAL VOLKSWAGEN CERTIFIED MECHANIC FOR FURTHER INVESTIGATION. HE DIDN'T TAKE LONG TO DETERMINE THAT DRAINAGE HOLES ON BOTH SIDES UNDER THE HOOD WERE CLOGGED. HE WAS ABLE TO UNCLOG THE HOLE ON THE PASSENGER SIDE IMMEDIATELY, BUT THE HOLE ON THE DRIVER SIDE IS LOCATED BENEATH PARTS THAT HAVE TO BE MOVED FOR ACCESS. I RECALLED NUMEROUS TIMES OVER THE YEARS WHEN I WAS CERTAIN I WAS HEARING THE SOUND OF WATER SLOSHING AROUND UNDER THE HOOD. I HAD ASKED ON MORE THAN ONE OCCASION AT TIME OF SERVICE FOR THE SOUND TO BE INVESTIGATED FURTHER. I WAS ALWAYS TOLD THE SAME THING: THERE WAS NOTHING TO EXPLAIN THE SOUND I WAS HEARING. I NOW BELIEVE THIS HAS BEEN A RECURRING PROBLEM OVER THE YEARS I'VE OWNED THE CAR, AND MIGHT HAVE IMPACTED MORE THAN JUST THE BATTERY AT ANY TIME. I THOUGHT THERE SHOULD BE MORE THAN ONE REPORT OF THIS PROBLEM ON FILE.

NHTSA ID

10731607

Incident

Jul 1, 2014

I KEPT NOTICING A SMELL OF GASOLINE. ONE MORNING WHEN I BACKED UP AND LOOKED FORWARD THERE WAS A PUDDLE. I GOT OUT, BENT DOWN AND SMELLED IT. IT WAS GAS. I BACKED UP A LITTLE MORE AND THERE WAS ANOTHER SMALL PUDDLE. IT ALSO WAS GAS. WHEN I FIRST SAW THE PUDDLES OF GAS I CALLED VOLKSWAGEN AND WAS TOLD THERE WAS NO RECALL FOR THIS AND THAT ANY RECALL THAT WAS ON MY VEHICLE HAS BEEN COMPLETE (NOTHING TO DO WITH THE FUEL LEAK). JUST THIS PAST WEEK (5/2/15) I NOTICED THE SAME SMELL. THIS TIME I COULD ACTUALLY SEE THE FUEL LEAKING FROM THE BACK PASSENGER SIDE AND I FILMED IT ON MY CELL.

NHTSA ID

10715961

Incident

Nov 18, 2013

Mileage

132,000 mi

AS WITH SIMILAR REPORTS THE CAR WAS DRIVEN THEN SAT FOR 24HRS, WHEN IT WAS STARTED AGAIN A STRONG GAS SMELL WAS NOTICED AND A PUDDLE OF GAS WAS FOUND UNDER THE PASSENGER REAR PANEL. IMMEDIATELY TOOK TO REPAIR STATION WHERE THEY COULD NOT FIND A LEAK. THEY FILLED THE TANK WITH GAS AND LEFT IT TO SIT OVERNIGHT AND UNDER PRESSURE. NO LEAK. 3 WEEKS HAVE PASSED WITH TYPICAL DRIVING, NOT EXCESSIVE USE AND NO LEAKS UNTIL TODAY SEPTEMBER 5TH 2014. STARTED THE CAR UP AND BACKED UP TO FIND A GAS PUDDLE AGAIN. *TR

NHTSA ID

10631008

Incident

Aug 12, 2014

Mileage

114,248 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A FUEL ODOR COMING FROM THE HOOD OF THE VEHICLE. THE CONTACT LIFTED THE HOOD AND NOTICED THAT FUEL WAS LEAKING FROM THE FUEL PIPE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.

NHTSA ID

10617171

Incident

Jul 18, 2014

Mileage

134,000 mi

WHEN I DO NOT USE THE CAR AFTER A FEW DAYS, AND THEN START IT, FUEL LEAKS FROM THE REAR PASSENGER SIDE OF THE CAR. IT SEEMS TO DRIP QUITE A BIT AT FIRST AND COMES FROM THE FRONT SOMEWHERE. DRIVING ALONG THE FIRST MILE YOU CAN SEE THE DRIP CONTINUES ON THE GROUND. THE LEAK STOPS AND AS LONG AS I USE THE CAR DAILY, NO LEAK REAPPEARS. WHEN I TOOK IT TO THE DEALER A FEW YEARS AGO, THEY COULDN'T FIND THE PROBLEM BECAUSE IT STOPPED LEAKING. I SHOULD HAVE LEFT IT THERE A FEW DAYS I GUESS. I STILL HAVE THE PROBLEM AND ONLY AFTER A FEW DAYS OF SITTING. *TR

NHTSA ID

10460587

Incident

May 6, 2008

Mileage

70,000 mi

THE CAR WAS PARKED. I ATTEMPTED TO START THE ENGINE, BUT IT DID NOT TURN OVER. I TRIED A SECOND TIME AND NOTICED WHITE SMOKE COMING FROM UNDER THE ENGINE HOOD. BY THE TIME I WENT INSIDE TO CALL FOR ROAD SERVICE AND RETURNED TO THE PARKING LOT, THERE WERE FLAMES SHOOTING FROM UNDER THE HOOD. THE CAR WAS DESTROYED. *TR

NHTSA ID

10437421

Incident

Nov 27, 2011

MAKE:VOLKSWAGEN MODEL: PASSAT YEAR:2000 STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION WAS FIRST REPORTED TO VW HILEY ABOUT 3 YEARS AGO. THEY CHECKED IT OUT AND COULD FIND NOTHING. I HAD SEEN OCCASIONAL LEAKS SINCE BUT THIS TIME SCARED ME BECAUSE IT WAS SO MUCH THAT MY GAS GAUGE MOVED AS A RESULT. I WAS HEADED TO WORK WHICH IS ABOUT 20 MINUTES AWAY. BY THE TIME I GOT THERE THE LEAK HAD STOPPED. TODAY IS JULY 5TH 2011. IT WAS SITTING SINCE JULY 1ST 2011. *KB

NHTSA ID

10410581

Incident

Jul 5, 2011

Mileage

106,000 mi

STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION HAS BEEN IN EXISTENCE FOR ABOUT FIVE YEARS, BUT NEITHER THE VW DEALER WHERE I BOUGHT THE CAR, NOR AN INDEPENDENT GARAGE WAS ABLE TO FIND IT (BY THE TIME I GOT IT INTO THE SHOP, THE LEAK WAS GONE AND THE GAS HAD EVAPORATED). IT HAS GRADUALLY WORSENED, THOUGH, AND LAST WEEK I TOOK IT TO THE NEAREST VW DEALER. WHEN THEY DETECTED THE STRONG ODOR OF GAS, THEY PARKED IT IN AN ISOLATED AREA. THE NEXT DAY THEY CALLED AND TOLD ME THAT THE "ROLLOVER" VALVE WAS DEFECTIVE AND THAT THE CAR NEEDED A NEW GAS TANK. IT IS CURRENTLY IN THE SHOP AT DREW VOLKSWAGEN IN LA MESA, CA, AWAITING PARTS. WHEN IT OCCURS, THIS IS A VERY SUBSTANTIAL LEAK WITH GAS STREAMING ONTO THE GROUND.

NHTSA ID

10409956

Incident

Jun 15, 2011

Mileage

50,000 mi

GASOLINE IS LEAKING FROM UNDER THE PASSENGER REAR SIDE OF MY 2000 VOLKSWAGEN PASSAT GLS V6; THE GASOLINE IS DRIPPING FROM THE HEAT SHIELD IN FRONT OF THE REAR TIRE. NOTE THAT THE FUEL DOOR / FILLER NECK IS ON THAT SIDE. SEE THE EXCERPT (FOLLOWING) FROM HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2000/VOLKSWAGEN/PASSAT/FUEL+SYSTEM COMPLAINT NUMBER: 10280791: SIMILAR TO OTHER REPORTS, THERE IS APPARENTLY A COMMON DEFECT WITH OLDER VW PASSATS (MINE IS A 2000) FUEL LINES LEAKING GAS WHEN PRESSURIZED BY THE FUEL PUMP. THE GAS LEAK OCCURS IN THE RUBBER FUEL LINE NEAR THE GAS TANK AND FILTER. THE LEAK WAS VISIBLE IN FRONT OF THE REAR WHEEL ON THE PASSENGER SIDE. MECHANICS, INCLUDING THE DEALER HAVE TROUBLE LOCATING THE LEAK SINCE IT APPEARS TO BE INTERMITTENT AND ONLY WHEN THE CAR IS FIRST STARTED FOR A MINUTE OR SO. THE LEAK IS SIGNIFICANT AND TYPICALLY INVOLVES ABOUT A CUP OF GAS. IT IS A FIRE HAZARD THAT SHOULD BE PART OF A RECALL, BUT APPARENTLY IS NOT. THIS PROBLEM SEEMS TO BE RELATED TO THE FOLLOWING RECALL FOR VOLKSWAGENS EQUIPPED WITH THE 1.8T (TURBO) MOTOR OR 4MOTION (AWD): 2000 VOLKSWAGEN PASSAT RECALL ID FROM NHTSA: 08V156000. *TR

NHTSA ID

10356922

Incident

Sep 22, 2010

Mileage

133,602 mi

PREVIOUSLY REPAIRED FUEL LEAK HAS RECURRED, ~18 MONTHS LATER. LEAK CAN BE SEEN WHEN VEHICLE HAS BEEN SITTING FOR SEVERAL HOURS AND IS THEN BACKED OUT OF GARAGE DOWN INCLINED DRIVEWAY. FUEL IS LEAKING FROM PASSENGER REAR WHEEL AREA. *TR

NHTSA ID

10335220

Incident

Jun 1, 2000

Mileage

68,000 mi

SIMILAR TO OTHER REPORTS, THERE IS APPARENTLY A COMMON DEFECT WITH OLDER VW PASSATS (MINE IS A 2000) FUEL LINES LEAKING GAS WHEN PRESSURIZED BY THE FUEL PUMP. THE GAS LEAK OCCURS IN THE RUBBER FUEL LINE NEAR THE GAS TANK AND FILTER. THE LEAK WAS VISIBLE IN FRONT OF THE REAR WHEEL ON THE PASSENGER SIDE. MECHANICS, INCLUDING THE DEALER HAVE TROUBLE LOCATING THE LEAK SINCE IT APPEARS TO BE INTERMITTENT AND ONLY WHEN THE CAR IS FIRST STARTED FOR A MINUTE OR SO. THE LEAK IS SIGNIFICANT AND TYPICALLY INVOLVES ABOUT A CUP OF GAS. IT IS A FIRE HAZARD THAT SHOULD BE PART OF A RECALL, BUT APPARENTLY IS NOT SINCE THE DEALER CHARGED ME FOR THE DIAGNOSIS AND REPAIR. *TR

NHTSA ID

10280791

Incident

Jul 30, 2009

Mileage

90,000 mi

2000 VW PASSAT 1.8T HAD FUEL LEAK. THE CAR HAD A FUEL LEAK IN THE GARAGE WHICH COULD HAVE CAUSED AFIRE. THIS IS A SERIOUS PROBLEM. I DID SOME READING AND THOUGHT IT WOULD BE COVERED BY A RECALL. HOWEVER, THE VW DEALER CHARLES MAUND VOLKSWAGAN INDICATED THAT IT WAS NOT COVERED BY ANY RECALL. *TR

NHTSA ID

10278967

Incident

Apr 10, 2009

Mileage

120,000 mi

MY 2000 VW PASSAT 1.8 MANUAL SMELLS STRONGLY OF GASOLINE ON A SEMI-REGULAR BASIS. DESPITE THE FACT THAT OTHER PASSATS FROM 1999-2005 ARE SUBJECT TO A RECALL FOR THIS PROBLEM, VW HAS REFUSED TO CORRECT THE SAME PROBLEM IN MY CAR, BASED ON THE VIN NUMBER. *TR

NHTSA ID

10267867

Incident

Feb 1, 2008

TL*THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHEN THE CONTACT STARTED THE VEHICLE, THERE WAS FUEL LEAKAGE AND SMOKE APPEARED FROM THE MUFFLER. SHE RECEIVED A RECALL NOTICE FOR THE FUEL SYSTEM AND TOOK THE VEHICLE IN FOR REPAIR. A TECHNICIAN REPAIRED THE VEHICLE, BUT DID NOT ACKNOWLEDGE THE SMOKE. THE CONTACT WAS INFORMED THAT THERE WAS NO FAILURE WITH THE VEHICLE. SHE HAS NOT DRIVEN THE VEHICLE SINCE THE REPAIR BECAUSE SHE FEELS IT IS UNSAFE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 156,520.

NHTSA ID

10267394

Incident

Apr 16, 2009

Mileage

156,520 mi

THE FUEL LINE ON MY 2000 VOLKSWAGEN PASSAT SIMPLY BROKE AS I WAS DRIVING. I DON'T KNOW HOW IT OCCURRED. THE FUEL LINE WAS REPAIRED AT A VOLKSWAGEN DEALERSHIP IN GLASTONBURY, CT. I AM FILING THIS COMPLAINT BECAUSE I AM NOT GETTING A SATISFACTORY ANSWER TO WHY THIS PROBLEM IS NOT BEING HANDLED THROUGH A RECALL EARLIER THIS YEAR OF 412,000 1999-2005 PASSATS AND THE POSSIBILITY THAT OTHERS ARE HAVING THE SAME PROBLEM. *TR

NHTSA ID

10254072

Incident

Jan 3, 2009

Mileage

134,000 mi

VOLKSWAGEN HAS A RECALL DUE TO FIRE HAZARD. BECAUSE I LIVE IN A SMALL TOWN, THE NEAREST VOLKSWAGEN DEALERSHIP IS IN THE NEXT STATE. WHEN I EXPLAINED THIS TO THE VOLKSWAGEN PEOPLE THEY SAID I HAD TO DO THIS RECALL AT A DEALERSHIP WITH NO COMPENSATION FROM THEM FOR MY TIME OR MY EXPENSE. THEY ALSO SAID THAT SINCE I CALLED THEM, THEY ARE NO LONGER LIABLE FOR THIS PROBLEM IF MY CAR CAUGHT ON FIRE. I TOLD THEM THAT I AM NOT WAIVING ANY OF MY RIGHTS WITH THIS PHONE CALL AND ASKED TO HAVE THE CALL RECORDED. THE NEAREST DEALERSHIP IS A SIX HOUR DRIVE FROM MY RESIDENCE AND BE EXPECTED TO WAIT THREE OR MORE HOURS FOR THE REPLACEMENT ON MY VEHICLE TO BE DONE. THIS IS UNACCEPTABLE FOR ME DUE TO THE FACT THAT I AM DISABLED AND ON A LIMITED INCOME. WE HAVE A VOLKSWAGEN REPAIR SHOP HERE IN MY TOWN. GERMAN MOTORS 1065 K ST ARCATA CA 95521 THEY WILL NOT LET ME HAVE THE RECALL DONE THERE. *TR

NHTSA ID

10250843

Incident

Dec 5, 2008

Mileage

119,000 mi

HEAT SHIELD CAUGHT FIRE WHILE DRIVING DOWN THE ROAD. I HAD BOUGHT THE CAR FROM CARMAX WHO HAD LIED ABOUT THE AUTO FROM THE BROKEN SEATBELTS FORWARD ON THE DAY OF SALE. VW DEALERSHIP REPAIRED AUTO AFTER FIRE BUT ANOTHER MISHAP WITH HEATSHIELD WHEN IT FELL OFF AND UNDER THE PASSENGER FRONT TIRE @ 65 MILE PER HR, WHILE DRIVING DOWN TURNPIKE. I WAS NOT INJURED THANKS TO A TRUCK DRIVER WHO ASSISTED MY NAVIGATION TO THE SIDE OF THE ROAD AND CUT OFF THE SHIELD SO I COULD RETURN HOME. THE TIE ROD WAS DAMAGED AND HAD TO BE REPLACED, SINCE THE FIRE THE CAR HAS NEVER BEEN THE SAME AND HAS BEEN A HAZARD, STALLING ON A BELTWAY, ETC... NO APPARENT REASON FOR THIS WAS FOUND ON A DIAGNOSTIC MACHINE AS IT HAS BEEN CHECKED SEVERAL TIMES..IT IS WHEN THE EMISSION LIGHT COMES ON AND A BAD SENSOR NEEDS REPLACED OR SWITCH. BUT NOTHING FIXES THIS CAR FOR LONG. *TR

NHTSA ID

10233137

Incident

Jun 30, 2006

Mileage

80,000 mi

EVENTS LEADING TO FAILURE. FIRST THE FUEL TANK DOOR SWITCH BECAME INOPERABLE FORCING ME TO REMOVE THE OPENING MECHANISM WHICH ALLOWED ME TO OPEN IT MANUALLY. TWO DAYS LATER THE ALARM BEGAN TO SOUND ON IT'S OWN, AND DID SO FOR AT LEAST 8 HOURS OR MORE. BY THE END OF THE NIGHT THE CAR WOULD NOT TURN OVER AND ALL THE FUNCTIONS IN THE DRIVERS SIDE DOOR AS WELL AS THE ALARM, CEASED TO OPERATE APART FROM THE LOCKS. I HAD TO REMOVE THE DRIVERS SIDE SEAT AND CARPET TO ACCESS THE CONVENIENCE CONTROL MODULE AND SUBSEQUENT WIRING, WHILE UNDERNEATH THE CARPET I TRIED TO SUCTION UP AS MUCH MOISTURE AS I COULD OFF THE BOTTOM OF THE FLOOR AND OUT OF THE PADDING. AS OF KNOW I AM QUOTED TO PURCHASE A NEW CONVENIENCE CONTROL MODULE TO CORRECT THE SITUATION. *TR

NHTSA ID

10214736

Incident

Jan 7, 2008

Mileage

113 mi

TL*THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WILL NOT READ THE AMOUNT OF FUEL THAT IS PRESENT IN THE FUEL TANK. THE FAILURE IS CAUSED BY A FUEL SENDER MALFUNCTION. THE DEALER AND THE MANUFACTURER REFERENCED RECALL # 01V157000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THEY STATED THAT ONCE A RECALL REPAIR IS PERFORMED, THEY DO NOT PERFORM THE REPAIR AGAIN. THE CONTACT'S VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 40,000 AND FAILURE MILEAGE WAS 38,000. UPDATED 01-14-08. *KB THE CONSUMER STATED HE IS EXPERIENCING PROBLEMS AGAIN. UPDATED 12/12/07. *JB

NHTSA ID

10193928

Incident

Jun 1, 2007

Mileage

38,000 mi

DT*: THE CONTACT STATED A PUDDLE OF FUEL ON THE DRIVEWAY WAS NOTICED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FUEL LINES, CLAMPS AND SEAL WERE REPLACED. ALSO, WHILE DRIVING AT VARIOUS SPEEDS, THE ABS LIGHT ILLUMINATED ON THE DASHBOARD. THE DEALER REPLACED THE ENTIRE ABS SYSTEM.

NHTSA ID

10165429

Incident

Aug 8, 2006

Mileage

81,000 mi