2009 Volkswagen Passat Problems

The check engine light and oil pressure light appeared on my dash screen as I was driving home from work. I pulled over to the nearest repair shop to have the vehicle diagnosed. Upon arriving, the mechanic noticed my oil was low and filled the car with oil. Once that was completed, the car would not start. I noticed it made unusual noises after several more failed attempts. I had the vehicle towed to an authorized dealership to further troubleshoot and they were able to confirm that the engine jumped time due to a failed timing chain tensioner, which requires a new engine since mine is an interference engine. Due to the timing chain tensioner failing, there was catastrophic damage done to the engine leaving the vehicle inoperable.

The contact owns a 2009 Volkswagen Passat. The contact stated that while driving approximately 35 MPH, the check engine and oil warning lights started flashing on the instrument panel. The contact took the vehicle to a certified mechanic, who attempted to start the vehicle; however, the engine skipped, and the vehicle failed to start. The contact stated that the timing chain had failed. The vehicle was not repaired. The contact learned of the Volkswagen Timing Chain Settlement, ID Number: 16/2765 for the timing chain; however, the campaign ended in 2019. The VIN was not under recall, and the vehicle was not included in the Volkswagen Timing Chain Settlement. The manufacturer was not informed of the failure. The failure mileage was 112,322.

On [XXX], a MIDAS shop found an alleged crack in the front part of the gas tank on the upper part of the tank by the floor board. The manager also stated that it could be a plastic seal from the fuel pump on the top part of the tank. The tank is located next to the exhaust system. My 2009 VW CC 4-Motion only has 122,xxx miles on it. I could see a wet spot and presumed I smelled gas but was not sure. He gave me a printout of what the cost would be to repair the system. I told him I would be filing a report with NHTSA. I then called Lunde's VW, W. Bell Rd., Peoria, AZ. I talked to a Tyler Rodriquez and he said there were no recalls and VW could not warrant the problem. I told him I would be filing a report with NHTSA and he did not respond to me. Both places were quite fast to elicit repairs from their business. Only MIDAS pointed out the exhaust pipes being near the gas tank. Approximately six years ago I had been to another VW dealership in Phoenix about my gas gauge needle not working properly and I was sold a gas cap to fix the problem. The problem has been a recurring one and my gas mileage fluctuates. This situation reminds me of the mid-1970s problem with the Ford Pinto gas tanks, which I believe was never resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I put fuel in the car and about to start the car and it won’t start. Lights flickering.

The power steering system failed. At first I thought the steering wheel was locked. I started the car and could not turn the wheel. The power steering light illuminated in red and there was a loud beeping sound when the car is turned on. It was not until the car was towed that I realized that the wheel was not locked. The tow truck driver was able to turn the wheel to steer the vehicle on to the truck bed. I had someone plug in a diagnostic machine. I do not recall the exact code but he said the power steering system was not getting a signal. He replaced the steering angle sensor but that did not fix the issue. I had passenger at the time and was concerned for my safety. Luckily, the system failed while the car was parked, but we were left stranded. I have come across the following information on the Kelley Blue Book website: Steering: gear box (other than rack and pinion) NHTSA CAMPAIGN ID: 08V577000 Report Date: Oct 31 2008 Vehicles Affected: 130 Consequence: DRIVER ATTEMPTS TO OVERCOME THE SYSTEM DURING MALFUNCTION WILL CAUSE (1) VIBRATIONS IN THE STEERING WHEEL; (2) THE STEERING SYSTEM MOTOR TO TURN OFF; (3) THE RED STEERING SYSTEM MALFUNCTION INDICATOR LIGHT TO ILLUMINATE; AND (4) AUDIBLE WARNINGS TO CHIME. A MALFUNCTIONING STEERING SYSTEM COULD LEAD TO A CRASH WITHOUT WARNING. What You Should Do: DEALERS WILL REPLACE THE STEERING GEAR IN THE AFFECTED VEHICLES. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 5, 2008. OWNERS MAY CONTACT VW AT 1-800-4822-8987. Summary: VW IS RECALLING 130 2009 PASSAT, PASSAT WAGON, AND PASSAT CC VEHICLES. SOME VEHICLES MAY HAVE AN ELECTROMECHANICAL STEERING GEAR CONTROL UNIT THAT CAN MALFUNCTION DUE TO A DAMAGED CAPACITOR. IF THIS MALFUNCTION OCCURS, THE DRIVER'S STEERING INPUT IS NOT PROPERLY PROCESSED BY THE SYSTEM AND THE VEHICLE MAY NOT RESPOND AS THE DRIVER INTENDS. THIS DEFECT CAN ONLY OCCUR IMMEDIATELY AFTER VEHICLE START-UP WHEN THE STEERING WHEEL IS MOVED FOR THE FIRST TIME AND AT SPEEDS LESS THAN 5 MPH.

The power steering system fails when the engine/engine compartment gets hot. The problem has appeared after the car has been shut down (such as when refueling or a quick run into a store) and then restarted. When the key is pushed in to start the car, there is a loud grinding noise, a visible shimmy of the steering wheel, followed by the red steering wheel icon indicating there is a problem and 3 chimes. The steering wheel is locked in position with very limited turning ability and ability to control the direction of the car.

The power steering system failed. At first I thought the steering wheel was locked. I started the car and could not turn the wheel. The power steering light illuminated in red and there was a loud beeping sound when the car is turned on. It was not until the car was towed that I realized that the wheel was not locked. The tow truck driver was able to turn the wheel to steer the vehicle on to the truck bed. I had someone plug in a diagnostic machine. I do not recall the exact code but he said the power steering system was not getting a signal. He replaced the steering angle sensor but that did not fix the issue. I had passenger at the time and was concerned for my safety. Luckily, the system failed while the car was parked, but we were left stranded. I have come across the following information on the Kelley Blue Book website: Steering: gear box (other than rack and pinion) NHTSA CAMPAIGN ID: 08V577000 Report Date: Oct 31 2008 Vehicles Affected: 130 Consequence: DRIVER ATTEMPTS TO OVERCOME THE SYSTEM DURING MALFUNCTION WILL CAUSE (1) VIBRATIONS IN THE STEERING WHEEL; (2) THE STEERING SYSTEM MOTOR TO TURN OFF; (3) THE RED STEERING SYSTEM MALFUNCTION INDICATOR LIGHT TO ILLUMINATE; AND (4) AUDIBLE WARNINGS TO CHIME. A MALFUNCTIONING STEERING SYSTEM COULD LEAD TO A CRASH WITHOUT WARNING. What You Should Do: DEALERS WILL REPLACE THE STEERING GEAR IN THE AFFECTED VEHICLES. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 5, 2008. OWNERS MAY CONTACT VW AT 1-800-4822-8987. Summary: VW IS RECALLING 130 2009 PASSAT, PASSAT WAGON, AND PASSAT CC VEHICLES. SOME VEHICLES MAY HAVE AN ELECTROMECHANICAL STEERING GEAR CONTROL UNIT THAT CAN MALFUNCTION DUE TO A DAMAGED CAPACITOR. IF THIS MALFUNCTION OCCURS, THE DRIVER'S STEERING INPUT IS NOT PROPERLY PROCESSED BY THE SYSTEM AND THE VEHICLE MAY NOT RESPOND AS THE DRIVER INTENDS. THIS DEFECT CAN ONLY OCCUR IMMEDIATELY AFTER VEHICLE START-UP WHEN THE STEERING WHEEL IS MOVED FOR THE FIRST TIME AND AT SPEEDS LESS THAN 5 MPH.

I put fuel in the car and about to start the car and it won’t start. Lights flickering.

RECALL UPDATE: CURRENTLY, INTAKE MANIFOLD NEEDS TO BE REPAIRED-ENGINE LIGHT ON-COST $1400.00. TOOK CAR TO DEALERSHIP FOR FUEL PUMP WAS TOLD IT WAS REPLACED BUT WOULD NOT GIVE EVIDENCE THAT IT WAS. SIDE FRONTAL AIR BAG NEVER REPLACED-WAS TOLD BY DEALERSHIP DID NOT NEED IT.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. UPON PURCHASING THE VEHICLE USED, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO VOLKSWAGEN OF ORANGE PARK (7220 BLANDING BLVD, JACKSONVILLE, FL 32244 (855) 758-7110) WHERE SHE WAS INFORMED THAT SHE WOULD HAVE TO PAY $100 TO HAVE THE INDICATOR TURNED OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED AND ADVISED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE FAILURE MILEAGE WAS UNKNOWN.

MY VW PASSAT 2009 SUSTAINED ENGINE FAILURE DUE TO FAILURE TIMING CHAIN/TIMING CHAIN TENSIONER AND NOW NEEDS VERY EXPENSIVE ENGINE REPAIR OR REPLACEMENT OF ENGINE. CAR DROVE OKAY FOR 15 MINUTES IN THE MORNING THEN IT WAS THEN PARKED FOR ABOUT 2 HOURS. WHEN TRYING TO RE-START THE CAR, THE CAR WOULD NOT START. MECHANIC NOTED ABSENT COMPRESSION IN 2 CYLINDERS AND DIAGNOSED IT TO BE DUE TO TIMING CHAIN SLIPPING. THIS HAPPENED AT 80,000MILES AND LESS THAN 10 YEARS (9 YEARS 9 MONTHS) OF PURCHASE OF THE VEHICLE. VW'S EXTENDED WARRANTY COVERS REPAIR/REPLACEMENT OF TIMING CHAIN BUT DOES NOT COVER REPAIR OF ENGINE DAMAGE RESULTED DUE TO TIMING CHAIN FAILURE. THE CAR WAS SERVICED AT VW DEALER REGULARLY AND THERE WAS NO WARNING OR INDICATION OF IMPENDING FAILURE OF THE TIMING CHAIN. OTHER OWNERS OF VW VEHICLES HAVE ALSO COMPLAINED OF HAVING IDENTICAL PROBLEMS ON ONLINE COMMUNITY WITH SOME PEOPLE COMPLAINING OF ENGINE STALLING WHILE DRIVING. THIS APPEARS TO BE A DEFECTIVE DESIGN RATHER THAN WEAR AND TEAR DUE AGEING AND I FEEL THAT VW SHOULD RECALL THE AFFECTED VEHICLES TO REPAIR THE PROBLEMS.

3 DIFFERENT OCCASIONS MY CAR WOULD LOOSE POWER AND SHUT DOWN ON THE HIGHWAY. I HAD IT TOWED AND ALL THREE TIMES THEY STATED IT WAS DIFFERENT THINGS AND THAT THEY HAD TO TAKE STEPS IN REPLACING GOOD PARTS TO FIND THE BAD ONES. JUST TO FIND OUT THAT IT WAS THE FUEL PUMP CONTROL MODULE THAT THEY THOUGHT IT WAS THE WHOLE TIME. NOW THERE IS A RECALL ON IT. WHICH I HAVE SUMMITTED THE PAPER WORK AND THEY CONVENIENTLY CANNOT FIND. THIS PAST WEEKEND MY CAR WOULDN'T TURN OVER AT ALL WHEN I TRIED TO START IT IN A PARKING LOT SO I HAD IT TOWED FOR THE 4TH TIME IN 2.5YEARS. THEY ARE CLAIMING THAT THE ENGINE MOTOR IS BAD AND IT WOULD COST $7500.00 TO REPLACE. THE TECHNICIAN CANNOT FIND ANY OIL LEAKS ND CLAIM THERE WAS ONLY ABOUT A HALF OF COURT OF OIL IN THE MOTOR. I HAD THE OIL CHANGED LESS THAN 2 MONTHS PRIOR AND BOTH VOLKSWAGEN AND MY MECHANIC SAID THAT THERE IS NO WAY IT COULD OF RUN FOR THAT LONG ON HALF A COURT OF OIL AND SHOULD HOLD 5.6 QUARTS. WHICH LEADS TO THE MOTOR EATING SO TO SPEAK THE OIL. ( A BAD ENGINE) ALTHOUGH I SPENT OVER $20'000.00 ON THIS VEHICLE AND HAVE HAD ALL THESE ISSUES VOLKSWAGEN IS TELLING ME THAT THEY WILL NOT HELP AT ALL WITH REPAIRING THE ENGINE. THAT I WILL HAVE TO EAT THE $9000.00 STILL OWED ON THE VEHICLE. WORDS CANNOT DESCRIBE HOW DISAPPOINTED I AM WITH THE CUSTOMER SERVICE BY VOLKSWAGEN.

THE CAR HAS STALLED MULTIPLE TIMES WHILE DRIVING. LIGHTS POP ON AND THE FUEL PUMP IS THE ERROR CODE, ALONG WITH MISFIRES. I HAVE HAD AT LEAST A DOZEN OR MORE CLOSE CALLS WITH THE STALL OUT AND FAILURE TO START UP, AND AT LEAST 2-3 TIMES I HAVE ALMOST BEEN SERIOUSLY INJURED OR KILLED DUE TO THE STALL OUT. IT STALLS WHEN ITS IN MOTION OR EVEN WHEN IT IS PARKED AND IS STARTING UP.

THE VEHICLE HAS ISSUES WITH THE FUEL PUMP , INTAKE & CYLINDERS . I WAS ABLE TO CHANGE THE FUEL PUMP BUT NOTICED ONLINE THE VEHICLE HAS BEEN RECALLED FOR THESE SAME ISSUES . WHEN TURNING THE CAR ON AND DRIVING IT TURNS OFF AND HARDENING THE STEERING WHEEL

TAKATA RECALL COIL SPRINGS BREAKAGES

TAKATA RECALL WANTING TO KNOW IF MY CAR IS ONE THAT HAS BEEN RECALLED FOR 18V148000 AND 08V57700 FOR SUSPENSION

The abs sensors are not functioning although they have been replaced. The dashboard has multiple failure lights. The vehicle is a VW CC not covered by the ABS recall although it exhibits identical issues.

2009 VW CC PULLING OUT INTO CROSS TRAFFIC THE ELECTRIC CONTROLLED PARKING BRAKE LOCKS UP. I HAVE HAD THIS HAPPEN SEVERAL TIMES NOW. I REFUSE TO SELL THE CAR LIKE IT IS OR LET ANYONE DRIVE IT. IT APPEARS TO BE RELATED TO THE SEATBELT. IF IT HAPPENS I UNDO MY SEATBELT AND REINSERT IT TO GET IT TO WORK AGAIN. IT SEEMS LIKE IT'S NOT PROGRAMMED TO BE A FAIL SAFE SYSTEM. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

2009 VW CC PULLING OUT INTO CROSS TRAFFIC THE ELECTRIC CONTROLLED PARKING BRAKE LOCKS UP. I HAVE HAD THIS HAPPEN SEVERAL TIMES NOW. I REFUSE TO SELL THE CAR LIKE IT IS OR LET ANYONE DRIVE IT. IT APPEARS TO BE RELATED TO THE SEATBELT. IF IT HAPPENS I UNDO MY SEATBELT AND REINSERT IT TO GET IT TO WORK AGAIN. IT SEEMS LIKE IT'S NOT PROGRAMMED TO BE A FAIL SAFE SYSTEM. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TENSION BELT, SHAKING & JUMPING THE ENGINE FEELS LIKES IT'S GOING TO FALL, THE MANIFORD VOLKSWAGEN HAS EXTENDED THE EMISSIONS CONTROL SYSTEMS WARRANTY FOR THE INTAKE MANIFOLD UNDER SPECIFIC CONDITIONS TO 10 YEARS OR 120,000 MILES, WHICHEVER OCCURS FIRST, FROM THE VEHICLE'S ORIGINAL IN-SERVICE DATE, FOR CERTAIN 2008 ' 2011 MODEL YEAR VOLKSWAGEN 2.0T ENGINE VEHICLES WITH ENGINE CODES CBFA AND CCTA., "WHICH I WENT TO THE VW SERVICE CENTER, AND THEY WASN'T TRYING TO HONOR ANY OF RECALLS OR THE EXTENDED, THIS WAS THE WORST SERVICE I EVER HAD, "I ALWAYS TAKE MY CAR TO THE DEALERSHIP SERVICE CENTER, I HAVE ALWAYS HAD TOYOTA DUE ALL MY SERVICE, AS I WAS SAYING, "I TOOK MY CAR IN FOR THE EXTENDED WARRANTY AND THAT'S WHEN ALL HELL BROKE LOOSE, THEY STARTED TRYING TO HAVE ME FIX OTHER STUFF ON MY CAR, COSTING $2,400.00, THE MAN WAS FORCING ME TO DO AN ENGINE SERVICE, AND WHEN I SAID I WASN'T READY TO DO THAT, HE BECAME MAD AND STARTED SAYING NOTHING WRONG WITH THE EXTENDED MANIFOLD, EVERYTHING WAS WORKING GOOD ON MY CAR UNTIL I BROUGHT MY CAR IN, EVEN THE MECHANICS MAN WAS SAYING HOW MY CAR WAS IN GOOD CONDITION, THE CRAZY THING, I HAD AN APPOINTMENT THAT WAS MADE WITH THE VW CUSTOMER CARE FOR THE EXTENDED WARRANTY, & THEY HAD MY CAR FOR OVER 7 HOURS AND ALL WAS DONE WAS AND REGULAR OIL CHANGE, "WHICH I THOUGHT THEY DID AN TRANSMISSION OIL CHANGE SINCE THAT'S WAS WHAT THEY WAS TELLING ME I NEEDED, BECAUSE THE ENGINE LIGHT WAS ON, AND I DIDN'T NEED A REGULAR OIL CHANGE, I JUST HAD ONE TWO MONTHS PRIOR, THEY WAS LIKE SAL-VERGERS, BECAUSE THEY HAVE A LOT OF RECALLS AND EXTENDED SERVICES, THEY NOT TRYING TO HONOR OF FOR FILL ANY OBLIGATION OF THE LAW, IT'S LIKE THEIR SALES PEOPLES IS TOLD TO MAKE THE PEOPLE WITH EXTENDED WARRANTY, RECALLS, FOUND SOMETHING WRONG, OR MAKE SOMETHING WRONG OTHER THEN THE CUSTOMER'S EXTENDED WARRANTY, RECALL, FOR MORE INFO CALL [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

THERE ARE 3 COMPLAINTS. I HAVE PURCHASED 2 VOLKSWAGEN PASSATS IN 2009. ONE IS WORKING FINE EXCEPT WINDSHIELD TANK LEAK, AND THE OTHER ONE HAS THE LEAKAGE AND AT THE SAME TIME AN ENGINE PROBLEM. I WOULD LIKE TO RECALL THE OTHER ONE OF WHICH I HAVE REGISTERED WITH VEHICLE ID HERE FOLLOWED BY THE BELOW REASONS AND REQUESTS. 1. WINDSHIELD TANK LEAKAGE SINCE THERE WAS NO ACCIDENT AND IT NATURALLY LEAKED. 2. ON THE 17TH OF NOVEMBER 2011, THE CAR SUDDENLY STOPPED AND EXHALED BLACK SMOKE AND I COULD NOT DRIVE ANY MORE. I DEFINITELY STOPPED AND CALLED A WRECK CAR AND WENT DIRECTLY TO THE DEALER. THE DEALER REPORTED AS STEERING COLUMN MODULE PROBLEM. (ALSO MENTIONED ABOUT INJECTOR ) 3. ON THE 14TH OF SEPTEMBER 2012, I WAS ON MY WAY TO WORK AND QUITE FAR AWAY FROM THE COMPANY, THE CAR SUDDENLY STOPPED WITH THE SAME PROBLEM AS 2011. I WAS LATE FOR WORK FOR SURE AND IT WAS ALMOST LIFE THREATENING CIRCUMSTANCE BECAUSE OF THE ENVIRONMENT. I CALLED THE WRECK CAR AND HERE IS ANOTHER REPORT FROM THE DEALER. "CUSTOMER STATES VEHICLE WAS DRIVING ROUGH, SHAKING AND EMITTING SMOKE EXCESSIVELY: SMELLED OF FUEL: MADE IT TO THE DEALERSHIP AND WILL NOT START. CHECK AND ADVISE. INSPECTED VEHICLE RETRIEVED P0300 RANDOM MISFIRE P0303 CYLINDER #3 MISFIRE AND P0087 FOR FUEL RAIL. NOTICED LARGE AMOUNTS OF WHITE SMOKE COMING FROM EXHAUST AND STRONG ODOR OF FUEL...)" 4. I HAVE POWER TRAIN WARRANTY FOR 5 YEARS OR 60K MILE (WHICH WILL BE THE FIRST) AND THE DEALER FIXED 2 TIMES FOR FREE BECAUSE OF THE WARRANTY. NOW EVEN THE WARRANTY IS BEING TERMINATED AND I HAVE NO OTHER WAYS TO SECURE MY SAFETY. FOLLOWED BY THE ABOVE REASONS, I WILL NOT BE ABLE TO DRIVE THIS CAR WHICH I HAVE PURCHASED IN 2009. WHEN I DRIVE THIS CAR, I DO NOT FEEL SAFE AND EVEN FEEL LIFE THREATENING DANGER WHILE I AM DRIVING BECAUSE THOSE MOMENTS IN THE PAST WERE VERY DANGEROUS. *TR

THE CAR HAD BEEN DRIVEN A SHORT DISTANCE AND PARKED. SHORTLY AFTER THAT IT CAUGHT ON FIRE AND WAS DESTROYED.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT ON VARIOUS OCCASIONS THE DRIVER SIDE DOOR FAILED TO CLOSE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THE FAILURE WITH A FAULTY DOOR LATCH. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 35,000.

THE VEHICLES MOTOR BEGAN MAKING AN IRREGULAR NOISE ( SOUNDED LIKE AN AIRPLANE ENGINE) BETWEEN 2-3RPMS AND THERE WAS SERIOUS VIBRATION THROUGH THE ENTIRE VEHICLE. THE VEHICLE CHUGGED ALONG AT LOW SPEEDS AND THE STEERING WAS DIFFICULT AND NOT THAT RESPONSIVE. THERE WAS SERIOUS VIBRATION THROUGH THE VEHICLE WAS LEFT AT THE SERVICE CENTER ON FRIDAY AS IT WAS LATE IN THE DAY. UPON RETURNING ON MONDAY MORNING, THE TECHNICIAN INFORMED ME THAT THE MOTOR MOUNT BOLTS (TWO) WERE MISSING AND THE THREADS FOR EACH WAS COMPLETELY STRIPPED. THE MOTOR WAS ROCKING BACK AND FORTH CREATING THIS DREADFUL NOISE.THE THREADS WERE RESTORED USING TAP AND DYE SET AND NEW BOLTS WERE INSTALLED. I WAS INFORMED THAT SOMETIMES THE BOLTS SNAP AND THIS IS A MANUFACTURERS DEFECT. I WAS TOLD THERE WERE OTHER SIGNS OF DAMAGE AND I KIND OF FEEL SOMETHING WILL BE FOUND ONCE MY WARRANTY IS UP AS A RESULT OF THIS MISHAPS. *TR

I RECENTLY PURCHASED A NEW 2009 VOLKSWAGEN PASSAT CC SPORT VEHICLE THROUGH BOARDWALK VOLKSWAGEN OF RICHARDSON TEXAS, WHO HAD THE CAR SHIPPED TO THEIR LOCATION FROM TYNAN'S VW IN COLORADO. I PICKED UP MY BRAND NEW 2009 VOLKSWAGEN PASSAT CC SPORT VEHICLE WITH 24 MILES ON THE AFTERNOON OF SATURDAY FEBRUARY 28, 2009. ON SUNDAY, AS I WAS DRIVING, THE CAR WOULD NOT ACCELERATE AND FUMES STARTED COMING OUT THE ENGINE COMPARTMENT AND TRANSMISSION FLUID LEAKED OUT AND SPRAYED ALL OVER THE ENGINE RENDERING THE CAR A SAFETY HAZARD AND FIRE HAZARD. THE CAR WAS TOWED BY VW ROADSIDE ASSISTANCE TO BOARDWALK VW, WHICH UPON CLOSER INSPECTION, THEY FOUND THE TRANSMISSION LINES MISPOSITIONED IN SUCH A WAY THAT THE COOLING FAN MOTOR CUT THE LINES OPEN CAUSING CATASTROPHIC TRANSMISSION FAILURE. THE ENGINE COMPARTMENT HAS BEEN CONTAMINATED WITH POTENTIALLY FLAMMABLE TRANSMISSION FLUID, AND THE TRANSMISSION WAS RUN WITH EXTREMELY LOW LEVELS OF FLUID BY THE ROADSIDE ASSISTANCE SERVICE TO GET IT ON AND OFF THE TOW VEHICLE, SERIOUSLY REDUCING THE MARKET VALUE AND SAFETY OF THE VEHICLE. I WENT TO TAKE PICTURES OF THE COMPROMISED VEHICLE WITH THE FAULTY TRANSMISSION LINE ROUTING AND ANOTHER PASSAT CC VEHICLE WITH THE CORRECT TRANSMISSION LINE ROUTING. TO SEE THE PROBLEM, THE CAR WAS RAISED, AND THE UNDERSIDE ENGINE COMPARTMENT COVER WAS TAKEN OFF. IN THE VEHICLE IN QUESTION, THE TRANSMISSION LINES WERE ROUTED IN FRONT OF A RADIATOR TUBE, LEAVING THEM IN CLOSE CONTACT WITH THE ROTATING RADIATOR FAN, WHICH EVENTUALLY CUT OPEN THE LINES CAUSING THE LEAK. THE FLUID LEAKED INTO THE ENGINE COMPARTMENT AND WAS BLOWN INTO THE ENTIRE ENGINE BY THE RADIATOR FAN. IN THE OTHER VEHICLE, THE TRANSMISSION LINES WERE ROUTED BEHIND THE RADIATOR TUBE, WHICH SHIELDS THEM FROM COMING INTO CONTACT WITH THE FAN. THIS CAN BE USED TO START A RECALL ON ALL PASSAT CC MODELS TO HAVE THEM CHECKED FOR INCORRECT ROUTING OF THE TRANSMISSION LINES, WHICH CAN CAUSE CATASTROPHIC TRANSMISSION FAILURE AND CUSTOMER PROBLEMS. *TR