2012 Volvo C30

On Jan. 8, 2026, and February 10, 2026, while driving on I-75 and 1-10 at approximately 70 miles an hour, my passenger door lock disengaged multiple times ---it came open -- while was driving on the highway at top speeds. It has done this at least 8 other times since then. When the door disengages, it is partially open, the wind comes into the car and all of the lights inside come on, the dash caution sign lights up and the dash reads that the door is open. The locks are still in lock position as they are when it automatically locks when you pull off in the car. So none of the doors are previously open. This may be what keeps the door from swinging fully open when driving. I have reported this happening to my Volvo dealer and they have not been able to find any electronic reading or figure out what is happening to tell them what is going on. Nor have they been able to duplicate the door opening in driving mode when they take it out, probably because it happens when I am driving on the highway. But the passenger door lock continues to disengage, breaching the vacuum sealed protection the car once offered. I understand this has happened with other Volvos, the S60 and possibly other P1 platform Volvos. I understand there have been door latch recalls on the Volvo product. Now it is happening with the C30 and must be addressed.

NHTSA ID

11718235

Incident

Jan 8, 2026

The top corners of the windshield have come loose from the seal. The risk is losing a windshield at highway speed. The vehicle was taken to the dealership who referred us to a body shop. The vehicle was then taken to Gerber Collision & Glass - Austin where the problem was confirmed.

NHTSA ID

11557020

Incident

Nov 14, 2023

The seal around the front windshield of the car is leaking. The leak lets water in the car while driving, it’s dripping down the windshield which is very distracting. The excess amount of water being let into the vehicle also fogs up the front windshield and side windows. This causes a huge visual impairment putting myself and others at risk on the road. There are many other Volvos from similar years and models that I’m seeing have the same issue. I have never had the issue looked at, but Volvo representatives say they know about the issue. However, there is no recall in place to fix the issue and to keep drivers safe on the roads.

NHTSA ID

11554638

Incident

Nov 8, 2023

My windshield has become loose and makes a very loud noise when going over any bumps. Im very concerned that at some point, it will shatter while driving.

NHTSA ID

11451805

Incident

Dec 6, 2021

- The front windshield leaks - This allowed water to fall into the footwells and enter the CEM which controls basically the whole car and made my car turn off while I was driving nearly 45mph which was very dangerous, the sudden surprise made me turn my attention away from the road - I don't have any details on it being inspected before but it has never leaked before and after a heavy rainstorm the problem with the leak arose and damaged my CEM, it was wet and corroded a bit and I figured that this water damaged the CEM - The electrical system was acting a bit funky like the radio not working right and my turn signals flashing faster than normal and the right headlight not working, it all happened in pretty much one day, I didn't really think it was anything serious until the car shut off - Volvo needs to recall this on pretty much all year C30s and possibly other Volvo models made around this year because this little leak can easily cause someone to lose control of their car

NHTSA ID

11419292

Incident

Jun 1, 2021

ON JANUARY 21, 2016, MY VOLVO C30'S FAULTY FACTORY-INSTALLED, BLEMISH-FREE, WINDSHIELD LEAKED WHICH PERMITTED WATER TO FLOW DOWN THE A PILLAR AND INTO THE CAR'S ELECTRONICS. AS A CONSEQUENCE, THE CAR BECAME QUICKLY DEBILITATED BECAUSE OF ELECTRICAL FAILURE. SMOKE BILLOWED FROM THE ENGINE COMPARTMENT BEFORE THE BATTERY CABLE WAS QUICKLY REMOVED. ON JANUARY 21, 2016, THE C30 WAS TOWED VIA FLAT BED TRUCK TO VOLVO OF DALLAS FOR REPAIR. THE COURTEOUS AND KNOWLEDGEABLE MAINTENANCE TECHNICIAN, KENNY, IMMEDIATELY IDENTIFIED THE PROBLEM AS A LEAKING WINDSHIELD AND STATED THAT 'THIS IS A KNOWN PROBLEM IN VOLVOS.' HE STATED, THE 'SEALANT/PRIMER MAY SEPARATE CAUSING A LEAK.' VOLVO OF DALLAS HELD THE CAR FOR A WEEK DURING REPLACEMENT OF THE LEAKING WINDSHIELD. I REQUESTED A FULL INSPECTION. APPARENTLY, THAT WAS COMPLETED. THE 4 YEAR WARRANTY IS DUE TO EXPIRE SOON. I DO NOT TRUST THAT THIS CAR, WHICH NOW HAS AN ELECTRICAL 'HISTORY,' IS ANY LONGER IN THE CAREFUL AND METICULOUS CONDITION IN WHICH I HAVE ALWAYS KEPT IT PRIOR TO THE LEAK. MY RESEARCH ONLINE AND THROUGH OTHER RESOURCES INFORMS ME THAT THE LEAKING WINDSHIELD IS A KNOWN SAFETY ISSUE IN LATER MODEL VOLVOS.

NHTSA ID

10823665

Incident

Jan 21, 2016

Mileage

44,700 mi

WHILE DRIVING MY VOLVO C30 REDESIGN, I STOPPED AT A STOP SIGN BEFORE I ENTERED MAIN ROAD FROM PARKING LOT AREA VEHICLE BEGAN TO ACCELERATE TO A HIGH SPEED INDEPENDENTLY CAUSING THE CAR TO MOVE TOWARDS THE INTERSECTION. NO CARS WERE APPROACHING SO I CONTINUED TURNING BUT IT WAS VERY UNSAFE. IT HAPPENED BEFORE AT FORT HOOD AND NEAR MY HOUSE IN TEMPLE TX. ALWAYS SAME CONDITIONS; AS I START TO ACCELERATE THE VEHICLE JUMP INTO A HIGH SPEED OR GEAR. THIS MORNING THE VEHICLE WAS ON HIGH REV IDLE, DID NOT WENT DOWN UNTIL I CHANGE TO MANUAL AND BACK TO AUTOMATIC. PLEASE ADVICE. *TR

NHTSA ID

10690020

Incident

Feb 22, 2015

Mileage

93,500 mi

WHILE STOPPED AT A RED LIGHT, MY 2012 VOLVO C30 RDESIGN BEGAN TO ACCELERATE TO A HIGH SPEED INDEPENDENTLY CAUSING THE CAR TO MOVE INTO THE INTERSECTION. I IMMEDIATELY JAMMED THE BRAKE PEDDLE TO STOP THE CAR FROM MOVING ANY FURTHER AND PUT THE CAR INTO PARK CAUSING THE CAR TO STOP. THE CAR CONTINUED TO REV FOR AN ADDITIONAL 5 SECONDS, THEN DROP DOWN TO A NORMAL IDLE. PLEASE HELP, WHAT'S WRONG? *TR

NHTSA ID

10621843

Incident

Aug 11, 2014

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

This is a Technical Journal. Vehicle type and platform identification.

This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory