2012 BMW 5 Series

In a letter dated September 26, 2013, BMW Group submitted a safety recall notice to NHTSA identifying a defect condition in the vacuum pump oil supply that may result in loss of power assist braking in 76,191 model year (MY) 2012 through 2014 BMW 3-Series, 5-Series, X1 SAV, X3 SAV, and Z4 vehicles equipped with 4-cylinder engines (NHTSA Recall 13V-454).According to BMW, movement of the seal disk within the camshaft may result in blocking of the oil supply to the vacuum pump, resulting in improper pump operation and loss of power assist braking.On July 11, 2013, BMW initiated a change to the camshaft geometry that prevented the seal disk from blocking the oil port.BMW has not received any braking complaints related to loss of power assist after the design change was implemented in production.The owners of all affected vehicles will be contacted by mail and asked to take their vehicle to a BMW dealer who will install a locking ring into the camshaft to keep the seal disk in its proper location.BMW expects to begin dealer and owner notification in November 2013 and complete dealer and owner notification in December when the remedy is expected to be available.Based on the actions taken by BMW, this investigation is closed.

I WAS DRIVING MY CAR ON A ROAD WHEN A WARNING LIGHT CAME ON. I PARKED THE CAR HOME, SINCE I WAS CLOSE TO HOME. THE SAME WEEK I TOOK THE CAR TO A BMW SPECIALIST BECAUSE THERE WAS A NOISE COMING FROM THE ENGINE. AFTER $467.00 SPENT ON LABOR, JUST TO TELL ME I NEED A NEW ENGINE. THIS CAR HAS 72K MILES. THIS IS A CAR THAT I ONLY DROVE ON WEEKENDS AND NOT EVERY WEEKEND. THE CAR IS NOW PARKED IN MY GARAGE BECAUSE TO REPAIR IT IT WILL COST ME $11K. I HAVE HEARD THIS COMPLAINT FROM SEVERAL BMW OWNERS. THE CAR STILL RUNS BUT THE NOISE WILL NO GO AWAY.

NHTSA ID

11231813

Incident

May 5, 2019

Mileage

72,000 mi

TL* THE CONTACT OWNS A 2012 BMW 5-SERIES. THE CONTACT STATED THAT THE VEHICLE EXCESSIVELY OVERHEATED WITHOUT WARNING. THE CONTACT CONSTANTLY HAD TO EXERCISE CAUTION IN THE EVENT THAT THE VEHICLE MAY HAVE REDUCED ENGINE POWER AND WAS UNCERTAIN IF THE FAILURE WOULD RESULT IN A FIRE. BMW GALLERY OF NORWOOD (918 BOSTON PROVIDENCE HWY, NORWOOD, MA 02062, (888) 441-2338) WAS NOTIFIED OF THE FAILURE, BUT HAD NOT SPECIFIED IF THE FAILURE WAS RELATED TO ANY RECALL CAMPAIGNS OR TECHNICAL SERVICE BULLETINS. THE DEALER STATED THAT FURTHER DIAGNOSTIC TESTING WAS REQUIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

NHTSA ID

11176482

Incident

Nov 1, 2018

Mileage

40,000 mi

I HAD AN ISSUE WITH THE TIMING CHAIN ON THIS VEHICLE. I DO BELIEVE THIS IS A SAFETY ISSUE. CAR FAILS WITH VERY LITTLE WARNING WHILE THE CAR IS BEING DRIVEN. IT IS NOT A QUESTION OF MAINTENANCE BUT OF A SPECIFIC MANUFACTURING FAULT. HOW WOULD ONE KNOW OF A DEFECT UNTIL SOMETHING GOES WRONG. THEN THE MANUFACTURER DOESN'T TAKE BLAME. MANUFACTURER KNEW ABOUT THE PROBLEM BUT DID NOT LET OWNERS KNOW ABOUT THE PROBLEM UNTIL SOMETHING HAPPENS WHILE DRIVING. BMW HAS SINCE REDESIGNED THE ENGINE BUT WHAT ABOUT THE EXISTING CARS WITH THE ISSUE?

NHTSA ID

11080146

Incident

Feb 28, 2018

Mileage

98,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2012 BMW 5-SERIES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 17V020000 (AIR BAGS) AND 17V138000 (POWER TRAIN). THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT SPOKE WITH THE DEALER, BMW OF COLUMBUS, GEORGIA, AND WAS INFORMED THAT PARTS WERE ORDERED FOR NHTSA CAMPAIGN NUMBER: 17V020000 (AIR BAGS); HOWEVER, VIN TOOL CONFIRMS REMEDY NOT YET AVAILABLE FOR THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE AND PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10993684

Incident

Jun 7, 2017

I WAS DRIVING AT ABOUT 65 MPH ON A HIGHWAY UPHILL, ENGINE COMPLETELY STALLED, NO POWER, GOT A MESSAGE "DRIVE-TRAIN MALFUNCTION, NO MAXIMUM OUTPUT, DRIVE MODERATELY". I WAS SURROUNDED BY CARS/SEMI TRUCKS, VERY DANGEROUS SITUATION. MANAGED TO PULL OVER ON THE SHOULD. COULD NOT RESTART CAR, GOT A MESSAGE "AUTOMATIC START/STOP DEACTIVATED: ENGINE WILL NOT START AUTOMATICALLY. PRESS THE START/STOP BUTTON TO START THE ENGINE." ABOUT 30 MINS AFTER ENGINE STALLED, I FINALLY RESTARTED THE CAR. CONTINUED TO DRIVE ON THE HIGHWAY FOR ABOUT 10 MILES @ 60-65 MPH. AT A LOCAL STREET, AS I SLOWED DOWN TO APPROACH A TRAFFIC LIGHT, ENGINE STALLED AGAIN, NO POWER, CAR STOPPED IN THE MIDDLE OF ROAD, GOT THE TWO SAME MESSAGES, COULD NOT START CAR. ABOUT 30 MINS AFTER ENGINE STALLED, I FINALLY STARTED THE CAR.

NHTSA ID

10895472

Incident

Aug 12, 2016

Mileage

58,700 mi

MY WINDSHIELD WIPERS MOVE ON THEIR OWN, THEY TURN ON AND OFF AS THEY PLEASE. BROUGHT THE CAR IN TWICE SO FAR AND BMW SERVICE CANNOT FIND THE PROBLEM. *TR

NHTSA ID

10619156

Incident

Jul 7, 2014

Mileage

47,000 mi

MY CAR WAS PARKED DURING A HAIL STORM. DURING THE STORM, THE BACK WINDSHIELD SHATTERED INTO A THOUSAND PIECES. THANK GOD NO ONE WAS IN THE VEHICLE AT THE TIME OF THE HAIL STORM! IT WAS MY UNDERSTANDING THAT THESE WINDSHIELDS ARE MADE OF SAFETY GLASS, THAT IS DESIGNED TO ABSORB ANY IMPACT, CRACK, AND STAY IN 1 PIECE. HOWEVER, QUITE THE OPPOSITE HAPPENED (I HAVE PICTURES), WHERE THE ENTIRE BACK GLASS BASICALLY EXPLODED AND GLASS PIECES WENT FLYING EVERYWHERE. THERE WERE EVEN PIECES OF GLASS ON THE FRONT FLOOR BOARD AND DASHBOARD. THIS MUST BE A DEFECT AND COULD HAVE BEEN A POTENTIAL LIFE THREATENING EVENT IF ANYONE HAPPENED TO BE IN THE VEHICLE DURING THIS STORM! *TR

NHTSA ID

10604762

Incident

May 23, 2014

Mileage

27,000 mi

BMW 550XI, NORMAL DRIVING, TIRE PRESSURE INDICATOR CAME ON, CAR BECAME UNSTABLE. PARKED VEHICLE AND OBSERVED LARGE BUBBLE IN FRONT RIGHT TIRE SIDEWALL HAD SPLIT, CAUSING RAPID DEFLATION. NO ROAD HAZARDS WERE INVOLVED, MECHANIC STATES THAT THESE TIRES GET SIDEWALL BUBBLES ALL THE TIME. *TR

NHTSA ID

10534315

Incident

Jun 8, 2013

Mileage

7,200 mi

This bulletin outlines the Customer Care Package program that has been designed exclusively for BMWvehicles with the N63 engine. Vehicles with the N63 high performance engine are engineered with EfficientDynamics that provides fueleconomy without compromising on its “class leading” power and performance. To ensure these engines keep delivering the ultimate performance, we have designed this Care Package thatincludes a 6 point check, and if necessary, the replacement of one or more of the following powertraincomponents: Hot-Film Air Mass Sensors PIEZO High Pressure Fuel Injectors Engine Vacuum Pump Fuel System Low Pressure Sensor/Feed Line Fresh Air Intake Turbo Seals Crankcase Ventilation Lines (Hoses)

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.