2005 Volvo S60 Problems

TWICE NOW OVER A TEN DAY PERIOD FIRST WHEN REDUCING SPEED TO A STOP OR THEN AGAIN AT A SPEED OF LESS THAN 5 MPH, THE CAR DIED...FIRST THE ENGINE DIED THEN ALL ELSE DIED. THE CAR WENT DEAD. I STILL HAD MY STEERING AND SLOWLY ROLLED TO THE CURBED THEN AS I GENTLY PUT ON THE BRAKES THE CAR JERKED TO A HALT. DURING THE SECOND INCIDENT THE CAR STILL JERKED AFTER I HAD STOPPED. A LOUD SOUND OF A FAN FROM THE ENGINE COULD BE HEARD. THE FAN STOPPED AFTER 10 TO 15 SECONDS. AFTER A MINUTE I RESTARTED THE CAR AND MADE IT HOME BOTH TIMES. *TR

THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR

TL* THE CONTACT OWNS A 2005 VOLVO S60. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE RESTARTED, BUT THE ENGINE STALLED AGAIN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MASS AIR FLOW SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 165,000.

TWICE NOW OVER A TEN DAY PERIOD FIRST WHEN REDUCING SPEED TO A STOP OR THEN AGAIN AT A SPEED OF LESS THAN 5 MPH, THE CAR DIED...FIRST THE ENGINE DIED THEN ALL ELSE DIED. THE CAR WENT DEAD. I STILL HAD MY STEERING AND SLOWLY ROLLED TO THE CURBED THEN AS I GENTLY PUT ON THE BRAKES THE CAR JERKED TO A HALT. DURING THE SECOND INCIDENT THE CAR STILL JERKED AFTER I HAD STOPPED. A LOUD SOUND OF A FAN FROM THE ENGINE COULD BE HEARD. THE FAN STOPPED AFTER 10 TO 15 SECONDS. AFTER A MINUTE I RESTARTED THE CAR AND MADE IT HOME BOTH TIMES. *TR

WHILE DRIVING ON I-81 IN VIRGINIA MY LEFT REAR TIRE DISINTEGRATED. I WAS ABLE TO MOVE RIGHT TO SAFETY AND WHEN DOING SO THE UPPER HALF OF THE TIRE ROLLED PAST ME AND CAME TO REST 50 FEET AHEAD OF THE CAR AGAINST THE RAILING. ALL TIRES ARE NEW, WITH LESS THAN 200 MILES ON THEM. I CALLED 911, THE STATE POLICE CAME AND CALLED A WRECKER. I WAS TOWED AND RECEIVED A REPLACEMENT TIRE AT A CAR SHOP AND RETURNED HOME. ON INSPECTION IT APPEARED THAT THE SIDEWALL COMPLETE GAVE A WAY. FORTUNATELY A PIECE OF THE RUBBER STAYED ON THE RIM THUS PROTECTING THE RIM FROM DAMAGE. THIS SHOULD NOT HAVE HAPPENED AND I WOULD LIKE YOU TO INVESTIGATE. FORTUNATELY NOBODY WAS HURT BUT THIS COULD HAVE BEEN A VERY SERIOUS ACCIDENT. THE CAR A 2005 VOLVO S60 IN FINE CONDITION HAD BEEN BOUGHT FROM CARMAX A WEEK EARLIER AND HAD BEEN FULLY INSPECTED PRIOR TO SALE. *TR

WE HAVE A 2005 VOLVO S60R. AFTER HITTING A POTHOLE AND DESTROYING THE RIGHT FRONT TIRE AND RIM WE REPLACED ALL FOUR TIRES AND WHEELS WITH O.E.M. 17" WHEELS AND PIRELLI P6 TIRES. LESS THAN 1000 MILES LATER TWO OF THE TIRES DEVELOPED BULGES IN THE SIDEWALL AT THE EXACT SAME LOCATION ON EACH TIRE. KLINE VOLVO WOULD DO NOTHING ABOUT IT SAYING IT WAS ROAD HAZARD DAMAGE, BUT THESE TIRES DIDN'T HIT ANYTHING THAT DOESN'T OCCUR IN THE NORMAL COURSE OF DRIVING, SMALL ROAD IRREGULARITIES AT LOW SPEED, ETC. PIRELLI AND VOLVO CORPORATE WERE OF NO HELP EITHER, BOTH JUST REFERRING ME BACK TO THE DEALER WHERE I BOUGHT THE TIRE. THERE ARE MANY, MANY PAGES OF COMPLAINTS ON VARIOUS INTERNET SITES ABOUT THIS TIRE DEVELOPING SIDEWALL BULGES AND HAVING BLOWOUTS. SOMEBODY SHOULD MAKE PIRELLI RECALL THESE TIRES BEFORE SOMEONE IS KILLED. *JB

VEHICLE HAS STALLED WITHOUT ANY WARNING SEVERAL TIMES WHILE TRAVELING AT HIGHWAY SPEEDS (60 MPH). FIRST INCIDENT OCCURRED DURING THE SUMMER OF 2011 AT 105,000 MILES. A SECOND, SIMILAR INCIDENT OCCURRED IN THE FALL OF 2011 AT 108,000 MILES. AUTO SCANDIA IN HERNDON, VA, REPLACED MASS AIR FLOW METER IN AN ATTEMPT TO ADDRESS THE PROBLEM. THE VEHICLE PERFORMED WELL FOR SEVERAL MONTHS WITHOUT INCIDENT. UNFORTUNATELY IT STALLED AGAIN IN MARCH 2012. THIS WAS ALSO WITHOUT ANY WARNING WHILE TRAVELING AT HIGHWAY SPEEDS (60 MPH). THE UNUSUAL HIGHWAY BREAKDOWN WAS VERY DANGEROUS. *TR

I OWN A 2005 VOLVO S60. WHEN DRIVING TODAY TO WORK, WITH NO WARNING, THE VEHICLE STALLED. I WAS UNABLE TO CONTROL THE GAS AND THE STEERING BECAME ROUGH. HITTING THE ACCELERATOR DID NOTHING. I WAS ABLE TO SLOW THE VEHICLE TO THE SIDE OF THE ROAD. ONCE I TURNED IT OFF AND BACK ON IT RESTARTED. IF THIS HAD HAPPENED ON A HIGHWAY, IT COULD HAVE RESULTED IN A MAJOR ACCIDENT. RESEARCH SHOWS THAT THIS IS A COMMON PROBLEM WITH VOLVO. THERE WAS A RECALL FOR THESE INCIDENTS FOR UNDER YEARS 2003 -AND 2004- 07V226000 . THE RECALL FOR THE S40 COVERED THROUGH 2006 - 08V033000. A SEARCH OF THE INTERNET FORUM SHOWS THAT THIS IS HAPPENING FOR A LOT OF THE 2005 MODELS AS WELL. PLEASE CONSIDER INCLUDING THESE MODEL YEARS AS THIS IS A DANGER. *KB

ANGLE/COLLAR GEAR/SLEEVE, HALDEX AWD. HUNDREDS OF THOUSANDS OF AWD VOLVOS HAVE THIS ISSUE YET VOLVO HAS NEVER TAKEN ACTION OR RECALLED PART. THIS IS JUST ONE OF MANY ISSUES THOUSANDS OF VOLVO'S HAVE. BUT THE AWD SYSTEM NON FUNCTIONING DUE TO STRIPPED TEETH CAUSED BY RUST BECAUSE OF INADEQUATE GREASE/LUBE ETC. ON THOUSANDS OF VEHICLES RANGING FROM THEIR SMALL SEDANS TO SUV'S SHOULD BE SOMETHING. THEY HAVE EVEN UPDATED THE ANGLE GEAR/COLLAR SLEEVE WITH ONE THAT HAS "HARDENED" TEETH, BUT NO RECALL ON A PART OF THE VEHICLE THAT IS SUPPOSE TO ALWAYS FUNCTION. A LOT WERE LUCKY ENOUGH IT HAPPENED WHILE STILL UNDER WARRANTY. BUT GETTING STUCK/STRANDED IN SNOW BECAUSE YOUR VEHICLE IS ONLY 2 WHEEL DRIVE WHEN ITS SUPPOSE TO BE AWD. I DID NOT FIND OUT MY AWD DID NOT WORK UNTIL I HAD GOTTEN STUCK IN THE SNOW. TURNS OUT HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD TO FIND OUT THIS SAME WAY. I BELIEVE VOLVO HAS JUST BEEN LUCKY NO ONE HAS DIED YET DUE TO FAILED AWD SYSTEM. I AM NOT CERTAIN ABOUT WHAT CONDITIONS NEED TO BE MET BEFORE A RECALL IS DONE. THIS IS JUST ONE OF THE ISSUES WITH VOLVO'S. I AM NOT SURE ON THE EXACT DATE MY AWD SYSTEM STOPPED WORKING BECAUSE DRIVING ON ANYTHING OTHER THAN SNOW, OR ICE YOU CANNOT TELL. BUT A SIMPLE SEARCH ON THE INTERNET AND HUNDREDS IF NOT THOUSANDS OF PEOPLE STARTING EARLY AS 2000'S TO MOST RECENT AS 2019 HAVING SAME ISSUES, SOME MORE THAN ONCE, AND A FEW COMING UP WITH THEIR OWN WAY OF FIXING VOLVOS ISSUE. BUT PHOTOS CAN BE FOUND ALL OVER THE WEB. ALSO VOLVO SELLS THESE ADVERTISED AS AWD WHEN IN FACT IT IS FWD ALL TIME, UNTIL FRONT TIRES LOSE TRACTION WHICH ONLY THEN DO THE REAR WHEELS ENGAGE. YET CAN BREAK OR MALFUNCTION EVEN THOUGH THEY ONLY EVER COME ON 20-30% OF THE VEHICLES TOTAL MILES DRIVEN. NOT SURE OF AWD DEFINITION BUT I ALWAYS THOUGHT IT STOOD FOR ALL WHEEL DRIVE, NOT FRONT WHEEL DRIVE; ALL WHEEL DRIVE WHEN FRONT WHEELS LOSE TRACTION.

INTERMITTENT ABS/ANTI SKID LIGHT. MY BRAKES ALSO SEEMED AFFECTED, PARTICULARLY THE STOPPING DISTANCE. AFTER THIS PROBLEM HAPPENED TO ME ABOUT 6 TIMES, I ASKED A SERVICE TECH AT MY LOCAL DEALER TO FIND THIS IS A COMMON PROBLEM. OTHER PEOPLE HAVE REPORTED BRAKES LOCKING. AFTER SEARCHING ON THE INTERNET I FOUND MANY OWNERS OF VOLVOS HAVE SUFFERED FROM THIS PROBLEM. IT SEEMS THAT THE ABS MODULE IS KNOWN FOR CAUSING STRANGE PROBLEMS CAUSED BY MALFUNCTIONS MOSTLY DUE TO COLD SOLDER JOINTS. MY CAR IN PARTICULAR IS AN '05 S60 2.4 M WITH 118K MILEAGE. AT WHAT POINT SHOULD A RECALL BE PLACED ON THESE UNITS? AN INTEGRAL PART OF AN ABS SYSTEM SEEM TO BE A MAJOR SAFETY ISSUE, DOES IT NOT? *TR

ANY DAY THE SUN IS SHINING, THE GLARE OFF THE DASHBOARD IS EXTREME AND RESULTS IN LITTLE TO NO VISIBILITY WHEN ENTERING TUNNELS, UNDERPASSES OR EVEN SECTIONS OF ROAD THAT ARE SHADED BY TREES. *JB

DT: THE CONTACT STATED THERE WAS NOT ENOUGH ROOM BETWEEN THE FLOOR AND BOTTOM OF THE DASHBOARD. THERE WAS NO WAY THAT THE CONTACT'S HUSBAND COULD GET FOOT TO THE BRAKE. THIS ALMOST CAUSED SEVERAL ACCIDENTS. THERE IS ONLY 11 INCHES BETWEEN THE FLOOR AND THE DASHBOARD . *AK UPDATED 1/19/2006 - THERE IS LITTLE CLEARANCE BETWEEN THE PEDALS AND THE UNDERSIDE OF THE DASH WHICH RESULTED IN THE CONSUMER SHOE HITTING THE UNDERSIDE OF THE DASH LIMITING HIS ABILITY TO MOVE HIS FOOT BETWEEN THE BRAKE PEDAL AND ACCELERATOR PEDAL. *NM

TL*THE CONTACT OWNS A 2005 VOLVO S60. WHILE DRIVING APPROXIMATELY 50 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. SUDDENLY, THERE WAS A LOSS OF POWER STEERING, WHICH REQUIRED GREATER EFFORT TO TURN THE STEERING WHEEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND TURNED OFF THE ENGINE. THE ENGINE WAS RESTARTED AFTER WAITING A FEW MOMENTS AND THE VEHICLE RESUMED NORMAL OPERATION. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE FAILURES OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIANS STATED THAT THE FAILURES WERE CONTRIBUTED TO THE POWER STEERING MODULE AND RECOMMENDED THAT IT BE REPLACED AT THE COST OF $200. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 83,000 AND CURRENT MILEAGE WAS 84,000.

TL*THE CONTACT OWNS A 2005 VOLVO S60. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE'S STEERING WHEEL SHAKES AND MAKES A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER TWICE. ON THE FIRST VISIT, THEY ROTATED THE TIRES AND, ON THE SECOND VISIT, THEY REPLACED THE ENGINE MOUNTS. THE STEERING WHEEL CONTINUES TO SHAKE. THE VIN, ENGINE SIZE, AND # OF CYLINDERS WERE UNKNOWN. THE CURRENT MILEAGE IS 28,000 AND FAILURE MILEAGE WAS 27,000.

ANGLE/COLLAR GEAR/SLEEVE, HALDEX AWD. HUNDREDS OF THOUSANDS OF AWD VOLVOS HAVE THIS ISSUE YET VOLVO HAS NEVER TAKEN ACTION OR RECALLED PART. THIS IS JUST ONE OF MANY ISSUES THOUSANDS OF VOLVO'S HAVE. BUT THE AWD SYSTEM NON FUNCTIONING DUE TO STRIPPED TEETH CAUSED BY RUST BECAUSE OF INADEQUATE GREASE/LUBE ETC. ON THOUSANDS OF VEHICLES RANGING FROM THEIR SMALL SEDANS TO SUV'S SHOULD BE SOMETHING. THEY HAVE EVEN UPDATED THE ANGLE GEAR/COLLAR SLEEVE WITH ONE THAT HAS "HARDENED" TEETH, BUT NO RECALL ON A PART OF THE VEHICLE THAT IS SUPPOSE TO ALWAYS FUNCTION. A LOT WERE LUCKY ENOUGH IT HAPPENED WHILE STILL UNDER WARRANTY. BUT GETTING STUCK/STRANDED IN SNOW BECAUSE YOUR VEHICLE IS ONLY 2 WHEEL DRIVE WHEN ITS SUPPOSE TO BE AWD. I DID NOT FIND OUT MY AWD DID NOT WORK UNTIL I HAD GOTTEN STUCK IN THE SNOW. TURNS OUT HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD TO FIND OUT THIS SAME WAY. I BELIEVE VOLVO HAS JUST BEEN LUCKY NO ONE HAS DIED YET DUE TO FAILED AWD SYSTEM. I AM NOT CERTAIN ABOUT WHAT CONDITIONS NEED TO BE MET BEFORE A RECALL IS DONE. THIS IS JUST ONE OF THE ISSUES WITH VOLVO'S. I AM NOT SURE ON THE EXACT DATE MY AWD SYSTEM STOPPED WORKING BECAUSE DRIVING ON ANYTHING OTHER THAN SNOW, OR ICE YOU CANNOT TELL. BUT A SIMPLE SEARCH ON THE INTERNET AND HUNDREDS IF NOT THOUSANDS OF PEOPLE STARTING EARLY AS 2000'S TO MOST RECENT AS 2019 HAVING SAME ISSUES, SOME MORE THAN ONCE, AND A FEW COMING UP WITH THEIR OWN WAY OF FIXING VOLVOS ISSUE. BUT PHOTOS CAN BE FOUND ALL OVER THE WEB. ALSO VOLVO SELLS THESE ADVERTISED AS AWD WHEN IN FACT IT IS FWD ALL TIME, UNTIL FRONT TIRES LOSE TRACTION WHICH ONLY THEN DO THE REAR WHEELS ENGAGE. YET CAN BREAK OR MALFUNCTION EVEN THOUGH THEY ONLY EVER COME ON 20-30% OF THE VEHICLES TOTAL MILES DRIVEN. NOT SURE OF AWD DEFINITION BUT I ALWAYS THOUGHT IT STOOD FOR ALL WHEEL DRIVE, NOT FRONT WHEEL DRIVE; ALL WHEEL DRIVE WHEN FRONT WHEELS LOSE TRACTION.

DT: THE CONTACT STATED WHILE VEHICLE WAS HAVING ROUTINE MAINTENANCE PERFORMED THE DEALER FOUND A BEND IN THE EXHAUST SYSTEM. THIS BEND COULD CAUSE THE DRIVESHAFT TO CRACK. THE DEALER SAID THE CONTACT MUST HAVE HIT SOMETHING TO CAUSE THE DAMAGE. BUT THERE WAS NO EVIDENCE THAT THE HE HIT ANYTHING. THE VEHICLE IS AT THE DEALER WAITING FOR AN INVESTIGATION. AT THIS POINT THE VEHICLE HAS NOT BEEN REPAIRED. *AK

THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR

DT: THE CONTACT STATED THERE WAS NOT ENOUGH ROOM BETWEEN THE FLOOR AND BOTTOM OF THE DASHBOARD. THERE WAS NO WAY THAT THE CONTACT'S HUSBAND COULD GET FOOT TO THE BRAKE. THIS ALMOST CAUSED SEVERAL ACCIDENTS. THERE IS ONLY 11 INCHES BETWEEN THE FLOOR AND THE DASHBOARD . *AK UPDATED 1/19/2006 - THERE IS LITTLE CLEARANCE BETWEEN THE PEDALS AND THE UNDERSIDE OF THE DASH WHICH RESULTED IN THE CONSUMER SHOE HITTING THE UNDERSIDE OF THE DASH LIMITING HIS ABILITY TO MOVE HIS FOOT BETWEEN THE BRAKE PEDAL AND ACCELERATOR PEDAL. *NM

2005 VOLVO S60 AWD TURBO. THE RIGHT TIRE RUBS ON THE INSIDE OF THE CARS FRAME WHEN I MAKE A LEFT TURN. WE HAVE BEEN TOLD THEY ALL DO IT. WE HAVE DRIVEN A FEW OTHER TYPES OF THE S60 MODEL AND HAVE FOUND THEY HAVE THE SAME ISSUE. NOW, OUR ISSUE IS THAT OVER TIME THIS WILL/COULD CAUSE THE TIRE TO FAIL AND RESULT IN A CRASH. VOLVO HAS REALIGNED THE CAR TWICE TO TRY TO CORRECT THE ISSUE, NOW THEY WOULD LIKE TO REMOVE THE INNER METAL SHIELDS TO SEE IF THAT WILL HELP. WE FEEL THOSE SHIELD WERE PUT ON THE CAR FOR A REASON AND THE REASON IS NOT TO BE TAKEN OFF AT A LATER DATE TO COVER UP A PROBLEM. *JB

I OWN A 2005 VOLVO S60R WITH ADJUSTABLE SUSPENSION. THE CAR EXHIBITS SIGNIFICANT "SIDE-STEP" PROBLEM WHICH IS A POTENTIAL SAFETY HAZARD WHILE DRIVING THROUGH DIP OR POTHOLES. OFTEN THE REAR END OF THE CAR WOULD SWAY DRAMATICALLY WHEN DRIVING ON THE HIGHWAY AT SPEED OF 40 TO 70 MPH. ONE TIME I DROVE THROUGH A FREEWAY THAT IS NOT WELL PAVED AND MY CAR'S REAR-END WOULD SKIPS TO ANOTHER LANE! IF THERE IS ANOTHER CAR NEXT TO ME I'D DEFINITELY HIT IT. *NM

DT: 2005 VOLVO SAA. THE CONSUMER STATED THAT IS==WAS A GLARE IN THE WINDSHIELD. THE DASHBOARD ITSELF WAS A TWO TONE COLOR BLACK AND TAN. THE BLACK PIECE WAS RIGHT ABOVE THE STEERING COLUMN, AND THE REST OF THE DASH WAS TAN . THEREFORE CAN SEE A CREASE IN THE GLARE OF THE WINDSHIELD. DEALERSHIP SAID EITHER PAINT THE BLACK PART OF THE DASHBOARD TAN OR PUT DASHBOARD COVER ON AT MY EXPENSE. IF SUN GLASSES USED THE GLARE WAS OKAY, BUT IF NOT USED THE GLARE WOULD BE IN MY RIGHT EYE. CONSUMER MUST LEAN OVER TO THE LEFT TO BE ABLE SEE WITHOUT THIS GLARE. *AK

While I was driving I felt very hot under my buttock than I heard it pop and burst, I pulled over to check, oh my got (OMG) thanks God I'm safe! There was a burn on my car seat!

HEADLIGHT WIRING AND CONNECTOR BURNED CAUSING LIGHT TO GO OUT. THE DEALER REPLACED THE WIRING AND CONNECTOR ACCORDING TO A TSB ISSUED BY VOLVO. DEALER STATED THAT THEY HAD REPAIRED SEVERAL VOLVOS WITH THIS PROBLEM. ALTHOUGH THE DEALER SAID THIS WAS A SAFETY ISSUE AND VOLVO ISSUED A TSB AND PROVIDED A REPAIR KIT FOR REPAIRS VOLVO DOES NOT CONSIDER THIS A SAFETY ISSUE. THANKFULLY, ONLY ONE LIGHT BURNED OUT AT THE TIME OTHERWISE I WOULD HAVE CRASHED AT 70 MPH. DEALER SAID BOTH HEADLIGHT WIRING CABLES AND CONNECTORS WERE BURNT AND THEY REPLACED BOTH. I REPORTED THIS SAFETY ISSUE TO TENNESSEE AND KENTUCKY CONSUMER PROTECTION DIVISION. THIS ONE LIGHT WENT OUT ON SEVERAL OCCASIONS BEFORE I TOOK THE CAR TO THE DEALER AND DISCOVERED THE SAFETY PROBLEM. REPAIRS MADE AT MY COST. *TR

VOLVO S60R: AT LESS THAN 50,000 MILES BOTH REAR WHEEL BEARINGS WERE REPLACED. MECHANIC STATED THAT IT APPEARED THEY WERE FROM A "BAD BATCH" AND WERE IN THE PROCESS OF FAILING. DRIVERS SIDE FRONT WHEEL NOW (AT 56,000 MILES) EXHIBITING SAME CHARACTERISITICS.

MY SEAT BELT GOT STUCK IN THE FRONT PASSENGER SIDE . NOW I'M GETTING A SERVICE MESSAGE ABOUT THE SRS SERVICE URGENT I DON'T KNOW WHY IT GOT STUCK BUT IT DID I CAN'T GET IT OUT OF SEAT BELT CLIP .

TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT THE SRS AIR BAG LIGHT REMAINED ILLUMINATED EVER SINCE THE VEHICLE WAS PURCHASED TEN MONTHS AGO. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE FAILURE RECURRED AND WAS NOT REMEDIED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 215,077. UPDATED 08/10/16*LJ *CN