2001 Audi Allroad

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

FUEL AND FUEL VAPOR LEAKS FROM THE TOP OF THE FUEL TANK PRESENTING A SERIOUS FIRE HAZARD WHEN MOVING (SLOWLY OR AT HIGHWAY SPEEDS) OR STATIONARY. THE FUEL LEAK IS MOST OBVIOUS WHEN THE TANK IS MORE THAN 1/2 FULL. VAPOR EMISSIONS OCCUR AT ALL TIMES RESULTING IN A FAILURE TO MEET EMISSIONS STANDARDS. A HARD PLASTIC MATERIAL IS USED FOR THE FUEL TANK'S VENT. IT IS CONNECTED TO A RIGID ALUMINUM VENT LINE. RELATIVE MOVEMENT AND AGING HAS RESULTED IN A FAILURE OF THE PLASTIC VENT. AUDI'S RECALL FIX FROM 2008 (NHTSA 08V-157) - I.E., INSTALLING AN EPOXY-FILLED MOLD - HAS NOT PREVENTED FAILURE OF THE PLASTIC VENT. SINCE THE PLASTIC VENT IS 'WELDED' TO THE TOP OF THE HDPE TANK, THE ENTIRE TANK MUST BE REPLACED TO ADDRESS THE FAILED VENT.

NHTSA ID

11032908

Incident

Aug 1, 2017

Mileage

127,000 mi

TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. WHEN FILLING THE FUEL TANK, THE CONTACT NOTICED THAT THE TANK LEAKED FUEL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,800.

NHTSA ID

10836406

Incident

Jan 26, 2016

Mileage

100,800 mi

TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE REINFORCEMENT NIPPLE TO THE ROLLOVER ON THE FUEL TANK FAILED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM) AND WOULD NOT BE REPAIRED UNDER THE RECALL. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10721533

Incident

May 25, 2015

TL* THE CONTACT OWNS A 2001 AUDI ALLROAD QUATTRO. WHILE DRIVING APPROXIMATELY 30 MPH, THE FRONT DRIVER SIDE AIR SUSPENSION SYSTEM FAILED WITHOUT WARNING CAUSING THE VEHICLE TO COLLAPSE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN AUTHORIZED DEALER WHERE THEY INFORMED HIM THAT THERE WAS A LEAK IN THE AIR SUSPENSION AIR BAG. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE AIR BAG SUSPENSION WERE PREVIOUSLY REPLACED IN 2005 AND 2006. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

NHTSA ID

10384191

Incident

Aug 6, 2005

Mileage

70,000 mi

AIRBAG LIGHT ON AND CONTROL MODULE NEEDS REPLACING. *TR

NHTSA ID

10370850

Incident

Dec 13, 2010

Mileage

83,500 mi

TROUBLE OCCURRED WITH BOTH DRIVER AND PASSENGER WINDOWS, BUT AT DIFFERENT TIMES. PASSENGER WINDOW WAS STILL UNDER WARRANTY AT THE TIME. WINDOW WOULD NOT CLOSE PROPERLY AND THEN WOULD SPONTANEOUSLY OPEN. ATTEMPTS TO CLOSE IT ENTIRELY WERE OFTEN NOT SUCCESSFUL. MOTOR WAS REPLACED ON BOTH WINDOWS-ONE UNDER WARRANTY, THE OTHER NOT. A SECOND OCCURRENCE WITH DRIVER WINDOW REQUIRED ANOTHER COSTLY REPAIR, ALTHOUGH THE CAUSE WAS DIFFERENT. THIS HAPPENS ALSO CURRENTLY WITH REAR PASSENGER WINDOW WHEN IT IS COLD. I HAVE HAD NOTHING BUT MECHANICAL ISSUES WITH THIS VEHICLE. *TR

NHTSA ID

10246460

Incident

Sep 10, 2008

Mileage

67,000 mi

I OWN A 2001 AUDI ALLROAD, WHICH I PURCHASED THROUGH A DEALER CERTIFIED PRE-OWNED. THERE HAVE BEEN SEVERAL UNUSUAL ISSUES WITH THIS VEHICLE, SUCH AS THE WATER PUMP BREAKING DOWN AT 50,000 MILES AND MANY ELECTRICAL ISSUES. THE MOST RECENT IS THE CAR SEAT HEATER, WHICH MALFUNCTIONED CAUSING A SHORT AND BURNING A HOLE IN THE DRIVER'S SEAT (WHICH IS LEATHER). LUCKILY, I CAUGHT IT BEFORE SMOLDERING OR A FIRE COULD HAVE ENSUED, WHICH COULD HAVE CAUSED ME BODILY HARM OR RISKED THE LIVES OF MY CHILDREN HAD WE BEEN ON A LONG DISTANCE TRIP. I AM IN CONTACT WITH AUDI AND A LOCAL DEALER WHO UPON INSPECTION OF THE VEHICLE WILL DETERMINE HOW TO PROCEED WITH THE REPAIR. MY BIGGEST CONCERN IS THAT I AM UNABLE TO FIND ANY REPORTS ON AUDI ALTHOUGH THEY ARE NOTORIOUS FOR HAVING MECHANICAL ISSUES. THIS ONE TRUMPS ALL OTHERS IN MY OPINION. THIS IS A MAJOR SAFETY ISSUE AND I KNOW OF ONE OTHER PERSON WHO HAS EXPERIENCED THIS, BUT IT WAS WITH A VW PASSAT WAGON. *TR

NHTSA ID

10246454

Incident

Oct 17, 2008

Mileage

67,000 mi

I BOUGHT AN AUDI ALLROAD 2001 2.7T A6 AT A DEALERSHIP IN ALBUQUERQUE NEW MEXICO. THE CAR, AT FIST, WAS HANDLING SO WELL. EVERYTHING SEEMED TO BE IN GREAT SHAPE AND WELL MAINTAINED. I TOOK A TRIP TO COLORADO AND UPON MY ARRIVAL TO MY DESTINATION, THE YELLOW "CAR UNEVEN SUSPENSION" LIGHT CAME ON. THE CAR IMMEDIATELY MADE SOME WEIRD NOISES AND SHIFTED WEIGHT WHILE I WAS DRIVING AT 80MPH ON THE HIGH WAY. I PULLED OVER AND VISUALLY INSPECTED THE CAR. NOTHING COULD BE SEEN. I TOOK IT TOO A VW DEALERSHIP TO HAVE THEM TELL ME WHAT THEY THOUGHT WAS WRONG. LONG STORY SHORT. NO ONE KNEW THE AUDI ALLROAD WELL ENOUGH... HOW CONVENIENT!! UPON MY RETURN TO NM AFTER COLORADO, I HAD THE CAR TAKEN TO AUDI IN ALBUQUERQUE. THEY TOLD ME THAT MY AIR RIDE SUSPENSION BAD WAS TORN OR DEAD. EITHER OR, IT WAS THE REASON FOR THE EXCESSIVE AMOUNT OF SHAKING AND VIBRATING WHILE DRIVING AT SOME SPEEDS. ALTHOUGH AFTER 80MPH THE CAR WOULD STOP SHAKING. AFTER 2 MONTHS OF HAVING MY AUDI ALLROAD SITTING AT AUDI, I SAVED UP ENOUGH MONEY TO HAVE THE AIR BAG REPLACED. YOU WOULD THINK THAT ON SUCH A VITAL PART OF THE CAR, THERE WOULD BE SOME SORT OF COVERAGE. I GUESS NOT. IN THE END IT COST ME $700 TO GET JUST ONE AIR RIDE SUSPENSION BAG REPLACED. IN THE END I WAS DISAPPOINTED MY AUDI'S RESPONSE TO THE PROBLEM AND THE PRICE THEY GAVE ME FOR THE PART. IRONICALLY, AUDI ACTUALLY TOLD ME THAT I NEEDED TO REPLACE TO AIR BAGS. THAT WAS B.S. I BOUGHT ONE BAG FROM AUDI AND DROVE MY CAR BACK TO ANOTHER DEALERSHIP AND HAD THEM REINSPECT AND REPLACE THE AIR BAG. ALL SEEMED WELL AND THE ONE AIRBAG FOR THE RIDE SUSPENSION WAS REPLACED. I DID NOT NEED 2. SO BE AWARE THAT AUDI WILL BLINDSIDE YOU WITH UNNECESSARY COSTS. BE AWARE OF THIS PROBLEM WITH THIS CAR. IT IS EXPENSIVE AND A LONG AND ROUGH ROAD TO REPLACE. THE CAR OVER ALL HAS A PRETTY GOOD REPUTATION AND WOULD RECOMMEND IT EVEN MORE IF IT DID NOT HAVE SUCH A PROBLEM. *TR

NHTSA ID

10228380

Incident

Dec 30, 2007

Mileage

84,600 mi

This bulletin provides information on the additional reporting requirements for safety related inquiries.

This informational bulletin explains how to order replacement VIN plates, Safety Certification Labels, etc.

This information bulletin contains instructions for technicans on how to ensure their TAC call goes smoothly.

This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light lens.

This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.

This informational bulletin contains all the the Audi Oil Quality Standards that should be used when doing an oil change.