2004 Audi Allroad

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH SOME RESEARCH I FOUND OUT THAT THE DEALER FIXED THE PROBLEM WITH EPOXY.

NHTSA ID

10851719

Incident

Mar 14, 2016

Mileage

195,800 mi

TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND LATER TO A DEALER FOR INSPECTION AND DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08V157000 (FUEL SYSTEM, GASOLINE), 06V198000 (ELECTRICAL SYSTEM), AND 04V133000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

NHTSA ID

10758950

Incident

Aug 23, 2015

Mileage

162,000 mi

WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS PROBLEM. I CONTACTED AUDI AND REQUESTED THEM TO REPLACE MY MOON ROOF. THEY GAVE ME THE RUN AROUND AND THEN UNFORTUNATELY, DECIDED THAT THEY ARE UNWILLING TO ASSIST ME WITH THE REPLACEMENT OF MY OWN MOON ROOF BECAUSE IT WAS NOT ONE OF THE MODELS RECALLED AND MY CAR IS OVER 10 YEARS OLD SO IT IS OUT OF WARRANTY. THANK GOD MY CHILDREN WERE NOT IN THE CAR TO BE INJURED BY EXPLODING GLASS AND THANK GOD IT WAS 5:00 IN THE MORNING SO THERE WAS NO TRAFFIC AROUND FOR THE EXPLOSION TO HAVE CAUSED AN ACCIDENT! AUDI HAS TREATED THIS LIKE IT'S NOT BIG DEAL, SOMETHING THAT SHOULD BE EXPECTED TO HAPPEN AFTER OWNING ONE OF THEIR CARS FOR 10 YEARS, AND THAT IT IS MY PROBLEM FOR HAVING AN "OLD" CAR. SHAME ON AUDI FOR NOT TAKING RESPONSIBILITY FOR THIS! *TR

NHTSA ID

10633244

Incident

Sep 11, 2014

Mileage

95,000 mi

ON AUG. 09 2014 COMMING TO A STOP I APPLIED THE BRAKES. ALL OF A SUUDEN THE ENGINE STARTED TO ACCELERATE UNCONTROLABLE TRYING TO MOVE THE CAR FORWARD. I PRESSED THE BRAKES AS HARD AS I COULD AND I STOPED THE CAR AFTER I HIT THE CAR IN FRONT WHEN I WAS ABLE TO TURN THE IGNITION KEY OFF. THIS SUDDEN UNINTENDED ACCELERATION MALFUNCTION ALSO HAPPENED ON JAN. 29, 2006 AND JAN. 30, 2011, ALSO REPORTED TO NHTSA AT THOSE TIMES. IT IS A LIFE SAFETY ISSUE AND SHOULD BE ADDRESSED A.S.A.P. THE MANUFACTURER REFUSE TO TAKE ANY ACTION. *TR

NHTSA ID

10629613

Incident

Aug 9, 2014

Mileage

38,840 mi

TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT THE BRAKES FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. WHILE DRIVING 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE DID NOT STOP. THE FAILURE CAUSED THE CONTACT TO REAR END ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING ON THE RESULTS OF THE DIAGNOSTIC TEST FROM THE DEALER. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,848. UPDATED 09/15/14*LJ THE CONSUMER STATED THE FAILURE IS UNINTENDED ACCELERATION NOT BRAKE FAILURE. MANUFACTURER REFUSED ASSISTANCE. UPDATED 1/16/15 *JS

NHTSA ID

10621341

Incident

Aug 9, 2014

Mileage

38,840 mi

TL * THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A FIRE ERUPTED IN THE VEHICLE DUE TO THE HEATED SEATS. THE VEHICLE WAS TAKEN TO DEALER WHERE THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 108,000.

NHTSA ID

10606513

Incident

Nov 12, 2013

Mileage

102,000 mi

THE SUSPENSION IN FRONT TIRES KEEP GOING OUT. AND WHEN I DID THE RESEARCH AS TO HOW TO FIX THIS PROBLEM ON AN AUDI IT STATED THAT THEY ARE FAMILIAR WITH THE PROBLEM AND ARE OF THIS PROBLEM BUT SEE ANY REASON AS TO WHY THEY SHOULD FIX IT. EVEN THOUGH THE PROBLEM EXISTED WHEN THE CAR REACHED A CERTAIN PART. *JS

NHTSA ID

10456964

Incident

Apr 13, 2012

SUDDEN UNINTENDED ACCELERATION , COMING TO A STOP SIGN, APPLYING THE BRAKES, THE ENGINE STARTED TO ACCELERATE UNCONTROLLED. I WAS ABLE TO STOP IT AFTER I PUSHED THE CAR IN FRONT. I SHIFTED IN PARK, THE ENGINE CONTINUED TO ACCELERATE AT HIGHER RATE WHEN I WAS ABLE TO TURN THE KEY OFF. *LN

NHTSA ID

10380950

Incident

Jan 30, 2011

Mileage

27,745 mi

This bulletin provides information on the additional reporting requirements for safety related inquiries.

This informational bulletin explains how to order replacement VIN plates, Safety Certification Labels, etc.

This information bulletin contains instructions for technicans on how to ensure their TAC call goes smoothly.

New document 2004-2020 A4 allroad, A6 allroad, A8L, R8 Spyder

This informational bulletin contains resource information for when the traffic feature is inoperative in the MMI navigation.

This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light lens.