2021 BMW 330E

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

1. The engine starter motor (specifically the pinion starter) has failed, and the auxiliary battery is also showing reduced capacity (only a portion of its 660 cold cranking amps). The vehicle is currently at a service center where the technician has diagnosed these issues. The components should be available for inspection upon request, as they have not yet been replaced. 2. The failure of the starter motor and battery primarily affects the vehicle's ability to start. While this could potentially strand you in an unsafe location, the information provided does not indicate any specific safety incident or risk that occurred during operation. No direct safety hazard has been reported. 3. Yes, a technician has diagnosed the problem and confirmed a fault code in the drivetrain related to the failed starter motor. The technician also identified the auxiliary battery's reduced output. This confirmation comes from a service center, which could be a dealer or independent shop. 4. The only inspection mentioned is by the technician at the service center. There is no indication that the manufacturer, police, insurance representatives, or others have inspected the vehicle or components. 5. Yes. Prior to the failure, when starting the car in the early morning, a "drive train service" message appeared on the display, advising you to visit a service center as soon as possible. This warning was the first symptom of the problem before the starter ultimately failed and the battery drained. This aligns with the technician's diagnosis of a drivetrain fault code related to the starter motor.

NHTSA ID

11720299

Incident

Feb 24, 2026

On 5/22/24 had a catastrophic failure of the Electric Motor Electronics and 12v Battery. I have requested that the BMW Serice Assistant provide me with all affected parts for inspection. Shutdown of the vehicle high voltage system could result in a crash. When this part fails along with the 12v battery you lose control of all vehicle electronics (steering, braking, electrical power, and propulsion). Yes, there was a previous voluntary recall campaign 19V-599s Service Information Bulletin (Revision 2) which replaced SI B12 27 19 dated October 2019 by BMW for this device. The vehicle and component has been inspected by the Richmond BMW Service Technician. I started to experience problems with the vehicle in late April and took it in for servicing and repair in early May. I was told that the problem was a computer programming recall that was fixed.

NHTSA ID

11590355

Incident

May 22, 2024

In Buford GA at the corner of Elm Tree Terrace and Buford Dam road, I was waiting for the light to turn on a decline. It is important to note that the car was driving in all-electric mode on a full charge. Once the light turned green I stepped on the accelerator to go and the car stalled. I believe the transmission slipped. The gears caught at high torque and jolted the car involuntarily forward. I didn't notice it at first but after a couple of sleepless nights with shoulder pain: I got an MRI and was found to have a torn rotator cuff. It is difficult to associate the injury as it is hard to access the force applied to the jolt. The only word I can use to describe the force of the jolt was violent. I believe there is a safety issue when a high torque electric motor is being run through a slipping or failing transmission and I suspect as a result I have suffered a injury as a result.

NHTSA ID

11444952

Incident

Dec 13, 2021

The Supplemental Restraint Systems (SRS) Front Passenger’s Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle's original in-service / first delivery date.

A vehicle listed above may arrive with a Check Control Message (CCM), and/or malfunction indicator lamp(MIL) illuminated. After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the front bottomactive air flap is obstructed or blocked. Thoroughly inspect the front bottom air flap, when applicable, remove any contamination that is found caught inand between the bottom air flaps (aka “blinds”) and/or the housing.

The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt betweenCombustion engine and starter generator torn And/or one or more of the following other issues are also occurring: Noise in the area of the belt drive. Odor from the engine compartment. Smoke formation in the area of the belt drive. Drive belt damaged or prematurely worn. Torn drive belt.

An interference noise (groaning noise) can be heard from within the heating and air-conditioning unit in thecenter of the instrument panel. The groaning noise always occurs when either a ventilation flap, air stratification flap or the recirculated airflap moves to a different position. Due to the complex design of the heating and air-conditioning unit, the kinematics causing it (top or bottom,left or right) may not be able to be precisely located. Depending on the vehicle model, the number of servomotors (and the associated kinematics unit) varies.Various models use either 2 or 3 servomotors.

The basic conditions for initializing the power windows are not met.