2022 BMW 330E

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Vehicle threw code 21A50A (Starter Pinion Timeout) and a Drivetrain Malfunction warning. Car still starts and drives. This is the exact mechanical failure described in Starter Recall 26V-438 / 26V-441, but my 2022 330e VIN is currently excluded.

NHTSA ID

11752593

Incident

Jul 22, 2026

Hours after a software update to the vehicle, a sudden unintended acceleration event occurred as I pulled into the alley of my office's driveway/garage. The brakes failed to work, and the vehicle rapidly accelerated in less than 2 seconds. In order to avoid endangering anyone, I steered the vehicle into City trash cans that were in front of a telephone pole. The vehicle was completely damaged, and both my passenger and I sustained severe injuries, including a vertebral compression fracture and torn neck ligaments. The vehicle is currently undergoing inspection by my insurance company. My safety was jeopardized entirely. If the vehicle had not collided with the telephone pole, it would have entered a street full of cars, thereby endangering pedestrians and other drivers. As of now, the issue has not been reproduced or confirmed by the dealer, and no attorney is willing to pursue the case due to the exorbitant costs associated with litigating against a major auto manufacturer. The police were present at the crash site, and the insurance company is currently examining the vehicle. There were no warnings displayed on the dashboard, nor was there any unusual behavior exhibited by the vehicle prior to the incident.

NHTSA ID

11527035

Incident

Jun 8, 2023

A vehicle listed above may arrive with a Check Control Message (CCM), and/or malfunction indicator lamp(MIL) illuminated. After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the front bottomactive air flap is obstructed or blocked. Thoroughly inspect the front bottom air flap, when applicable, remove any contamination that is found caught inand between the bottom air flaps (aka “blinds”) and/or the housing.

The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt betweenCombustion engine and starter generator torn And/or one or more of the following other issues are also occurring: Noise in the area of the belt drive. Odor from the engine compartment. Smoke formation in the area of the belt drive. Drive belt damaged or prematurely worn. Torn drive belt.

An interference noise (groaning noise) can be heard from within the heating and air-conditioning unit in thecenter of the instrument panel. The groaning noise always occurs when either a ventilation flap, air stratification flap or the recirculated airflap moves to a different position. Due to the complex design of the heating and air-conditioning unit, the kinematics causing it (top or bottom,left or right) may not be able to be precisely located. Depending on the vehicle model, the number of servomotors (and the associated kinematics unit) varies.Various models use either 2 or 3 servomotors.

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.