2008 BMW 535XI

Car is over heating. Replace water pump and thermostat. Car still over heating. Bad water pumps.

NHTSA ID

11611307

Incident

Apr 14, 2024

the taillight, blinker and reverse light all went out and when I pulled the components out To check to see if the bulbs are burnt all of the bulbs are perfectly fine, but the aluminum pieces were sparking, and the whole component will not work

NHTSA ID

11590941

Incident

May 26, 2024

Station wagon lift gate has severe wiring failures between the lift gate and body. This problem is well known throught the blog community. Broken wires cause failures, and electrical danger, to the rear lighting system that includes brake, running, back up, and turn signals. Also effected is the rear wiper, defroster, and operation access to open and close the lift gate. Tailgate failure would prohibit emergency opening and access to spare tire and fuses. I have already spent $3,000 on one harness replacement (dealer) and am looking at another $3,000 to repair (dealer) more wiring that will restore the brake/running lights on one side (failed state inpection). The internal lighting diagnostics did NOT indicate any lighting problems or warning. Broken wires could also cause failures to some or all of the entire electrical system. Very dangerous.

NHTSA ID

11508175

Incident

Feb 3, 2023

The passenger seat occupancy sensor stopped working. On the NHSTA website I found where BMW offered a 15 year warranty for this part. What was the negotiation with NHSTA that BMW offered this warranty? It is warranty SI B01 01 18. My car on the list is the E60 and E61 with option 456 (Comfort Seat). BMW refuses to honor this warranty and want to charge me $2,700 to repair this. Note that the front passenger seat is rarely occupied. Why should this part fail prematurely?

NHTSA ID

11463604

Incident

Feb 15, 2022

The vehicle's engine caught fire approximately 13 1/2 hours after last having been driven. I parked it in my driveway at 9pm on April 15, 2022. I was alerted to a fire in the engine by my neighbor at 10:30am on April 16, 2022. The entire engine was engulfed in flames, melting all of the plastic components. It burned through my hood and affected every part of the engine. We were able to get the fire out with a garden hose before it spread to the house and my parents' two other vehicles parked next to it. No one was burned while putting out the fire, but several neighbors and family members did breathe in the toxic smoke. 911 was called and the fire department confirmed the fire was out. The driveway under the vehicle has burn damage, but we haven't moved the vehicle yet to see the extent of it. The check engine light had been on since purchase. The vehicle had been maintained by a mechanic specializing in import motors. He was unable to determine the cause of the check engine alert, and said it was a problem that BMW has with several of their models of this era. The vehicle was only covered under liability insurance, so our insurance company has not required an inspection. It has not yet been inspected by a mechanic or any other entity. The vehicle is available for inspection if requested.

NHTSA ID

11461541

Incident

Apr 16, 2022

MY BMW IS A 2008 BMW 535XI THAT WAS MANUFACTURED ON 02/2008. I HAVE HAD AN ISSUE WITH CYLINDER 4 MISFIRING SO I CHANGED ALL 6 SPARK PLUGS AND CYLINDER 4 IGNITION COIL ONLY TO HAVE CYLINDER MISFIRING STILL. I TOOK IT TO A MECHANIC AND THEY CHECKED AND STATED THAT I HAD A BAD IGNITION COIL BECAUSE MY SPARK PLUG AND IGNITION COIL SMELLED LIKE FUEL. MY FRIEND IS A TECH AT A LOCAL BMW DEALERSHIP AND TOLD ME NOT TO REPAIR IT YET BECAUSE BMW HAS ISSUED A RECALL FOR MY VEHICLE WHICH IS A E61 SPORTS WAGON. I WILL PROVIDE THE DOCUMENT THAT SHOWS THAT MY VEHICLE IS UNDER THE AFFECTED VEHICLES. WHEN AT IDLE MY CAR SHAKES. THIS HAS BEEN GOING ON FOR ABOUT A YEAR I JUST NEVER HAD THE MONEY TO FIX IT AND DIDN'T KNOW WHAT THE ISSUES WERE UNTIL NOW. I DON'T KNOW THE EXACT DATE SO I WILL PUT TODAY'S DATE.

NHTSA ID

11320619

Incident

Apr 8, 2020

TL* THE CONTACT OWNS A 2008 BMW 535XI. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE MISFIRED THE VEHICLE WAS TAKEN TO THE LOCAL DEALER BMW OF COLUMBIA LOCATED AT (1900 I70 DR. SW, COLUMBIA MO) WHO DIAGNOSED THAT THE ENGINE CYLINDER NUMBER 4 MISFIRE WAS DUE TO DEFECTIVE FUEL INJECTORS. THE FUEL INJECTORS WERE REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,450.

NHTSA ID

11319458

Incident

Jun 1, 2019

Mileage

93,450 mi

FOR OVER THE PAST YEAR, THE (SMALL) ENGINE LIGHT HAS BEEN REPEATEDLY & CONSTANTLY GOING ON/OFF. I'VE HAD SENSORS, SPARK PLUGS, TUBES & EVERYTHING UNDER THE SUN REPLACED AND HAVE TAKEN (OR TOWED IN MOST CASES) THE CAR TO MANY DIFFERENT AUTO REPAIR SHOPS FOR MULTIPLE QUOTES & REPAIRS. THE LATEST PROBLEM IS THE SMALL ENGINE LIGHT CAME ON & THE CAR WAS STUCK IN PARK AND WOULD NOT ENGAGE IN DRIVE OR REVERSE. IT WOULDN'T SHIFT. AFTER TURNING THE CAR OFF AND THEN ON AGAIN, THE ENGINE LIGHT WAS COMPLETELY GONE & THE CAR WAS FINE TO DRIVE/REVERSE. AFTER DRIVING THE CAR A FEW BLOCKS, THE ENGINE MALFUNCTION/REDUCE SPEED LIGHT CAME ON, THE POWER WAS DRASTICALLY REDUCED & I ALMOST GOT HIT BY A DUMP TRUCK. IN 2008, I BOUGHT MY BMW BRAND NEW BECAUSE I WANTED NO CAR ISSUES BECAUSE I AM NOT A MECHANIC. EVERY SINCE I BOUGHT THIS CAR I HAVE HAD NOTHING BUT REPEATED & DIFFERENT ISSUES THAT NO MECHANIC CAN IDENTIFY. AND IT ALL STARTED WITH THE HIGH-PRESSURE FUEL PUMP WHICH WAS REPLACED THREE TIMES (HPFP). AFTER THE THIRD HPFP WAS REPLACED, AND THE CAR WAS IN THE SHOP LITERALLY FOR THREE MONTHS STRAIGHT, I GOT A LAWYER INVOLVED AND BMW CORP APOLOGIZED & SAID I COULD HAVE A CHOICE OF: 1/ GETTING A DIFFERENT CAR THAT THEY PICKED OUT (A 535I NOT THE XI I BOUGHT BECAUSE OF SNOW AND ICE CONDITIONS) 2/ THEY CUT ME A CHECK FOR A FEW THOUSAND AND TOLD ME TO SHUT UP AND I COULD NEVER SPEAK OF WHAT HAPPENED OR BE PART OF FUTURE LAWSUITS OR CLASS ACTIONS. I'VE NEVER FELT SAFE DRIVING MY 2008 BMW (116K MILES ON IT OVER 12.5 YEARS) EVERY BMW OWNER THAT BOUGHT A BMW BETWEEN THE RANGE OF YEARS KNOWS EXACTLY WHAT I AM TALKING ABOUT RE: THE CONSTANT AND NEVER-ENDING ISSUES THAT ALL START WITH THE HPFP & ESCALATE FROM THERE. REPAIR SHOPS CAN'T FIX THE ISSUES & BMW COVERS UP. NHTSA HASN'T DONE ANYTHING ABOUT THIS MASSIVE BMW ISSUE AFFECTING THE VAST MAJORITY OF OWNERS. JUST GOOGLE IT!

NHTSA ID

11279664

Incident

Nov 10, 2019

Mileage

116,000 mi

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

BMW: ON SOME VEHICLES, WHEN STARTING, LOW BEAM, WITH 0552 OPTION, WOULD BRIEFLY FLASHES, DUE TO A FAULTY LED MAIN LIGHT MODULE THAT NEEDS REPLACING. MODEL 2008-14 F01, F02, F06, F07, F10, F12, F13, F25. *PE