RoadVitals

2002 BMW R1150GS

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
21
Latest Jun 3, 2020
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jul 31, 2001
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
1 injuries, 0 deaths reported

Overview

Our database contains 21 NHTSA owner-reported complaints for the 2002 BMW R1150GS, most frequently naming the brakes, fuel system and powertrain (other) categories. 1 safety recall has been issued covering this model year; 1 NHTSA investigation names it; and 4 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes1252.2%
  • Fuel system417.4%
  • Powertrain (other)417.4%
  • Electrical14.3%
  • Interior & seats14.3%
  • Transmission14.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
01V246000

SERVICE BRAKES, HYDRAULIC

Jul 31, 2001
2,997 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTORCYCLES. THE DISTANCE BETWEEN THE BRAKE LINE AND THE SPEEDOMETER DRIVE CABLE COULD BE TOO SMALL. DUE TO COMPRESSION AND REBOUND OF THE FORK, THE SPEEDOMETER CABLE COULD CONTACT AND CHAFE THE BRAKE LINE.
The risk: BRAKE FLUID LEAKAGE COULD OCCUR, RESULTING IN A LOSS OF FRONT BRAKING CAPABILITY. IF THIS HAPPENED, DEPENDING ON TRAFFIC CONDITIONS AND THE RIDER'S REACTIONS, A CRASH COULD OCCUR.
The remedy: DEALERS WILL MEASURE THE DISTANCE BETWEEN THE FRONT BRAKE LINE AND SPEEDOMETER CABLE. THE BRAKE LINE WILL BE REPLACED IF THE DISTANCE TO THE SPEEDOMETER CABLE IS FOUND TO BE TOO SMALL OR IF IT IS DAMAGED. A NEW PROTECTIVE SLEEVE WILL BE INSTALLED IN THE SPEEDOMETER CABLE NEAR THE FRONT FENDER. OWNER NOTIFICATION BEGAN DECEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117, OPTION #5.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

PE03054ClosedPreliminary Evaluation

FUEL LINE LEAKAGE

Opened Dec 1, 2003
Closed Jan 23, 2004

BMW IS CONDUCTING A RECALL (04V-028).AN INFORMATION REQUEST(IR)RESPONSE WAS NOT RECEIVED. UPON BMW'S RECEIPT OF THE IR, AND AFTER DISCUSSIONS WITH ODI, BMWDETERMINED THAT A RECALL WAS NECESSARY. ON CERTAIN MOTORCYCLES, THE O-RING CONTAINED WITHIN THE FUEL LINE QUICK-DISCONNECT COUPLING COULD BECOME DAMAGED.FURTHER, THERE IS ALSO A PROBLEM INVOLVING CRIMP-TYPE HOSE CLAMPS, WHICH CAN ALSO RESULT IN A SMALL FUEL LEAK.DEALERS WILL INSPECT, AND IF NECESSARY, ADJUST ALL CRIMP-TYPE HOSE CLAMPS.ALSO ALL FUEL LINE QUICK-DISCONNECT COUPLINGS WILL BE INSPECTED.IF A LEAK IS DETECTED, THE QUICK-DISCONNECT O-RING WILL BE REPLACED.IF DAMAGED, THE COUPLING WILL BE REPLACED.OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGSLed to recall 04V028000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 21
Electrical
Filed Jun 3, 2020
Fire reported1 injury reported

SUSPECTED ELECTRICAL FIRE LED TO THE MOTORCYCLE BEING ENGULFED IN FLAMES SHORTLY AFTER STARTUP. *TR

NHTSA ID
11327171
Incident
Jun 2, 2020
Mileage
22,419 mi
Powertrain (other)Transmission
Filed Apr 26, 2012

MY 2002 BMW 1150GS MOTORCYCLE HAS ONLY JUST OVER 41K MILES ON THE ODOMETER. THESE MOTORCYCLES ARE ADVERTISED TO THE PUBLIC AS ABLE TO DRIVE FOREVER ACROSS CONTINENTS, BUT THAT IS NOT THE CASE. I WAS VERY SURPRISED WHEN IT LOST SOME INTERNAL GEARS LAST WEEKEND AND SOMETHING LET GO IN THE GEARBOX WHEN SHIFTING BETWEEN 5TH AND 6TH UNDER NORMAL OPERATING CONDITIONS. AFTER REGULAR MAINTENANCE, THE TRANSMISSION IS NO LONGER OPERATIONAL. METAL FRAGMENTS CAME OUT OF THE TRANSMISSION WHEN DRAINED OF FLUID. THIS IS A TOTAL TRANSMISSION FAILURE AND WILL NEED TO BE REPLACED. I WAS TRAVELING AT NEAR 65 MILES PER HOUR ON A VEHICLE WITH ONLY TWO WHEELS AND WAS VERY FORTUNATE THAT I WAS NOT IN HEAVY TRAFFIC AND THAT THE BIKE'S REAR WHEEL DID NOT LOCK UP. THIS COULD HAVE RESULTED IN A FATALITY IF I WERE TO HAVE BEEN THROWN FROM THE BIKE AND / OR REAR ENDED BY OTHER VEHICLES UPON MY RAPID DECELERATION. THERE WAS A NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION RECALL OF SIMILAR BIKES BUILT AROUND THE SAME TIME (SEE NUMBER: 02V319000). ALTHOUGH MY MOTORCYCLE WAS MANUFACTURED AND ASSEMBLED AT OR NEAR THE SAME TIME, MY LOCAL BMW DEALER OR BMW OF NORTH AMERICA WILL NOT PROVIDE ANY REPAIRS. I BELIEVE THAT MY BMW MOTORCYCLE HAS SEVERE DESIGN, MANUFACTURING, AND OR MATERIAL DEFECTS THAT SHOULD BE EXAMINED IN MORE DETAIL. THIS IS A SERIOUS SAFETY ISSUE. A CURSORY REVIEW OF THE INTERNET REVEALS SIMILAR PROBLEMS OF RELATED MOTORCYCLES BUILT BY BMW. I URGE THE NATIONAL HIGHWAY TRAFFIC SAFETY ASSOCIATION TO FULLY INVESTIGATE THIS MATTER AND PROVIDE NOTICE TO OTHER CONSUMERS THAT MAY BE UNAWARE OF THIS POTENTIALLY FATAL DESIGN DEFECT. *TR

NHTSA ID
10456593
Incident
Apr 20, 2012
Mileage
41,034 mi
Fuel system
Filed Sep 27, 2007

TL*THE CONTACT OWNS A 2002 BMW R1150RA (NA). WHILE DRIVING 50-55 MPH, THE CONTACT SMELLED GAS FUMES AND THEN NOTICED FUEL LEAKING FROM THE QUICK RELEASE MECHANISM. AS OF SEPTEMBER 27, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE MANUFACTURER STATED THAT THEY WOULD REPLACE THE QUICK RELEASE MECHANISM FOR FREE. THE CURRENT AND FAILURE MILEAGES WERE 8,000.

NHTSA ID
10204247
Incident
Aug 21, 2007
Mileage
8,000 mi
Powertrain (other)
Filed Sep 18, 2006

IN APRIL 2005, I EXPERIENCED A FINAL DRIVE FAILURE ON MY 2002 BMW R1150GS. DURING A 36,000 MILE SERVICE, I REPORTED A SLIGHT OIL LEAK AROUND THE RUBBER BOOT ON THE FINAL DRIVE SHAFT. BMW REPLACED THE FINAL DRIVE BEARING THAT WAS STILL UNDER WARRANTY. THE ENTIRE FINAL DRIVE WAS REPLACED DURING THE SERVICE AT NO CHARGE. THE FINAL DRIVE FAILURE PROBLEM IS A MAJOR ISSUE AND I AM AWARE OF SIX LOCAL BMW MOTORCYCLES, BOTH R AND K SERIES THAT HAVE EXPERIENCED FINAL DRIVE FAILURES IN THE PAST THREE YEARS. *NM

NHTSA ID
10168484
Incident
Apr 18, 2005
Mileage
35,900 mi
Powertrain (other)
Filed Oct 5, 2004

2002 BMW R1150GS MOTORCYCLE SUFFERED A FAILURE OF THE FINAL DRIVE ASSEMBLY IN THE SHAFT DRIVE MECHANISM. THERE WAS NO WARNING. THE SEAL BLEW OUT AND THE SHAFT BEARINGS DISINTEGRATED CAUSING THE WHEEL TO HOP UP AND DOWN SEVERELY AT ABOUT 70 MPH. I WAS ABLE TO PULL THE BIKE OVER SAFELY WITHOUT A CRASH. THE ENTIRE FINAL DRIVE WILL HAVE TO BE REPLACED. FORTUNATELY, IT IS STILL UNDER WARRANTY. HAD IT FAILED LITERALLY 30 SECONDS EARLIER, I WOULD HAVE BEEN LEANED WAY OVER IN A VERY TIGHT CORNER AND THE LIKELIHOOD OF A SERIOUS ACCIDENT WOULD HAVE BEEN EXTREMELY HIGH. THE LEAKING GEAR OIL COATED THE REAR TIRE CAUSING IT TO BECOME VERY SLICK. IT ALSO COATED THE REAR BRAKE PADS CAUSING THEM TO BECOME INEFFECTIVE. THE BIKE IS NOW AT THE DEALERSHIP AWAITING REPAIRS.*AK

NHTSA ID
10093667
Incident
Oct 2, 2004
Mileage
28,850 mi
Brakes
Filed Jun 4, 2004

THIS MOTORCYCLE IS EQUIPPED WITH A LINKED ABS BRAKE SYSTEM. THE REAR WHEEL AND FRONT WHEEL WORK TOGETHER. THE MOTORCYCLE WAS WITHOUT BRAKES FOR AN UNDETERMINED PERIOD OF TIME. *AK *NM

NHTSA ID
10071616
Incident
Feb 25, 2004
Mileage
16,400 mi
Fuel system
Filed Oct 1, 2003

GAS LEAK

NHTSA ID
10041059
Incident
Oct 1, 2003
Mileage
2,300 mi
BrakesPowertrain (other)
Filed Jul 8, 2003

FINAL DRIVE FAILURE ON BMW R1150GS MOTORCYCLE AT 28,200 MILES RESULTING IN LOSS OF OIL AND REQUIRING COMPLETE FINAL DRIVE AND ABS SENSOR REPLACEMENT.*AK

NHTSA ID
10025621
Incident
Jun 21, 2003
Mileage
28,200 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

MC51142327

EQUIPMENT

Leaks have been reported in fork legs. The cause is reported be from oil lubricating film with accompanying dirt/grease ring is incorrectly interpreted to be a leaking fork leg. Investigations have shown that the part is not defective.

SIB-63-02-01

EXTERIOR LIGHTING

BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM

SIB-16-02-09

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE

SB-00-021-07

FUEL SYSTEM, OTHER

BMW MOTORCYCLE: ENGINE FUELS CONTAINING ETHANOL. BMW MOTORRAD HAS NO OBJECTION TO THE USE OF SI ENGINE FUELS CONTAINING UP TO A MAXIMUM OF 10% ETHANOL AND IMPOSES NO WARRANTY RESTRICTIONS. ETHANOL MIXTURES IN PROPORTIONS HIGHER THAN 10% CAN HAVE AN ADVERSE EFFECT ON PERFORMANCE AND CAN RESULT IN DAMAGE TO COMPONENTS THAT COME INTO CONTRACT WITH FUEL. NO WARRANTY CLAIMS WHATSOEVER FOR DAMAGE CAUSED IN THIS WAY WILL BE ACCEPTED. NO MODEL YEARS LISTED. *PE

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW R1150GS by model year
YearComplaintsRecallsInvestigationsIssue Index
2003311—
2002Viewing211141.5
2001311—
2000311—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.