2008 BMW X3 Sav

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

THE PASSENGER SEAT OCCUPANCY SENSOR IS DEFECTIVE. THIS IS PART OF THE "SEAT MAT", WHICH IS UNDER RECALL. BMW SENT AN INITIAL NOTICE OF RECALL IN SEPTEMBER OF 2017. AS OF APRIL 20, 2018 THE PARTS ARE STILL NOT AVAILABLE TO PERFORM THIS RECALL. OVER 7 MONTHS! NO ONE AT THE DEALER OR BMW USA CAN GIVE US A STRAIGHT ANSWER AS TO WHEN THE PARTS WILL BECOME AVAILABLE. THE Q AND A PART OF THE NOTICE INDICATES NO ONE SHOULD SIT IN THE PASSENGER SEAT UNTIL THIS IS FIXED! WHY IS BMW BEING ALLOWED TO CONTINUE TO DELAY FIXING THIS SAFETY DEFECT? I WOULD LIKE TO KNOW WHAT THE NHTSA IS DOING TO MAKE BMW REPAIR THIS IN A TIMELY MANNER!

NHTSA ID

11089086

Incident

Apr 4, 2018

Mileage

78,000 mi

LAST WEEK DASH 4X4 LIGHT COMES ON A,UDIBLE RAPID CLICKING SOUND COMES FROM REAR JUST AFTER CAR IS TURNED OFF...I BROUGHT THE VEHICLE TO WEST PATERSON MOTORS IN WOODLAND PARK, NJ FOR DIAGNOSTICS. MECHANIC STATES COMPUTER CODES INDICATE IT'S TRANSFER CASE FAILURE, AND TO REPLACE IT COSTS OVER $ 2,600.00 ! HOW DOES THE VEHICLE SUCH AS BMW GETS AWAY WITH SUCH POOR QUALITY, PARTS THAT FAIL SO SOON, SO EXPENSIVE? HOW IS THIS POSSIBLE? PLEASE RECALL TRANSFER CASE PLEASE, THIS VEHICLE DOES NOT EVEN HAVE 85,000 MILES ON ODOMETER YET ...

NHTSA ID

11084806

Incident

Apr 6, 2018

Mileage

83,000 mi

I HAVE BROUGHT MY VEHICLE TO BLOOMFIELD NJ DEALERSHIP ON SEVERAL OCCASIONS IN 2013, 2014, 2015 DUE TO VEHICLES INABILITY TO SHIFT GEARS SWIFTLY, RMP GOING TO 34,000 AND TRANSMISSION NOT SHIFTING GEARS. I DRIVE ABOUT 6,000MILES PER YEAR SOMETIMES LESS. ALL DEALER WOULD SAY "VEHICLE PERFORMS AS DESIGNED"....OR "UNABLE TO DUPLICATE THE PROBLEM". AROUND JUNE 20, 2016 WHEN IN THE DRIVEWAY I PUT GEAR IN REVERSE BUT VEHICLE WOULD NOT MOVE. I CALLED BMW DEALER DESCRIBING THE INABILITY OF MY CAR MOVING IN REVERSE DEALER REPRESENTATIVE STATED ITS TRANSMISSION FAILURE. THE VEHICLE WAS TOWED TO TRA-PAR TRANSMISSIONS IN BELLEVILLE NJ ON JUNE 23, 2016 CONFIRMED TRANSMISSION FAILURE AND REPLACED IT JUNE 27, 2016 FOR $ 3, 092.19 !!! COME TO FIND OUT THROUGH READING COPIES OF RECEIPTS DEALER HAD NOT DESCRIBED ISSUES AS THERE WERE ON THEIR WORK ORDERS! AFTER I READ MOST OF THEM, THEY DON'T EVEN MENTION THE TRUE REASON WHY THE VEHICLE WAS BROUGHT IN ! I'M VERY DISGUSTED WITH THEM AND I FIND BMW DEALER STALLING TACTICS AND DECEPTION CRIMINAL.

NHTSA ID

11084794

Incident

Jun 20, 2016

Mileage

68,995 mi

RECALL NOTIFICATION WAS RECEIVED IN NOV 2017. DEALER HAS YET TO REPAIR. IS THIS LENGTH OF DELAY ACCEPTABLE?

NHTSA ID

11084277

Incident

Oct 30, 2017

I HAVE 2 DANGEROUS RECALLS. ONE-NO ONE CAN SIT IN THE PASSENGER SEAT BECAUSE THE AIR BAGS MAY NOT DEPLOY AND THE SECOND, MY ENGINE CAN BE ON FIRE DUE TO A PVC VALVE. BMW HAS NO REMEDIES AND IT HAS BEEN OVER 4 MONTHS, THIS IS UNACCEPTABLE. SOMEONE HAS TO PUT THE PRESSURE ON BMW TO GET THIS FIXED IMMEDIATELY. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11082069

Incident

Nov 17, 2017

TAKATA RECALL - I CALLED EAST BAY BMW AND BMW OF CONCORD DEALERSHIPS SINCE RECEIVING SAFETY RECALL IN JUNE 2017 TO MAKE AN APPOINTMENT FOR THE AIRBAG RECALL SERVICE AND I HAVEN'T RECEIVED A CALL BACK REGARDING THE PARTS ARRIVING TO THE DEALERSHIP. IT IS NOT NOVEMBER AND I STILL HAVEN'T RECEIVED A SINGLE PHONE CALL.

NHTSA ID

11043612

Incident

Jun 30, 2017

SINCE PURCHASE IN 2013 FROM A DEALER, WITH ONLY 43000 MILE CHANGED BATTERY TWICE AT BMW PETER PAN, REPLACED POWER STEERING PUMP, WINDOW REGULATOR, REPLACED STARTER , PLUS OTHER SERVICES AND WINDOW WIPERS ARE FAULTY, T-CASE ACTUATOR REPLACED, SWAY BAR REPLACED, TOTALING $9531.38. I TRIED TO COMPLAIN TO BMW CORPORATION FOR SELLING A LEMON CAR . PLEASE LET ME KNOW WHO I CAN COMPLAIN ABOUT THIS CAR. RIGHT NOW IT ONLY HAS 57K MILES ON IT AND I AM BEING TOLD IT NEEDS MORE WORK.

NHTSA ID

10993087

Incident

May 22, 2017

NHTSA CAMPAIGN NUMBER: 16V071000 . ALMOST A YEAR AND A HALF AND STILL NO RESOLUTION FROM BMW MEANWHILE WE ARE AT RISK EVERYDAY. I WOULD LIKE TO AT LEAST SEE A SCHEDULE FOR REPAIR RATHER THAN THEM USING ATTRITION TO MITIGATE THEIR COST.

NHTSA ID

10991788

Incident

May 26, 2017

Mileage

80,000 mi

While driving the vehicle on normal roads at10mph and above, a "cracking" sound from the top of the B-pillar(s) is heard.

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

BMW: SELECTIVE CATALYST REDUCTION MODULE (SCR) HAS A STORED FAULT, PRESSURE BUILD UP IS LOW, CAUSING SERVICE ENGINE SOON LIGHT TO ILLUMINATE. *

BMW: SOME VEHICLES, WITH 552 OPTION, ARE EXPERIENCING A MALFUNCTION OF LED HEADLIGHT ON ONE WHERE IT FLICKERS ON AN DOFF DURING DRIVING AND THE CONTROL CHECK MESSAGE IS INDICATING DEFECTIVE DRIVING LIGHT OR PARKING LIGHT. *PE