2024 Chevrolet 3500HD Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Chevrolet 3500HD, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags125.0%
- Engine125.0%
- Interior & seats125.0%
- Powertrain (other)125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
The contact owns a 2024 Chevrolet Silverado 3500HD. The contact stated that while driving at various speeds, the vehicle jerked, with the check engine and several other unknown warning lights illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that an unknown part was replaced. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the sensor kit and fuel level sensor were replaced; however, the failure persisted. The contact stated that on a separate occasion, the check engine warning light illuminated. The vehicle was taken to a different dealer, ValMark Chevrolet in New Braunfels, TX, where it was diagnosed that the engine control module, gateway module, service brake light and steep sensor had failed. The shaft sensor, gasket, and passenger’s side rear axle were replaced. The dealer test-drove the vehicle and informed the contact that the codes were cleared. Afterward, the contact was informed that the codes were not reset. Most recently, an abnormal sound was coming from the drive line between one and nine miles per hour, intermittently. The vehicle was not diagnosed or repaired after the most recent failure. The contact informed the dealer that the air bag warning light was illuminated. The dealer diagnosed that the overhead console needed to be replaced. The vehicle was replaced. The driver's seat frame seized and was replaced. The contact stated that the lights across the dashboard were flashing. Most recently, while the contact's husband was driving at various speeds, the transmission failed to function as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The transmission was replaced.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2024 Chevrolet Silverado 3500HD. The contact stated that while driving at various speeds, the vehicle jerked, with the check engine and several other unknown warning lights illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that an unknown part was replaced. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the sensor kit and fuel level sensor were replaced; however, the failure persisted. The contact stated that on a separate occasion, the check engine warning light illuminated. The vehicle was taken to a different dealer, ValMark Chevrolet in New Braunfels, TX, where it was diagnosed that the engine control module, gateway module, service brake light and steep sensor had failed. The shaft sensor, gasket, and passenger’s side rear axle were replaced. The dealer test-drove the vehicle and informed the contact that the codes were cleared. Afterward, the contact was informed that the codes were not reset. Most recently, an abnormal sound was coming from the drive line between one and nine miles per hour, intermittently. The vehicle was not diagnosed or repaired after the most recent failure. The contact informed the dealer that the air bag warning light was illuminated. The dealer diagnosed that the overhead console needed to be replaced. The vehicle was replaced. The driver's seat frame seized and was replaced. The contact stated that the lights across the dashboard were flashing. Most recently, while the contact's husband was driving at various speeds, the transmission failed to function as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The transmission was replaced.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that the tailgate opened unexpectedly. The contact stated that he had not left the tailgate partially secured and the failure was recurring. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the tailgate release switch needed to be replaced. The vehicle was not repaired. The dealer related the failure to NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages). The VIN was not included. The manufacturer was informed of the failure. The failure mileage was approximately 60,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The contact owns a 2024 Chevrolet Silverado 3500HD. The contact stated that while driving at various speeds, the vehicle jerked, with the check engine and several other unknown warning lights illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that an unknown part was replaced. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the sensor kit and fuel level sensor were replaced; however, the failure persisted. The contact stated that on a separate occasion, the check engine warning light illuminated. The vehicle was taken to a different dealer, ValMark Chevrolet in New Braunfels, TX, where it was diagnosed that the engine control module, gateway module, service brake light and steep sensor had failed. The shaft sensor, gasket, and passenger’s side rear axle were replaced. The dealer test-drove the vehicle and informed the contact that the codes were cleared. Afterward, the contact was informed that the codes were not reset. Most recently, an abnormal sound was coming from the drive line between one and nine miles per hour, intermittently. The vehicle was not diagnosed or repaired after the most recent failure. The contact informed the dealer that the air bag warning light was illuminated. The dealer diagnosed that the overhead console needed to be replaced. The vehicle was replaced. The driver's seat frame seized and was replaced. The contact stated that the lights across the dashboard were flashing. Most recently, while the contact's husband was driving at various speeds, the transmission failed to function as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The transmission was replaced.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .