Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2000 Chevrolet Astro submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
DOOR HANDLE ON RIGHT REAR DUTCH DOOR OF OUR 2000 ASTRO VAN BROKE SUDDENLY WHEN TRYING TO OPEN DOOR. WHILE THE DUTCH DOOR FEATURE IS OPERATIONALLY VERY HANDY, THE DOOR DESIGN ALWAYS HAD A FLIMSY FEEL TO IT - SO WE ALWAYS USED GREAT CARE WHEN OPENING AND CLOSING. AFTER IT BROKE, WE FOUND THE NHTSA #634576 WITH SIMILAR COMPLAINTS, SO FELT OBLIGATED TO ADD TO YOUR LIST. *TR
CHEVY 2000 ASTRO, CUTS OUT WHILE DRIVING. WE EVEN PUSHED THE VAN INTO A CHEVY DEALER AND THEY COULD NOT TELL US WHAT IT WAS AFTER HOOKING IT UP TO DIAGNOSTICS. WE FIGURED IT WAS THE COIL WIRE. RECENTLY THE VAN HAS BEEN BOGGING DOWN WHEN IT IS UNDER LOAD. ALSO, WHEN IT RAINS IT RUNS ROUGH. WE TOOK IT TO A SHOP AND THEY REPLACED OUR FUEL FILTER. IT RAN FINE BUT STILL CUTS OUT SOMETIMES RUNNING UP HILL. SO WE CHANGED THE SPARK PLUGS. IF YOU LET THE VAN SIT OVER THE WEEKEND WITH OUT DRIVING IT, THE VAN WAS REALLY HARD TO START. UNTIL FINALLY IT JUST WOULDN'T START AT ALL. IN ADDITION THE DOOR LOCKS SOMETIMES WORK AND SOMETIMES DON'T . THE DRIVER SIDE WINDOW IS VERY SLUGGISH GOING UP YOU ACTUALLY HAVE TO HELP IT BY PULLING UP ON IT. WE KEEP BLOWING FUSES WHEN WE USE OUR CIGARETTE LIGHTER TO CHARGE OUR CELL PHONE. IT REALLY NEEDS HELP. *TR
TL* - THE CONTACT STATED THAT 2000 CHEVROLET ASTRO LS' LOCKS FAILED, NOT ALLOWING HER TO GAIN ENTRANCE TO THE VEHICLE ON OCTOBER 18, 2006. THE FAILURE WAS DUE TO THE DOOR LOCK ACTUATOR MELTING. THE CONTACT STATED THAT THE VEHICLE WAS TOWED TO EAGLE AUTOMOTIVE. THE MECHANIC REPLACED THE ACTUATOR, BUT REMOVED THE RELAY BECAUSE THE CIRCUIT WAS CONTINUOUSLY CLOSED. THE MECHANIC SAID THAT IF THEY DIDN'T REMOVE THE RELAY IT WOULD MELT THE ACTUATOR AGAIN. THE CONTACT STATED THAT SHE BELIEVED THE FAILURE WILL REOCCUR. THE CONTACT STATED THAT SHE WENT TO MONUMENT CHEVROLET AND ASKED FOR A PRINT OUT OF THE MAINTENANCE REPAIRS. THE CONTACT FOUND THAT THIS VEHICLE HAS BEEN REPAIRED ON APRIL 3, 2001 FOR BACK DOOR LOCKS AND AGAIN ON FEBRUARY 14, 2002 FOR THE SLIDING DOOR. THE ACTUATOR ASSEMBLY ON THE RIGHT WAS ALSO REPLACED ON THE DRIVER DOOR. THE CONTACT STATED THAT THE DRIVER DOOR AND THE SLIDING DOOR WERE THE ONLY DOORS ON THE VEHICLE THAT HAD FUNCTIONING LOCKS. THE CONTACT STATED THAT ALL OF THE OTHER DOOR LOCK HANDLES WERESTUCK AND COULDN'T BE PULLED TO LOCK OR UNLOCK THE DOORS. SHE HAS TRIED TO GET RESOLUTION FROM THE MANUFACTURER, AND THEY SAID THAT BECAUSE IT WAS NOT TOWED TO A DEALERSHIP THEY WOULD NOT REIMBURSE HER FOR ANY REPAIRS. THE MANUFACTURE WAS GIVEN A FILE #1-438966317. THE CONTACT ALSO SENT PICTURES TO THE MANUFACTURER OF THE BURNT OUT ACTUATORS AND WITH A CERTIFIED LETTER.*AK THE CONSUMER STATED THE BRAKES FAILED, HOWEVER SHE WAS TOLD NOTHING WAS WRONG. THE CONSUMER WAS TOLD THE BRAKES WERE DESIGNED TO FAIL ON UNEVEN PAVEMENT UNDER 25 MPH. THE TROQUED CONVERTER BURNED OUT. THE LOCKS HAD AN ELECTRICAL SHORT. UPDATED 03/19/07. *JB
HAVE BROUGHT VAN IN 4 TIMES IN 4 YEARS ABOUT ELECTRICAL PROBLEMS. SMELLING WIRES BURNING. HAVE GONE THROUGH 6 BATTERIES IN 4 YEARS. REPLACED ALTERNATOR. RADIO/CD HAS BEEN REPLACED. NEW CD STOPED WORKING AFTER 1 WEEK OF BEING REPLACED. DEALER REFUSES TO REPLACE AGAIN. RADIO, OVERHEAD DIGITAL TEMP & MISC GAGES GOES OUT, SPEEDOMETOR, BATTERY, FUEL, AND ODOMOTER QUITS, ONLY THE OIL STILL WORKS. ABS BREAKING PROBEMS, PEDEL TO FLOOR, HAVE RAN INTERSECTIONS DUE TO THIS. HAVE HAD MINOR DINGS TO BUMPER BECAUSE IT ROLLED TO STOPS AT LOW SPEEDS. LOUD CLUNK IN REAR WHEN STOPPED TOO. DEALER REFUSED TO CALL IT A LEMON. REFUSED TO HELP FIX BECAUSE ITS A LEASE. ALSO HANDLE OVER PASSENGER AIRBAG DISINTEGRATED IN 3RD YEAR, AND NOW THE DRIVER ARM REST IS SPLIT IN 4TH YEAR. *AK
MY REAR HATCH DOOR OF MY 2000 ASTRO VAN WILL NOT OPEN. ALL OF THE LOCKS ON MY VAN ARE NOT WORKING AS THEY SHOULD BUT AT LEAST I CAN USE THE INSIDE DOOR HANDLES TO GET IN AND OUT. THE HATCH HAS NO INSIDE DOOR RELEASE SO IN CASE OF AN ACCIDENT I WOULD NEVER BE ABLE TO GET MYSELF OUT OF THE BACK IF THAT WERE THE ONLY WAY OUT. ALSO, IF YOU ARE BRAKING AND HIT A BUMP THE BRAKES WILL NOT WORK. I HAVE HAD SEVERAL CLOSE CALLS BECAUSE I COULD NOT STOP THE VAN BECAUSE OF A BUMPY INTERSECTION AND THE BRAKES NOT HOLDING.*AK
ON TWO OCCASIONS BRAKE LIGHTS BECAME INOPERABLE. DEALER WAS CONTACTED, AND INFORMED CONSUMER THAT WIRES WERE STRIPPED UNDERNEATH THE DASH. PLEASE PRIOVIDE FURTHER DETAILS. *AK
HAVE TAKEN BACK TO DEALER TWICE, THEY DONT'T UNDERSTAND WHAT'S GOING ON, SUPPOSE TO LOOK INTO IT AND GET BACK WTIH ME, THIS HAS BEEN AN ONGOING PROBLEM SINCE PURCHASE OF VEHICLE, HAVE EVEN TOLD AT ONE POINT I WAS CRAZY, DIDN'T KNOW WHAT I WAS TALKING ABOUT UNTIL THIS LAST VISIT 7/2000 SLIDER RATTLE WAS FIXED HOWEVER, FRONT PASSENGER DOOR STILL RATTLES AND THE DASHBOARD IS SPLITTING IN FRONT OF MY EYES, DEALER HAS NO ANSWERS WILL LOOK INTO IT. PLEASE HELP I HAVE SMALL GRANDCHILDREN THAT RELY ON MY VEHICLE. I CAN'T BE WORRIED ABOUT ITS SAFTEY AND WATCHING THIS VEHICLE DETERIORATE BEFORE MY EYES.*AK
ANT-LOCK BRAKE SYSTEM HAD TO REPLACED. ALSO, SINCE PURCHASE IN MAY 2000, FOLLOWING COMPONENTS HAD TO BE REPLACED OR REPAIRED: LIGHTS ON DASHBOARD COMING OFF AND ON/PASSENGER SIDE SEATBELT TIGHTENED AND WON'T RELEASE/DRIVER'S SEAT HAD LOOSE BOLTS AND MOVED/DRIVER AND PASSENGER DOORS RATTLED/ MOULDINGS INSIDE FELL OFF/PASSENGER'S WINDOW STUCK/TV CAME ON AND OFF ON ITS OWN WHILE DRIVING, REPLACED TWICE/INTERIOR LIGHTS STOPPED WORKING WHEN IN PARK/ ENGINE IDLED/ LIGHTS INSIDE FLICKERED/ FUEL SENDER INOPERATIVE/ WIRES IN CEILING RATTLING,AIR CONDITIONER IN REAR NOT WORKING/ REPLACED HEATER THAT DID NOT WORK IN REAR, AND PASSENGER'S AIRBAG COVER NOT FLUSHING, AND CONSUMER WORRIED IT MAY DEPLOY AT ANY TIME. *AK
THE PROBLEMS WIHT THE ELECTRICAL SYSTEM AND THE FRONT POWER TRAIN APPEAR TO BE CORRECTED. HOWEVER, I STILL SMELL THE SCENT OF BURNING CIRCUITS. I AM STILL STRUGGLING TO GET THE REAR POWER TRAIN TAKEN CARE OF.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .