Recalls, owner-reported complaints, investigations and safety data
Data refreshed
Our database contains 2 NHTSA owner-reported complaints for the 2000 Chevrolet C/K Series, most frequently naming the brakes category. 5 NHTSA investigations name it; and 11 manufacturer communications are on file.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
When owners filed reports about this model year
Not enough dated records to plot a meaningful trend — 2 months of data.
Complaints grouped by the component NHTSA recorded
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
No recalls in our database for this model year
That does not guarantee a specific vehicle is unaffected — recalls are issued against VINs, and new campaigns are announced regularly. Check a VIN on NHTSA.gov.
NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.
PARKING BRAKE FAILURE
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
HYDRAULIC PUMP FAILRES
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PARKING BRAKE FAILURE
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PARKING BRAKE FAILURE
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
Reports submitted to NHTSA, shown in the owner's own words
LEAVING MY JOB TODAY , WAS BACKING OUT AND WENT TO STOP AND RIGHT REAR BRAKE LINE BLEW LEG GOT BEAT UP TRYING TO JAM ON PARKING BRAKE AND TWISTED LEFT LEG IN PANIC BRAKE LINE BLEW NEXT TO FUEL TANK. *TR
I HAVE OWNED A 2000 CHEVY TAHOE FOR 3+ YEAR AND HAVE HAD ANTI LOCK BRAKE PROBLEMS. THE BRAKE DO NOT ENGAGE SOMETIMES AND ALMOST CAUSE ME TO CRASH AND CREATING A DAMGEROUS SITUATION. I AM A CAREFUL DRIVER SO I ALWAY KEEP THE PROBLEM IN MIND AND TRY TO ALWAYS GIVE MY SELF ENOUGH TIME TO STOP, BUT SOMETIME IN EMERGENCY WHEN I REALLY NEED THE BRAKES THEY DON'T ENGAGE AND HAVE ALMOST HAD ACCIDENTS. THIS HAS BEEN AN ON GOING PROBLEM EVER SINCE I BOUGHT THE CAR. THE BRAKE DON'T ENGAGE AND THE VEHICLE KEEPS GOING EVEN WITH FULL PRESSURE. MOST OBVIOUS WHEN ROAD IS WET. VERY SCARY
A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE
POWER TRAIN:AUTOMATIC TRANSMISSION
MALFUNCTION INDICATOR LAMP (MIL) ON, TRANSMISSION STUCK IN THIRD GEAR, INSTRUMENT CLUSTER INOPERATIVE. *TT UPDATED *EH 2006 AND PRIOR GM PASSENGER CARS AND LIGHT DUTY TRUCKS. *SC
STRUCTURE:BODY:TAILGATE
TAILGATE SUPPORT CABLE. RECALL 04007A. GM PARTS BULLETINS & INFORMATION. *TT UPDATED *EH
ENGINE AND ENGINE COOLING:ENGINE
ROUGH IDLE AFTER START, AND/OR A SERVICE ENGINE SOON (SES) LIGHT. VARIOUS MODELS INCLUDING THE 1995 CHEVROLET AND GMC S/T MODELS. *TT
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
A FAILURE OF THE ELECTRONIC DIESEL FUEL INJECTION PUMP, LEAKING TO COMPLAINTS OF POOR PERFORMANCE OR FUEL ECONOMY, HARD / NO STARTS, HESITATION, AS WELL AS ILLUMINATION OF THE SERVICE ENGINE SOON LIGHT. *TT
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
SUBJECT REGARDING EXHAUST SYSTEM RUMBLE / RATTLE NOISE. *JG
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.
Complaint and recall counts across every year of this model
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.