1996 Chevrolet C3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Chevrolet C3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes933.3%
- Engine518.5%
- Fuel system311.1%
- Visibility311.1%
- Tires & wheels27.4%
- Interior & seats13.7%
- Electrical13.7%
- Body & structure13.7%
- Powertrain (other)13.7%
- Transmission13.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
1996 CREWCAB DULEY 3500 PROBLEMS WITH EARLY WARE OF BRAKE. ROTORS TURNED AT 12000 AND NOW REPLACING BRAKE PADS EVERY FEW THOUSAND MILES DUE TO EXCESIVE WARE. DEALERS HAVE HAD TRUCK IN AT LEAST 10 TIMES FOR BREAKING ISSUES SINCE PURCHASE IN 1996. PUT NEW PADS ON IN DEC AND AT 2000 MILES THEY ARE BEING REPLACE AGAIN. MAJOR WEAR TO THE PADS
THE FRONT BRAKES ON MY CHEVROLET TRUCK HAVE TO BE REPLACED EVERY 3000MI. THEY FIRST NEEDED REPLACEING AT 12000MI WITH ALL OF THIS BEING UNLOADED HIGHWAY MILES THIS IS EXCESSIVE. THE PROBLEM HAS STEADILY GOTTEN WORSE TO WHAT IT IS NOW AT 3000MI REPLACEMENT. I HAVE HAD 2 RELATIVES WITH THE SAME PROBLEM ON C-1500 AND C-2500 TRUCKS. I WAS TOLD THAT YOU ALREADY HAD AN OPEN IVESTIGATION ON THE PROBLEM BUT I COULD NOT FIND IT ON YOUR WEB SIGHT. A LITTLE INFO IF YOU PLEASE. [email protected]
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
1996 CHEV. 1 TON DUALLY 6.5 DIESEL, ENGINE AUTOMATICALLY SHUTS OFF WHILE DRIVING LIKE IT'S STARVING FOR FUEL. AFTER READING THE FOLLOWING WEBSITE WITH THE DOZENS OF EXACT SAME PROBLEMS I REALIZED THIS IS AN ON GOING PROBLEM THAT CHEVROLET NEEDS TO ADDRESS. WHAT IF WE WOULD HAVE HAD OUR 4 HORSES AND 3 CHILDREN WITH US ON A HIGHWAY AND THIS HAPPENED? WHY ARE SO MANY OF US SPENDING HUNDREDS OF DOLLARS TRYING TO FIND OUT WHAT THE CAUSE IS AND REPLACING SO MANY PARTS WHEN THE DEALERSHIPS ARE APPARENTLY AWARE OF THIS ONGOING PROBLEM? HTTP://WWW.DIESELDOCTOR.COM/MESSAGEBOARD/DATA/119.HTML THERE SHOULD BE A RECALL ON THESE LIFT, TRANSFER AND FUEL PUMPS AND A WIRE CHECK (TO ENSURE NO WIRES HAVE BEEN DESTROYED) TO PREVENT A SERIOUS DISASTER.
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TRUCK SHUTS DOWN WHILE MOVING DOWN THE HIGHWAY. THIS IS A 1996 CHEVROLET C3500 DIESEL. PARTS WERE COVERED UNDER WARRANTY UNTIL 120,000 MILES. PROBLEM NEVER SOLVED AND VEHICLE STILL SHUTS DOWN AND YOU HAVE NO CONTROL. *TR
MOTOR SHUTS OFF AT ANYTIME,PARKED OR ON HIGHWAY. THE DEALERS SAY THEIR IS A PROBLEM WITH THE DESIGN OF THE INJECTOR PUMPS. THIS IS A VERY SERIOUS PROBLEM IN THAT , THIS VEHICLE IS DESIGNED TO HAUL AND PULL VERY HEAVY LOADS. I CONTINUE TO HAVE THIS PROBLEM AND G. M. REFUSES TO ASSIST IN ANYWAY. I CONTACTED CUSTOMER ASSISTANCE AND WAS TOLD THAT MY VEHICLE IS OUT OF WARRANTY AND G.M. IS NOT RESPONSIBLE,EVEN THOUGH IT WAS BEING WORKED ON FOR THIS PROBLEM BEFORE THE WARRANTY RAN OUT, ACTUALLY THE MILEAGE WENT OVER WARRANTY WHILE IT WAS BEING REPAIRED. I HAVE TRIED TO EXPLAIN TO THEM THAT THIS VEHICLE COULD KILL SOMEONE ,IF THE ENGINE SHUTS DOWN AT THE WRONG TIME E.G. DOWN HILL WITH TRAVEL TRAILER IN TOW, CROSSING A RAILROAD, OR ANY OTHER SCENARIO YOU MAY THINK OF. HOW MANY UNEXPLAINED ACCIDENTS AND DEATHS HAVE OCCURRED DUE TO THE DESIGN OF THIS INJECTOR PUMP. I AM TOLD BY MANY MECHANICS THAT THE CHANGE TOOK PLACE AFTER 1994 AND THEY HAVE HAD PROBLEMS WITH THEM SINCE.I CAN NOT STRESS ENOUGH THE IMPORTANCE OF THIS SAFETY ISSUE AND WOULD APPRECIATE SOMETHING BEING DONE. I NOTICED THAT SOMEONE ELSE HAS THE PROBLEM AND FILED A COMPLAINT WITH YOUR DEPARTMENT . REF , ODI ID: 814633. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WHEN THERE IS COLD TEMPERATURE OR HUMID CONDITIONS WINDSHIELD WIPERS GET WET, AND WHEN CONSUMER TURNS THE SWITCH, THE WINDSHIELD WIPERS DO NOT WORK. *AK
WINDSHIELD WIPERS OPERATE ERRATICALLY ON ALL SETTINGS. WHEN WIPERS ARE TURNED ON MIST THEY OPERATE ON HIGH. A RECALL WAS ISSUED ON THE VEHICLE, HOWEVER , THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
OVER TWO YEARS, I HAVE HAD 3 BELT FAILURES ON B.F GOODRICH LT 225/75 R16 TIRES. ONE FAILURE RESULTED IN A BLOWOUT THE OTHER TWO WERE DETECTED BY EXTREME VIBRATION WHILE DRIVING ON THE HIGHWAY. NOTIFIED B.F. GOODRICH ON THE LAST FAILURE. 3 FAILURES OF THE SAME TYPE SEEM ABOVE NORMAL FOR A TIRE IN THIS CATEGORY. B.F. GOODRICH STATED THAT THEY HAVE HAD NO COMPLAINTS OF THIS TYP OF FAILURE BUT AGREED TO GIVE ME A CREDIT OF 20% OFF A NEW TIRE BASED ON THE TREAD REMAINING ON THE OLD ONE.
WHILE VEHICLE WAS BEING DRIVEN TREAD SEPARATED ON THE REAR TIRE , ALSO OTHER TIRES WERE SHOWING SIGNS OF CRACKING AND TREAD SEPARATION. AMERI STAR TIRE SIZE LT22575R16M+S DOT NUMBER AD1LCWA285. *AK THE REMAINING TIRES WERE INSPECTED AND WERE FOUND TO HAVE TREAD CRACKS AND SPLITS. THE MANUFACTURER WANTS THE DAMAGED TIRE TO BE RETURNED FOR PROCESSING THE CLAIM. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
ELECTRONIC CONTROL MODULE FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
BATTERY ACID WAS LEAKING ONTO ENGINE. PROBLEM HAS OCCURRED 2YEARS AGO. DEALER & MANUFACTURER KNEW IT WAS A PROBLEM, BUT WON'T DOING ANYTHING UNTIL A RECALL HAS BEEN ISSUED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
PASSENGER SIDE DOOR STRICKER PIN CRACKED. YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
DIFFERENTIAL FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TRANSFER CASE FAILED SEVERAL TIMES, CAUSING GEAR TO STICK INTO 4-WHEEL DRIVE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .