2010 Chevrolet Cobalt Owner Complaints

Fuel lines leak around fuel tank, causing a fuel smell around the vehicle and a major fire hazard

NHTSA ID

11696707

Incident

Sep 23, 2025

Problem with Steering column rattle

NHTSA ID

11696686

Incident

Oct 30, 2025

The contact's daughter owns a 2010 Chevrolet Cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. There was no warning light illuminated. Due to the failure, extra effort was needed to steer the vehicle. The vehicle was not diagnosed or inspected for the failure. The manufacturer was notified of the failure and informed the contact that there were no recalls related to the failure for the VIN. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 14V153000 (Steering). The vehicle was not repaired. The failure mileage was approximately 54,000.

NHTSA ID

11689350

Incident

Sep 10, 2025

Mileage

54,000 mi

Air bag says it needs serviced Gas gadge is all over the place hard to tell how much gas I actually have in my tank.

NHTSA ID

11687046

Incident

Sep 1, 2025

The contact owned a 2010 Chevrolet Cobalt. The contact stated that, while her daughter was driving at an undisclosed speed during an ice and rainstorm with poor visibility, a vehicle parked sideways in the middle of the roadway suddenly appeared. Unable to stop in time, the vehicle collided with the driver's side rear of the other vehicle, causing it to spin and veer onto the shoulder of the roadway before coming to a complete stop. The air bags deployed but failed to properly inflate, greatly reducing their effectiveness, which the contact held responsible for the various injuries sustained by the three occupants. No warning lights were illuminated. The vehicle was towed to a storage facility and deemed a total loss by the contact's insurance provider. A police report was filed, and injuries were reported. All three occupants were transported to a local hospital by EMTs. The driver was treated for facial injuries sustained from striking the steering wheel. The minor occupant, who was seat-belted in the front passenger seat, was treated for injuries suffered to the right side of their forehead after hitting and breaking the front windshield, as well as a contusion across their chest caused by the seat belt. The contact was treated for a dislocated left shoulder and sustained multiple bruises. The manufacturer was notified of the incident, opened a case, and referred the contact to the NHTSA hotline for further assistance. The VIN was not available. The failure mileage was unknown.

NHTSA ID

11684808

Incident

Jan 1, 2013

Our daughter observed a significant puddle forming under her vehicle and noticed a strong smell of gasoline. She sent us a video, which clearly showed gasoline leaking from the driver-side rear area of the car. Due to the proximity of the fuel leak to the exhaust pipe, we had the car towed to a mechanic, as it was too dangerous to drive. The mechanic diagnosed the issue as a severely rusted-out fuel line that required immediate repair. At no point did the vehicle display any warning lights or alerts related to this issue. Alarmingly, our daughter had unknowingly driven the car while the leak was occurring, unaware of the serious fire risk this posed. We believe this is a serious safety hazard that could lead to a fire or explosion and strongly urge an investigation. This failure occurred without warning and could have resulted in a catastrophic outcome. We are fortunate this was caught in time, but others may not be as lucky.

NHTSA ID

11673793

Incident

Jul 15, 2025

UNKNOWN

NHTSA ID

11662262

Incident

May 20, 2025

Internal mechanism of the driver-side door handle broke and the door would not open from the inside. Tne dealership confirmed that the inside door ah glue is broken. The cable retainer snapped apart and the cable cannot stay connected. This might be available for inspection. Driver must exit the vehicle by crawling over to the passenger side. The problem has been confirmed by a Chevrolet dealer. There were no warning lamps or messages. The manufacturer no longer makes this part and it could not be replaced. Service description says that the customer had an electrical concern and that the door would not unlock from the inside. This was inaccurate. It was mechanical. The door could unlock, it could not open. The dealership would not let the diagnosis proceed until the customer agreed to that statement. The dealership inaccurately recorded the mileage.

NHTSA ID

11621929

Incident

Oct 24, 2024

I FOUND OUT ABOUT THE RECALL ON THE 2007-2009 ON THE CORROSION OF THE GAS LINES ON DRIVERS SIDE REAR WHEEL WHEN I TOOK MY CAR TO A CHEVY DEALER AND THEY SAID ITS THE SAME THING THATS HAPPENING TO MY CAR.AND THAT THEY ONLY DID THE RECALL ON 2007-2009 COLBALT MODELS .THE LAST COLBALT'S MADE WAS THE 2010 MODELS.WHY DIDNT THEY RECALL THEM ALSO.I TOOK IT TO ANOTHER CHEVY DEALER IN AMELIA AND THEY SAID THE SAME THING.THIS NEEDS TO BE RECALLED ASAP.ITS A SAFETY RELATED DEFECT FROM GM AND THEY KNOW IT.IF I HAVE TO I WILL GET A LAWYER AND SUE G.M. PERIOD.I CANT AFFORD TO FIX GM'S MISTAKES.THEY NEED TO COME CLEAN AND FIX THEM.IT LEAKS OUT GAS AND COULD START A FIRE OR EXPLODE WHILE I AM IN THE CAR.I DEMAND THIS TAKEN CAR OF BY GM AND STOP KICKING THE CAN DOWN THE ROAD.I WILL NOT STOP OR GIVE UP ON THIS .SENCE I WAS TOLD BY 2 DIFFRENT CHEVY DEALERSHIPS.

NHTSA ID

11600169

Incident

Jun 4, 2020

The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not covered under the recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V171000 (Electrical System). The failure mileage was approximately 260,000.

NHTSA ID

11569973

Incident

Jan 27, 2024

Mileage

260,000 mi

Seatbelts lock up and do not move. Seatbelts are front driver and passenger side. Seatbelts can't be worn because they do not work

NHTSA ID

11565908

Incident

Dec 20, 2023

The contact owns a 2010 Chevrolet Cobalt. The contact stated that while driving at 35 MPH, there was an abnormal odor of fuel inside the vehicle. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to the fuel line. The manufacturer was contacted and offered help with a new vehicle. The contract stated that the failure was related to NHTSA Action Number PE20011 (Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The failure mileage was approximately 107,000.

NHTSA ID

11564088

Incident

Jan 7, 2024

Mileage

107,000 mi

Bright LED lights when driving at night, specifically of other SUV or truck vehicles. This has affected my driving at night by blinding and giving me headaches. How can we prevent a safer road? Why is this approved? Why do headlights need to be so bright, that they are blinding to other vehicles? This is a huge safety concern and needs to be addressed. I drive a smaller car, but i shouldnt have to be punished because i drive a smaller vehicle. This isnt about specifically the make and model of the car, but solely on the bright LED headlights that are dangerous while i am driving at night.

NHTSA ID

11561455

Incident

Dec 20, 2023

UNKNOWN. My traction and ABS light keeps coming on. My steering is off some. My turning right or left is making ruff popping sounds in the steering. My ABS and Traction lite keeps coming on.

NHTSA ID

11543273

Incident

Aug 27, 2023

You Need to Reopen the Case. Due to the FACT that GM or who made the Cobalt's, Failed to tell you that THEY PUT HEAT COIL TAPE AROUND THE GAS LINES RIGHT WHERE IT RUSTED AND GAS LEAKS. WHEN THERE COIL TAPE GETS WET WITH SALT WATER FROM THE SNOW, ITS THERE HEAT COIL WRAP THAT TRAPS AND KEEPS THE SALT WATER IN SIDE THE COIL WRAP THATS TRAPED TO THE GAS LINE.I CAN PROVE IT.I HAVE THE HEAT COIL WRAP FROM MY CAR.ITS THERE FAULT NOT THE WEATHER CONDITIONS.PERIOD.WILLING TO TAKE TO COURT WITH EVIDENCE. - [XXX] , US INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11542813

Incident

Aug 24, 2023

The contact owns a 2010 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The vehicle was taken to an independent mechanic, who informed the contact that there was a fuel leak due to corrosion in the polymer blocks that attached the fuel lines. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other). The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11537338

Incident

Jan 15, 2020

Leaking fuel from plastic gas tank seam.i had it inspected by two,one Chevrolet dealer ship and my own macanic.both are saying its a malfuction on the plastic seal around the plastic gas tank.And Both are telling me I Need to Report this as soon as possible because its Leaking alot of fuel and can burst into flames, or Blow up, They both agree it is VERY VERY DANGEROUS.PERIOD AND I SHOULDNT BE DRIVING IT.they also agree it is a manafacture failure.and defentley needs to be recalled A.S.A.P. before all the people who do have the last Cobalts that were made before there Bankruptcy case.Lordstown should of recalled these knowing there 2007-2009 had problems with fuel leakage.

NHTSA ID

11536372

Incident

Mar 22, 2023

My car had a fuel pump go, then within MONTHS, another. We then dealt with the SAME problem symptomatically, and was told it was the fuel pump sensor. Within the last few weeks, I am having all the same issues-including the car intermittently not starting, gasoline leaking from the vehicle, both noticably missing from the gauge (i.e 1/8 tank less than night prior), odor of gas in the car, stalling out while driving and trying to start it, but also now dripping gas from the car. A new issue popped up, which is the dash light coming up saying "check gas cap". This past Thursday, my car wouldn't start again, and has not started since. It's concerning that the Chevy Cobalt has had recalls for the same exact problems, literally thousands of complaints that mirror mine- for every model year EXCEPT the 2010. It's also interesting that they also stopped producing the Cobalt entirely in 2010 too, but considering the amount of faults and issues I've seen documented in every year model it's not a shock. I'm concerned that despite the amount of complaints that include 2010 models, they were excluded from the recall and seeing that my situation is another one that won't be covered, fixed, or made right by GM is something that doesn't make sense. I have also seen, that in 2021 an investigation was launched specifically into this exact issue with the 2010, as well. I'm carless right now, with no answers from Chevy other than that it's not part of the recall, yet it's part of the problem. Something is VERY wrong here. It's shocking they wouldn't recall a vehicle knowing it's dripping gas, pooling gas, it's such a hazard for not only anyone driving them, but anyone driving near us or even PARKED near us. Please help do something! Also I have videos of my car dripping, 2 days prior to it not starting, if there is somewhere I could send those as well.

NHTSA ID

11522342

Incident

May 11, 2023

Unknown

NHTSA ID

11521094

Incident

May 8, 2023

The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 70 MPH, there was an abnormally strong gasoline odor coming from the vehicle. The contact pulled over on the side of the road. The contact checked under the vehicle and notice that fuel was leaking from the vehicle. The vehicle was towed to an independent mechanic and the contact was informed that the fuel line was fractured and needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was 111,000.

NHTSA ID

11506098

Incident

Jan 24, 2023

Mileage

111,000 mi

The contact owns a 2010 Chevrolet Cobalt. The contact stated that the vehicle would not immediately start as needed, and the odor of fuel was present inside and outside of the vehicle. After parking the vehicle, the contact discovered fuel leaking from the rear driver’s side of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The contact indicated that the vehicle had exhibited the failure listed in the NHTSA Investigation: PE20011. The failure mileage was 59,980.

NHTSA ID

11500774

Incident

Jan 6, 2022

Mileage

59,980 mi

Fuel lines are both leaking on the driver-side of the car, about halfway back along the length of the vehicle. I've sent it in for repairs, but I know I'm not the only one with this issue. The car has been driven gently and only has 52,000 miles on it.

NHTSA ID

11494898

Incident

Nov 20, 2022

The fuel line was leaking gasoline. It put the safety of the driver and other cars on the road as the car was leaking gasoline as it drove on the highway and city streets. The problem was confirmed by a service center and the fuel lines were replaced. No inspection by manufacturer, police etc. No warnings at all, car was starting rough and/or not starting at all.

NHTSA ID

11493130

Incident

Jun 23, 2022

Air bag light is on the dash and the passenger seat does not sense weight on the seat so all airbags are disabled I know many others with this problem and it is a serious issue that there should be a recall for

NHTSA ID

11487876

Incident

Oct 4, 2022

There seems to be a fuel leak on the driver's side rear tire line. Was told that it was very common for my vehicle to have this and that there is no fix for it.

NHTSA ID

11484100

Incident

Aug 5, 2022