2016 Chevrolet Cruze Problems

Coolant system and engine fan

My engine needed oil I checked the dip stick added the oil the next day my engine started leaking and over heating come to find out there’s a pcv issue the valve cover gasket along with multiple other seals need replaced I was unaware of anything wrong no indication of over heating I just smelled the heat and was able to see after popping the hood the radiator fan is now not working and gas is coming through the valves

The contact owns a 2016 Chevrolet Cruze. The contact stated that upon returning to the parked vehicle, while attempting to unlock the doors with the key fob, the doors failed to open. The contact was able to open the door manually using the key. The contact stated that upon entering the vehicle and closing the front driver's side door, the doors locked and failed to unlock. The contact depressed the brake pedal and pressed the Push to Start button, but the vehicle failed to start or unlock. The message "No Key Fob Detected" was displayed. The contact disassembled the key fob and wiped the battery; however, the failure persisted. The contact called his wife, who arrived with another key fob. The vehicle was able to restart after several attempts. The message "Theft Alarm" was displayed. The contact was trapped inside the vehicle for 5 minutes and was sweating due to the temperature inside the vehicle. The contact drove to the residence; however, the instrument panel was partially inoperable. The contact stated that only the RPMs, the speedometer, and the odometer were operable. Upon returning to the residence, the vehicle restarted and operated as needed after several attempts. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 56,639.

My tire pressure sensor keeps coming on even after I had it worked on. 3 of them shows the pressure level but one shows 2 lines but no pressure level but there’s air in the tire. The other problem I’m having is the check engine light is on. Please advise if any issues are recalls or do I need to take my car to a service center. Thank you

After 3 years of having this car it’s overheating each summer requiring the coolant system, hoses, thermostat, and water pump to be replaced each summer. As well as major oil leaking after full tune ups.

My engine needed oil I checked the dip stick added the oil the next day my engine started leaking and over heating come to find out there’s a pcv issue the valve cover gasket along with multiple other seals need replaced I was unaware of anything wrong no indication of over heating I just smelled the heat and was able to see after popping the hood the radiator fan is now not working and gas is coming through the valves

Component or System Failed/Malfunctioned: The turbocharger has been identified by a GM service center as the component that failed or malfunctioned. It is available for inspection upon request at the service center where the diagnosis was made. Safety Risk: The safety of myself and others was compromised due to the vehicle stalling unexpectedly while driving. This resulted in potential rear-end collisions, as well as the inability to accelerate, posing a risk in traffic situations. Confirmation by Dealer or Independent Service Center: Yes, the issue has been confirmed by a GM service center where the turbocharger was diagnosed as the problem. They provided a repair estimate of $2,170 for the turbocharger replacement. Inspections by Manufacturer, Police, Insurance, etc.: The vehicle has been inspected by a GM service center, but it has not been inspected by police, insurance representatives, or other independent parties beyond the GM service center. Warning Lamps, Messages, Symptoms: Prior to the vehicle stalling, warning messages such as "Service Stabilitrak" appeared on the dashboard. These messages were accompanied by engine shaking, and the car did not respond to acceleration attempts. These symptoms first appeared just before each incident of stalling.

Power train system (po299) A turbocharger harnesses the flow of exhaust gases that spins an internal turbine. This turbine then forces or packs air into the engine faster than normal .This action increases the horsepower of the engine. When it doesn’t work!!!!A failed turbo charger will cause a decrease in engine performance which isn’t for family . (Manufacturer recall number:A212338300 recall date 11/05/21

I HAVE A 2016 CHEVROLET CRUZE AND THE TURBOCHARGER INTERCOOLER HOSE BASICALLY BROKE FROM WHERE THE END OF THE HOSE STARTS AND A LITTLE BIT DOWN IN THE MIDDLE AREA OF THE END PART OF THE HOSE. AND THIS CAUSED MY ENGINE'S POWER TO BE REDUCED INMENSLY. TO THE POINT THAT I HAD MY FOOT PRESSING ALL THE WAY DOWN ON THE ACCELERATOR AND IT COULD NOT GO ANY FURTHER DOWN, AND MY CAR WAS MOVING SLOWER THAN A TURTLE, AND THIS IS NOT AN EXAGGERATION! AND ALSO, AT TIMES WHEN I HAVE BEEN AT A RED LIGHT MY CAR TURNS OFF. ONE TIME MY CAR TURNED OFF WHILE I WAS DRIVING ON THE STREET WITH CARS BEHIND ME. LUCKILY, I WAS ABLE TO PULL INTO A SHOPPING CENTER. AND THE AIR CONDITIONER IS ALSO FAILING BECAUSE I KEEP PUTTING FREE ON SO IT CAN BE COLDER AND ALL THAT COMES OUT IS HOT AIR. I DID NOT KNOW THAT THIS INTERCOOLER HOSE WAS A MAJOR PART OF MY VEHICLE'S FUNCTION. ALSO, THE TRACTION LIGHT CAME ON, WHEN I ALREADY HAD IT OFF. IF CHEVROLET CRUZE OWNERS DO NOT KNOW ABOUT THIS ISSUE, THEY NEED TO KNOW. BECAUSE THIS ISSUE COULD EVENTUALLY MESS UP THE ENTIRE MOTOR AND POSSIBLE BLOW IT OUT. WHICH WE ALL KNOW A NEW MOTOR IS VERY EXPENSIVE

When I start my car it will sputter then die, also cuts off while driving. It cuts off but will crank up and die again after so many tries it will drive a while and do it again. The check engine was on and I have fixed the O2 sensor, the mass air flow sensor, Ive replaced the turbo hose it had a big chunk ripped out of it which we have no clue how that happened, I just changed the PCV valves a few weeks ago and the car started but would not go in drive nor reverse put it back in shop and cleaned the throttle body and it ran good the whole day today I started cutting off again.

Hit a buck on highway. When airbags went off I felt sudden sharp pain in my left arm. I was later advised that it most likely was shrapnel from the airbag. It was obvious from the injury something hit my arm with a lot of force. The car was a total loss and in possession of insurance company. Concerned that it could have been my eye.

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving 25 MPH, the front air bag warning light illuminated, and the message "Service Air Bags" was displayed. The vehicle was taken to the dealer that stated that the front passenger side air bags needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 137,000.

The rear brakes lights have a crack causing water to leak through. The water caused damage to the converter output

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving 25 MPH and depressing the brake pedal, the check engine warning light illuminated, and the message "Service Brake System" was displayed simultaneously. The vehicle failed to respond. The contact stated that he applied more pressure to the brake pedal and the vehicle responded. The contact was able to continue driving; however, the failure recurred while driving to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that the vacuum pump had seized, which fractured the camshaft. The mechanic diagnosed that the vacuum pump and the camshaft needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 108,000. The contact wanted to include the number of the brake pump part of their vehicle - 12662789. The contact also stated that other SUV models of various model years have the same defective part.

While driving, I went to make a right turn and the power steering went out making the turn very difficult using manual muscle to complete the turn. Fortunately, it was in a parking lot. After the ignition was turned off for about 45 minutes, I turned it back on and the steering functioned normally. However, I am very concerned if this problem would again happen and I am driving at a speed and this problem would appear, it could possibly cause a serious accident because of the unexpected action that would be required.

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving on several occasions at various speeds, the steering wheel pulled to the left forcibly. The contact also stated that the vehicle was oversteered, and the wheel made the vehicle move in a straight line. The vehicle was taken to an independent mechanic where it was diagnosed that the inner tie rod had separated from the steering gear and both inner tie rods and tires needed to be replaced. The contact associated the failure with NHTSA Campaign Number: 15V442000 (Steering). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 61,000.

Water leak in trunk. Took car in 3 time to have it fixed after them doing the recall( 84279073 f-lamp kit). Every time it went in they found a leak in a different spot. 15Feb17 they found water leaking from right side of the spoiler retainer holes. Dealer removed spoiler applied double back tape and sealer. Reinstalled spoiler 02Mar17 found pin hole leak in weather strip. Dealer replaced weather strip. 01jan24 start having electrical issues. Hard starting/ running weird and finally dead battery. Had les swabs install battery and remove water in trunk. Car starts but shuts off when driving. 05mar24 Dealer finds leak coming from right side spoiler and now 1 licence plat bolt. Charged me 600.00 . to reseal. Here we go again They could never stop/find the leak before and will not warranty previous work. Isn't this a fire/safty issue? That started the recall in the 1st place. And why wasn't drain plugs required for this yr.car. I believe it was in the newer one. I would like to know how many people had to take their car in multiple times to never have the problem truly fixed. Is this a tactic used to make consumers go away and say they fixed the recall, but never really did.

MY DRIVER'S SIDE WINDOW FELL INTO THE DOOR UNEXPECTEDLY. NO DAMAGE, NO ACCIDENT. JUST SEEMED TO FALL INTO DOOR WITH NO PRECURSOR.

I BOUGHT A 2016 CHEVROLET CRUZ NG ON SEPTEMBER 7, 2016. ON SEPTEMBER 10, 2019, I TOOK MY VEHICLE TO THE CHEVROLET AGENCY TO CHECK THE WATER FILTERING OF THE 3 LIGHT STOP OF THE CAR, IT LEAKED WATER AGAIN AFTER THE REPAIR OF THE RECALL N162064340 . ON THIS VISIT I WAS NOTIFIED THAT THE CAR HAD A RECALL OF THE STEERING SYSTEM (RECALL N182201620) WHICH PRESENTS A FAILURE IN THE PACKAGING OF THE STEERING BOX CAUSING MOISTURE TO ENTER THE PART AND DEACTIVATE THE POWER STEERING. AFTER CHECKING THE CAR THE AGENCY INDICATED THAT THERE WAS NO PROBLEM WITH THE STEERING SYSTEM AND THE AGENCY CLOSED THE RECALL N182201620. ON NOVEMBER 5, 2019, WHEN I STARTED MY VEHICLE AND PUT IT IN DRIVE, THE STEERING SYSTEM WAS DEACTIVATED, PREVENTING ME FROM TURNING, I IMMEDIATELY STOPPED THE VEHICLE, AND THE BOARD THREW A MESSAGE 'THE POWER STEERING HAS BEEN DEACTIVATED, DRIVE WITH CAUTION', THE STEERING WHEEL IS COMPLETELY HARD AND IT IS NOT POSSIBLE TO MANIPULATE IT. I CONTACTED THE AGENCY AND THE CAR WAS TOWED TO THE CHEVROLET WORKSHOP AT MY COST, THE AGENCY ANALYZED THE FAULT AND RESPONDED THAT IT WAS NOT RELATED TO RECALL N182201620 (SAME FAULT THAT IS NO LONGER SHOWN ON THE GM PAGE) AND THAT THE THE CAR HAD NO GUARANTEE, THE AGENCY NOTIFIED ME THAT I SHOULD PAY FOR THE CHANGE OF THE PART. TALK TO GM 01800 AND I REPORT THE SITUATION, THEY CONTACTED ME AFTER 72 HOURS WITHOUT AN ANSWER, AFTER 6 DAYS GM'S RESPONSE WAS THAT THE VEHICLE HAD NO WARRANTY AND THAT THEY WOULD NOT REPAIR IT, THE ADVISOR INDICATED THAT THE RECALL OF THE STEERING SYSTEM WAS THE RESPONSIBILITY OF THE AGENCY AND THAT GM WAS NOT RESPONSIBLE, THEY REFUSED TO GIVE ME A TECHNICAL RESPONSE OF THE FAILURE OF THE PIECE AND THEY VIOLATION OF IATF RULE 16949: 2016 CLAUSE 10.2.6, THEY REFUSED TO PERFORM AN ANALYSIS OF THE PIECE FAILED AND REFUSED TO CHANGE OR REPAIR THE FAULT OF THE STEERING SYSTEM FOR FREE.

THE DRIVER INFORMATION CENTER, SPEEDOMETER, TACHOMETER, FUEL GAUGE, TEMP GAUGE, AND TOUCHSCREEN DISPLAY QUIT WORKING THIS MORNING ON OUR '16 CRUZE. CAR STARTS AND RUNS FINE BUT KNOW WAY OF KNOWING OUR SPEED OR WHAT GEAR IT'S IN. PERSISTS THROUGH BATTERY DISCONNECT.

Purchased a 2016 Chevrolet Cruze on [XXX]. [XXX]. As of July 26th I paid $862 on repairs for the car to be smoking this morning on my way to work [XXX]. In total I’ve spent Almost or close to $2,000 in car repairs. This purchase was for my 17 year old daughter as a graduation present and for college. She was driving and car started to run hot and cut off in a busy intersection. She was unable to take the car to North Carolina. The owner blocked me and the staff haven’t been accommodating since this process. Nor will they look at the car. This has put me in a financial burden and the safety conditions this vehicle is under. And damage this could have cause my daughter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I HAVE A 2016 CHEVROLET CRUZE AND THE TURBOCHARGER INTERCOOLER HOSE BASICALLY BROKE FROM WHERE THE END OF THE HOSE STARTS AND A LITTLE BIT DOWN IN THE MIDDLE AREA OF THE END PART OF THE HOSE. AND THIS CAUSED MY ENGINE'S POWER TO BE REDUCED INMENSLY. TO THE POINT THAT I HAD MY FOOT PRESSING ALL THE WAY DOWN ON THE ACCELERATOR AND IT COULD NOT GO ANY FURTHER DOWN, AND MY CAR WAS MOVING SLOWER THAN A TURTLE, AND THIS IS NOT AN EXAGGERATION! AND ALSO, AT TIMES WHEN I HAVE BEEN AT A RED LIGHT MY CAR TURNS OFF. ONE TIME MY CAR TURNED OFF WHILE I WAS DRIVING ON THE STREET WITH CARS BEHIND ME. LUCKILY, I WAS ABLE TO PULL INTO A SHOPPING CENTER. AND THE AIR CONDITIONER IS ALSO FAILING BECAUSE I KEEP PUTTING FREE ON SO IT CAN BE COLDER AND ALL THAT COMES OUT IS HOT AIR. I DID NOT KNOW THAT THIS INTERCOOLER HOSE WAS A MAJOR PART OF MY VEHICLE'S FUNCTION. ALSO, THE TRACTION LIGHT CAME ON, WHEN I ALREADY HAD IT OFF. IF CHEVROLET CRUZE OWNERS DO NOT KNOW ABOUT THIS ISSUE, THEY NEED TO KNOW. BECAUSE THIS ISSUE COULD EVENTUALLY MESS UP THE ENTIRE MOTOR AND POSSIBLE BLOW IT OUT. WHICH WE ALL KNOW A NEW MOTOR IS VERY EXPENSIVE

I was driving down the road when my son said he smelled something and made pull over. There were what I thought were small flames on the floor so i dumped my water on them, then i realized the seat itself was melting and dripping stuff on the floor. then the seat went up. Very shortly after that the car was completely engulfed and is now a total loss.

PASSINGER FRONT SEAT IS JAMMED AND CAN NOT BE MOVED FORWARD OR BACKWARD

Both side airbags deployed without crash or damage to the vehicle. Passenger and driver seatbelts locked. Front airbags did not deploy.

IN SEPTEMBER, MY DAUGHTERS 4 SIDE AIRBAGS BLEW OUT WHILE DRIVING. SHE WASN'T IN ANY COLLISION OR ACCIDENT, THEY JUST BLEW OUT AND THE PIECE THAT BLEW OUT ON HER SIDE, HIT HER IN THE HEAD TOO.IN MAY, LESS THAN A WEEK AFTER WE GOT THE CAR, SHE WAS GOING UP AROUND A CURVE, SOMEONE CAME AROUND THAT CURVE ON HER SIDE, HITTING HER DRIVER SIDE MIRROR, CRACKING,AND BREAKING THE GLASS. SHE WAS RAN OFF THE ROAD BY THE OTHER DRIVER, AND SHE DID GO OVER ROCKS, SCRATCHING THE BOTTOM OF THE CAR, WE PUT IT ON A LIFT AND THERE WASN'T ANY DAMAGE, JUST SCRATCHED. AFTER HER AIRBAGS DEPLOYED, I WAS TOLD TO CONTACT GENERAL MOTORS RIGHT AWAY, SO I DID. I TOLD THEM WHAT HAPPENED, AND MADE SURE I TOLD THEM WHAT HAPPENED IN MAY,THE LADY THAT TOOK THE CLAIM, SAID THAT'S FINE, SHE WILL MAKE SURE ALL THAT WAS NOTATED! NOW, FROM THE TIME I CALLED GM, IT TOOK THEM A WEEK TO CONTACT ME, WHICH IS UNACCEPTABLE. I EVEN CALLED BACK IN A COUPLE DAYS DEMANDING SOMEONE CONTACT ME RIGHT AWAY. I WAS TOLD IT WAS A MECHANICAL ISSUE, AND IT NEEDS TO BE DEALT WITH. I WAS TOLD BY A GM DEALERSHIP, THAT IT IS VERY OBVIOUS IT WAS MECHANICAL, FAULTY AIRBAGS. IT TOOK ALMOST 3 WEEKS FROM THE TIME I CALLED GM FOR THEM TO GET IT TO A DEALERSHIP AND GET THEIR INVESTIGATOR OUT TO LOOK AT IT. SHE CAN'T DRIVE THE CAR, THE SEATBELTS DON'T WORK AND AIRBAGS DEPLOYED,SO I REFUSE TO LET HER DRIVE IT. SO FROM THE TIME THE INVESTIGATOR CAME OUT AND LOOKED AT IT, RECORDED HIS FINDINGS, IT WAS ANOTHER 2 WEEKS.MY DAUGHTER CALLED THE LADY AT GM AND THE INVESTIGATOR THAT CONTACTED HER TO GET INFO. I SENT AN EMAIL ASKING WHY IT'S TAKING SO LONG TOO. FINALLY, GM CALLED ME, SAYING THE DECISIONS ARE FINAL AND THEY 'FOUND NO MERIT THAT IT WAS A MECHANICAL ISSUE',AND THEY WON'T BE DOING ANYTHING TO HELP. SHE ALSO TOLD ME NOTHING LIKE THAT HAS EVER HAPPENED BEFORE. I WANT THEM TO TAKE RESPONSIBILITY! THEY ARE USING WHAT HAPPENED IN MAY!

The contact owns a 2016 Chevrolet Cruze. The contact stated that on several occasions, a strange noise could be heard while the brake pedal was depressed. The contact stated while accelerating above 35 MPH, the Service Stabil Trak and powertrain control module (PCM) warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the powertrain control module (PCM) failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.

Issue has been reported by other owners, code PIP5558C Around 60k miles, clutch pedal started sticking to the floor and not returning unless manually lifted. By 118k miles issue had worsened to the point that car was no longer driveable. Clutch master cylinder was damaged/degraded, as well as clutch slave. Brake system lifespan was likely shortened, and I luckily didn't have a complete brake failure as has happened with others.

The driver's windshield wiper is not working properly. It seems that the wiper has become loose. I live in Florida and it rain a majority of the time, so this is a issue when it comes to driving everywhere.

The contact owns a 2016 Chevrolet Cruze. The contact stated that after depressing the button to raise the front driver’s side window, a mechanical motor noise was present, and the window would not move and remained stuck in the halfway opened position. The vehicle was taken to an independent mechanic who diagnosed that the front passenger’s side window regulator was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 83,000.

THERE IS A DISTINCT "CLUNKING" NOISE COMING FROM THE REAR OF THE VEHICLE WHEN TRAVELING OVER A BUMP, THROUGH A DIP OR ON AN UNEVEN ROAD SURFACE. THE CHEVROLET DEALER HAS CONFIRMED THAT THE PROBLEM IS IN THE REAR SUSPENSION, BUT THAT CHEVROLET DOES NOT HAVE A REPAIR FOR THE PROBLEM. I HAVE DRIVEN FOUR OTHER 2016 CHEVROLET CRUSE VEHICLES WITH SIMILAR MILES AND THEY ALSO HAVE THE PROBLEM. THE CHEVROLET DEALER STATES THAT THEY ALSO HAVE ENCOUNTERED THE PROBLEM IN NUMEROUS 2016 CHEVROLET CRUZE VEHICLES. I AM BEING TOLD TO OPERATE THE VEHICLE WITH THIS KNOWN CONDITION AS CHEVROLET MAY OR MAY NOT DEVELOP A REPAIR FOR THE REAR SUSPENSION PROBLEM.

The contact owns a 2016 Chevrolet Cruze equipped with Continental Tires, Tire Line: Conti Pro Contact, Tire Size: 195/65/R15, DOT Number: P5AEWBNU1018. The contact stated while driving 45 MPH, there was an abnormally loud sound coming from the front and rear passenger’s side tires. Upon visual inspection, that contact found no issues with the tires. The contact stated that the tires were original tires. The cause of the failure was not yet determined. The manufacturer was not notified of the failure. The failure mileage was 89,000.