2018 Chevrolet Equinox Fuel system Problems

The car cut off on the street with no warning. Once I crank the car back up and pulled over, it was leaking fuel and coolant with no warning lights on the dash boatd

NHTSA ID

11741675

Incident

May 23, 2026

The fuel management system leaked from car causing fuel to pour out of 2018 chevy equinox d2

NHTSA ID

11739653

Incident

May 22, 2026

The contact owns a 2018 Chevrolet Equinox. The contact stated that the engine Auto START/STOP system intermittently failed to restart the vehicle while at a complete stop, requiring the driver to shift to park(P) to manually restart the vehicle. The contact stated that while driving at various speeds, there was an abnormally strong fuel odor entering the vehicle from the A/C vents. The message "Reduced Engine Power" was displayed, and the vehicle went into LIMP Mode and failed to exceed 10-15 MPH. The vehicle was taken to an independent mechanic, where it was diagnosed, and the failure was associated with GM Customer Satisfaction Program: N242489010 (Possible Leak at Fuel Injector Rail Assembly). The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the program. The vehicle was not repaired. The failure mileage was approximately 120,000.

NHTSA ID

11733511

Incident

Mar 24, 2026

Mileage

120,000 mi

The contact owns a 2018 Chevrolet Equinox. The contact stated that while attempting to stop the vehicle, the brake pedal was firm while depressed, and the vehicle stalled, shut off, and failed to restart. The vehicle was later towed back to the residence. While inspecting under the hood, the contact discovered that the fuel pump had failed. The cause of the failure was not determined. The manufacturer was notified of the failure and informed that the VIN was not included in NHTSA Campaign Number: 18V358000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer had not yet contacted. The failure mileage was 85,900.

NHTSA ID

11724548

Incident

Mar 6, 2026

Mileage

85,900 mi

The contact's mother owns a 2018 Chevrolet Equinox. The contact stated that while his sister was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the high-pressure fuel pump and other fuel system parts needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 18V358000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 75,000.

NHTSA ID

11722282

Incident

Feb 16, 2026

Mileage

75,000 mi

Automatic transmission slips and shutters/shakes when accelerating and going from a complete stop. Vehicle is not drivable long distances as the issue gets worse as the car heats up. No codes or sensors are indicating a problem. This is an ongoing problem despite having the transmission rebuilt. Issues first started a year ago and have been progressively getting worse.

NHTSA ID

11721679

Incident

Dec 1, 2025

Got word from the mechanic at the dealership that the cam shaft is leaking oil as well as the fuel injectors retainers are out and need to be sealed as they are also leaking. the engine went into safe mode to prevent any engine fires.

NHTSA ID

11717648

Incident

Feb 2, 2026

The contact owns a 2018 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle sputtered, and there was a strong fuel odor inside the vehicle. The contact stated that while depressing the accelerator pedal to move off from a stop light, the engine shut off. The traction control and check engine warning lights were illuminated. The failure had occurred while the contact was driving her minor child to school. The vehicle was driven to the residence. The vehicle was then towed to the dealer; however, the diagnostic result was not provided to the contact. The contact referenced an unknown recall with a similar failure; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 148,000.

NHTSA ID

11717348

Incident

Feb 9, 2026

Mileage

148,000 mi

For the 4th time since November 2025, my vehicle has shut off while driving and there was a severe gas smell. Check engine and traction control lights on dash. So far the turbo booster and fuel injector have been replaced but the issue keeps happening. This vehicle is not on recall list for high pressure fule pump recall. I think it should be. Vehicle goes into limp mode and all the gas leaks right out of the vehicle making it unsafe to drive due to a fire hazard. I have spent over $4000 trying to make this vehicle safe to drive.

NHTSA ID

11716731

Incident

Nov 14, 2025

My car has a slow crank and when I am driving down the road it cuts off completely and does not want to crank. I have a signal on my car that says reduced speed and the speed is cut down and drags . My car also smells like gas and there is a leak coming from the vehicle it drains really bad . my brakes goes out every few months . My Car radio goes out like there is a shortage. Its horrible

NHTSA ID

11713676

Incident

Jan 1, 2026

The contact owns a 2018 Chevrolet Equinox. The contact stated that there was an abnormal odor of fuel coming from the vehicle. The contact stated that the brake pads were wearing abnormally quickly. The message speed reduced was displayed. The engine warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 150,000.

NHTSA ID

11713323

Incident

Jan 24, 2026

Mileage

150,000 mi

My wife and I were driving to Galveston on I-45 and were driving through La Marque when our car suddenly lost power. I started moving over to the outside lane and went to turn on the emergency lights. I realized the lights were already on. We heard a thump and thought that the serpentine belt had broken and that the engine would overheat, followed up by white smoke coming from the dash vents. My wife opened her window and leaned out the window while I tried to control the SUV without power. A truck pulled next to us and the passenger screamed that our car was on fire. I stepped on the brakes, but my foot went to the floor without effect. I hit the button for the emergency parking brake, but it didn't stop the car. I let the car slow down and then black smoke was coming from the vents. We were choking from breathing the smoke and I tried to open my window, but all electrical systems had quit working. The car finally slowed enough for me to shove the gear shift into park. My wife jumped out of the car and fell to the pavement, also hitting the concrete barrier on the side of the highway. My seat belt was stuck and I kept pushing the button and reached for my pocket knife to cut the belt when it released. At this point, flames were coming from the vents when I reached for the door handle and open the door. I fell out of the car onto the highway, rolling away. I was finally able to get up and saw several vehicles stopped behind us, but some were still driving through. I got away from the car and found my wife who was being helped by another man who stopped ahead of us. The car was on fire, mostly from the back, heavily in the left rear where the gas tank is. The car was completely burned and an unknown retired firefighter said all of the signs point to a defective fuel pump.

NHTSA ID

11708995

Incident

Dec 26, 2025

The contact owns a 2018 Chevrolet Equinox. The contact stated that there was an abnormally strong fuel odor coming from the vents while driving 45 MPH. The check engine warning light was illuminated. The vehicle was taken to Advance Auto, where the contact was informed that there was a fuel leak, which could cause fire. The contact was advised to park the vehicle. The vehicle was taken to the dealer, where it was diagnosed that all four fuel injectors were leaking and required immediate attention. The contact was advised that the parts needed to be ordered to do the repair. The vehicle was not repaired due to the cost. The contact related the failure to NHTSA Campaign Number: 18V358000(Fuel System, Gasoline); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance in adding the VIN to the recall. The failure mileage was unknown.

NHTSA ID

11707454

Incident

Dec 9, 2025

Vehicle chocks when starting, once started the vehicle begins to smell of gas. There is a leak on the underside of the vehicle which also smells of gas.

NHTSA ID

11703044

Incident

Dec 3, 2025

The vehicle calls power module has failed

NHTSA ID

11683197

Incident

Aug 26, 2025

My fuel pump just gave out randomly while driving on the highway. Unable to drive over 14mph. I head other 2018 Equinox’s experienced this problem often. I believe my vehicle should be included as well. In the past I’ve also gotten a random alert that my forward collision was disabled while driving on the highway with no warning. It always goes away on its own.

NHTSA ID

11664252

Incident

Jun 1, 2025

The contact owns a 2018 Chevrolet Equinox. The contact stated that while the vehicle was parked, the vehicle failed to immediately start. The vehicle was started after several attempts. The contact stated that while stopped at a red light the vehicle began shaking and lost motive power. Additionally, the contact stated that when the vehicle was shifted into park(P), the vehicle stalled three times, and the vehicle was restarted after several attempts. The contact stated that on another occasion, while driving at an undisclosed speed, there was a gasoline odor inside the cabin of the vehicle. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that all four fuel injectors were damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 134,000.

NHTSA ID

11659245

Incident

May 5, 2025

Mileage

134,000 mi

This rare equinox has a Turbocharge issue that causes rapid engine power loss, and melting under the manifold and around the fuel injector pipes. The recent recalls do not include this GM made diesel equinox due to its rarity, and small consumer ownership of 506,775 units sold in its lifetime. However, GM has been just as negligent with this diesel 1.6L, as with the other major model lineup. Diesel particulate sensor goes bad every year around installation anniversary (previous recall). Stated every year in purchase anniversary month 10/2021, 10/2022

NHTSA ID

11654962

Incident

Feb 14, 2025

The car had a full tank of gas prior to driving. While driving the car suddenly goes to empty and stalls out. Now the car won’t start and the battery works fine.

NHTSA ID

11638504

Incident

Jan 25, 2025

Fuel injection systems is leaking onto the engine

NHTSA ID

11628772

Incident

Dec 4, 2024

Purchased the car on 10/20/2023. Since that time it had 7 check engine lights with the P2459 code for Diesel Particulate Filter Regeneration Frequency. The car has powered down 3 times and been repaired several times, for things NOT that code. The vehicle is currently powered down at the dealership where purchased, as I attempt to mediate repairs and costs. I have spent $9398.73 in repairs, Uber’s, rentals, car payments, and warranty payments. And, I am still without a working vehicle.

NHTSA ID

11615767

Incident

Oct 27, 2023

At 12pm on June 11, 2023 I was parked in a church sparking lot in East Rochester and was facing the church's stone wall. My vehicle was only 2 feet from the was when the car accelerated toward the wall and all of the airbags opened and the hood and side panels were affected causing the vehicle was considered totaled by my insurance. My foot was on the brake and I was preparing to put the car in park when the car lurched forward and hit the wall at a high rate of speed. GM examined the car and gave me a report I could not understand but their report indicated that there was not a vehicle defect. I find this highly improbable. I can send the report and perhaps your organization can read it or do your own inspection of my vehicle. Thank you very much for your attention to this matter. This same thing has happened to 2 other people I know who drive Equinoxes. Best Regards, [XXX] [XXX] Cell [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11538740

Incident

Jun 11, 2023

GM Brake Vacuum Pump - I understand there was a recall done a few years ago on this part. This is a known issue with GM, and they seem to refuse to address it in ALL their vehicles. My vehicle went out of service on Friday, July 7, 2023, after fueling and would not start. I was 5 days over the 100-day Carvana warranty, but they agreed to repair the sensor that Firestone said I needed to have replaced along with the spark plugs. After repairing these items, it still was doing the same thing of starting up but making a horrible sound and not turning over. They suggested I have it towed to the dealership. The dealership called 7/12/23 and stated that I needed a new vacuum pump and a sleuth of other parts that would cost me around $1900 in repairs. This car has 61,121 miles on it. When I purchased it, it had a little over 57,000 miles on it. From the sounds of it, I was incredibly lucky this happened where and when it did as oppose to being stopped in the middle of the road and the auto start/stop failing me. There were zero warning lights, alerts from the app, etc. I did hear a noise one time about a month ago, but I thought I kicked up something because I was traveling down a dirt road and when I stopped and got out to look I did not see anything hanging. As soon as I got on the main road the noise resolved.

NHTSA ID

11532039

Incident

Jul 7, 2023

The braking system failed as the engine compartment filled with smoke and flames. At first the doors remained locked but eventually unlocked so that the occupants were able to exit the vehicle unharmed. The vehicle was consumed by the fire before the fire department could extinguish the fire(5-10 minutes).

NHTSA ID

11490707

Incident

Oct 23, 2022

Has had 2 codes come up for bad fuel injectors maybe more before it hit 50,000 miles dealer can't recreate cases a bad miss fire really surprised it runs

NHTSA ID

11483420

Incident

Apr 18, 2022