2023 Chevrolet Equinox Owner Complaints

**NHTSA Complaint Summary: 2023 Chevrolet Equinox Warranty & Safety Failure** * **First Stall & Initial Negligence:** After a factory engine replacement, the vehicle suffered a fuel system failure. Castle Rock Chevrolet falsely claimed it was repaired, leading to a catastrophic stall on a high-speed highway with raw gasoline and burning plastic odors. * **Second Stall & False Diagnosis:** Following a tow, the dealership cleared the car, claiming "no errors". Within 24 hours, it stalled again in live traffic. Castle Rock then refused emergency warranty service and hung up on you. * **Critical Safety Hazard:** The vehicle experiences a severe electrical voltage drop (triggering **"Engine Power Is Reduced"** and **"Battery Saver Active"** warnings). This causes a sudden, dangerous **loss of Electric Power Steering (steering locks up)** and **fuel injection failure** while driving in traffic, creating an extreme crash risk. This recurring hazard stems from improperly reassembled or melted wiring harnesses following dealership repairs.

NHTSA ID

11762541

Incident

Aug 21, 2026

The ongoing issues with my 2023 Chevrolet Equinox, VIN [XXX], which I have brought to your dealership multiple times for the same unresolved problem. I was told three separate times that the engine light was fixed. I checked the vehicle today, and the engine light is still on. I was misled three times. Since purchasing this vehicle, I have not been able to drive it. Instead, I have spent the last four weeks repeatedly picking up and dropping off the car at your dealership. The vehicle has spent more time in your service department than with me. This has caused significant loss of time, money, and peace of mind. You have wasted my time, energy, and resources, and your team has already put 95 miles on my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11758877

Incident

Jul 30, 2026

The vehicle is experiencing repeated, sudden engine stalling while driving at speed, creating an immediate risk of a severe traffic collision. In March 2025, the fuel pump failed and was replaced by an independent mechanic, who later had to clear a system clog in August 2025 after a second stall. In August 2026, the dealership replaced the fuel pump under an official NHTSA safety recall. Within days of receiving the vehicle back, the new recall remedy failed, causing the vehicle to stall in traffic again and nearly cause a major accident. The vehicle has suffered four separate fuel-system-related failures/stalls under 87,000 miles. The manufacturer's official recall remedy has failed to resolve the safety hazard, and the vehicle remains entirely unsafe to drive.

NHTSA ID

11758547

Incident

Aug 18, 2026

From the very first day of purchase, the vehicle displayed a check‑engine light, which I immediately pointed out to your salesperson. My concerns were dismissed, and I was assured that it was “not a big deal,” despite the fact that the issue was clearly present at the time of sale. Since then, I have spent substantial time and money attempting to resolve the vehicle’s defects. A mechanic spent six hours diagnosing and attempting repairs, yet the vehicle continues to display serious fault codes, including: EVAP System Switching Valve “B” Performance / Stuck Open DC/DC Converter Voltage Sensor “A” Range/Performance

NHTSA ID

11757291

Incident

Jul 30, 2026

I own a 2023 Chevrolet Equinox that is experiencing unexpected loss of power while driving, hard starting, warning lights, and fuel-system-related diagnostic trouble codes. There is an open GM recall/customer satisfaction program related to the fuel system. I contacted General Motors and was given Customer Assistance Case #1069141090. GM advised me that the applicable recall repair needs to be performed. I brought the vehicle to Bomnin Chevrolet West Kendall and explained that the vehicle was losing power unexpectedly while being driven. The dealership acknowledged that it could see the recall but told me that Bomnin reserved the right not to perform the recall repair and directed me to drive the vehicle to another dealership in Miami Lakes. I am concerned about being instructed to continue driving a vehicle that can unexpectedly lose power while in traffic. I am reporting this because I believe the condition presents a potential safety risk and the recall-related issue has not been resolved.

NHTSA ID

11756537

Incident

Aug 7, 2026

Our 2023 Equinox needs the high pressure fuel pump replaced after we broke down on the side of the road. Thankfully, we were able to get to a safe location while we waited for a tow truck since our vehicle would no longer accelerate. There is currently a recall (N242450160) for Equinoxes made between 2023-2024 for the exact issue/part replacement ours needs. However, we were not notified of this recall because our VIN number is not currently included in the recall.

NHTSA ID

11754786

Incident

Aug 2, 2026

Purchased vehicle at 53k miles in March 27 of this year it broke down April 27 a month later took it to Chevy dealership. They said it had recall to reprogram fuel pump later discovered the high pressure fuel pump went out and one fuel injector went bad at the same time. I wasn’t informed on recalls when purchasing vehicle. Bill was $1300+ I had to come out of pocket $520 for the repairs.July 12 the ac compressor went out but i cancelled my warranties cause they didn’t cover all repairs so I had to replace compressor my self.

NHTSA ID

11752653

Incident

Apr 27, 2026

The contact owns a 2023 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed on several occasions, the vehicle lost automotive power with the check engine warning light continuously illuminated. The vehicle was taken to a local Auto Zone and a diagnostic machine retrieved DTC: P0191. The vehicle was then taken to a local dealer where it was diagnosed, and the contact was informed that the high-pressure fuel pump was inoperable and needed to be replaced. The vehicle was repaired. The contact associated the failure with Technical Service Bulletin: N242450160. The manufacturer was notified of the failure. The failure mileage was 34,000.

NHTSA ID

11751557

Incident

Feb 1, 2026

Mileage

34,000 mi

My 2023 Equinox RS losses power during quick acceleration for lane changes or passing. It will also lose power during some turns at normal speed. It will also accelerate and deaccelerate at a low speed making it feel like the gears are slipping. Auto stop on occasion will be a hard take off requiring a firm foot on the brake. At time it will also shift hard into 1st gear. My car has been in the dealership three times for this issue and the last time the tech said there was a recall for the issue and performed some reset and gave me the car back. Other than that they said there is nothing they can do about it. This issue presents a major safety issue especially when it losses power during a lane change or passing someone. I can't anticipate when the power will come back and by that time the traffic has now caught up to me. This problem started probably 6-8 months after I purchased the car new from the dealership.

NHTSA ID

11749947

Incident

Dec 1, 2023

This malfunction occurred twice while driving in town and on interstate. Car went into low power mode due to fuel pump and fuel injectors failing. Stopped running and would not restart.

NHTSA ID

11749757

Incident

Feb 28, 2026

Reduced power displayed and engine light came on. This happened on very early morning commute. Dangerous early morning timeframe before 6 am in very dense rural area to where speed totally reduced and then pulled over to losing engine power. Was basically stranded, no one around. Would not start. Had towed. Without vehicle for 5 days and Chevy dealership service could not recreate the issue. Codes read P0089 and P00C6. I am finding out by researching this is a recall issue in previous vehicles. Why not the 2023? This will likely happen again and my commute round trip is 2.5 hrs every day. I am afraid to drive this vehicle. My safety and others are at risk not if but when it happens again. This vehicle very well maintained and now I can't trust it.

NHTSA ID

11748903

Incident

Jul 1, 2026

See attached document for complaint.

NHTSA ID

11747873

Incident

May 19, 2026

The vehicle experienced multiple instances of sudden engine stall and loss of motive power. These failures occurred without warning, leaving the vehicle immobilized in high-traffic areas, including a turn in a multi-lane roadway. This defect creates an unreasonable risk of a rear-end collision or being stranded in hazardous traffic conditions. Incident Chronology: Initial Failure: In April 2026, the vehicle stalled in an intersection. After a manual reset of the Check Engine Light (CEL), the vehicle stalled again during a turn. Diagnostic codes P228C (Fuel Pressure Regulator 1 Exceeded Control Limits) and P0089 (Fuel Pressure Regulator 1 Performance) were present. First Attempted Repair: The dealership performed a Technical Service Bulletin (TSB)/recall procedure to calibrate the fuel pump and pressure sensors. Recurrence: Immediately upon retrieval, the vehicle stalled again. The vehicle would not restart or maintain idle, necessitating a second tow. Final Repair: The dealership recalibrate the module. Additional Safety Concerns: the vehicle experienced multiple "Reduced Engine Power" events and "Check Engine" flashes while traveling at highway speeds (approx. 70 mph). Manufacturer Response: Despite the "Engine" designation of the diagnostic codes, GM initially claimed the fuel pump was not covered under the powertrain warranty. While partial assistance was provided for repairs, the recurring nature of these stalls suggests a significant reliability issue with the high-pressure fuel system components and engine. After purchasing 4+ Equinox's within the last few years without any issue this is the worst experience I have had thus far.

NHTSA ID

11746684

Incident

Apr 13, 2026

I was driving on freeway and went to pass a semi. The suv hesitated and had terrible turbo lag. It almost caused an accident if it hadn’t been for the truck behind me taking action to avoid a collision.

NHTSA ID

11739944

Incident

May 23, 2026

Fuel pump has been repaired twice since I bought the vehicle brand new and now it’s faulty again it’s going to the dealership for a third time again

NHTSA ID

11739851

Incident

May 24, 2026

The vehicle experienced multiple instances of sudden engine stall and loss of motive power while navigating active downtown intersections and airport terminal lanes in Atlanta, GA. These failures occurred without warning, leaving the vehicle immobilized in high-traffic areas, including a turn in a multi-lane roadway. This defect creates an unreasonable risk of a rear-end collision or being stranded in hazardous traffic conditions. Incident Chronology: Initial Failure: In February 2026, the vehicle stalled in an intersection. After a manual reset of the Check Engine Light (CEL), the vehicle stalled again during a turn. Diagnostic codes P228C (Fuel Pressure Regulator 1 Exceeded Control Limits) and P0089 (Fuel Pressure Regulator 1 Performance) were present. First Attempted Repair: The dealership performed a Technical Service Bulletin (TSB)/recall procedure to calibrate the fuel pump and pressure sensors. Recurrence: Immediately upon retrieval, the vehicle stalled again in a "no parking" zone at a major airport after 45 minutes of operation. The vehicle would not restart or maintain idle, necessitating a second tow. Final Repair: The dealership replaced the fuel pump assembly. Additional Safety Concerns: Approximately 4,000 miles prior to the fuel pump failure, the vehicle experienced multiple "Reduced Engine Power" events and "Service ESC" flashes while traveling at highway speeds (approx. 70 mph) in rainy conditions. The dealership replaced all fuel injectors and spark plugs at that time. Manufacturer Response: Despite the "Engine" designation of the diagnostic codes, GM initially claimed the fuel pump was not covered under the powertrain warranty. While partial assistance was provided for repairs, the recurring nature of these stalls suggests a significant reliability issue with the high-pressure fuel system components and engine.

NHTSA ID

11737976

Incident

Feb 14, 2026

The back window shattered in my driveway after Getting in car to go to work. Happened when shut the door.

NHTSA ID

11736935

Incident

May 8, 2026

It keeps stalling and trying to die out. I seen this has been an issue in previous years and in some cases this year. There has not been a recall issued yet for the 2023.

NHTSA ID

11731574

Incident

Apr 16, 2026

I have confirmed with a reputable repair shop that my alternator is defective and is dangerous to drive. No dealership in my area will entertain that this is a possibility. I have consistently had problems with braking, accelerating and steering. My vehicle throws codes constantly for suspension, communications, safety restraints, air bags, rear differential, ABS and more. This vehicle is a significant danger to myself and others. This has been happening since the day I purchased it. There is also an active safety bulletin regarding my fuel pump that the manufacturer will not address. Again, This vehicle will hurt someone.

NHTSA ID

11728904

Incident

Feb 15, 2024

On January 21, 2026 i was involved in a car accident with a tractor in which the tractor collided with my passenger front side of my car causing me to slide into corn field causing the total destruction of my vehicle. None of my airbags deployed. There were no warning lamps or indicators from the vehicle showing a fault prior to the accident. The vehicle has been inspected by the insurance adjustor. It is unknown if other vehicles have had the same issue to my knowledge.

NHTSA ID

11728894

Incident

Jan 20, 2026

Recall/Loss of Power I am filing a safety complaint regarding a 2023 Chevy Equinox. The vehicle began losing engine power and will not go over 40 mph. This creates a dangerous driving situation because the vehicle cannot maintain highway speed. The vehicle has a fuel system recall, and the issue appears to be related to the fuel system. The vehicle is currently at a Chevrolet dealership and has been there for almost a month. The vehicle is currently inoperable. This is a safety concern because loss of engine power while driving could cause an accident. I am requesting that this issue be investigated as a safety defect. Sincerely, [XXX]   VIN [XXX] Mileage: 63,000 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11727639

Incident

Mar 2, 2026

Check engine light turns off and on every day and it’s popping up high pressure fuel pump I Was told it was a problem with these make year and model vehicles and was considered a recall but was told my vin didn’t pop up as a recall and have to pay out of pocket I had less than 30,000 miles.

NHTSA ID

11727457

Incident

Dec 19, 2025

My Equinox completely stopped functioning in the middle of a major intersection as I was making a left turn during 5pm traffic. I was able to push the car out of the intersection with the help of other drivers (they had to exit their vehicles to assist) and the car restarted - I drove back roads to chevy dealership with the car cutting out unexpectedly twice more while the vehicle was moving and then restarting. No warning light came on. Dealership said my fuel pump "exploded" and pieces were also caught in the fuel injectors and all had to be replaced.

NHTSA ID

11726263

Incident

Nov 20, 2025

I can be driving at speeds up to 40 -60mph. The car will just shut down on high way, putting not only myself but children at risk of a crash. The car will start reduced power engine, and the engine will start to stall and completely shut down. I have taken it to nick chevy in tarentum pa multiple times regarding this issue. They state software issue. But every so many months it does it again. Putting my life and children life in danger for just stopping on major highways.

NHTSA ID

11719731

Incident

Feb 22, 2026

Within the past two months, I have experienced multiple significant mechanical failures that raise serious concerns about the reliability and safety of this vehicle. First, the air conditioning compressor failed at approximately 55,000 miles. This was an unexpected and costly repair for a vehicle that is only two years old and has been properly maintained. Shortly thereafter, the fuel pump failed. I became aware there was a recall related to the fuel system; however, when the dealership ran my VIN, it did not populate under the recall campaign. Despite this, the component still failed. Now, I am experiencing continued stalling and drivability issues, particularly when coming to a stop or when the automatic start/stop system engages at traffic lights. Based on the symptoms, I believe the secondary fuel pump may also be malfunctioning. A vehicle stalling in traffic creates a clear safety hazard. I rely on this vehicle daily, and repeated fuel system failures at this mileage are unacceptable. I am requesting the following: A full diagnostic review of the fuel system under manufacturer oversight Consideration for coverage or reimbursement of recent repairs Investigation into whether my vehicle should have been included in the applicable recall Assurance that this vehicle is safe to operate I have maintained this vehicle appropriately and did not expect major component failures at 55,000 miles. I am extremely concerned about both reliability and safety moving forward. Please advise on next steps and how Chevrolet intends to address this matter.

NHTSA ID

11717726

Incident

Jan 9, 2026