1998 Chevrolet Express 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1998 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags120.0%
- Brakes120.0%
- Electrical120.0%
- Engine120.0%
- Fuel system120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
I OPENED THE PASSENGER SIDE DOOR OF MY VEHICLE AND LEANED INTO THE VAN TO START MY VEHICLE. THE MIDDLE OF MY BACK WAS TOUCHING THE BAR ABOVE THE AIRBAG COMPARTMENT WHEN THE AIRBAG WENT OFF DIRECTLY INTO BY BACK. MY VEHICLE HAD NOT BEEN STARTED YET, NOR HAD IT BEEN IN AN ACCIDENT, IT WAS PARKED IN MY DRIVEWAY ON MY PROPERTY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
HYDRAULIC BRAKE LINES FAILED WHILE IN A PARKING LOT. DRIVING ABOUT 20 MPH, APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. HELD BRAKE PEDAL TO THE FLOOR AND THE VEHICLE EVENTUALLY STOPPED. HAD VEHICLE TOWED TO A LOCAL REPAIR SHOP AND MECHANIC STATED STEEL BRAKE LINE TO LEFT FRONT WHEEL HAD BROKEN DUE TO CORROSION. I HAD ALL STEEL BRAKE LINES REPLACED. SEVERAL OTHER LINES WERE ALSO BADLY CORRODED. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
PMD PUMP MOUNTED DRIVER FAILURE HAS HAPPENED SEVERAL TIMES, MADE BY STANADYNE,
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
PMD PUMP MOUNTED DRIVER FAILURE HAS HAPPENED SEVERAL TIMES, MADE BY STANADYNE,
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
PMD PUMP MOUNTED DRIVER FAILURE HAS HAPPENED SEVERAL TIMES, MADE BY STANADYNE,
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .