2011 Chevrolet Express 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2011 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags133.3%
- Brakes133.3%
- Fuel system133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2011 CHEVROLET EXPRESS 2500. THE CONTACT STATED THAT WHILE AT A RED LIGHT, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CARGO VAN. THE AIR BAGS DID NOT DEPLOY AND A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, NECK AND THORACIC REGION WHICH REQUIRED CONTINUOUS MEDICAL ATTENTION AND SURGERY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DIAGNOSIS WAS UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE WAS 64,000. THE VIN WAS NOT AVAILABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WE BOUGHT A NEW CHEV 2500 WORK VAN. ; EMPLOYEE APPLIED BRAKES AND HAD NO BRAKES OR STEERING . AS A RESULT RAN INTO THE BACK OF ANOTHER VEHICLE. APPROX DAMAGE IS OVER 9000 ; TWO EMPLOYEEES WERE TAKEN TO THE HOSPITAL. THIS VEHICLE ONLY HAD 4800 MILES; HAD TO BE SOMETYPE OF FACTORY PROBLEM. WE CURRENTLY HAVE ANOTHER 2009 CHEV. 2500 WORK VAN; WE LOST THE POWER STEERING AND BRAKES AT APPROX. 25,000 MILES; BUT, THERE WAS NO ACCIDENT. WE HAVE 2 OF THESE VANS AND BOTH OF THEM HAVE HAD A SERIOUS / MAJOR BRAKE PROBLEM. HAS TO BE A FACTORY DEFECT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WE'VE HAD THREE SEPARATE CHEVY EXPRESS CNG VANS EXPERIENCE SIGNIFICANT RELEASES OF COMPRESSED NATURAL GAS ON EIGHT SEPARATE OCCASIONS OVER THE PAST THREE YEARS. THE RELEASES OCCUR WHILE FUELING THE VEHICLES IN VERY COLD WEATHER. GM HAS REPLACED SOME OF THE CNG TANKS, BUT THE RELEASES CONTINUE TO OCCUR. GM BELIEVES THE RELEASES ARE RELATED TO CNG TANK VALVE O-RING FAILURES, BUT THEY HAVE MADE NO FORMAL RESPONSE AT THIS POINT. TWO OF OUR VANS HAVE BEEN IDLE FOR WEEKS AS A RESULT OF THE LEAKING TANKS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .