2012 Chevrolet Express 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2012 Chevrolet Express 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system360.0%
- Exterior lighting120.0%
- Seat belts120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
HAVE A 2012 CHEVROLET CUT AWAY VAN FOR A SCHOOL BUS USE. STARTED LEAKING GASOLINE OUT OF THE PRESSURE SIDE LINE ON THE FURL MODULE. HAD TO HAVE TOWED TO CHEVY DEALER FOR REPAIRS. THEY HAD TO REMOVE FUEL TANK TO MAKE REPAIRS . THEY REPLACED FUEL MODULE IN THE TANK. THE COST OF REPAIRS WAS 1166.41$.
THE VAN IS A 2012 CUT AWAY SCHOOL BUS. ON 1-20-2018 DEVELOPED A GASOLINE LEAK ON THE VENT SIDE OF THE FUEL MODULE ON TOP OF THE FUEL TANK.TOOK TO CHEVY DEALER FOR REPAIRS. THEY REPLACED THE FUEL MODULE INTHE TANK. THEY HAD TO REMOVE THE TANK TO PERFORM REPAIRS. AT A COST OF 1188.39$.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
VEHICLE HAD NO RUNNING LIGHTS. CHECKED BULBS AND FUSES OK .VAN WENT TO CHEVY DEALER WAS CHARGED 100.00 CHECKOUT FEE. THE DEALER FOUND NO GROUND FROM BCM . THEY TOLD ME IT WOULD BE 752 55 TO THIS POINT FOR THEM TO RUN AN AUXILIARY CIRCUIT TO FIX OR IT WOULD COST 1200.00 -1500.00 TO FIND THE PROBLEM AND REPAIR. I WENT WITH THE CHEAPER OPTION. I DO BELIEVE NO RUNNING LIGHTS ON A VEHICLE WOULD QUALIFY AS A SAFETY CONCERN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
DRIVER'S SETABELT LOCKS UP, PREVENTING THE BELT FROM BEING DRAWN OFF THE REEL. THIS PREVENTS THE DRIVER FROM USING THE SEAT BELT. THE ISSUE OCCURS WHILE THE VAN IS PARKED AND STATIONARY, REPEATED ATTEMPTS TO GIVE SLACK ON THE REEL AND EXTEND IT ARE UNSUCCESSFUL. THIS IS THE THIRD CHEVROLET EXPRESS VAN MY COMPANY OWNS THAT HAS EXPERIENCED THIS PROBLEM.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .