RoadVitals

2011 Chevrolet Hhr

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
203
Latest Mar 26, 2026
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Apr 30, 2014
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
16
16 injuries, 0 deaths reported

Overview

Our database contains 203 NHTSA owner-reported complaints for the 2011 Chevrolet Hhr, most frequently naming the fuel system, electrical and airbags categories. 3 safety recalls have been issued covering this model year; and 1,128 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
14E021000

ELECTRICAL SYSTEM:IGNITION:SWITCH

Apr 30, 2014
14,529 units potentially affected
The defect: UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
The risk: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
The remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
UCI-FRAM GroupView on NHTSA.gov
14V171000

ELECTRICAL SYSTEM:IGNITION

Apr 10, 2014
2,191,014 units potentially affected
The defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
The risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
The remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
General Motors LLCManufacturer number 14113,14133View on NHTSA.gov
14V047000

AIR BAGS; ELECTRICAL SYSTEM:IGNITION:SWITCH

Feb 10, 2014
2,190,934 units potentially affected
The defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors LLCManufacturer number 13454/14063/14092View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 203
Fuel system
Filed Mar 26, 2026

Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.

NHTSA ID
11727282
Incident
Jan 10, 2026
Interior & seats
Filed Jun 23, 2025

The contact owns a 2011 Chevrolet HHR. The contact stated that while approaching the locked vehicle, the contact noticed that the rear driver's side door had failed to latch securely and was open. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 42,495.

NHTSA ID
11668600
Incident
Jun 22, 2025
Mileage
42,495 mi
Fuel system
Filed Dec 19, 2024

Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.

NHTSA ID
11631633
Incident
Dec 13, 2024
Fuel system
Filed Aug 24, 2024

Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?

NHTSA ID
11610617
Incident
Aug 22, 2024
AirbagsElectricalSteering
Filed Jan 10, 2024

There is a serious electrical glitch that's in the computer, that causes the car to perform poorly at a slow speed, which cases the steering to become very hard to turn, and maintain lanes while driving. All lights, warnings, and gauges fluctuate back and forth, while the bell inide the car when stared keeps chiming.

NHTSA ID
11564742
Incident
Nov 17, 2023
Fuel system
Filed Oct 23, 2023

Fuel line/gas leaking from faulty tube carrying ignitable flammable fluid...no warning just smell and sighting at stop..went to savoy IL dealer immediately and had replaced @ 1k cost approx. 2+ yrs ago...cel

NHTSA ID
11551279
Incident
Jun 17, 2021
Fuel system
Filed Aug 21, 2023

fuel line leak

NHTSA ID
11539705
Incident
Aug 17, 2023
Fuel system
Filed Aug 17, 2023

Fuel Line is leaking on back left rear. Other models have recall but i have a 2011 with the same exact problem

NHTSA ID
11539144
Incident
Aug 14, 2023

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIT3271Q

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

PIP6104

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

PIP4902V

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

PIP4902U

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

PIT5214G

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.

13598

New Vehicle Monitoring Programs Section in IVH

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Hhr by model year
YearComplaintsRecallsInvestigationsIssue Index
2011Viewing2033050.8
20105154047.5
20095085154.0
20086155155.2
20077265051.7
20061,0066049.9

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.