2016 Chevrolet Malibu Hybrid

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The contact owns a 2016 Chevrolet Malibu. The contact stated that while shifting into park(P), the vehicle failed to recognize that the transmission was in park(P). The contact had to manipulate and maneuver the gear shifter several times before the vehicle recognized that the gear shifter was in park(P). The message to "Shift-to Park" was illuminated. While receiving a routine oil change, the vehicle failed to start. The mechanic charged the battery; however, the vehicle failed to start. The vehicle was inspected, and it was determined that the was experiencing the "Shift to Park" failure. The contact found information of NHTSA Campaign Number: 16V502000 (Electrical System, Power Train); and linked the failure to the recall. The dealer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.

NHTSA ID

11667071

Incident

Jun 16, 2024

Mileage

72,000 mi

Stability track warning randomly appears while driving and spontaneously causes total brake failure and the brakes fail to slow or stop vehicle. It has newer brakes but it’s very dangerous to drive. Currently being sent to Chevrolet dealership

NHTSA ID

11666586

Incident

Jun 10, 2025

Water leaks into the trunk and back seat of the vehicle because the seal around the upper brake light in the rear glass is faulty, causing a mildew/mold odor in the trunk. It is not available for inspection as I had it repaired and sold the vehicle. The problem was confirmed by the glass company to did the repair for much less than the quote the dealership provided. The vehicle was inspected by the dealership. There were no warning lamps, messages or other symptoms prior to the failure.

NHTSA ID

11649216

Incident

Sep 20, 2022

The check engine light came on and we brought it to the shop where they said the code is for the electronic brake system modulator. It is also causing the ABS to malfunction and be hypersensitive. There is a recall for the same make/model/year of vehicle, except the month before her car was manufactured. I believe this is a safety issue that needs to be looked into and that her car should also be a part of this recall. We purchased the car in mid November and the engine light showed up a couple weeks later. I contacted GM who said to contact this site to request further investigation for safety risks.

NHTSA ID

11635349

Incident

Dec 11, 2024

There’s a warning on the display that says ‘shift to park’ while the vehicle is already in park. This is causing the battery to drain/die and needs jumpstart everyday. Battery was tested and does not need to be replaced. I’m surprised this hasn’t been recalled yet. Online search ‘Chevy Malibu shift to park’ shows this is a common problem. Here’s a YouTube link that includes comments to prove this further. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11611028

Incident

Jul 15, 2024

Our 2016 Chevy Malibu Hybrid intermittently began alerting of "Reduced Engine Power" and the accelerator would not allow the vehicle to accelerate. This happened twice, once on a busy highway that caused rapid deceleration of the vehicle. We brought the vehicle to the mechanic and there were a bunch of codes related to the accelerator position sensor. With parts and labor $415 to fix. Upon researching, there are a bunch of reports on car forums related to this. I believe there have been previous reports to the NHTSA. This problem needs to be fixed and a recall issued to have Chevy replace the Accelerator Position Sensor before someone gets hurt or killed. Once I pick up the vehicle, I will upload the invoice and see if I can get specific code numbers.

NHTSA ID

11580422

Incident

Mar 29, 2024

The contact owns a 2016 Chevrolet Malibu. The contact stated that while her husband was driving at an undisclosed speed, the brakes were inoperable. The contact stated that the vehicle eventually stopped as needed. The vehicle was driven to the residence. The vehicle was taken to two independent mechanics; however, the failure could not be duplicated. The vehicle was taken to the dealer where it was diagnosed with a failed brake master cylinder. The contact was informed that the brake master cylinder needed to be replaced. The vehicle was not repaired. The contact was advised that the parts to repair the vehicle were no longer in production. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

NHTSA ID

11571724

Incident

Dec 18, 2023

Mileage

75,000 mi

I was driving my car home from work and all of a sudden my car starting showing in the dash engine power reduced. My car literally couldn't go anywhere. So I pulled over and shut the car off for a minute started it back up and it was running great and then I happen again a few minutes later. So I took it to the dealership were i purchsed it and they replaced the gas pedal they said a sensor was bad and that was causing the problem.So picked up the car a couple days later and it happen again about two weeks later...

NHTSA ID

11458179

Incident

Jan 13, 2022

PI to help diagnose A/C concern

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.