2007 Chevrolet Malibu Fuel system Problems

MY GAS GAUGE HASN'T BEEN WORKING FOR A FEW YEARS AND I WAS WONDERING IF THERE WAS A RECALL ON THAT, IT SEEMS THAT A LOT OF CHEVY MALIBUS HAS HAD THIS PROBLEM

NHTSA ID

11578495

Incident

Apr 10, 2019

my car has stalled multiple times while in use, on the highway. VERY SCARRY!

NHTSA ID

11508049

Incident

Sep 30, 2021

I can hear the U joint clicking like it wants to fail and suddenly randomly there is a loss of powersteering. This issue caused my father who is on oxygen to go to the hospital.

NHTSA ID

11490174

Incident

Oct 12, 2022

While driving along the highway the steering wheel began to turn slightly by itself and powering steering displayed on dash and wheel was hard to steer. Fuel pump floater goes out

NHTSA ID

11452155

Incident

Feb 1, 2022

THE FUEL GAUGE IS NOT WORKING PROPERLY. OK IN FILLED THE TANK UP TODAY AND PUT IN A LOCUS FUEL CLEANER (01/22/2021) ONLY BECAUSE IT WAS LIKE MY CAR WAS GASPING FOR GAS. MY FUEL GAUGE KEEPS MOVING UP IN DOWN. EVEN THOUGH I HAD JUST FILLED THE TANK UP IT WOULD CHIME DROP TO EMPTY ACCULERATE LIKE IT WAS HAVING A HARD TIME BREATHING SPIKE BACK UP TO THE FUEL LEVEL START DRIVING FINE THEN ALL OF A SUDDEN DROP DOWN TO E. NOW THE CAR IS HAVING A HARD TIME START LIK IT IS NOT GETTING ANY GAS AT ALL. I HAVE READ SEVERL COMPLAINTS ABOUT THIS ISSUSE

NHTSA ID

11389508

Incident

Oct 16, 2020

Mileage

100 mi

TAKATA RECALL AIRBAG SENSO ALWAYS ON; AUTO DRIVER SIDE WINDOW, SIDEVIEW MIRRORS; SEATBELT SENSOR & SOUND ALERTS WHEN SHOULDN'T; AC COOLING SYSTEM DOESN'T GET COOL; FUEL GAUGE DOESN'T WORK & ALWAYS ON LOW-FUEL INDICATOR EVEN WHEN WE'VE FILLED UP; DOME LIGHT DIM; POWER LOCKS DON'T WORK PROPERLY - ONLY DRIVER SIDE WORKS SOMETIMES

NHTSA ID

11242970

Incident

Sep 30, 2015

MY 2007 CHEVY MALIBU IS HAVING PROBLEMS WITH THE FUEL GAUGE. THE FUEL GAUGE SHOWS EMPTY WHEN I HAVE A FULL TANK OF GAS THEN IT GOES UP TO FULL. WHEN I DRIVE FOR A WHILE THE GAUGE GOES DOWN TO EMPTY. ALSO THE ENGINE CHECK LIGHT STAYS ON. SOMETIMES IT GOES OUT BUT COMES BACK ON. THE FUELS GAUGE IS ERRATIC DO NOT KNOW HOW MUCH FUEL IS IN THA TANK AT ANY GIVEN TIME. MECHANIC SAID IS VERY EXPENSIVE TO FIX.

NHTSA ID

11081117

Incident

Aug 28, 2017

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. AFTER FILLING THE VEHICLE WITH FUEL, THE FUEL GAUGE REFLECTED FULL AND THEN DROPPED TO EMPTY. THE CONTACT STATED THAT THE FAILURE OCCURRED FOR APPROXIMATELY ONE YEAR. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC IN JULY OF 2013 FOR THE SAME FAILURE. THE VEHICLE WAS NOT REPAIRED THIS TIME. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.

NHTSA ID

11054445

Incident

Nov 22, 2017

Mileage

117,000 mi

WHILE DRIVING YOU CAN FEEL STEERING TIGHTENING UP AND A SLIGHT HUM ESPECIALLY MAKING LEFT AND RIGHT TURNS, GAS GAUGE GOES UP AND DOWN FROM FULL TO EMPTY CONSTANTLY, ENGINE LIGHT STAYS ON BECAUSE OF GAS CAP REPLACED 4 TIMES WORKS FOR AWHILE LONGEST WAS ABOUT A MONTH, ALSO STAYS ON BECAUSE OF DUEL GAUGE FLUCTUATING CONSTANTLY.

NHTSA ID

11005558

Incident

Jun 2, 2017

Mileage

78,450 mi

MY GAS GAUGE ALWAYS READS EMPTY EVEN AFTER I FILL UP THE TANK. SO NOW MY CHECK ENGINE LIGHT IS ALWAYS ON BECUASE IT BELIEVES MY GAS LOW. THIS HAPPENS IN MOTION, STATIONARY ON THE STREET AND ON THE HIGHWAY.

NHTSA ID

10968864

Incident

Apr 30, 2015

Mileage

1,000 mi

THIS IS ISSUE HAS BEEN HAPPENING SINCE LATE DECEMBER AND HAS PROGRESSIVELY GOTTEN WORSE! WHILE DRIVING (WHETHER ON HIGHWAY AT 60+ MPH OR IN TOWN DOING UNDER 40MPH), POWER STEERING WILL GO OUT MULTIPLE TIMES; ALONG WITH FUEL GAGE WILL CONSISTENTLY SHOW EMPTY. ALSO WHILE DRIVING THE AIRBAG INDICATION LIGHT WILL GO FROM AIRBAG ON TO AIR BAG OFF SEVERAL TIMES. THE ONLY THING THAT REMEDIES THE POWER STEERING GOING OUT IS TO TURN THE CAR OFF AND THEN BACK ON, SOMETIMES MORE THAN ONCE. *TR

NHTSA ID

10947417

Incident

Jan 24, 2017

Mileage

226,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FUEL GAUGES ON THE INSTRUMENT PANEL BECAME INOPERABLE. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

NHTSA ID

10817211

Incident

Dec 31, 2014

Mileage

80,000 mi

THE FUEL PUMP SENSOR HAS GONE BAD TWICE IN 4 YEARS. I HAVE HAD TO REPLACE IT BOTH TIMES. WHEN IT GOES OUT, THE LOW FUEL LIGHT COMES ON WHENEVER THE TANK IS FULL AND THE CHECK ENGINE LIGHT STAYS ON UNTIL THE TANK IS EMPTY.

NHTSA ID

10778867

Incident

Aug 1, 2014

Mileage

80,000 mi

WHEN FILLING FUEL TANK TO FULL, FUEL GAUGE WILL SUDDENLY SHOW EMPTY, THEN OVER NEXT 50 MILES OR SO, THE FUEL GAUGE LEVEL WILL SWING WILDLY BETWEEN EMPTY AND FULL. THIS RESULTS IN THE CHECK ENGINE LIGHT COMING ON. AFTER ABOUT 50 MILES, THE CORRECT FUEL LEVEL WILL REGISTER AND THEN 50 MILES AFTER THAT, THE CHECK ENGINE LIGHT TURNS OFF.

NHTSA ID

10778106

Incident

Nov 25, 2014

Mileage

100,000 mi

MY FUEL GAUGE GOES UP AND DOWN AT RANDOM TIMES. THE GAUGE GOES DOWN WHEN IDLING OR AT A STOP. THIS IN TURN CAUSES MY CHECK ENGINE LIGHT TO TURN ON. WHILE THE GAS GAUGE WILL GO BACK TO ITS NORMAL POSITION AFTER A LITTLE BIT OF DRIVING. THE CHECK ENGINE LIGHT REMAINS ON. THERE ARE NO ISSUES WITH THE GAS CAP, BUT AFTER A LITTLE RESEARCH I HAVE FOUND IT TO BE A FAULTY LEVEL SENSOR. AS IT'S A REOCCURRING PROBLEM WITH MANY CHEVY MALIBU'S, I DON'T KNOW HOW THERE HASN'T BEEN A RECALL YET. GOOD THING I DON'T HAVE TO GET MY CAR TESTED UNTIL 2017 OR I WOULD NOT PASS EMISSIONS DUE TO THE CHECK ENGINE LIGHT BEING ON.

NHTSA ID

10767297

Incident

Sep 14, 2015

Mileage

65,000 mi

FUEL GAUGE NO LONGER FUNCTIONING. AFTER REFUELING, THE FUEL GAUGE BEGAN ACTING SPORADIC, AT TIMES IT WOULD INDICATE THAT FUEL TANK WAS EMPTY EVEN AFTER REFUELING. CONDITION CONTINUED TO GET WORSE AND PRESENTLY FUEL GAUGE JUST READS EMPTY. ALSO THE CHECK ENGINE INDICATOR LIGHT CAME ON AND ENGINE CODE P0463 IS ACTIVE.

NHTSA ID

10759346

Incident

May 15, 2015

Mileage

85,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. WHEN THE FUEL TANK WAS HALF FULL, THE GAUGE WOULD ERRONEOUSLY DECREASE TO EMPTY AND THE LOW FUEL LIGHT WOULD ILLUMINATE. THE DRIVER WAS UNABLE TO DETERMINE THE AMOUNT OF FUEL IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL CAP WAS FAULTY. THE CAP WAS REPLACED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO INDICATED THAT THE FUEL FLOATER WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10732620

Incident

Jun 3, 2013

Mileage

70,000 mi

ISSUES WITH THE FUEL PUMP ASSEMBLY GOING OUT; GAS GAUGE READING EMPTY WHEN THE TANK IS FULL. *TR

NHTSA ID

10702853

Incident

Mar 31, 2015

I JUST GOT MY 2007 MALIBU LTZ AND AFTER I FILL THE TANK WITH GAS I DROVE THE CAR FOR 10 MILES WHEN GAUGE INDICATOR SHOW THAT I HAVE AN EMPTY TANK SINCE THAT DAY I NEVER HAVE AN ACCURATE READING AND THE CHECK ENGINE LIGHT IS ON NOW I THINK ITS THE FUEL PUMP. *TR

NHTSA ID

10694610

Incident

Mar 14, 2015

Mileage

120,500 mi

MY FUEL GAUGE SHOWS LOW FUEL MOST OF THE TIME .MY LIGHTS ON THE DASH CHANGE CHECK ENGINE LIGHT COMES ON SOMETIMES THEN GAS GAUGE WORKS.THEN IT GOES OFF AND THINGS CHANGE AIR BAG WARNING COMES ON.THINGS JUST JUMP AROUND NEVER THE SAME MIX OF THINGS. *TR

NHTSA ID

10689373

Incident

Feb 5, 2014

Mileage

81,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. AFTER REFUELING THE VEHICLE, THE FUEL GAUGE DISPLAYED EMPTY. IN ADDITION, THE CHECK ENGINE AND THE FUEL WARNING LIGHTS CONTINUOUSLY ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LEVEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10669307

Incident

Mar 18, 2009

FUEL SYSTEM FAILURE - GAS HAND DOWNS AND LOW FUEL LIGHT COMES ON AND EVENTUALLY THE CHECK ENGINE LIGHT COMES ON. THIS WAS REPAIRED IN 01/2010. AS OF JULY 2014 THIS ISSUE HAS REOCCURRED. THIS IS A ISSUE WHICH I FEEL THERE SHOULD BE A RECALL BASED ON THE NUMBER OF COMPLAINTS FILED.

NHTSA ID

10734193

Incident

Jan 11, 2010

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THE FUEL GAUGE FAILED TO OPERATE AND WOULD ALWAYS INDICATE THAT THE FUEL WAS LOW. THE DEALER REPAIRED THE FLOAT SENSOR BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FLOAT SENSOR NEEDED TO BE REPLACED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

NHTSA ID

10630674

Incident

Aug 1, 2012

Mileage

25,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. AFTER THE CONTACT FILLED UP THE FUEL TANK, THE FUEL GAUGE OPERATED NORMALLY UNTIL 3/4 OF FUEL WAS LEFT IN THE TANK. ONCE THE FUEL WAS AT 3/4, THE FUEL GAUGE WOULD DISPLAY AS EMPTY. AS A RESULT, THE DRIVER WAS UNABLE TO DETERMINE HOW MUCH FUEL WAS IN THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000. UPDATED 10/7/14*CN THE CONSUMER STATED THE VEHICLE TURNED OFF IN HEAVY TRAFFIC. THE FUEL GAUGE DID NOT REGISTER THAT THE TANK WAS EMPTY. UPDATED 3/11/2015 *JS

NHTSA ID

10627465

Incident

Aug 1, 2013

Mileage

34,000 mi

THE FUEL PUMP IN MY 2007 CHEVY MALIBU WENT OUT. WE REPLACED THE PUMP, THIS LASTED ABOUT 2 WEEKS AND WENT OUT. REPLACED IT WITH ANOTHER PUMP, THIS ONE LASTED ABOUT A WEEK AND WENT OUT. *TR

NHTSA ID

10627291

Incident

Jul 17, 2014

Mileage

98,000 mi