2018 Chevrolet Malibu Owner Complaints

The contact owns a 2018 Chevrolet Malibu. The contact stated that there was an abnormally strong gasoline odor coming from the vehicle. The contact stated that while driving at various speeds on several occasions, the accelerator pedal was depressed, but the vehicle failed to respond, requiring the driver to pull over to the side of the road. The message "Engine Power Reduced" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the fuel injectors had failed and needed to be replaced. The mechanic retained the vehicle and informed the contact that it was unsafe to drive due to a potential fire risk. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not under recall. The dealer advised the contact to bring the vehicle in for service. The manufacturer was notified of the failure and confirmed that the VIN was not under recall. The failure mileage was approximately 169,000.

NHTSA ID

11755237

Incident

Jul 31, 2026

Mileage

169,000 mi

I own a 2018 Chevy Malibu. At approximately 57,000 miles, the original engine experienced a vacuum pump failure that resulted in catastrophic engine damage. The engine was replaced by General Motors under the vehicle's warranty. I then drove the vehicle for approximately another 52,000 miles with the warranty replacement engine. At that point, I experienced a sudden loss of braking while driving. My vehicle was again diagnosed with a vacuum pump failure, and the vacuum pump was replaced. Approximately one week after the vacuum pump replacement, the warranty replacement engine suffered catastrophic failure. The repair facility diagnosed cylinder #3 scoring and informed me that the engine required replacement. I was told that the engine failure was related to the vacuum pump failure. Because the warranty replacement engine was no longer covered under warranty, General Motors initially declined to cover the repair. Initially, neither General Motors nor the Chevrolet dealership was willing to accept responsibility for the issue. After continued discussions, General Motors ultimately agreed to provide partial financial assistance as a goodwill adjustment. However, I was still left responsible for paying a substantial amount out of pocket to purchase and install a third engine. The cost has created a significant financial burden that I have struggled to afford, especially because the repair involved a component that I was informed has a known history of failure. I was also informed that vacuum pump failures are a known issue with these vehicles and that General Motors is aware of the problem, although no recall has been issued. I am submitting this complaint because I have experienced multiple vacuum pump failures, two catastrophic engine failures, and have now required three engines in the same vehicle. This has resulted in significant financial hardship, loss of use of my vehicle, and serious concerns about the safety and reliability of this vehicle.

NHTSA ID

11754547

Incident

Oct 2, 2025

A software error in 1.5L turbo model disable fuel injectors, preventing the engine from starting or causing a sudden stall while driving. It’s been confirmed to be an previously opened recall that was fixed by previous owner. But, is happening again to me. Yet I’m being told It has been closed and cannot be fixed unless I pay out of pocket. There are warning signs that pop up like reduced speed while I am driving etc. which reduces my speed and is incredibly unsafe.

NHTSA ID

11753826

Incident

Jun 6, 2025

I’ve reported this problem but as I got into the repair their was far more damaged that was caused due to the vacuum pump. It took out my exhaust camshaft and sent metal through out and the timing needs replaced as well. A shop would rather total my car than what it would cost to fix. I’m attempting to fix it myself but have been without my car for months now. This is created such a hardship and the money it’s continues to take as more and more needs to be fixed or replaced as well as all the gaskets and screws that are only one time use as well as parts like my high pressured fuel line I mean this lost keeps going. I and to replace the water pump as well and all due to this vacuum pump that’s been reported and reported and nothing has been done this is outrageous that what’s caused is so much more then just a vacuum pump it can destroy your vehicle miles don’t matter the less or if you have more the pump goes out when it feels like it. Creating more issues then it should and potentially totaling out a vehicle as it’s been said mine should be. So I’m trying to fix my car to prevent losing it and it’s been one thing after another and such a nightmare. The fact that this issue continues to be ignored is unacceptable and a complete disregard to public safety due to the serious safety issue as mine I could barley get my car to stop the breaks were hard and unable to push down without basically standing on them to get into stop at only 7-8 miles per hour I was moving when the vacuum booster went out. Someone should not have to die to have this issue addressed and to be taken seriously and made right! I can’t believe nothing has been done and that it’s not required to have to address this issue with the severity it bring to one’s safety as well as public safety is beyond me. This is a major lawsuit and people’s lives and lovely hood should be taken more seriously and instead nothing is being done. It’s very concerning to think what has to happen for this to be addressed!

NHTSA ID

11753408

Incident

May 7, 2026

When placed into park and try to turn the car off, the vehicle's dashboard still says "shift to park". It's already in park but not registering. The vehicle will not shut off

NHTSA ID

11752481

Incident

Oct 12, 2022

JUST BOUGHT THE CAR AND THE CAR IS RECEIVING ERROR: "SHIFT TO PARK". THIS APPEAR TO BE A KNOW ISSUE FOR 2018 CHEVY MALIBU HYBRID. CAR CUT OFF IN MIDDLE OF TRAFFIC

NHTSA ID

11751389

Incident

Jul 17, 2026

While coming down McClure pass in Colorado my brakes failed. The the car went to engine power reduced mode. After getting the car to an independent mechanic I was told that the vacuum pump failed and exploded the parts into the camshaft. After 2 days of repairs I was finally able to get my car back to working order. This could have been a fatal car accident coming down a mountain pass. I was able to get stopped safely because I know the road. I had just driven 700 miles over Eisenhower Pass, Vail Pass, Glenwood Canyon, and then the final pass being McClure pass where it failed. I bought this car brand new and I probably won't buy another Chevy after this. This was a terrifying experience that I will have lasting trauma from.

NHTSA ID

11750766

Incident

Jul 9, 2026

Odometer Fraud. The contact purchased a 2018 Chevrolet Malibu. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 93,000. The contact stated that while attempting to trade the vehicle with the dealer, the dealer declined the trade due to a possible odometer fraud. The dealer discovered from the Carfax report that the mileage was 98,000.

NHTSA ID

11746683

Incident

Dec 20, 2025

Mileage

98,000 mi

I keep having the shift to park issue. I had it repaired January 2022 and is beginning to have this issue again.

NHTSA ID

11744080

Incident

May 4, 2026

REDUCED ENGINE LIGHT CAME ON TICKING NOISE STOPPED 2 TIMES ON THE HIGHWAY REPAIR LOT RAN A DIAGNOSTIC UNABLE TO FIND THE ISSUE CAR IS NOT WORKING FOUND MANY CODES STILLUNABLE TO FIX THE ISSUE

NHTSA ID

11743065

Incident

May 13, 2026

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving on the interstate and attempting to exit the ramp at 40-45 MPH, the brakes failed. After restarting the vehicle, the check engine warning light illuminated. The contact related the failure to NHTSA Campaign Number: 18V576000 (Service Brakes, Hydraulic). The vehicle was towed to the local dealer, where it was diagnosed that the vacuum pump had failed. The vehicle was not repaired. The manufacturer was contacted, confirmed there was no recall and referred the contact to the NHTSA Hotline. The approximate failure mileage was 150,000.

NHTSA ID

11742983

Incident

Jun 4, 2026

Mileage

150,000 mi

The shift to park is a problem it killed my battery because the car stays on and when I was driving the car turned off in the middle of turning causing someone to almost hit me this is the 3rd time that happened to me but the shift to park has been a problem since I got this car and Chevy does nothing about it

NHTSA ID

11742798

Incident

Apr 25, 2022

I went to put my car in park and it was saying "Shift to Park" on my dashboard even though I was already in park. I know that there was a lawsuit that was won for this very defect but my car is not recalled for this and I feel every Malibu should be especially if almost every Malibu is experiencing the same issue Nationwide. It cannot be a coincidence. Also I have been having issues with a knocking noise on the back of the car when I am driving and I'm being told it's also another common issue with Malibu's known as the Knuckles that need replaced which are not cheap. If these are common issues on every Malibu then every Malibu needs to be recalled for the issue to be fixed not just certain ones. My Malibu has not had one recall but has had the same issues that other Malibu's had with multiple recalls done.

NHTSA ID

11742533

Incident

Jun 6, 2026

Shift to Park!!! everytime i shut my car off

NHTSA ID

11742474

Incident

Dec 18, 2025

My 2018 Malibu is stalling, it is covered under Recall N192221960, and the dealer is refusing to properly scan or fix the issue. They did the recall and the car is still doing the same thing but worse.

NHTSA ID

11741758

Incident

Apr 14, 2026

Whenever I go to park my car, I get a " Please shift to park message. This means I am not able to turn off the car because I continuously try to get the park to identify as parked.

NHTSA ID

11738552

Incident

Feb 1, 2025

The vacuum break booster went out. My check engine light came on and it said power reduced I’m not sure exactly. Because my power didn’t reduce but my car seems to be misfiring. Luckily I was going to be turning at a light and there was a few cars in front of me so I wasn’t going fast. As I got closer to the car in front of me I applied my breaks. They would not move and were hard and I gave it all I had to try to get my car to stop and thank god it did. Then my car stalled. I tried to start it and it just kept cranking but wouldn’t turn over, it also would not turn off till about the 3 times I push then button it finally turned off. Yes my safety and others would surely been at risk I wouldn’t have been able to stop in time if someone pulled in front of me or stopped suddenly I would not have been able to stop. If a child ran into the street I inn o way could’ve stopped! My step dad is a mechanic and he also ran a test on the check engine light and it threw 7 codes from this occurring. It didn’t give me no time it was very sudden. Once the engine power reduced appeared on my dash the check engine light came on and my car began misfiring in less then 45 seconds I went to apply the breaks and they were hard and I could barely stop. That was when I was almost about to be at a full stop so I wasn’t going very fast at all and I almost rear ended the person in front of me waiting to turn at the light. Then my car stalled. It all happened within 1 min 30 seconds from the warning my engine power was reduced but my engine power wasn’t not reduced either, and from then my check engine light and it all only took less then 2 minutes to all occur. It was sudden, no warning to think my breaks would not work at all and very quickly it could’ve been so much worse I can’t even imagine. Very alarming and fearful or my life and others from this occurring with no time to react and no idea what happened was going to. I will not buy a Chevy Malibu again and I was going to!

NHTSA ID

11736822

Incident

May 5, 2026

The check engine light keeps coming on and off with a warning that the engine power is being reduced. The dealership's service center can't locate the issue. The car's traction warning went off and the car's speed was reduced while driving. This happened twice in the same day. When you shut the car off and turn it back on the warning goes away and the car drives normal. This is very unsafe. Had this happened on the highway there could have been a serious accident.

NHTSA ID

11735731

Incident

May 5, 2026

The contact owns a 2018 Chevrolet Malibu. The contact stated that the gear shifter was intermittently stuck in park(P). The contact turned the steering wheel, engaged and disengaged the parking brake several times, per the Owner's manual instructions, and the gear shifter was able to shift out of park(P). The vehicle was taken to an independent mechanic, where the failure recurred. The mechanic was able to move the gear shifter out of park(P) after several attempts. The mechanic was unable to diagnose the vehicle and referred the contact to a dealer for assistance. The contact contacted two dealers, who advised that there was no availability for an appointment. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 89,992.

NHTSA ID

11734298

Incident

Apr 14, 2026

Mileage

89,992 mi

The contact owns a 2018 Chevrolet Malibu. The contact stated that while his daughter was driving and stopped at a traffic light, while depressing the accelerator pedal, the vehicle failed to respond, and the vehicle lost automotive power. The contact stated that five minutes after restarting the vehicle, the vehicle operated as intended. A dealer was contacted. The vehicle was taken to dealer, where it was diagnosed that the engine control module needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 19V642000 (ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 75,000.

NHTSA ID

11733336

Incident

Apr 18, 2026

Mileage

75,000 mi

The contact owns a 2018 Chevrolet Malibu. The contact stated that on several occasions while driving at various speeds, the message "Engine Power Reduced" was displayed, and the check engine warning light was illuminated. The contact stated that after 20 minutes of consecutive driving, the vehicle drove sluggishly and lost power. The vehicle was taken to an independent mechanic, where the check engine warning light was reset, but the diagnostic result was not provided. The vehicle was then taken to another independent mechanic where a diagnostic test could not be performed because the machine was unable to remain connected to the ECM. The vehicle was then taken to a dealer, but was not diagnosed. The contact stated that an unknown software update was performed; however, the failure persisted. The vehicle was taken to the same dealer where it was diagnosed and determined that three fuel injectors were weak, there was a crack in the lower oil pan, and that the oil pan needed to be replaced. The vehicle was partially repaired by replacing the oil pan, but the fuel injectors were not replaced. The contact stated that on several occasions during the summer, after turning the vehicle off, the message "Shift to Park" was displayed. The vehicle was turned on and the shifter was shifted several times and was turned off several times until the correct gear selection was recognized. The manufacturer was not notified of the failure. The failure mileage was approximately 116,000.

NHTSA ID

11733040

Incident

Apr 1, 2024

Mileage

116,000 mi

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, a fuel odor was detected, and the vehicle failed to accelerate above 30 MPH. The check engine warning light was illuminated. Additionally, the rearview camera intermittently failed to display while reversing, and the vehicle made an abnormal clicking sound. Upon inspection, the contact discovered a fuel leak beneath the engine. The vehicle was towed to the residence, where an independent mechanic determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 130,000.

NHTSA ID

11732427

Incident

Apr 15, 2026

Mileage

130,000 mi

The contact owns a 2018 Chevrolet Malibu. The contact stated that there was an oil leak coming from the engine. While driving at an undisclosed speed, the message "Engine Power Reduced" and "Service Stabili-trak" were displayed. Occasionally, the automatic emergency braking activated unexpectedly, and while the vehicle was stopped, the vehicle shuddered abnormally. The vehicle also decelerated and stalled occasionally. Additionally, the volume on the radio was stuck, the steering wheel command controls failed to operate as needed, and the air compressor was recently replaced. The contact associated the failures with NHTSA Campaign Number: 20V668000 (POWER TRAIN), 19V642000(ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE), 18V400000(AIR BAGS), and 18V358000(FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recalls. The vehicle was taken to the dealer where it was diagnosed with air compressor failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 150,842.

NHTSA ID

11730437

Incident

May 10, 2023

Mileage

150,842 mi

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving very slowly into a parking space, the brake pedal was pressed to stop the vehicle, but the vehicle experienced unintended acceleration and suddenly accelerated forward at a very high rate of speed and crashed into a furniture store showroom window. During the incident, the front end of the vehicle was severely damaged, but no air bags deployed. No injuries were reported. A police report was taken at the scene, and the vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was not yet contacted. The failure mileage was 80,000.

NHTSA ID

11730355

Incident

Apr 8, 2026

Mileage

80,000 mi

I had a tire installed by a repair shop approximately one month ago. I recently discovered that the tire installed on my vehicle is the incorrect size. My vehicle requires size 225/55R17, but the shop installed size 245/45R17. This creates a safety concern due to improper fitment, which can affect handling, stability, and overall vehicle performance. I only discovered the issue after experiencing a separate flat tire and inspecting all tires on the vehicle. I contacted the business to have the issue corrected, but they refused to assist me. During multiple phone calls, both the manager and assistant manager were dismissive, unprofessional, and terminated the calls without providing any resolution. The incorrect tire remains on the vehicle, and the business has failed to correct their error.

NHTSA ID

11728876

Incident

Apr 2, 2026