1997 Chevrolet Silverado Problems

BRAKE LINE RUSTED INTO ON LEFT REAR WHEEL WAS REPAIRED, EVERY SINCE THIS HAPPENED BRAKE PEDAL IS VERY SPONGY STOPPING POWER IS NOT WHAT IT USED TO BE OR SHOULD BE. I HAVE ALSO REPLACED FRONT CALIPERS,ROTORS,PADS,MASTER CYLINDER,POWERBRAKE BOOSTER,REAR DRUMS, SHOES,CYLINDERS,EMERGENCY BRAKE CABLE .CANNOT GET THE AIR OUT OF BRAKE SYSTEM VERY ANNOYING SITUATION AND DANGEROUS BECAUSE I CANNOT STOP TRUCK VERY QUICKLY DUE TO SPONGY BRAKES. *TR

WHEN GOING 10 MPH OR LESS, APPLYING THE BRAKES EITHER PRODUCES A VERY HARD PEDAL OR ANTI-LOCKS KICK IN. THIS HAS HAPPENED ON DRY ROADS WITH LIGHT TO MODERATE PEDAL PRESSURE. WAS INSTRUCTED THAT ONLY 1999 AND NEWER SILVERADOS ARE INCLUDED IN A CAMPAIGN. *TR

DT*: THE CONTACT STATED THE VEHICLE PULLS TO THE RIGHT INTERMITTENTLY. THE PULLING OCCURS SUDDENLY AND LAST FOR ONLY A SECOND. THE CONTACT HAD THE VEHICLE INSPECTED FOR THE PROBLEM BY AN INDEPENDENT REPAIR SHOP IN 2000. THE REPAIR SHOP WAS UNABLE ABLE TO DETERMINE THE CAUSE OF THE PULLING. THE PROBLEM CONTINUED AND THE CONTACT CALLED THE LOCAL DEALER YESTERDAY. THE DEALER WAS ABLE TO DETERMINE A POSSIBLE CAUSE BY PHONE AND SUGGESTED REPAIRING THE STEERING SENSOR. *NM UPDATED 03/17/06. *JB

CHEVROLET SILVERADO 1997, STEERING PINION GEAR SEPARATION. *BF THE CONSUMER STATED HIS VEHICLE PULLED TO LEFT OR RIGHT REAL HARD AND THERE SHOULD BE A RECALL ON THE VEHICLE JUST LIKE THE CHEVROLET MALIBU HE HAD WHICH HAD A RECALL ON THE RACK AND PINION, WHICH NEVER EXHIBITED A PROBLEM. *JB

TL* THE CONTACT OWNS A 1997 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE PARKED, THE DRIVER'S SIDE PANEL CAUGHT ON FIRE. ALSO, THE CONTACT MENTIONED THAT THE POWER LOCKS AND THE POWER WINDOWS FAILED TO OPERATE PROPERLY. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS NOT DESTROYED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER HAD BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 187,600. UPDATED 9/29/14*CN UPDATED 2/26/2015 *JS

TL*THE CONTACT OWNS A 1997 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 50 MPH IN RAINY WEATHER CONDITIONS, THE WINDOW WIPERS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO A CRACKED JOINT IN THE MOTOR. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 89,000 AND CURRENT MILEAGE WAS 113,000.

I CURRENTLY OWN A 1997 SILVERADO EXT CAB FLEET SIDE. I'VE HAD MY BRAKES SERVICED NUMEROUS TIMES AND IT CONTINUES TO PULL TO THE LEFT WHEN I'M BRAKING. ALSO IT'S VERY HESITANT IN PICKING UP SPEED WHEN PASSING EVEN WITH MAJOR TUNE-UPS AT CHEVY DEALERSHIPS ONLY TO BE SERVICED. I'M CONSTANTLY PURCHASING FRONT TIRES FOR MY TRUCK, WITH FRONT END ALIGNMENTS BEING DONE OFTEN WITH THE PURCHASE OF THESE TIRES. *JB

SHIFTS HARD AND MAKES A LOUD SOUND AND JERKS THE VEH. I TALKED TO MANY TRANSMISSION SHOPS. AND THEY SAY THAT IT IS VERY COMMON WITH THE 97 MODELS IT COST AROUND $300.00 DOLLARS TO FIX. SOMETHING TO DO WITH SHIFTING TUBE THAT HAS TO BE DRILLED OUT BECAUSE OF FLUID PRESSURE. THIS IS ALSO TRUE WITH EVERY VEH WITH THE SAME TRANSMISSION. NOW YOU NOW THE TRUTH SO FIX THE PROBLEM GM. YOUR GETTING AS BAD AS F.O.R.D. *AK

ENGINE IS A 6.5 TURBO DIESEL. I BOUGHT THIS VEHICLE USED SO HAVE NO PREVIOUS HISTORY WHETHER IT HAPPENED BEFORE I OWNED IT. VEHICLE ENGINE STARTED TO DIE WHILE DRIVING, OCCASIONALLY AT FIRST. IT WOULD RESTART IMMEDIATELY SOMETIMES AND SOMETIMES IT HAD TO SIT FOR A WHILE. THIS PROBLEM STARTED IN YEARS PREVIOUS TO 2010 INTERMITTENTLY BUT BECAME MORE FREQUENT IN 2010- 2011. DIDN'T MATTER WHAT SPEED I WAS TRAVELING, IT WOULD QUIT ON THE INTERSTATE GOING 75 MPH OR IN DRIVEWAY GOING 5 MPH. SHUT OFF WITHOUT WARNING AND IMMEDIATELY LIKE SOMEONE TURNED THE KEY OFF. ALL POWER STEERING AND POWER BRAKES FAILED BUT FORTUNATELY I WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD AND STOP IT WHEN IT HAPPENED, ONLY BECAUSE I KNEW HOW TO STEER WITH OUT POWER STEERING AND HAD THE STRENGTH TO DO IT. WITH OTHERS THIS COULD EASILY CAUSE SERIOUS ACCIDENTS. MULTIPLE ATTEMPTS WERE MADE OVER THE YEARS WITH A MECHANIC TO FIND THE PROBLEM WITH NO LUCK. FINALLY SOMEONE SUGGESTED REPLACING THE PMD MODULE WHICH I DID IN 2011 AND IT SOLVED THE PROBLEM FOR 3 MORE YEARS. IT IS NOW HAPPENING AGAIN. I WAS TOLD THE PMD MODULE NEEDS TO BE LOCATED OUTSIDE OF THE ENGINE COMPARTMENT BECAUSE IT GETS TOO HOT AND CAUSES THIS FAILURE. I BELIEVE THIS CONSTITUTES A POOR DESIGN AND A DEFECT THAT NEEDS TO BE RECTIFIED. SINCE THIS HAPPENED TO MY VEHICLE I HAVE TALKED WITH SEVERAL OTHER PEOPLE JUST IN MY AREA WHO OWN THE SAME TYPE OF ENGINE AND HAVE HAD THE SAME PROBLEM AND OTHERS IN OTHER AREAS. *TR

DT: THE AUTOMOBILE WOULD NOT START. NO PREVIOUS PROBLEMS, THIS WAS THE FIRST INCIDENT. THE CONSUMER ASSUMED IT WAS THE FUEL PUMP. AN INDEPENDENT MECHANIC CAME OUT TO INSPECT THE VEHICLE. HE DETERMINED THE FUEL TANK SENDING UNIT ASSEMBLY HAD CAUGHT ON FIRE WHICH MELTED THE WIRING INSIDE THE FUEL TANK. THERE WERE NO VISIBLE FLAMES, WHEN THIS INCIDENT OCCURRED WAS UNKNOWN. HE WAS UNAWARE OF THIS PROBLEM AND WOULD HAVE NOT KNOWN UNLESS THE MECHANIC HAD PULLED THE FUEL PAN BED AND DISCOVERED THIS FAILURE. THE MECHANIC OFFERED NO EXPLANATION AS TO WHY THIS HAPPENED. THE PLASTIC SIMPLY MELTED, AND THE WIRING WAS BURNED. THERE HAVE BEEN NO REPAIRS OR CORRECTIONS MADE AT THIS TIME. *AK

ENGINE IS A 6.5 TURBO DIESEL. I BOUGHT THIS VEHICLE USED SO HAVE NO PREVIOUS HISTORY WHETHER IT HAPPENED BEFORE I OWNED IT. VEHICLE ENGINE STARTED TO DIE WHILE DRIVING, OCCASIONALLY AT FIRST. IT WOULD RESTART IMMEDIATELY SOMETIMES AND SOMETIMES IT HAD TO SIT FOR A WHILE. THIS PROBLEM STARTED IN YEARS PREVIOUS TO 2010 INTERMITTENTLY BUT BECAME MORE FREQUENT IN 2010- 2011. DIDN'T MATTER WHAT SPEED I WAS TRAVELING, IT WOULD QUIT ON THE INTERSTATE GOING 75 MPH OR IN DRIVEWAY GOING 5 MPH. SHUT OFF WITHOUT WARNING AND IMMEDIATELY LIKE SOMEONE TURNED THE KEY OFF. ALL POWER STEERING AND POWER BRAKES FAILED BUT FORTUNATELY I WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD AND STOP IT WHEN IT HAPPENED, ONLY BECAUSE I KNEW HOW TO STEER WITH OUT POWER STEERING AND HAD THE STRENGTH TO DO IT. WITH OTHERS THIS COULD EASILY CAUSE SERIOUS ACCIDENTS. MULTIPLE ATTEMPTS WERE MADE OVER THE YEARS WITH A MECHANIC TO FIND THE PROBLEM WITH NO LUCK. FINALLY SOMEONE SUGGESTED REPLACING THE PMD MODULE WHICH I DID IN 2011 AND IT SOLVED THE PROBLEM FOR 3 MORE YEARS. IT IS NOW HAPPENING AGAIN. I WAS TOLD THE PMD MODULE NEEDS TO BE LOCATED OUTSIDE OF THE ENGINE COMPARTMENT BECAUSE IT GETS TOO HOT AND CAUSES THIS FAILURE. I BELIEVE THIS CONSTITUTES A POOR DESIGN AND A DEFECT THAT NEEDS TO BE RECTIFIED. SINCE THIS HAPPENED TO MY VEHICLE I HAVE TALKED WITH SEVERAL OTHER PEOPLE JUST IN MY AREA WHO OWN THE SAME TYPE OF ENGINE AND HAVE HAD THE SAME PROBLEM AND OTHERS IN OTHER AREAS. *TR

ENGINE INTAKE ANTI-FREEZE LEAK IS A KNOWN PROBLEM FOR 1997 CHEVY TRUCKS AND SHOULD BE A FACTORY PAID FOR FIX. BUT NO THEY DON'T WANT TO DO THAT, WE AS CONSUMERS HAVE PAID AS MUCH AS 600.00 TO 700.00 TO HAVE GM DEALERS TO DO THIS. WITCH I THINK IS WRONG!!!!!!!!!*JB

TL* THE CONTACT OWNS A 1997 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE PARKED, THE DRIVER'S SIDE PANEL CAUGHT ON FIRE. ALSO, THE CONTACT MENTIONED THAT THE POWER LOCKS AND THE POWER WINDOWS FAILED TO OPERATE PROPERLY. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS NOT DESTROYED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER HAD BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 187,600. UPDATED 9/29/14*CN UPDATED 2/26/2015 *JS

I WAS STOPPED IN TRAFFIC AND WAS REAR ENDED BY A FORD F-150 GOING 20-40 MPH ESTIMATED. BOTH MY SON AND I WERE HURLED BACKWARDS BECAUSE THE SEATS COLLAPSED BACKWARDS. WE BOTH SUSTAINED INJURIES TO OUR NECKS AND BACKS. I BELIEVE THAT IF WE WERE NOT REAR ENDED OR THE SEATS WOULDN'T HAVE COLLAPSED WE WOULD HAVE NOT RECEIVED ANY INJURIES. I BELIEVE THESE SEATS HAVE A POTENTIAL OF BEING DANGEROUS AND THE COMPANY NEEDS TO DO SOMETHING ABOUT IT RIGHT AWAY BEFORE SOME ELSE GETS INJURED. *JB

I CURRENTLY OWN A 1997 SILVERADO EXT CAB FLEET SIDE. I'VE HAD MY BRAKES SERVICED NUMEROUS TIMES AND IT CONTINUES TO PULL TO THE LEFT WHEN I'M BRAKING. ALSO IT'S VERY HESITANT IN PICKING UP SPEED WHEN PASSING EVEN WITH MAJOR TUNE-UPS AT CHEVY DEALERSHIPS ONLY TO BE SERVICED. I'M CONSTANTLY PURCHASING FRONT TIRES FOR MY TRUCK, WITH FRONT END ALIGNMENTS BEING DONE OFTEN WITH THE PURCHASE OF THESE TIRES. *JB

THERE WAS AN INTERMITTENT PULL TO THE RIGHT. THE PULLING WOULD BECOME MORE SEVERE WHEN TURNING TO THE RIGHT. ON ONE OCCASION THE VEHICLE SWERVED VIOLENTLY TO THE RIGHT. THE BRAKES WERE REPLACED BUT THE PROBLEM STILL EXISTED. THE DEALER WAS UNABLE TO FIND THE PROBLEM. THE CONSUMER REQUESTED THE DEALER PAY FOR REPAIR. SCC *JB

APPROXIMATELY IN 2006, WITH ONLY 30,000 MILES, I NOTICED ANTIFREEZE POOLING UNDER MY 1097 SILVERADO PICKUP. I TOOK MY VEHICLE TO AN AUTO REPAIR SHOP AND WAS TOLD THAT IT NEEDED A NEW RADIATOR. THE RADIATOR WAS REPLACED. APPROXIMATELY ONE MONTH LATER THE SAME PROBLEM. THE RADIATOR WAS AGAIN LEAKING. THE RADIATOR WAS REPLACED THREE TIMES UNTIL THE OWNER OF THE REPAIR SHOP STATED THAT HE WOULD NO LONGER REPLACE THE RADIATOR AND EXPLAINED THAT THE 1997 SILVERADO PICKUP WAS KNOWN FOR A CONDITION CALLED. ELECTROLYSIS. IT WAS SUGGESTED THAT I REMOVE THE BATTERY CABLE AFTER EACH TIME I DROVE THE VEHICLE. I STARTED TO REMOVING THE POSITIVE BATTERY CABLE AND WITHIN 3 WEEKS THE SAME PROBLEM. I THEN CONTACTED RUDOLPH CHEVROLET DEALERSHIP IN EL PASO, TEXAS. THEY REFUSED TO TACKLE THE PROBLEM AND REFERRED ME TO EMMITT RADIATOR SHOP, ALSO IN EL PASO, TEXAS. THEY ADVISED THAT THEY WOULD CHARGE $80.00 PER HOUR WITH A MINIMUM OF 10 TO 12 HOURS WITH NO GUARANTEE. THEY DID SUGGEST THAT I REMOVE BOTH POSITIVE AND NEGATIVE BATTERY CABLES. THIS IS WHERE THE PROBLEM WITH THE EXPLODING BATTERY COMES TO LIGHT. WHEN I WOULD TRY TO REMOVE THE BATTERY CABLES AFTER EACH TRIP, EVEN TO THE MOVIES OR OUT TO DINNER, THE BATTERY WOULD BE SO HOT THAT IT WOULD BURN MY HANDS. I ALSO KEPT REPLACING THE BATTERIES AND FINALLY ASK A SALESWOMAN AT AUTO ZONE SUPPLY HOUSE WHAT WAS WRONG WITH THE BATTERIES AND HE POINTED TO THE BATTERY AND SAID, "LOOK AT THE SIDES OF THE BATTERY, HOW IT IS EXTENDING OUTWARD IT COULD EXPLODE". AGAIN I WAS TOLD ME THAT THEY DID NOT HAVE THE EQUIPMENT TO FIX THE PROBLEM. THIS FALLS INTO THE CATEGORY OF A LEMON AND GENERAL MOTORS KNEW OF THIS PROBLEM OR SHOULD HAVE KNOWN OF THIS PROBLEM THE 1997 SILVERADO PICKUP AND HAVE PLACED CONSUMERS IN HARMS WAY. *TR

TL* THE CONTACT OWNS A 1997 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE PARKED, THE DRIVER'S SIDE PANEL CAUGHT ON FIRE. ALSO, THE CONTACT MENTIONED THAT THE POWER LOCKS AND THE POWER WINDOWS FAILED TO OPERATE PROPERLY. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS NOT DESTROYED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER HAD BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 187,600. UPDATED 9/29/14*CN UPDATED 2/26/2015 *JS

SPEED SENSOR FAILED, PLEASE ADD FURTHER DETAILS.*AK

TRANSMISSION WENT OUT AT 40,000 MILES. CONSUMER WAS TOLD THAT TRANSMISSION WAS NOT UNDER WARRANTY. *AK BATTERY AND ALTERNATOR FAILED, SHORT CIRCUIT FUSE CAUSED FAILURE OF BRAKE LIGHTS AND TURN SIGNALS. INJECTOR FAILED. WATER PUMP FAILED. VEHICLE JUMPED OUT OF GEAR, WAS TOWED TO DEALER WHO INFORMED CONSUMER THAT TRANSMISSION NEEDED REPLACED, CONSUMER IS ANGRY THAT A VEHICLE WITH SUCH LOW MILEAGE WOULD HAVE TRANSMISSION FAILURE AND CHEVROLET WILL NOT ASIST IN REPAIRS. *SLC

PARKED IN MY DRIVEWAY WARMING UP, BAG ENGAGED. LEFT EAR HURT BY BLAST AND RINGING IN LEFT EAR. *TR

WHILE DRIVING, THE CONSUMER WAS INVOLVED IN A FRONT END COLLISION. UPON IMPACT, THE AIR BAGS DEPLOYED. AS A RESULT OF THE DEPLOYMENT, THE AIR BAGS BURNED THE CONSUMERS FACE AND ARMS. PLEASE PROVIDE FURTHER INFORMATION. *JB

WHILE DRIVING AT 65 MPH CONSUMER HEARD A LOUD POPPING SOUND. THEN, LOST CONTROL OF THE VEHICLE AND ALMOST COLLIDED WITH A UTILITY POLE. UPON FURTHER INSPECTION CONSUMER NOTICED A BASEBALL SIZED HOLE IN THE RIGHT REAR TIRE, AND TREAD SEPARATION FROM THE TIRE. THERE WERE NO INJURIES INVOLVED WITH THIS INCIDENT. MANUFACTURER AND DEALER WERE NOTIFIED.*AK

CONSUMER COMPLAINED ABOUT HAVING PROBLEMS WITH THE TIRES. THE TIRES ARE FIRESTONE. MANUFACTURE WAS CONTACTED.*AK

THE ABS BRAKING SYSTEM MAKES A GRINDIND NOISE AND DOES NOT STOP THE TRUCK PROPERLY.I HAVE DRIVEN PAST DRIVEWAYS AND ALMOST WENT THROUGH A STOP SIGN INTO ONCOMING TRAFFIC. I WORK FOR THE CITY SO GETTING TO WORK TO PLOW IS IMPORTANT, BUT I CANT TRUST THE TRUCK TO GET ME THERE SAFELY

CONSUMER COMPLAINED ABOUT HAVING PROBLEMS WITH THE TIRES. THE TIRES ARE FIRESTONE. MANUFACTURE WAS CONTACTED.*AK

DT*: THE CONTACT STATED WHILE STANDING ON THE TAILGATE OF THE VEHICLE BROKE CAUSING MINOR INJURIES. THERE IS A NHTSA RECALL, # 06V066000 CONCERNING THE TAILGATE: HINGES: ATTACHMENTS. THE VEHICLE HAS THE SAME PROBLEM AS INDICATED IN THE RECALL; HOWEVER IS NOT INCLUDED IN THE RECALL DUE TO THE VIN AND THE YEAR OF THE VEHICLE. THE DEALER HAS BEEN NOTIFIED HOWEVER, THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER HAS BEEN ALERTED.

WOULD LIKE TO FILE COMPLAINT ON THE FRAME WORK OF 1997 1/2 TON CHEVROLET PICK-UP. HAD A HEAD ON COLLISION WITH ANOTHER CAR, CAUSING LIFE LONG DISABILITY. *AK

AT 62,000 MILES FAN CLUTCH BROKE AND NOW TRANSMISSION NEEDS TO BE REPLACED, 2ND GEAR IS GONE. THE REAR SEAL IS LEAKING AND WAS REPLACED ALREADY AT 18,600 THE FRONT BRAKES WERE REPAIRED AT 25,600 THEN AT 35,300 THE ENTIRE FRONT BRAKES COMPLETELY REPLACED ROTORS AND ALL(PROBLEMS WITH CALIPERS) THE REPAIRING DEALER CLAIMED IT WSN'T COVERED UNDER WARRANTY EVEN THOUGH ALL REPAIRS WE DONE BY CHEVROLET DEALERS. NOW I AM FACING APPROXIMATELY $2,000. IN REPAIRS TO THE TRANSMISSION.......CHEVROLET GIVE ME A BRAKE. E.*AK

WHILE SITTING AT A TRAFFIC LIGHT CONSUMER WAS REAR ENDED AT ABOUT 50 MPH AND SEAT BELTS DID NOT TIGHTEN UP, AND THE SEAT ITSELF COLLAPSED. CONTACTED DEALER.*AK

DEFECTIVE FRONT PASSENGER SEAT BELT GETS LOCKED. YH

WHEN MAKING A LEFT OR RIGHT TURN, THE STEERING WHEEL GIVES AND CAUSES TEMPORARY STEERING LOSS. TS THE VEHICLE ALSO SUSTAINED THE FOLLOWING FAILURES, THE PCV VALVE MALFUNCTIONED CAUSING THE #2 AND #3 HEAT SHIELDS IN THE TRANSMISSION TO CRACK. THIS MALFUNCTION WAS REPAIRED AND NOW THE 4 LOW GEAR IS INOPERABLE. ALSO, THE FUEL PUMP, OXYGEN SENSOR, AIR CONDITIONER COMPRESSOR AND PUMP MALFUNCTIONED. NOTICEABLY AFTER PURCHASE, THE DRIVER SIDE SEAT GIVES WHEN BRAKING. *JG

AIR CONDITIONER ISN'T WORKING PROPERLY DUE TO THE CLUTCH WITHIN THE A/C COMPRESSOR BURNING OUT, CAUSING HOT AIR TO COME OUT. DEALER IS UNABLE TO FIND THE PROBLEM UNTIL A NEW TRANSMISSION IS NEEDED. *AK *ML