2004 Chevrolet Ssr Body & structure Problems

THE PASSENGER'S DOOR OF MY SSR WAS BECOMING DIFFICULT TO OPEN AND I WAS CONFIDENT THE ISSUE WAS THE SAME PROBLEM I HAD EXPERIENCED PREVIOUSLY WITH THE DRIVER'S SIDE DOOR. IT IS A KNOWN DEFECT AND RESULTANT TECHNICAL SERVICE BULLETIN (TSB 05-08-64-026) WHICH PREVIOUSLY HAD BEEN FIXED BY KEN DIXON CHEVROLET (JUNE OF 2011). AT THAT TIME, KEN DIXON (NOW MANAGED UNDER WALDORF CHEVY CADILLAC) DECLINED MY REQUEST TO REPLACE PASSENGER'S SIDE DEFECTIVE PART EVEN THOUGH THE TSB HAD INDICATED TO DO SO. WALDORF CHEVY CADILLAC NOW SAYS THE PART REQUIRED TO FIX MY CAR IS DISCONTINUED AND NOT AVAILABLE. I WAS TOLD "IT CANNOT BE FIXED. THE PART IS DISCONTINUED, NOT AVAILABLE FROM GM." I ASKED, "ARE YOU SAYING I HAVE TO LIVE WITH IT AND THERE IS NO FIX? THAT IS, GM ISSUED A TSB AND THEN DISCONTINUED THE PART WITH NO FUTURE PLANS OR OPTIONS FOR CARS THAT ARE LESS THAN 10 YEARS OLD?" THE ANSWER WAS "CORRECT, YOU MAY PICK UP THE CAR". I WAS GIVEN NO INDICATION THAT WALDORF CHEVY CADILLAC OR GM WOULD ATTEMPT TO FIND ANY SOLUTION. WHEN I RECEIVED THE CAR BACK FROM WALDORF CHEVY CADILLAC, THE DOOR IS NO LONGER OPERATIONAL FROM THE INSIDE. I NOW HAVE A CAR WITH A PASSENGER SIDE DOOR THAT CAN NO LONGER BE OPENED FROM THE INSIDE. I HAVE BEEN LEFT TO DRIVE A VEHICLE THAT IS UNSAFE TO DRIVE WITH NO MECHANISM IN PLACE BY GM TO ADDRESS AN ISSUE THAT IS A DOCUMENTED DEFECT IN A CAR THAT IS LESS THAN 10 YEARS OLD AND HAS 30,000 MILES ON IT. I AM CONCERNED WITH HAVING TO DRIVE THIS VEHICLE WITH NO MEANS TO OPEN THE PASSENGER SIDE DOOR FROM THE INSIDE. THIS COULD RESULT IN TRAGIC OUTCOME IN THE CASE OF ACCIDENT, VEHICLE MALFUNCTION OR SOME OTHER INCIDENT REQUIRING IMMEDIATE EXIT FROM THE CAR. I AM AT A COMPLETE LOSS TO UNDERSTAND HOW GM CAN DISCONTINUE A PART IDENTIFIED WITHIN A TSB AS THE FIX FOR A KNOWN PROBLEM AND NOT PROVIDE SOME MEANS TO FIX THE SAFETY ISSUE OF THIS CAR. *TR

NHTSA ID

10643036

Incident

Sep 15, 2014

Mileage

30,000 mi

TL*THE CONTACT OWNS A 2004 CHEVROLET SSR. THE CONTACT STATED THAT THE PASSENGER SIDE DOOR HANDLE FAILED, WHICH PREVENTED HIM FROM OPENING THE DOOR. THE DRIVER'S SIDE DOOR HANDLE WAS REPLACED UNDER WARRANTY ON NOVEMBER 22, 2006. THE DIAGNOSIS FOUND THAT THE DOOR HANDLES WERE MADE WITH DEFECTIVE PLASTIC; THEREFORE, THEY BECOME PERMANENTLY INOPERABLE FROM THE INSIDE OF THE VEHICLE. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE REPAIR COST WAS ESTIMATED AT $377. A REPORT WAS FILED WITH THE MANUFACTURER, BUT THEY WOULD NOT ASSIST WITH THE REPAIR. THE CONTACT PLANS ON HAVING THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND CURRENT MILEAGE WAS 54,300. 4/01/09 *NJ THE DEALER FOUND A BROKEN INNER HANDLE BRACKET. UPDATED 04/09/09. *JB

NHTSA ID

10262035

Incident

Mar 5, 2009

Mileage

54,000 mi

SSR IS PARKED IN DRIVEWAY IN NOV 07. RECEIVE APPROX TWO INCHES OF RAIN, SSR LEAKED IN FLOOR ON PASSENGER SIDE. APPROX 1 1/2" OF WATER IN FLOOR. TOOK TO CHECK DEALER, DEALER OUTSOURCED PROBLEM. WAS TOLD THERE WAS A CRACK IN "A PILLAR". RESEALED PILLAR, PROBLEM SOLVED. RECEIVED THREE INCHES OF RAIN IN APR 08, SSR LEAKED IN FLOOR ON PASSENGER SIDE. APPROX 2" OF WATER IN FLOOR. TOOK BACK TO CHEVY DEALER, DEALER OUTSOURCED PROBLEM. TOLD LEAK IS DIFFERENT PROBLEM, TOLD CAR DOOR HAD TWO SIDED STICKY ADHESION WHICH WAS NOT STICKING TO DOOR, REPAIRED. I DON'T BELIEVE THIS SOLUTION SOUNDS CORRECT. *TR

NHTSA ID

10226756

Incident

Apr 29, 2008

Mileage

10,500 mi

THE CONVERTIBLE TOP CONTINUES TO HAS ISSUES. THE DEALER HAS REPLACED THE SEALS AT LEAST 4 TIMES, ADJUSTED THE WINDOWS 6-8 TIMES. CHEVY OFFERED TO MAKE A PAYMENT FOR ME BUT THE PROBLEM CONTINUES. I HAVE ALSO COMPLAINED ABOUT WIND NOISE AND LEAKAGE SINCE DAY ONE. *JB

NHTSA ID

10174246

Incident

May 30, 2004

RE: 2004 CHEVY SSR, HOOD PROP NOT STRONG ENOUGH TO HOLD HOOD UP. *BF THE HOOD PROP BENDS UNDER THE WEIGH OF THE HOOD. THE CONSUMER IS CONCERNED ABOUT THE POSSIBILITY OF THE HOOD PROP FAILING AND THE HOOD FALLING RESULTING IN INJURY OR DEATH. *NM

NHTSA ID

10098922

Incident

Jan 1, 1901

2004 CHEVROLET SSR: HOOD PROP FAILURE. THE FLIMSY HOOD PROP HOLDING THE GIGANTIC SSR HOOD IS BENT. I HAVE PURCHASED AN ALUMINUM HOOD PROP TO USE INSTEAD OF THE FAULTY FACTORY THIN PROP. MANY HAVE FAILED AND HOODS HAVE FALLEN ALL THE WAY CLOSED. MINE WOULD TOO WERE I TO CONTINUE USE. JG

NHTSA ID

10086739

Incident

Mar 6, 2004

Mileage

250 mi

TRUCK COMES WITH FLIMSY HOOD SUPPORT, NOT STRONG ENOUGH TO SUPPORT WEIGHT OF HOOD. FELL ON MY BACK.

NHTSA ID

10086566

Incident

Aug 10, 2004

Mileage

900 mi

VEHICLE: 2004 CHEVROLET SSR PROBLEM: FLIMSY HOOD PROP ROD AND A VERY HEAVY HOOD. THE ROD SLIPPED AND THE HOOD FELL. LUCKILY NO ONE WAS INJURED, BUT COULD EASILY HAVE BEEN. SOLUTION: THE 2005 CHEVROLET SSR IS REPORTED TO HAVE A SELF SUPPORTING PNEUMATIC LIFT. THE 2003 AND 2004 SSRS SHOULD BE RETROFITTED BY CHEVROLET AT NO COST TO THE OWNER.

NHTSA ID

10086516

Incident

Aug 8, 2004

Mileage

3,500 mi