2023 Chevrolet Tahoe Electrical Problems

When GM announced the recall involving the potential for catastrophic engine failure, I immediately contacted Bridgewater Chevrolet in NJ to schedule the required recall inspection. I was told the dealership could not perform the inspection because it had not yet received the required 'diagnostic tool' from GM. Once they received the equipment, they contacted me and on Oct 1, 2025, they completed the required recall inspection and informed me that my Tahoe had passed the recall inspection and that the vehicle was safe to continue driving. On XXX while driving over the Driscoll Bridge on the [XXX] with my daughter and our dog, the engine catastrophically failed without warning as I began to exit on exit [XXX] to [XXX] into heavy traffic. With no warning, the vehicle flashed that it was in neutral and then suddenly lost all power and stopped completely in a traffic lane, creating an extremely dangerous situation. After a few mins, I was able to get it started briefly, enough to coast along to a spot a few hundred feet away where there was a shoulder. From there the wheels locked and it would not move at all and windows would not open. It had to be dragged completely inoperable with locked wheels onto a flatbed three separate times. It was first dragged and flat bedded off the Parkway to a place we felt unsafe so we stayed locked in the car in July heat with no windows down, then to my mechanic and then to the dealership. I am unsure of the damage that may have caused. The dealership received the vehicle on XXX and within a day told me that it was indeed what my mechanic and they suspected - the catastrophic failure recall they had inspected and passed the vehicle for. As of today, XXX, I was told they just received an engine and can start a full replacement this week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755999

Incident

Jul 7, 2026

We had car checked due to strange and erratic shifting in less than a year of owning. Then took in for recall, they stated it was fine and performed the remedy with higher grade oil. Still had issues and took to another dealership to look at and they stated it was fine as well. About 2 months later while I was driving it was hesitating and would kind of buck and when I was about to turn on to a busy road it just stopped. I couldn’t do anything at all, the entire car was locked up. The tow truck driver couldn’t even get it into neutral to tow. Dealership said it’s the engine and it needs to be completely replaced.

NHTSA ID

11748582

Incident

Jun 9, 2026

2023 Tahoe Z71 had recently been put in the shop, and evaluated for engine failure recall. Dealership/GM deemed it failed test for replacement, we were given 0W40 oil and sent back out, this last weekend we had catastrophic engine failure while operating at 50+MPH.

NHTSA ID

11733261

Incident

Apr 19, 2026

At less than 50,000 miles, my alternator went out and had to be replaced, causing the battery to need to be replaced also. Now, at only 51,000 miles, my transmission is having problems and causing the vehicle to jerk when shifting. This vehicle has had regular maintenance performed by a combination of dealers and certified service centers since it was purchased brand new. I have never had this much trouble with a vehicle and am very concerned about it's overall safety and integrity, given the severity of the problems for something that is not old and does not have high mileage.

NHTSA ID

11729681

Incident

Apr 7, 2026

My 2023 Chevrolet Tahoe LS has experienced repeated service issues within the first year of ownership. The vehicle has been in the repair shop five separate times and out of service for approximately five months total. Due to extended repair periods, the mileage remains extremely low. A primary concern involved the steering system. The steering wheel was noticeably off-center while driving straight, requiring continuous correction to maintain proper lane position. Steering-related components were inspected and replaced. There were no warning lights present at the time. However, improper steering alignment raised safety concerns regarding vehicle tracking and stability. The vehicle has been inspected and repaired by authorized service providers. I am submitting this complaint to determine whether this reflects a broader safety-related issue with this model year.

NHTSA ID

11720383

Incident

Aug 31, 2025

Since 15,394 miles vehicle has experience multiple system failures upon vehicle startup. 2/24, 2/25, 12/25, 1/26. In all of these 4 instances the brakes become spongy/hard, steering wheel locks, and I am not able to control vehicle. Dash lights up; "Brake system failure - 43mph top speed", "Fwd collision system unavailable", "Service traction control", "Service ESC", "Service steering column lock", "Service brake pad monitor". Dealership has replaced, Telematic control module, Electronic brake control module (EBCM), Serial data gateway module, Park assist module and most recently they replaced the battery and cleared the codes to "fix" the same intermittent but recurring condition. In 11/24 Recall N242447990 was performed, reprogramming of Brake system control module and Serial Data Gateway Module, the exact same issue happened before and after the recall.

NHTSA ID

11719052

Incident

Jan 22, 2026

I purchased a 2023 Chevy Tahoe in Oct 2025. Since then, I have been trying to figure out how to set up the myChevrolet app. The OnStar button doesn’t work so I called OnStar. After multiple calls, they told me that the account is linked to the previous owner and can’t be transferred because of a faulty telematics communications module. The faulty module is also causing the clock to run slow, which indicates battery drain is beginning. The OnStar module failure poses a huge safety and privacy risk. Safety concerns include battery failure that can cause me to be stranded and the fact that the previous owner has the ability to start my vehicle at any time, even while parked in my garage posing a risk to my family’s health/life with trapped carbon monoxide building up. Privacy concerns include the previous owners ability to track my vehicle, lock and unlock doors, access my contacts, call log, location, and more. This is a significant risk. The dealership should not have sold me a vehicle with a defective module without repairing it and now refuse to fix it. This should have been included in GMs factory recall for 2023 Tahoe TCU’s or a new recall should be issued. Consumers should not bear the burden to fix a widely known safety, health, and privacy risk.

NHTSA ID

11714438

Incident

Oct 18, 2025

When I started my car at home, all of the dash warning lights came on, one after another. I put the car in reverse and started backing out of my driveway. I tried to stop but there were NO BRAKES! I slowly pulled back into my driveway and turned the car off. I had to take off work that day because I didn't dare to drive the car. The next day I started the car up and the check engine light was on. Luckily, I had brakes and I could go to work. Now, a day later, my engine light is not on. I made an appointment at the dealership. They can't get me in until mid February so I'm stuck with this problem, not knowing if the brakes are going to fail while driving. Oddly enough, when talking to a co-worker who has a 2023 Chevrolet Suburban, she recently had the same exact problem with her car. She has an appointment scheduled as well. I also read a complaint on this website that had identical problems. This car only has 8500 miles on it. It's still new! Someone is going to be killed or hurt very badly if this ever happens while driving. Please look into this.

NHTSA ID

11714006

Incident

Jan 26, 2026

As the owner of a 2023 Chevrolet Tahoe, I am currently experiencing persistent issues with the instrument cluster going dark and a severely malfunctioning GM 6.2L L87 engine. In November of the previous year, I encountered a sudden and alarming loss of engine power while traveling on a multilane highway at a speed of 70 mph. I successfully maneuvered the vehicle to a narrow shoulder, where I remained, accompanied by a Highway Patrol officer, for over three hours until a tow truck arrived. The GM certified dealership informed me that the engine was seized. The mechanics were unable to start or manually turn the engine. Upon removal of the engine’s oil pan, they found metal fragments in the oil. After having undergone an engine recall “fix” three months earlier, which included an inspection and oil service change to a more viscous 0W - 40, a new oil filter, and a new filler cap; in November, my engine failed and was replaced with a new 6.2L L87 engine. Initially, I was pleased with the repair, but I have since lost confidence that my car is safe after the new engine began exhibiting symptoms of a pending failure. The Tahoe hesitates on acceleration when merging with highway traffic, the engine dies when decelerating, the check engine light flashes at highway speeds, and the instrument cluster turns off at random. The vehicle that has been outfitted with a brand new engine is currently at the Chevrolet dealership; however, just like in August of 2025 during the Recall inspection, the mechanics there were unable to find any problems with their work or the new engine. They simply erased the stored P0300 engine diagnostics codes and ignored my evidence video, which showed the check engine light blinking at highway speeds. Despite the repair attempts, the issues have not been resolved, and the vehicle continues to pose a safety hazard.

NHTSA ID

11712732

Incident

Nov 25, 2025

Truck bucked twice in high-speed lane of the highway, gas pedal went soft and we luckily were able to coast the truck to the side of the highway without getting hit. The truck put itself in neutral when we lost the engine and the truck would not restart. It had to be towed, while me and my two kids stood on the side of a dangerous highway for 45 minutes in the snow. The truck has 52,000 miles, Engine was already replaced at 10,000 miles. It just passed the recall inspection and had the upgraded oil that was recommended.

NHTSA ID

11711945

Incident

Jan 17, 2026

The car was parked totally normal, went into a store, then came out to start it and when it was put in drive every light on the dash came on and gave a warning for “brake system failure top speed 43 mph” “service traction control” “service esc” “service steering column lock” “service brake pad monitor” “trailer brakes disabled service required”. Shut the vehicle off and restarted with same results. Brakes were inoperable and almost hit the car parked in front of me. Let the car shut down for a couple hours came back and started it and now everything acts normal except there is a Check engine light. Haven’t read the codes yet but am making an appointment at the dealer for warranty work.

NHTSA ID

11705492

Incident

Dec 16, 2025

The car presented steering lock column issues with repair lights on at 50 miles. Since then, they have repaired the system numerous times and replaced that system fully twice. They also replaced the manual start system and six other pieces of the car over 18 visits to two different Chevy dealerships. The car still reduces speed and stops acceleration, has electric issues in the windows, lights and gate etc.

NHTSA ID

11704193

Incident

Feb 5, 2025

The engine in my vehicle has experiences major failures in valve flap adjusters, multiple valve failures, valve cover issues, and over consumption of oil by over a quarter in a week and a half of average driving. My safety was put at risk because the engine failure resulted in traction control malfunctions while going 70 mph up hill on a major interstate. This led to extreme shaking which did not stop until slowing down to below 15 mph. Luckily I was a mile from an exit and was able to coast off the road quickly; it was decent enough weather, and I was less than 5 miles from my destination so I could creep between 15-30 mph to not exacerbate traction control alarms. That slow mph did back up traffic behind me. As far as I am aware the problem was likely reproduced by the dealership service tech, which led to their recommendation to replace the whole engine. They do not consider it to be covered by any warranty anymore. The engine may be in their possession still, but I am unsure. There were zero warning lights/prompts from the vehicle that anything was going wrong prior to the shaking and loss of traction control at high speed. The dealer service team suggested that my high miles led to the engine failure. I do highway driving with it and have followed all manufacturer recommendations for oil changes, and even more frequent changes with OEM oil since about 80k miles. I do not think this engine should have failed at this amount of mileage. I made note of oil consumption around 95k miles and measured oil loss regularly. It was a little less than a quart every 2K to 3k miles which manufacturer states is within spec so I would top off oil. A year ago it had a TCM wire replaced after burning in half. 3 weeks ago I also had to replace the entire turbo. The wire rendered my car unable to go in gear. The turbo failure put me into limp mode. I think the turbo failure was a sign of a deeper issue that went undiagnosed.

NHTSA ID

11691414

Incident

Sep 24, 2025

On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.

NHTSA ID

11690914

Incident

Jan 6, 2025

On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.

NHTSA ID

11690910

Incident

Sep 29, 2025

At a stoplight vehicle wanted to stall out Motor was shaking

NHTSA ID

11682781

Incident

Aug 24, 2025

The sounds from the radio works only 10% of the time, the radio sound also is what produces the turn signal blinking sound. Additionally there is a scratching noise coming from the speakers almost like a bad signal from the tuner. This is very distracting and a safety concern, especially when the turn signal does not audible make a sound. When I call Chevy they say it will be $300 to diagnose, and if you look online this is a known issue amongst newer model Chevy.

NHTSA ID

11666094

Incident

May 20, 2025

I filled my car up with gas and turned it on and it started shaking. Several warnings popped up on the dashboard screen including, Service ESC, Service traction control, And forward collision system unavailable. My cruise control was disabled I had to hold my foot at an angle to keep the speed at 45-50 mph, Causing it to take 10 hours for me to get home from Austin to Dallas. The check engine light was on the entire time and flashed for the last hour to hour and a half. I was unable to pull over at that time because it was dark And I was in the middle of nowhere by myself. The next day I turned my car on.The only thing on was the check engine light, Is , however , around 1 pm that day it Started doing the same thing. I drove it from My patient's house in allen To galleria chevrolet in Dallas. They told me my battery was too low to run diagnostics and I needed to replace it. So I bought a battery and brought it to them. They replaced the Next morning And told me there were no codes showing up so There was nothing wrong with my car and it was a fluke. Exactly one week later the same thing happened to my car. I called the dealership and they Hao it toewd to the service dept. After I repeatedly called them to check on the status of my car, they told me it was the fuel injector #1. They then were able to apply for a loaner car for me as I am a hospice nurse. These are same exact issues that the GM 6.2 L engines are having with the recall they just announced. I have a 5.3 L engine. I am afraid to put my kids in my car. Please help get GM to take responsibility for this!

NHTSA ID

11658044

Incident

Apr 6, 2025

While driving on the highway at high speed, my vehicle suddenly shut down and went into neutral. After a few minutes of trying to start it, it started and I was able to drive it home. The following day, on my way to the dealership for an inspection, while driving on a busy street, it shut down again. This time, it wouldn't restart, and I had to call the police and a tow truck to have it towed to the dealership. I was freaking out as I had my daughter inside the car with me. At that point, the vehicle had around 26,000 miles. The dealership inspected it and determined the engine was faulty and needed to be replaced. After the engine was replaced, the vehicle seemed fine, but recently, I've been experiencing problems again. The car struggles to start when it shuts off during stops, using the auto shut-off feature, and there's an intermittent hard shifting issue. It feels like the engine is failing again or maybe the transmission, but I've been told that unless the dealership can replicate the issue when I bring it in, they can't do anything. I'm concerned about being stranded on the road again, especially since my daughter is always with me. The vehicle’s engine and mechanical components don’t seem reliable, and I no longer feel safe driving it. However, I have no other option as it is my daily car for work and everything else. I’ve asked for an extended warranty from the dealership after the engine replacement, but I was told GMC doesn’t offer one for this issue. I’ve seen others on social media report similar problems, and I want to share my experience, as I’m just one of many customers facing this issue.

NHTSA ID

11653464

Incident

May 7, 2024

Repeated issues with the infotainment system had to be replaced 3 times to date. The motor blew at 49,000 miles 3 weeks ago. The replacement motor is on back order and it is very difficult to get a loaner vehicle, not to mention having to make a payment on the vehicle that I don’t have to use.

NHTSA ID

11647157

Incident

Feb 21, 2025

When we first purchased our 2023 Tahoe the engine was making a tiking noise we took it back and they told us it was because it was brand new time past engine always needs oil when we drive it u have to press gas pedal it also has electrical problems back camera turns on and off . Brake sensors don’t work . I almost had a bad car accident due to the engine that it had stop because it said reduced power while I was on a highway . I lost my son 3 yrs ago in a car wreck . I don’t want no more accidents so please help me figure some out with my Tahoe . I also went to dealership and they directed me to a manager . Manager never help never called back or nothing we bought truck at friendly Chevrolet

NHTSA ID

11646401

Incident

Feb 21, 2025

Traveling on the interstate late at night in the winter with my family, which includes small children, a clicking noise began but then went away. No diagnostic lamps came on, everything seemed fine, vehicle responded appropriately. Moments later, on a remote stretch of interstate, we lost power and the engine shut down. The vehicle would not turn back on. We were stranded in the dark on a freezing night.

NHTSA ID

11640037

Incident

Jan 24, 2025

After getting gas just outside of Pueblo Colorado on [XXX] I was entering [XXX] and luckily I was in the right lane when all of a sudden no power to the vehicle. I was able to make it by inches in the clear on the shoulder of the road. Being [XXX], I had trouble crawling over the console through the passenger side of the vehicle because I could not safely see the traffic on the interstate to exit the vehicle on the driver side. The state police could not come to assist us with any type of traffic control because of other accidents. The BNSF railroad has a mutual aid pack with them when needed in an emergency situation. They were able to come assist us with the red lights for traffic control, and the tow truck arrived and was able to flatbed the vehicle to a GM Chevy dealership. The tow truck also delivered our 26 foot travel trailer to the nearby campground. If it wouldn’t have been for the BNSF police this could’ve been horrendous accident because of the traffic. I have never been in a more scary situation as with the 2023 Tahoe built by a major corporation and being as unsafe as it is. I have been told the engine needs to be replaced because the bearings failed with metal fragments found in the oil pan. GM has been aware of this problem with the 6.2 engine for many years and has never done anything. Is it gonna take people getting killed on the highway to get something done. Sent from my iPad INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11639288

Incident

Dec 26, 2024

While driving, without warning my brake system failed and vehicle did not stop when I applied my foot on the breaks. In addition to while driving up a steep incline the engine failed as I was actively applying my foot to the gas pedal causing vehicle to roll backwards. Most importantly i do not feel confident using this vehicle any further knowing that the brakes are Not operating as they should, risking my life and my children’s life is nonnegotiable. Someone help please.

NHTSA ID

11638420

Incident

Jan 23, 2025

The contact owns a 2023 Chevrolet Tahoe. The contact stated that soon after purchasing the vehicle, the vehicle's lane assist feature would be active with no other vehicles in the contact vehicle's vicinity. The contact also stated that multiple other electrical defects would occur such as the backup camera activating while in drive(D), the instrument panel intermittently going blank, and various other defects. The vehicle was taken to the dealer on multiple occasions where they failed to duplicate the failure. The contact then stated that while driving at 80 MPH, the instrument panel went blank. The contact attempted to pull the vehicle over; however, an unknown turn-off of the vehicle warning message appeared on the instrument panel as a warning chime was also emitted from the vehicle. The contact then stated that the vehicle then came to an abrupt stop where the engine and brakes seized, while traveling at 34 MPH. Due to the failure, the contact was taken to the hospital where they were treated for whiplash, inflammation in the neck and spine, 7 bulging discs in the spine, and pain in various parts of the body. The vehicle was towed to a dealer where it was diagnosed with engine failure; the vehicle's engine was replaced under warranty. Despite the repair, the contact refused to take possession of the vehicle as they did not feel safe driving the vehicle. The manufacturer was notified of the failure and a case was filed; the contact had yet to receive any assistance from the manufacturer. The failure mileage was approximately 15,000.

NHTSA ID

11637289

Incident

Sep 3, 2024

Mileage

15,000 mi