2023 Chevrolet Tahoe Powertrain (other) Problems

[XXX] Diagnose on XXXX vehicle shudder dealer stated felt some tire vibration. Back to the dealer in August same issue. Tahoe shudder and misfiring first seen by [XXX] chevy of [XXX] on XXX stated it the DFM and its very pronounced. There is no correction that can be made to change this shudder. XXX service transmission, not able to shift soon warning light came on while driving down the road multiple times. Dealership stated caused by low voltage charged battery and sent me on my way. went back and GM had them to check battery over again and again and they finally replaced my battery. XXX back in the shop at Bentley Chevrolet Florence AL. kept 2 weeks. Stated shudder is a normal operation from the GM tech. also received a misfire code as it clearly is missing while at idle it almost acts as if its going to go dead at a red light. tach case # XXXBentley tech stated that GM reviewed data their response was this is a normal operating condition. This vehicle has only 23,000 miles its a 2023 Tahoe z71 and still under the powertrain warranty, but they refuse to fix the misfire acting like its going to go dead at a red light. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11767272

Incident

Jun 20, 2026

I am filing this safety complaint regarding the sudden and unexpected transmission failure of my 2023 Chevrolet Tahoe at approximately 110,000 miles. My transmission failed without any warning, creating a serious and frightening safety concern. There was no advance indication that I was about to experience a major mechanical failure. A transmission failing unexpectedly creates the potential for an extremely dangerous situation, particularly when traveling at highway speeds, navigating intersections or driving in heavy traffic. I purchased this vehicle brand new and have consistently had it serviced at Bergstrom Chevrolet of Madison. My maintenance history includes approximately 20 dealership visits between January 2023 and July 2026. Despite this extensive service history, the transmission failed less than four years after I purchased the vehicle. I am extremely concerned that such a critical component could fail without warning. An unexpected transmission failure can put the driver, passengers and surrounding motorists at risk, particularly if the vehicle suddenly loses its ability to accelerate or maintain speed. The Chevrolet dealership diagnosed the transmission failure and provided an estimate of approximately $7,500 for replacement. I contacted General Motors to report the failure and request assistance. GM denied my request solely because the vehicle had exceeded its warranty mileage. When I asked whether the decision could be appealed, I was told no appeal was available. My primary concern is the safety implications of this unexpected failure. I believe this incident warrants investigation to determine whether other owners of 2023 Chevrolet Tahoes may be at risk of experiencing similar transmission failures without warning. I am requesting that NHTSA review this incident and determine whether a potential transmission safety defect exists.

NHTSA ID

11767179

Incident

Sep 19, 2026

Water pump failed. The part is on back order with an ETA of October 29. Vehicle is currently at the dealership. I received no alerts before failure.

NHTSA ID

11766270

Incident

Aug 17, 2026

I am writing to express my disappointment with how the L87 engine recall was handled on my 2023 Chevrolet Tahoe. I purchased this vehicle for approximately $82,000 and brought it to Kunes Chevrolet in Lake Geneva multiple times for scheduled maintenance. During my first visit after learning of the recall involving potential connecting rod and crankshaft defects, I specifically asked when my vehicle would be inspected and repaired. I was repeatedly told that I would receive additional information in the mail and that I would be contacted when repairs became available. Over the course of several oil change visits, I continued to ask about the recall. Each time, I received essentially the same response. During my most recent visit, I was informed that when the recall procedure became available, the dealership would listen to the engine with a stethoscope and then determine whether the vehicle required repairs or only a switch to a heavier oil viscosity. As a customer who invested $82,000 in a full-size SUV, I found that response extremely disappointing. The recall concerns involve engine components that could potentially lead to catastrophic engine failure. Being told that the solution may simply be listening to the engine and installing thicker oil did not inspire confidence in the long-term reliability of the vehicle. Ultimately, my confidence in both the vehicle and the handling of this recall deteriorated to the point where I no longer felt comfortable taking long trips with my family. I made the difficult decision to trade the vehicle in less than two years after purchase, resulting in an approximately $26,000 financial loss. I believe customers who invested significant amounts of money in these vehicles deserved clearer communication, a more proactive response, and a solution that restored confidence in the product. Unfortunately, my experience left me with serious trust concerns regarding both this recall process and General Motors' customer commitment.

NHTSA ID

11759440

Incident

Oct 1, 2025

I have a 2023 Chevy Tahoe with 45k miles. Today driving two kids home from our football practice I was driving along at around 40mph and all of a sudden the transmission downshifted and almost locked the rear tires up. If it was winter, wet, or cool, there is no doubt that the tires would have locked up. Check engine light came on, and now the vehicle wont move in reverse and at around 45-50 mph the engine is running at 3,000 rpms. I volunteer to be a youth football coach and always have a car full of children. This isn't normal or safe. P.s. I should've bought the Ford Expedition.

NHTSA ID

11755139

Incident

Aug 5, 2026

Rear wheels suddenly lock up momentarily during downshift at 30-50 mph (most reproducible 35-40). Transmission in a high gear (8th-10th); any throttle input commanding a downshift can trigger it: as the downshift executes, rear wheels briefly stop, skid with an audible chirp, vehicle jerks violently. Reproducible on demand, multiple times per drive, on video. Highest-speed event ~50 mph, family aboard. NO advance warning: no check engine light, no message, no stored code, no gradual onset. Traction control sometimes activates at the instant of the skid, sometimes not — always reacting to traction already lost, never before. A driver has no opportunity to anticipate or react. THIS IS A LOSS-OF-CONTROL HAZARD. It is especially dangerous in a turn, on wet pavement, or in traffic. Onset May 2026. Pursued repair since, across three shops: an independent, twice (no codes/leaks/abnormal findings; MAF replaced; unresolved; referred to dealer), then a GM dealer 3 days (test drove 34+ miles, no codes, fluid good, all shifts correct; declined recommended control-module recalibration, cause unconfirmed). Lockup recurred within 5 miles of leaving, same day; I returned immediately, asked for a tech ride-along while fresh — did not occur. Next day, a second GM dealer: tech note said fluid was low, though the same RO's inspection passed that fluid and found no leak; no leak ever identified anywhere. Paid $672 for a fluid exchange — unresolved. Days later, same dealer measured 265F on a 30-mile road test and condemned the transmission. Full replacement underway, largely out of pocket. Symptom matches recall 26V-085 (momentary rear wheel lockup, worn control valve, 10-speed/ETRS) covering 2022 models. My 2023 is not included. I am not asserting a diagnosis — no one has established the cause — but I ask ODI to consider whether that campaign should include additional model years. The failed transmission is available for inspection; videos available on request.

NHTSA ID

11751780

Incident

May 1, 2026

While traveling out of town on the highway,we had a sudden loss of power. My vehicle wouldn’t accelerate or shift. My check engine light came on and a message displayed that said something about reduced power. After limping to a dealership while in another city, I managed to wait hours for my husband to pick me and my children up. We waited several days for the dealership to tell us it was the valve body that needed replaced. My vehicle was NOT in the original recall for the valve body, although we experienced the exact same issues that the recalled vehicles experienced. This entire experience was horrifying. Along a stretch of highway that I was unfamiliar with, speed limits of 80mph, and a sudden, complete loss of motor power and speed, this could have someone. I had a vibration while staying at any constant speed for months prior to this, I had taken the vehicle in numerous times but was told the only thing to fix it was a software repair and that wouldn’t take care of the problem entirely. This vibration was and still is so bad that my phone will fall from the magnetic mount if I don’t let off the accelerator or increase acceleration. My vehicle still doesn’t seem to run properly but I am unable to get it to reproduce any issues when at the dealership. Extremely unnerving to travel with my family out of town or state and wonder if my fairly new vehicle will make it.

NHTSA ID

11751779

Incident

May 1, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at 40 MPH, a warning message advising to reduce acceleration was displayed, the Check Engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the failure was recurrent. The dealer was notified of the failure and diagnosed the vehicle with a valve failure. No further information was available. The manufacturer was notified of the failure. The failure mileage was approximately 57,000.

NHTSA ID

11743755

Incident

Jun 9, 2026

Mileage

57,000 mi

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at 75 MPH, the vehicle shut off without warning. Due to the failure, the contact used excessive force to steer the vehicle off to the shoulder of the highway where the vehicle was then towed to a dealer. After the vehicle remained in the dealer's possession for over a week, the vehicle was diagnosed with an engine failure. The contact was then informed that the vehicle was placed under recall NHTSA Campaign Number: 25V274000 (Engine) and that the engine would be replaced. Despite the engine repair, the contact stated that an abnormal, rattling sound would emit from the vehicle upon start of the engine. In addition, the contact stated that the vehicle would violently jerk upon depression of the accelerator pedal while at a complete stop. The failure started intermittently; however, the contact stated that overtime the failure became more persistent. The vehicle was taken to the dealer where they claimed that the transmission was four quarts low on transmission fluid; they then informed the contact that they could not guarantee that remedy would repair the failure. The contact stated that failure improved; however, she would still experience a slight hesitation upon depression of the accelerator pedal. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 39,000.

NHTSA ID

11737295

Incident

Apr 1, 2025

Mileage

39,000 mi

Engine stopped while driving 70 mph down the highway and the car shifted into neutral. Had to cost to side of the road. Took car into dealership and even though the car was certified safe drive and the engine had no issues 5 months ago, I was told the engine was now locking up. The engine failed despite using the higher viscosity oil that chevy recommended. These greedy cunts at chevy placed me and my family's lives in danger to save a buck; they knew that the engines would fail and instead of replacing the engines, they put thicker oil in the cars to hopefully get the cars past warranty.

NHTSA ID

11734750

Incident

Apr 29, 2026

Transmission has had a failure to shift problem on several occasions resulting in deceleration and a decreased ability to accelerate. This has occurred on most occasions at highway speeds while passing a vehicle causing a very unsafe condition. Dealer has evaluated and determined the transmission valve body is defective and needs replaced. Upon researching the problem, many similar GM vehicles are experiencing the same issue

NHTSA ID

11734300

Incident

Jan 23, 2026

The engine randomly shut off while driving down the interstate and wouldn’t start back up. The car had the recall “remedy” done to it. Inspection and thicker oil. The only warning I got was to restart the engine after it shut off. My safety was compromised by breaking down on a main interstate coming through Memphis with no emergency lane to pull over in.

NHTSA ID

11733812

Incident

Apr 17, 2026

At less than 50,000 miles, my alternator went out and had to be replaced, causing the battery to need to be replaced also. Now, at only 51,000 miles, my transmission is having problems and causing the vehicle to jerk when shifting. This vehicle has had regular maintenance performed by a combination of dealers and certified service centers since it was purchased brand new. I have never had this much trouble with a vehicle and am very concerned about it's overall safety and integrity, given the severity of the problems for something that is not old and does not have high mileage.

NHTSA ID

11729681

Incident

Apr 7, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving 50 MPH, the transmission unexpectedly downshifted before the engine seized. The check engine warning light was illuminated, and the reverse(R) indicator was flashing. The contact was unable to restart the vehicle. The semi-truck behind the vehicle almost crashed into the rear of the vehicle. After several minutes, the contact was able to restart the vehicle; however, the failure reoccurred. The check engine warning light illuminated, and the reverse(R) indicator light was flashing. The contact was able to restart the vehicle and pulled over to the side of the road. The vehicle failed to accelerate 5 MPH. The contact drove back to the residence slowly. The contact arrived at the residence, and the vehicle failed to shift into reverse(R). The vehicle was towed to the dealer. The vehicle remained at the dealer unrepaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11725684

Incident

Mar 19, 2026

Mileage

70,000 mi

The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) in November 2025 by the local dealer. The contact stated that the engine had passed the inspection, and a higher viscosity oil had been added along with the other steps stated in the recall. The contact stated that while driving approximately 55 MPH, the accelerator pedal was depressed; however, the vehicle failed to respond. The gear shift indicator indicated that the transmission had been shifted into neutral(N). The contact attempted to shift to drive(D) when the vehicle stalled. The vehicle was stopped but was unable to restart the vehicle. The vehicle was towed to the same dealer who had completed the recall repair. The dealer diagnosed the vehicle and determined that the engine, starter, radiator, and fuse block needed to be replaced. The vehicle was being repaired. The manufacturer was informed of the failure and a complaint was filed. The failure mileage was approximately 48,000.

NHTSA ID

11720668

Incident

Feb 9, 2026

Mileage

48,000 mi

Truck bucked twice in high-speed lane of the highway, gas pedal went soft and we luckily were able to coast the truck to the side of the highway without getting hit. The truck put itself in neutral when we lost the engine and the truck would not restart. It had to be towed, while me and my two kids stood on the side of a dangerous highway for 45 minutes in the snow. The truck has 52,000 miles, Engine was already replaced at 10,000 miles. It just passed the recall inspection and had the upgraded oil that was recommended.

NHTSA ID

11711945

Incident

Jan 17, 2026

I asked the dealer for information about the L87 6.2L engine rod bearing failure recall. I was told that they wouldnt perform the work until i recieved a letter from GM. This was when i got my first oil change. Then every oil change after that i asked the same question. At 43401 miles i parked the vehicle and havent driven it since. I am afraid to have something happen to me or my family. I paid $82,000.00 for a vehicle that GM's fix is to add thicker oil. I think that the rods and bearings should at least be visually inspected. The dealers maintenance manager at Kunes Lake Geneva says theyll listen to it with a stethescope. If it sounds ok theyll change the oil. I paid way to much to chance my familys safety on thicker oil. To make the situation better the vehicle blue books for $56,000.00 IT DEPRECIATED $26000.00 IN TWO YEARS. That is unacceptable.

NHTSA ID

11707716

Incident

Aug 10, 2023

2nd Powertrain failure in 4 months in 2023 Tahoe with 6.2L engine. The first being the Camshaft and lifters failing at highway speeds, which was repaired. The second issue the engine seized while on a tollway going approx 70 MPH with my spouse, children, and family in the vehicle. We were able to coast to the shoulder while waiting on a tow truck. Because of the engine being seized, the Tahoe is waiting on the engine to be replaced. While we wait, we were told they have no loaner vehicles and there are no GM rental vehicles available with who they contract through. Having a 2023 leased vehicle fail twice in 4 months with children in the vehicle is unacceptable and brings to question the safety and reliability of the vehicle moving foreward.

NHTSA ID

11696297

Incident

Oct 18, 2025

I was driving on an interstate when the vehicle check engine light came on and it went into limp mode causing the vehicle to go into low speed in the middle of traffic. Check engine light code P0747

NHTSA ID

11694402

Incident

Oct 18, 2025

While traveling on [XXX] approximately 20 miles west of Rawlins WY the vehicle entered “limp mode” causing us to drive at an unsafe slow speed. The transmission caused a check engine light to activate which was confirmed by a service technician in Rawlins with a PO747 code show on his OBD2 scanner. The problem was confirmed by the servicing dealer in Lincoln NE. The transmission was inspected by the servicing dealer. They replaced the valve body and fasteners approximately 1 1/2 months later. The problem first occurred at the time of the incident and I had no prior warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11688021

Incident

Jul 16, 2025

Torque converter needed to be replaced, and then a week later still had the same shuttering and loss of power and the valve body needed to be replaced. Got it back and it still is shuddering and hard shifting.

NHTSA ID

11682088

Incident

Jul 30, 2025

Our 2023 3L diesel Tahoe had 63,000 miles on it and went into limp mode (CEL on) in late April 2025. We took it to the dealership and they diagnosed the valve body as the problem. We continued to drive it (as they mentioned it would be months before a replacement part would be in) while I did some research and discovered the magnitude of the problem. Just google it! Meanwhile, the rear wheels locked up on me after I had picked up our two children from daycare. It felt like we had a log chain hooked to our hitch that snapped us back - really hard! Felt like we had been rear-ended. This could have easily caused us to get in an accident, or worse, but thankfully we were not in heavy traffic. Our dealership was able to provide us a loaner truck. Approx. 50 days later, we were informed that we were approved for a new transmission - which was also on backorder! Almost 80 days later, our new transmission has arrived and been installed. We are very disappointed with how GM has handled the issue. We were lucky our dealer provided a loaner, as many have not. There are after-market providers who clearly state the upgrades they've made to the valves bodies, and while GM says they've upgraded the ones they make now, they won't share any details. I'm aware of this same limp mode/rear wheel lock up happening multiple times (on the same vehicle) to people in very low-mileage vehicles (less than 1000 miles). This isn't a small problem, and GM knows it. We will see how far we get with this "new" transmission, but as you could guess, I don't have high hopes! I just pray that no one gets killed.

NHTSA ID

11674252

Incident

Apr 28, 2025

Engine light came on. Flagged for a bad transmission valve body. Informed by dealership that the piece is on backorder and has been on back order for months.

NHTSA ID

11672560

Incident

Jun 3, 2025

Transmission issue. Vehicle has the Duramax Diesel with 10-speed transmission. I am aware of issues with earlier year/s transmissions. I have experienced shuddering, jerking, a SINGLE momentary rear axle lockup. Jerky engagement from drive to reverse and or back. Reduced Acceleration warning on display. Check engine light comes and goes. Waiting for dealer to further inspect, drain fluid, etc. It appears from the VIN check that this vehicle had some metal work/paint prior to delivery to selling dealer, paint does not match. The transmission issue at 15,000 miles is just plain scary and not what one expects. That this vehicle sold as a 2023 has same issues as earlier model years makes me wonder if this is in fact a late 2022 model with the known defective transmission valve body? Any help appreciated.

NHTSA ID

11671104

Incident

Jul 3, 2025

While traveling on the highway, the vehicle suddenly lost all power. The gas pedal became unresponsive, and the engine ceased functioning entirely—without any prior warning or indicators. I was forced to coast into a nearby parking lot to prevent a potential collision. This incident put both myself and my child at serious risk of injury or worse, had it occurred at a higher speed or in heavier traffic. Once stopped, the vehicle would not restart. I had no choice but to have it towed to the dealership for evaluation. A week later, the dealership diagnosed the issue as a locked-up engine, confirming that a full engine replacement is necessary. Unfortunately, the replacement engine is currently on backorder, and they are unable to provide an estimated time of arrival. To make matters worse, the dealership has no loaner vehicles available for at least a month. GM only offers a rental reimbursement of $44 per day, which is significantly below the cost of even a basic rental vehicle in our area ($74/day). This leaves me with limited transportation options, even though I am currently making monthly payments of over $1,400 on a vehicle that is completely unusable. Adding to the severity of this situation, the vehicle is also subject to a manufacturer recall, but no remedy or parts are currently available to resolve the issue. As a parent of multiple children, this entire experience has left me shaken. I cannot begin to imagine the consequences had this failure happened at a higher speed or in less forgiving conditions. I am extremely concerned for my family’s safety going forward. GM has stated they will not extend or provide additional warranty coverage until the repair is complete, which leaves me feeling unprotected and anxious about the future reliability of this vehicle. The absence of warning signs and the total loss of power while driving make this a critical safety concern that must be addressed. I urge NHTSA to hold the manufacturer accountable.

NHTSA ID

11669503

Incident

Jun 19, 2025