2023 Chevrolet Tahoe Engine Problems

6.2L L87 V8, connecting rod / crankshaft bearing failure even after I passed the recall inspection at a dealership. On [XXX], I was traveling approximately 55Mph and my engine completely shut off as well as the entire vehicle electronics. I lost power steering capabilities, and my brakes felt like they were kicking back at me. I was at crash risk from loss of power in traffic along with the loss of steering abilities, but I was lucky and was able to avoid traffic and get into the shoulder from 2 lanes away and slow to a stop. I got lucky because the loss of power steering made control extremely difficult. On [XXX], I brought my vehicle to All American Chevrolet in Middletown NJ for the safety recall N25249003 with 16,219 miles on my Tahoe. A few hours later I was called and said my engine was fine and passed inspection. On the day of failure, my car only had 21,111 miles on it. So, my engine still failed even after the oil change, and inspection process and it was extremely dangerous, after only 4,892 miles after their safety inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11775347

Incident

Aug 7, 2026

I own a 2023 Chevrolet Tahoe equipped with the 6.2L V8 engine. The vehicle has experienced repeated significant engine problems, including a previous complete engine replacement and subsequent issues with the replacement engine. The original engine required replacement due to engine-related problems. Following that replacement, the vehicle developed lifter noise and required another extended stay at the dealership for repairs. The vehicle has now been out of service for approximately 4–5 weeks while the dealership attempts to diagnose and repair the issue. After the dealership completed work to address the lifter noise, the technician identified an additional concerning engine noise. The dealership has since reported suspected bottom-end damage in the crankshaft area and has escalated the findings to GM engineering for further diagnosis and repair recommendations. I am concerned about the recurring internal engine failures, particularly given that this is the second engine installed in the vehicle. These problems raise serious concerns about the reliability and safety of the 6.2L engine. A failure involving the crankshaft, connecting rods, or internal engine bearings could potentially result in sudden engine failure or loss of power while driving. The vehicle has been inspected by an authorized GM dealership, and the current suspected damage has been reported to GM engineering. The final diagnosis and recommended repair are still pending. I am requesting that NHTSA review these repeated engine failures, including failures involving replacement engines, and investigate whether there is an ongoing safety or manufacturing defect affecting these vehicles.

NHTSA ID

11774593

Incident

Sep 3, 2026

The car had the recall done for the engine issues 1 year ago. Pico test past and oil was changed to new oil. All service is handled by Chevrolet dealer. Now the issue. After leaving home and driving on a highway for about 25 minutes I received lights on the dashboard indicating. Several issues. Flashing engine light, ecm issue amoung some others. I then noticed what sounded like a missfire of the engine. Since I was on my way out of town I decided to turn around and take directly to dealer. I dropped the car off. When I finally turned the car off at the dealer lot and restarted it I also noticed metal clanging coming from engine. The next day I was texted by the dealer that I would be getting a new engine. Car has 78,644 miles.

NHTSA ID

11773464

Incident

Oct 22, 2026

AT 60,720 ON CAR MILES ENGINE FAILED. THIS IS THE SECOND ENGINE FAILURE. DEALERSHIP PERFOMRED TEST PER RECALL ON SECOND ENGINE, AND ENGINE FAILED LESS THAN 30,000 MILES LATER. EXPERIENCED LOSS OF POWER FOR A FEW MINUTES BEFORE FAILURE. THE REPLACEMENT ENGINE HAD 52,000 MILES ON IT.

NHTSA ID

11772383

Incident

Oct 12, 2026

The AFM/DOD system failed and resulted in lifters and rocker arm failure.

NHTSA ID

11771099

Incident

Oct 1, 2026

On 4/23/25, the check engine light came on and the vehicle reduced power. It was taken to dealership and a warranty service was performed, L87 Engine loss of propulsion. The vehicle was in service for 90 days. On 7/15/26, vehicle shifted itself into neutral while driving on the highway, with 4 kids in the car. This is a safety issue for our family and all around us, as car loses ability to drive at interstate speeds. It would not go back into drive, needed to pull over and get towed to dealership. Dealership diagnosed it needed a new engine and radiator; it was in service for 60 days. On 10/10/26, vehicle shifted itself into neutral while driving with one kid in car while driving on the highway. Vehicle gave the "conditions not correct for shift" and would not go back into drive. Vehicle was shut off and was stalled on the highway, after a time of it being off, vehicle started back up and the check engine light was on. This is a safety issue for our family and all around us, as car loses ability to drive, once again, at interstate speeds.

NHTSA ID

11770617

Incident

Oct 10, 2026

First occurrence was 2/03/24 check engine light came on felt stumble in engine continued driving to get home set up appt with dealership. They codes P318C and P318F were present numerous things were checked and found excessive crank shaft end play, removed oil pan and found thrust bearing in bottom of pan broken into pieces. GM authorized engine replacement. The vehicle had 4,603 miles on it. Repairs were completed and vehicle picked up 03/12/24 Second occurrence was 05/28/26 while driving at interstate speeds heard squeaking noise then knocking sounds coming from engine was able to make it home and had vehicle towed to dealership the next day. This time no codes but was determined to be defective engine and was replaced again mileage on vehicle this time was 33,521 miles I started using the 0w/40 oil as soon as recall came out actually before I received information in mail I am hearing rods rattling at start up now until oil pressure picks up on the latest engine installed but it still is running at present time.

NHTSA ID

11769927

Incident

Feb 3, 2024

I was picking my Tahoe up after a replacement on the blown motor was complete. (L87) I started it and immediately knew something was wrong. I reported it to the service advisor and the response was there were no warning lights so it must be fine. I asked them to sit in my car and they agreed it was not running right. They took it back and replaced a sparkplug that was causing the #2 cylinder to misfire. Almost 3 months later I was driving on the freeway when my Tahoe felt like it was going to stall. Again I had no warning lights appear. The diagnostics showed the same #2 cylinder misfiring caused by another sparkplug issue. This is all within 2,500 miles on a brand new engine.

NHTSA ID

11769920

Incident

Sep 27, 2026

While traveling on I-684 at highway speed, my 2023 Chevrolet Tahoe with 43,000 miles suddenly shut off without warning and automatically shifted into neutral. I had a complete loss of propulsion. As a car guy who has been following the GM 6.2L engine recall issue, I suspected it could be that. I was traveling in the left lane and had to carefully coast across active lanes of traffic to reach the shoulder. My wife and two young children were in the vehicle, and the sudden loss of propulsion created a significant risk of collision. There were no warning illuminations, messages, or other symptoms that I observed prior to the failure. The vehicle was subsequently towed to my Chevrolet dealer for diagnosis and is available for inspection upon request. As confirmed by the dealer, the engine completely seized causing the loss of propulsion. I will also share, about 1 year ago after the GM recall was issued, I took my truck back to the dealer. They cleared the engine for the propulsion issue, changed the oil for 0W40 and changed the oil fill cap in line with GM recall standards.

NHTSA ID

11769467

Incident

Oct 2, 2026

* Lifter bores and camshaft. yes * The vehicle started to shake and started sending out alerts for multiple problems while we were driving on the interstate * Yes. Bale Chevrolet estimated approx. $10,000 repair bill * No. It's currently at the dealership * As the car began to shake we started receiving numerous warnings, but not prior to the shaking.

NHTSA ID

11768276

Incident

Sep 26, 2026

I am submitting this complaint regarding my 2023 Chevrolet Tahoe equipped with the GM 6.2-liter V8 engine. VIN: [XXX]. At approximately 40,000 miles, the original engine experienced a major failure and was completely replaced by a Chevrolet dealership under warranty. I have now driven fewer than 10,000 miles on the replacement engine and am experiencing a very similar engine-related problem again. The vehicle is currently back at the Chevrolet dealership being inspected and repaired. This is extremely concerning because the original engine failed at only approximately 40,000 miles, and the replacement engine has developed a similar problem after fewer than 10,000 miles. The GM 6.2-liter V8 has been the subject of numerous reported engine problems and complaints, and I believe this repeated failure warrants NHTSA’s attention. I am concerned there may be an underlying or recurring defect affecting these engines that has not been adequately addressed. I am also concerned about the potential safety implications of an engine or valvetrain failure while driving. An unexpected loss of power or significant mechanical failure could create a dangerous situation, particularly at highway speeds or in traffic. I can provide dealership documentation showing the original engine replacement, the mileage at which it occurred, and the current repair visit. This documentation establishes that the vehicle has experienced significant engine-related problems twice within a relatively short period, including a similar problem with the replacement engine after fewer than 10,000 miles. I respectfully request that NHTSA document this complaint and review whether there is a broader pattern of premature or repeated failures involving the GM 6.2-liter V8 used in 2023 Chevrolet Tahoe vehicles and whether further investigation or corrective action is warranted. Replacing the original engine did not resolve the issue, as the replacement engine has now developed a similar problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA ID

11764926

Incident

Aug 28, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and was unable to restart. The message "Engine Overheating - Stop Driving Immediately" was displayed. The vehicle was towed to the dealer, who determined that the engine had failed, and the engine was replaced. The manufacturer was notified of the failure by phone. The failure mileage was 32,295.

NHTSA ID

11764668

Incident

Jun 24, 2025

Mileage

32,295 mi

We were driving on the highway and the engine started making a ticking noise and AFM light came on. Took the car to the dealership for inspection and they said the lifter had collapsed and it would cost $1000 to tear the engine down to see if the camshaft was damaged. Asked for the estimate to replace camshaft and lifters and they quoted $10,000.

NHTSA ID

11764400

Incident

Aug 20, 2026

Our Tahoe was included in the recall. The dealership inspected it, found no issue at the time, and told us to switch to a different oil viscosity, which we did. This vehicle has only ever been serviced at a Chevrolet dealership. On August 20th, while driving on the highway, the engine shut off without warning and we had to coast to the shoulder. We attempted to restart it several times, but the engine would not hold an idle. After shutting off all accessories, including the A/C and radio, the vehicle finally started. We brought it back to the dealership for inspection, and once again they could not find any issue. Today, September 14, 2026, we heard loud clanking coming from the engine. We pulled over immediately and had the truck towed to the dealership. At this point, we believe the engine is no longer serviceable and will need to be replaced. We do not believe the change in oil viscosity is an adequate fix for the 2022 to 2024 6.2L engines covered under the GM recall, including the one in our Tahoe. An engine dying without warning at highway speed is a serious safety hazard, and we were fortunate it didn't end in a collision.

NHTSA ID

11764113

Incident

Sep 14, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated there was a misfire in the engine, with the engine warning light illuminated. The message “Collision Mitigation System Off” was displayed. There was a burning odor coming from the vehicle after the failure. The vehicle started shaking abnormally. The vehicle was taken to the local dealer, where it was diagnosed and determined that the lifter and crankshaft needed to be replaced. The contact purchased a rebuilt engine, and the engine was replaced at another service center. The failure mileage was approximately 82,000.

NHTSA ID

11764103

Incident

Sep 3, 2026

Mileage

82,000 mi

Hard shudder when driving between 45 to 50 mph and when you decelerate around 12 to 15 mph. Inspected at Lond Lewis Chevrolet stated and now being inspected by Bentley Chevrolet due to Lond Lewis Chevrolet doing absolute nothing. Tahoe has 23,000 miles currently. Bought new one owner always serviced as should.

NHTSA ID

11763723

Incident

Jun 10, 2026

1 week and 1 day later we are stranded again on the side of highway going full speed in our Tahoe. We took it to two different certified Chevy dealerships and they gave us a vague resolution and this issusr is not fixed at all. Our engine is locking up on us at full speed on the highway. This vehicle has 83,000 miles on it and we’ve maintained this vehicle very well.

NHTSA ID

11762588

Incident

Sep 7, 2026

We were driving full speed down the highway and the vehicle completely shut down steering wheel locked and we were stranded for six hours. Turns out the dealer said it was just the battery and they fixed the grounding of the battery. I’m sorry but I’m not satisfied with this response. I’m scared to drive this vehicle.

NHTSA ID

11761638

Incident

Aug 29, 2026

A couple weeks ago, the truck suddenly started running rough and the front collision avoidance system failure message displayed. Immediately took it to the dealership. Computer read out showed #7 fuel injector failed. Repaired and was fine. Yesterday, 8/27/26, same thing happened again. Immediately went to the dealership. Now #4 fuel injector failed. Service manager just called and states that Chevrolet does not have that injector and on backorder with no date of expected delivery. No other Chevy dealer has #4 fuel injectors either. Tells me that there is an overwhelming demand for fuel injectors that indicates a defect. Meanwhile, the truck is out of service and GM is not addressing the issue to replace all the defective injectors.

NHTSA ID

11760405

Incident

Aug 27, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was taken to a dealer, where the NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) remedy was completed with an oil change and oil cap replacement. Approximately three months later, while the contact's wife was driving approximately 45 MPH, the engine stalled. The driver was able to coast to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the engine had failed. The engine was replaced. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 22,000.

NHTSA ID

11760258

Incident

Aug 28, 2026

Mileage

22,000 mi

My 2023 Chevrolet Tahoe (VIN: [XXX]) suffered a catastrophic failure of the 6.2L V8 L87 engine assembly — specifically the connecting rod and crankshaft components — at freeway speeds on [XXX], just 9 days after purchase. The original failed engine is no longer available for inspection as it was removed and returned as a core by Shaheen Chevrolet in Lansing, MI as part of the warranty replacement process. The only symptom prior to failure was a brief squeaking noise that began approximately 0.5 miles before the engine failed. No warning lamps, messages, or other indicators appeared at any point before the failure. The engine then failed suddenly and completely at freeway speed, causing immediate loss of propulsion. My family was left stranded in an unsafe roadside location until a tow truck arrived. Sudden loss of power at freeway speeds creates significant risk of collision for both the vehicle's occupants and surrounding motorists. The failure was inspected and confirmed by Shaheen Chevrolet as a GM manufacturing defect involving the connecting rod and crankshaft. No police, insurance representatives, or GM field engineers inspected the vehicle beyond the dealership. GM authorized a full engine replacement under Special Coverage warranty (10 years/150,000 miles). The replacement engine (GM part #12740076) was on national backorder for over two months due to supplier capacity constraints. A loaner vehicle was provided during that time. This failure occurred despite a prior GM recall addressing the same rod/crankshaft defect having been performed on this vehicle. The recall remedy was ineffective. I have no confidence the replacement engine will not fail again. With approximately 597,630 vehicles affected, this represents a serious and ongoing public safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11758923

Incident

Apr 12, 2026

My vehicle, 2023 Tahoe, previously had the GM Recall 25V-274 / N252494001 remedy performed (0W-40 oil swap) in October of 2025. Despite completing the manufacturer's official recall remedy, the engine suffered a sudden, dangerous loss of motive power at highway speeds when I was making an out of state move and traveling alone; it was terrifying. I had to have it towed to the nearest dealership and that is where it is now as I had to leave since I was in the middle of moving. I need a new engine. I have no idea how I will get my Tahoe to my new residence or when. The dealership was not open on Sundays so I had to find a place to stay after leaving my Tahoe full of my items and my bike. I was so afraid it would be broken into. I had an oil pressure warning right before the engine completely stalled. And, I was accelerating up an incline and it felt like my Tahoe couldn't get enough power to make the incline. My Tahoe only has 35,047 miles, and threw the Diagnostic Trouble Code P0016 through my ONSTAR app as well as with the tech at the dealership. And, I am having a lot of trouble with GM corporate with rental cars. I had to pay out of pocket in order to get back on the road with my belongings as I start a new job this week at my new home. I had to leave some belongings and my bike with my Tahoe at the dealership.

NHTSA ID

11756494

Incident

Aug 9, 2026

When GM announced the recall involving the potential for catastrophic engine failure, I immediately contacted Bridgewater Chevrolet in NJ to schedule the required recall inspection. I was told the dealership could not perform the inspection because it had not yet received the required 'diagnostic tool' from GM. Once they received the equipment, they contacted me and on Oct 1, 2025, they completed the required recall inspection and informed me that my Tahoe had passed the recall inspection and that the vehicle was safe to continue driving. On XXX while driving over the Driscoll Bridge on the [XXX] with my daughter and our dog, the engine catastrophically failed without warning as I began to exit on exit [XXX] to [XXX] into heavy traffic. With no warning, the vehicle flashed that it was in neutral and then suddenly lost all power and stopped completely in a traffic lane, creating an extremely dangerous situation. After a few mins, I was able to get it started briefly, enough to coast along to a spot a few hundred feet away where there was a shoulder. From there the wheels locked and it would not move at all and windows would not open. It had to be dragged completely inoperable with locked wheels onto a flatbed three separate times. It was first dragged and flat bedded off the Parkway to a place we felt unsafe so we stayed locked in the car in July heat with no windows down, then to my mechanic and then to the dealership. I am unsure of the damage that may have caused. The dealership received the vehicle on XXX and within a day told me that it was indeed what my mechanic and they suspected - the catastrophic failure recall they had inspected and passed the vehicle for. As of today, XXX, I was told they just received an engine and can start a full replacement this week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755999

Incident

Jul 7, 2026

My 2023 Tahoe HC 6.2L VIN Passed the Catastrophic Engine Safety Recall stating my Engine was SAFE. The dealership performed a change in oil velocity per GM's directives. Then the engine seized upon accelerating. No warnings, just dead, yet able to coast through a large intersection on a -20F day where NOTHING worked on the vehicle. Even though the engine would not turn over when hitting the Start button, it would only allow 15 minutes worth of Emergency Flashers before the sensors shut the vehicle completely down. We had to abandon the vehicle on the side of the road, with key fob in this NEW vehicle, hike to safety, and for warmth. Total mess up as how to tow the vehicle, even when I advised NOTHING (but SiriusXM) worked and could not put vehicle into Neutral. Had to wait almost a month for a Replacement Engine. Once Replacement Engine installed, I expressed how my vehicle did not feel, nor sound the same as the original. The dealership ensured that it was a 6.2L Engine Replacement, without being able to tell me where it came from, how many miles on it, or the serial number to this new engine. I was told to give it 500-1000 miles to allow Replacement Engine to "settle". Exactly 300 miles in, on the expressway, just coming out of a bottle neck slowdown, I got up to around 45-50 mph and it was like I hit an invisible wall! Vehicle lost propulsion. Seat belts locked. No brake lights since I was accelerating. Extremely thankful nobody was behind me. Obviously let go of the gas. Pause. Then I was able to drive the vehicle to a safe location off of the expressway, and shut it down. Immediately called dealer. Restarted, drove about 15 miles to safety, went to shut off and it would NOT turn off. Sounded as if trying to start it while already running. 20 min to turn off. 5 months at dealer, they could not mimic/see any issues, even though I could "feel" the loss of propulsion at lower speeds. Fearing ALL lives, I had to trade down yet more $

NHTSA ID

11753757

Incident

Jan 20, 2026

Piston ring went bad causing catastrophic engine failure. Now needs new motor. Only had 62k miles. It had been burning oil but was taken to the dealership for maintenance and they didn’t report anything.

NHTSA ID

11750556

Incident

Jul 2, 2026