2007 Chevrolet Uplander

ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]

The contact owns a 2007 Chevrolet Uplander. The contact stated that the sliding door on the passenger’s side of the vehicle was opening independently. The contact had the vehicle modified because as a disabled driver, and had a ramp installed for the wheelchair. The contact stated that whenever the sliding door was opened, the ramp failed to fully deploy. The contact stated that the sliding door was opening at various speeds. The contact stated that he had taken the vehicle to the company that had modified the vehicle. The company advised the contact that the vehicle was nearly 20 years old, and that parts to repair the sliding door were no longer available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000.

NHTSA ID

11660899

Incident

Feb 14, 2025

Mileage

72,000 mi

MY VEHICLE STARTED MAKING A SCRUBBING NOISE WITH THE STEERING WHEEL AS I WAS DRIVING AND THIS NOISE GOT EVEN MORE NOTICABLE AS I MADE ANY TURNS .I STOPPED AND CKED THE POWER STEERING FLUID AND IT WAS !T FULL LEVEL.NOW IT MAKES A WOOING NOISE AS WELL. ALSO UPON STARTING OFF FROM A TRAFFIC LIGHT OR STOP SIGN I EXPERIENCED A TERRIBLE JERKING SENSATION WITH A KNOCK SOUND.THE VAN HAS BEEN SERVICED FOR REG MAINTENANCE OVER THE YEARS AND DEEMED MECHANICALLY OK ,OTHER THAN A FEW REG MATIENANCE ISSUES AND MY SISTER SOLD ME THE VAN IN GOOD CONDITION .I AM CONCERNED WITH THIS STEERING CONDITION NOW AS WELL AS THE SLOW START JERK/KNOCK.IT HAS ONLY BEEN SERVICED THRU THE YEARS AT CHEVROLET DEALERSHIP.MAINLY IN MARION, VA.CHEVROLET.BOTH ISSUES OCCURED WHILE VEHICLE WAS ON THE ROAD AND RUNNING.I AM CONCERNED SHE ,MY SISTER MAY HAVE MISSED A RECALL NOTICE AT SOME POINT.NOW I AM THE OWNER OF THE UPLANDER 07 VAN.

NHTSA ID

11416328

Incident

May 10, 2021

Mileage

101,000 mi

TL* THE CONTACT OWNED A 2007 CHEVROLET UPLANDER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHARGING SYSTEM FAILURE WARNING MESSAGE WOULD FLASH ON THE INSTRUMENT PANEL AS THE VEHICLE WOULD SIMULTANEOUSLY REDUCE ITS POWER. SOON AFTER THE WARNING LIGHT DISSIPATED, THE VEHICLE WOULD RESUME NORMAL DRIVING OPERATION. THE CONTACT THEN STATED THAT WHILE DRIVING AT 35 MPH, THE VEHICLE BEGAN TO EMIT A BLACK SMOKE FROM THE ENGINE WITHOUT WARNING. AS THE CONTACT BEGAN TO MAKE A LEFT TURN, A FLAME IGNITED FROM THE DRIVER SIDE OF THE ENGINE AND THE CONTACT IMMEDIATELY PARKED AND EXITED THE VEHICLE. THE CONTACT THEN CALLED THE AUTHORITIES AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AT THE SCENE. NO INJURIES WERE REPORTED AS A RESULT OF FIRE. THE DEALER NOR THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 189,363.*DT THE CONSUMER STATED SHE STILL HAS THE VEHICLE IN HER POSESSION.

NHTSA ID

11397636

Incident

Feb 19, 2021

Mileage

189,363 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET UPLANDER. THE CONTACT STATED THAT WHILE REVERSING INTO THE DRIVEWAY, THE FRONT DRIVER'S SIDE RACK AND PINION FRACTURED MAKING THE VEHICLE INOPERABLE. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO INDICATED THAT THE CAUSE OF THE FAILURE WAS DUE TO A DEFECTIVE MATERIAL USED IN THE SUSPENSION. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

NHTSA ID

11376719

Incident

Nov 1, 2020

Mileage

200,000 mi

MY 2007 CHEVY UPLANDER HAS BECOME UNSAFE. MULTIPLE MECHANICS HAVE GIVEN DIFFERENT GUESSES AS TO WHAT THE PROBLEM MAY BE. WHEN DRIVING, IF I STOP AT A STOP SIGN OR RED LIGHT, OR EVEN DURING STOP-GO TRAFFIC, THE VAN WILL SUDDENLY JERK WHEN I GO TO ACCELERATE. SOMETIMES THE JERK IS INCREDIBLY FORCEFUL AS IF I HAVE BEEN HIT FROM BEHIND. TWO MECHANICS HAVE RECOMMENDED A COMPLETE TRANSMISSION REPLACEMENT BUT SAY THAT THEY HAVE HAD SIMILAR COMPLAINTS FROM OTHER OWNERS OF THE SAME MAKE/MODEL VEHICLE. BECAUSE THE VAN DOES THIS, IT IS HARD TO ACCELERATE IMMEDIATELY FROM A STOPPING POINT. THIS CAUSES UNSAFE DRIVING/TRAFFIC CONDITIONS AS I CAN NOT BE CERTAIN MY VAN WILL IMMEDIATELY ACCELERATE WHEN NEEDED. *TR

NHTSA ID

11321489

Incident

Jan 1, 2020

Mileage

138,000 mi

POWER STEERING WENT OUT THEN THE TRANSMISSION WENT OUT HADN'T EVEN HAD THE VEHICLE 3 MONTHS

NHTSA ID

11310799

Incident

Dec 6, 2019

I HAVE PUT ON LESS THAN 2000 ON TIRES - EVERY TIME (FROM THE FIRST DAY) I TRAVEL GRAVEL THE TIRES BECOME PUNCTURED. I HAVE HAD NO LESS THAN 10 FLATS DUE TO THIS.

NHTSA ID

11253411

Incident

Sep 5, 2019

I WAS DRIVING DOWN THE ROAD AND ALL THE SUDDEN MY CHECK ENGINE LIGHT WENT ON AND THEN THE REDUCED ENGINE POWER CAME ON THE DASHBOARD AND REDUCE MY SPEED I COULDN'T GET IT UP TO SPEED I PUSH ON THE GAS TO GET UP AND SPEED AND IT WON'T GET UP I HAD TO PULL OVER TURN IT OFF RESTART IT AND WHAT THEN NOT EVEN A MINUTE IT DID IT AGAIN AND I WAS GOING DOWN THE HIGHWAY GOING 60

NHTSA ID

11233262

Incident

Jul 18, 2019

Mileage

157,000 mi

This PI directs technician to training regarding sliding door operation.

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.