2012 Chrysler 200 Body & structure Problems

THE 2016 CHRYSLER 200 has a defect in it , the drain hoses become plugged and flood the interior of the car. There is no easy way to access these hoses without taking apart the cowl under the hood of the car and removing the windshield wipers to access the drain. It has happened now three times costing 500 each time to have it cleaned and blown out ... There needs to be something done about this . As it can cause electrical problems in the car with all the water that floods in through the heater area... Chrysler is well aware of this problem all the way back to the Sebring yet they have done nothing to correct it . They ever tell the buyer that this need to be cleaned and they really provide no access to the owner to clean the area without disassemble of the cowl area and windshield wipers. Which is more than most buyers can do , when you take it to Chrysler they tell you its Maintenace . Yet it is no where in the book Nore covered by their Maintenace package. It will rot out the car Floor boards and will cause the car to be worth less .... Chrysler should have to make this right with all owners either offering a free cleaning every year of a rebate on their vehicle

NHTSA ID

11452755

Incident

Feb 18, 2022

TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR STARTED TO SMOKE. THE CONTACT STATED THE SHE ATTEMPTED TO EXTINGUISH THE FIRE WITH WATER HOWEVER, SHE WAS UNABLE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE CONTACT A DISABLE PERSON, WAS SCARED FOR HER SAFETY AND THE SAFETY OF OTHERS. THE CONTACT CALLED THE DEALER WHERE SHE SCHEDULE AN APPOINTMENT AND LATER TAKEN THE VEHICLE TO LONE STAR CHRYSLER DODGE JEEP RAM DEALER, (8811 INTERSTATE 35 ACCESS RD, SAN ANTONIO, TX 78211) BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT NOW THE DRIVER SIDE DOOR FAILED TO LOCK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SENT OUT A THIRD PARTY AND THE CONTACT WAS INFORMED THAT THE DOOR WAS BADLY BURNED AND THERE WAS NOTING ELSE THEY COULD DO. THE FAILURE MILEAGE WAS APPROXIMATELY UNKNOWN.

NHTSA ID

11315672

Incident

Jan 23, 2020

I WAS TRAVELING 55 MPH ON THE HIGHWAY MY TIRE BLEW OUT AN THE FENDER BLEW OFF BUT SOMEHOW THE CARS WHOLE ENGINE WIRING SYSTEM WAS RIPPED OUT OF THE CAR IN WHICH THE WHOLE CAR WENT COMPLETELY DEAD OF ALL ELECTRICITY THANKFULLY I WAS ABLE TO PULL ON SHOULDER OF HIGHWAY BEFORE THE CAR STOPPED ROLLING.

NHTSA ID

11204022

Incident

Oct 8, 2018

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2012 CHRYSLER 200 CONVERTIBLE. WHEN ATTEMPTING TO CLOSE THE CONVERTIBLE TOP, THE LATCH USED TO SECURE THE ROOF FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DODGE CHRYSLER JEEP OF WINTER HAVEN (299 CYPRESS GARDENS BLVD, WINTER HAVEN, FL 33880, (888)-612-3182) WHERE IT WAS DIAGNOSED THAT THE ROOF MODULE FAILED AND NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT THAT THE PART WAS DISCONTINUED AND RECOMMENDED THE CONTACT LOCATE THE PART. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TRY TO LOCATE PARTS THROUGHOUT HER STATE. THE FAILURE MILEAGE WAS 97,000.

NHTSA ID

11139696

Incident

Jul 10, 2018

Mileage

97,000 mi

2012 CHRYSLER 200. CONSUMER WRITES IN REGARDS TO RAIN WATER BACK FLOW INTO PASSENGER SIDE FROM CLOGGED TUBE, CUSTOMER SEEKS REIMBURSEMENT. *LD THE CONSUMER STATED THE MANUFACTURER PROVIDED REIMBURSEMENT. *JS

NHTSA ID

10994730

Incident

Mar 2, 2018

THE CAR ACCUMULATES DEBRIS BELOW THE WINDSHIELD UNDER THE PLASTIC TRAY WHICH CLOGS UP A DRAIN TUBE WHICH THEN MAKES THE WATER FLOOD BACK THROUGH THE HEATER CORE INTO THE PASSENGER SIDE OF THE CAR . WETTING THE FLOOR SOAKING THE CARPET AND CAUSING RUST AND BLACK MOLD. I HAD IT FIXED ONCE, BUT AFTER INVESTIGATION INTO THE CHRYSLER CARS THAT THIS IS AN ON GOING PROBLEM WITH ALL THEIR VEHICLES FOR YRS NOW. THIS NEEDS TO BE RECALLED AND THIS DESIGN FLAW FIXED. EITHER THEY NEED TO HAVE FREE MAINTENANCE OF THIS OR THEY NEED TO HAVE A SEPARATE TUBE FOR RAIN DRAINAGE AND A DIFFERENT TUBE FOR AC HEAT DRAINAGE.. IT HAS CAUSE DEPRECIATION OF MY OVER ALL RESALE VALUE OF THIS CAR PLUS CAUSED CARPET PADDING DAMAGE RUST AND POSSIBLY MOLD IN MY CAR.. CHRYSLER KEEPS LAYING BACK ON THE OWNERS SAYING MAINTENANCE PROBLEM .. AND CHARGING OVER 500 TO FIX IT. IT'S NOT LIKE AN OWNER CAN EASILY CLEAN THIS AREA IT INVOLVES TAKE APART THE WINDSHIELD WIPERS ETC

NHTSA ID

11039920

Incident

Oct 25, 2017

Mileage

13,000 mi

MOLD INSIDE PASSENGER DOOR AND BACK LEFT SIDE DOOR, EVERY TIME IT RAINS, WATER COLLECTS IN THE DOOR AND NEVER COMES OUT - CAUSING MOLD TO FORM. CAR HAS NEVER BEEN WRECKED AND IT WAS BOUGHT BRAND NEW

NHTSA ID

11004291

Incident

Aug 1, 2016

Mileage

48,000 mi

TL* THE CONTACT OWNS A 2012 CHRYSLER 200. WHILE DRIVING 45 MPH, A LOUD NOISE WAS HEARD. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED THAT THE FRONT PASSENGER SIDE FENDER WALL WAS LOOSE AND WRAPPED AROUND THE TIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO DETACH THE FENDER WALL FROM THE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FENDER WALL NEEDED REPLACEMENT. THE FRONT PASSENGER SIDE FENDER WALL WAS REPLACED. A MONTH LATER, THE CONTACT DROVE OVER A HOLE AND THE FENDER WALL HAD TO BE REPLACED AGAIN. THE ISSUE RECURRED A THIRD TIME, BUT THE FENDER WALL WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

NHTSA ID

10920322

Incident

Aug 20, 2016

Mileage

135,000 mi

WAS DRIVING CAR GOING ONLY 25-30 MPH AND MADE AN ATTEMPT TO SLOW DOWN TO A STOP WHICH I HAD PLENTY OF TIME AND SPACE BETWEEN CAR IN FRONT OF ME AND MY FRONT FENDER TO DO, AS I APPLIED BRAKES I NOTICE IT GO ALL THE WAY TO THE FLOOR AND MY CAR WOULDN'T STOP WHICH SOON AFTER HAVING PLENTY OF SPACE TO DO IT LED TO A REAR END COLLISION AS MY BRAKES FAILED TO WORK CORRECTLY WHEN APPLIED. I HAVE A POLICE REPORT TO VERIFY THE INCIDENT ON 09/27/2016 IN APPLETON, WI. BECAUSE I WAS GOING AT A REALLY SLOW SPEED AT THE TIME LUCKILY NO ONE WAS REALLY HURT WHEN THIS OCCURRED AROUND 10:00 AM IN AN AREA WITH LITTLE TO NO TRAFFIC AT THE TIME, BUT EVEN KNOW I WAS ONLY GOING AROUND 20 WHEN THERE WAS AN IMPACT MY CAR WHICH WAS NEW PRIOR TO THIS ACCIDENT IS NOW CONSIDERED UNDER STATE LAW IN WISCONSIN A SALVAGE VEHICLE AS REPAIRS EXCEEDED THE VALUE AT THE TIME OF 7000.00

NHTSA ID

10915183

Incident

Sep 27, 2016

Mileage

96,000 mi

WHILE DRIVING AT 40 MILES PER HOUR, THE HOOD FLEW UP, AND BACK, INTO THE WINDOW AND MARKED THE ROOF. WE DISCOVERED THAT THE HOOD RELEASE HAD BEEN PULLED EARLIER, INSTEAD OF TRUNK RELEASE. MY ISSUE, AFTER CLOSING THE NOW "SPRUNG" HOOD, WE TESTED THE SECONDARY "SAFETY" LATCH, IT DID NOT HOLD

NHTSA ID

10893670

Incident

Aug 5, 2016

Mileage

31,000 mi

TL* THE CONTACT OWNS A 2012 CHRYSLER 200. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V282000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. ON A SEPARATE OCCASION, WHEN THE BRAKES WERE APPLIED AND THE GEAR WAS PLACED INTO PARK, THE VEHICLE ACCELERATED THROUGH A WALL. THE AIR BAGS DEPLOYED. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER TOWED TO GEICO. THE FRONT END OF THE VEHICLE WAS REPLACED. THE DEALER DIAGNOSED THE BRAKES. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

NHTSA ID

10871687

Incident

Feb 15, 2016

Mileage

55,843 mi

DEAR SIR/ MADAM: 11-08-15 A FIRE OCCURRED AT MY HOUSE WHICH WAS LOCATED AT [XXX], ON THE ABOVE DATE, I PARKED MY 2012 CHRYSLER 200 IN THE GARAGE AND WENT TO BED. APPROXIMATELY 45 MINUTES TO 1 HOUR AFTER RETIRING, I WAS AWAKENED BY A LOUD EXPLOSION AND MY NEIGHBORS BEATING ON MY FRONT DOOR TO AWAKEN ME AND MY 21 YEAR OLD GRANDSON. HE ALSO WAS SLEEPING IN ANOTHER BEDROOM. WHEN BOTH OF US ATTEMPTED TO ESCAPE FROM THE HOUSE THROUGH THE KITCHEN/GARAGE ENTRANCE, WE WERE MET MY HEAVY BELLOWING GREY AND BLACK SMOKE THAT PREVENTED OUR EXIT AND ALMOST OVERWHELMED US. SEVERAL MONTHS LATER, I AM YET SUFFERING FROM THE SHOCK AND EMOTIONAL TRAUMA. BECAUSE OF DEALING WITH FLASHBACKS, NIGHTMARES, INTERMITTENT WAVES OF NERVOUSNESS, DEEP SADNESS, FEELINGS OF GRIEF/LOSS, PERIODIC CONFUSION, DIGESTION ISSUES, AND NUMEROUS FINANCIAL CONCERNS, I AM IN PROFESSIONAL COUNSELING. I HAVE BEEN UNABLE TO WRITE THIS LETTER UNTIL NOW. EVEN NOW, A FRIEND IS ASSISTING ME WITH COMPLETING THIS COMMUNICATION. THIS IS THE SECOND CONTACT I HAVE HAD WITH YOUR CORPORATION. THE FIRST WAS THE MORNING AFTER THE FIRE, WHEN MY SON CALLED ON MY BEHALF FROM HIS CELL PHONE. HE WAS INFORMED THAT THERE WAS NO RECALL OF THIS PARTICULAR CHRYSLER 200, HOWEVER THERE WERE SOME KNOWN PROBLEMS WITH THE GAS TANK AND IGNITION SYSTEMS THAT WERE BUILT BETWEEN MARCH AND NOVEMBER OF 2012. PLEASE UNDERSTAND. I LOST MY HOUSE, 23 LONG YEARS' WORTH OF CHERISHED BELONGINGS, AND THE CAR I RECENTLY PURCHASED. I LOST EVERYTHING IN THE FIRE. I DECIDED THAT,I WOULD RATHER INITIALLY CONTACT CHRYSLER DIRECTLY. MY HOPE IS THAT CHRYSLER WILL UNDERSTAND THE GRAVITY OF THE SITUATION AND DO THE RIGHT THING WITHOUT GOING THROUGH EXPENSIVE ATTORNEYS. [XXX] HTTPS://ONEDRIVE.LIVE.COM/REDIR?RESID=CEBFB7D86D50E64D!750&AUTHKEY=!AALIPDBQWPWSZE8&ITHINT=FOLDER%2C INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10871613

Incident

Nov 8, 2015

CAN SEE BUBBLING THRU PAINT ON ENGINE HOOD TOOK TO DEALER WAS TOLD ALUMINUM HOOD IS CORRODING

NHTSA ID

10862234

Incident

Apr 1, 2014

Mileage

25,000 mi

WHEN DRIVING, AFTER A RAIN, ESPECIALLY WHEN TURNING CORNERS WATER COMES RUSHING TO THE FRONT OF THE CAR FROM UNDERNEATH THE DASHBOARD. MOST TIMES THE PASSENGER SIDE IS DRENCH AND THE DRIVER SIDE IS SLIGHTLY DRENCHED BUT I'M SURE THIS A PROBLEM BECAUSE THERE MUST BE WIRES EXPOSED. PLEASE HELP.

NHTSA ID

10744323

Incident

May 13, 2015

Mileage

36,000 mi

2012 CHRYSLER 200. CONSUMER WRITES IN REGARDS TO PAINT BUBBLING AND RUST ON VEHICLE. *TGW THE CONSUMER NOTICED THE PAINT ABOVE THE PASSENGER SIDE HEAD LIGHT WAS BUBBLING, INDICATING RUST. HE TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION. THE DEALER STATED IT APPEARED THE VEHICLE HAD PREVIOUSLY BEEN PAINTED. CHRYSLER INSTRUCTED THE CONSUMER TO SEND PICTURES OF THE VEHICLE. AFTER LOOKING AT THE PICTURES, CHRYSLER STATED THE PROBLEM WAS DUE TO AN ENVIRONMENTAL ISSUE. *JB

NHTSA ID

10648109

Incident

Jun 1, 2014

WITHIN 2 DAYS OF PURCHASING THIS VEHICLE, REAR BRAKES WERE SQUEALING LIKE THEY WOULD DO IF THEY WERE DUE TO BE REPLACED. I BROUGHT IT BACK TO THE DEALERSHIP AND THEY SUPPOSEDLY INSPECTED THEM AND TOLD ME "ITS JUST RUST FROM SITTING ON THE LOT AND IT WILL CLEAR UP AFTER YOU DRIVE IT A WHILE", IT CONTINUED AND A COUPLE MONTHS FOLLOWING THE FIRST VISIT I RETURNED WITH THE VEHICLE AND TOLD THEM IT STILL WAS MAKING THE NOISE AND THEY CHECKED IT OUT AGAIN AND SAID "OH, ITS JUST DUST ON THE BRAKES AND IF YOU STEP ON YOUR BRAKES HARD AT ABOUT 40 MPH THAT SHOULD TAKE CARE OF THE PROBLEM". HERE WE ARE 2 YEARS LATER AND THE REAR BRAKES STILL MAKE THE SQUEALING NOISE. ABOUT JUNE/JULY OF THIS YEAR TIMEFRAME I BROUGHT MY VEHICLE IN TO THE DEALERSHIP BECAUSE I HAVE ABOUT 5 DIFFERENT SPOTS ON THE HOOD AND GRILL OF THE VEHICLE HAS THE PAINT "BLISTERING" AND RUST UNDERNEATH. THE DEALERSHIP DIDN'T CALL ME AND TELL ME WHAT THEY WERE GOING TO DO ABOUT IT SO I CALLED THEM ABOUT A MONTH LATER. THE WARRANTY GUY AT THE DEALERSHIP TOLD ME THAT CHRYSLER WAS GOING TO "SEND A WHOLE NEW HOOD" WHICH I GUESS DIDN'T MAKE MUCH SENSE TO ME BUT WHATEVER. TO DATE I HAVEN'T HEARD FROM THE DEALERSHIP ANY FURTHER ON THIS MATTER AND THE VEHICLE IS NEARING THE LIMITS ON THE WARRANTY PERIOD FOR MILEAGE. THE DEALERSHIP I HAVE BEEN DEALING WITH IS JOHN HIRSCH'S MOTORS IN CAMBRIDGE, MN. *TR

NHTSA ID

10648573

Incident

Jul 31, 2012

Mileage

800 mi

ON SEVERAL OCCASIONS MY FAMILY WAS INJURED WITH SEVERE CUTS DUE TO DELAMINATION OF THE DOOR HANDLES. THIS AFFECTED EVERY DOOR THAT SAW REGULAR USE. I WAS CUT, MY WIFE WAS CUT AND MY DAUGHTER WAS CUT. DOORS AFFECTED WERE: DRIVER, FRONT PASSENGER SIDE AND REAR PASSENGER SIDE. THE DELAMINATED CHROME ON THE DOOR HANDLE CREATES A RAZOR SHARP EDGE. THE CUT OCCURS WHEN OPERATING THE DOOR HANDLE. *TR

NHTSA ID

10615579

Incident

May 15, 2013

Mileage

10,000 mi

EXCESSIVE "FISH TAILING" IN MINIMAL SNOWY CONDITIONS, VERY UNSTABLE, ABSOLUTE DEATH TRAP. I FELT LIKE I WAS GOING TO END UP SMASHING INTO A PASSING CAR OR TRUCK . DROVE FOR 30 MILES PER HOUR FOR 260 MILES WHILE THERE WASN'T MORE THAN ONE INCH ON SNOW ON THE GROUND BECAUSE THE REAR END OF THE CAR WAS SWING IN ALL DIRECTIONS, MY WIFE AND DAUGHTER TERRIFIED. I JUST BOUGHT THE CAR BACK IN AUGUST 2013 THUS A FEW MONTHS AGO AND HAD NO ISSUES DRIVING ON DRY GROUND BUT ONLY IN SNOW AND WET CONDITIONS. *TR

NHTSA ID

10556597

Incident

Dec 3, 2013

. THERE ARE ABOUT 8 CARS AHEAD OF ME IN MY LANE AS WE WAIT FOR THE GREEN LIGHT. WHEN THE LIGHTS TURN GREEN I NOTE THAT MY LANE HASN'T MOVED AND THE BUSES ARE STEADY CHUGGING THROUGH THE INTERSECTION IN THE LEFT LANE I LOOK INTO MY REARVIEW MIRROR, I WAS THE LAST CAR IN LINE FOR THIS STOP AND I HADN'T EVEN GOTTEN MY FOOT OFF THE BRAKE AND ALL I COULD SEE WAS A BIG BLACK GRILL COMING TOWARD ME. I BRACED MY HANDS ON THE STEERING WHEEL AND SHOUTED PLEASE DON'T HIT ME' BEFORE I COULD FINISH THE SENTENCE BLAM!' FORTUNATELY THE CARS AHEAD OF ME WERE JUST STARTING TO MOVE FORWARD. MY HEAD SNAPPED SO HARD MY EARS WENT FULL. THE DASH MAT ON MY CAR CAME AT ME LIKE AN AIRBAG. MY PHONE IN THE FRONT CENTER CONSOLE FLEW FORWARD AND HIT THE SHIFT KNOB AND THE BACK POPPED OFF AND MUST HAVE SHAKEN THE BATTERY LOOSE. THE COFFEE IN MY LIDDED CUP SPEWED OUT THRU THE SMALL SIPPING HOLE ALL OVER THE CORNER OF MY LEATHER SEATS. I SAT STUNNED, TRYING TO ASSESS WHAT JUST HAPPENED. I KNEW THAT MY NECK AT THE BASE OF MY SKULL WAS BURNING, AS I REACHED TO PULL THE DASH MAT OFF OF ME I REALIZED MY RIGHT ARM HURT. I STILL HADN'T TAKEN MY FOOT OFF OF THE BRAKE AND I COULDN'T BELIEVE WHAT JUST HAPPENED. I HAVE BEEN REAR ENDED ...ALMOST $5000 WORTH OF REAR END DAMAGE, AND MEDICAL BILLS FOR WHIPLASH AND A BROKEN ELBOW! I AM BEING TOLD BY CHRYSLER THAT THERE IS AN ACTIVE HEAD RESTRAINT RECALL (THIS RESTRAINT COULD HAVE PREVENTED MY WHIPLASH). LOSS OF WORK, AND MEDICAL COSTS, HAD TO HIRE AN ATTNY. AGAINST THE OTHER DRIVER, STILL TRYING TO RECOVER MY FINANCIAL LOSSES. *TR

NHTSA ID

10549313

Incident

Mar 25, 2013