1999 Chrysler Concorde Owner Complaints

The contact owned a 1999 Chrysler Concorde. The contact stated while in a parking lot as he placed the vehicle into Drive, the vehicle revved and accelerated, and the contact had not depressed the accelerator pedal. The contact stated no warning light was illuminated. The contact stated that the vehicle crossed the parking lot, jumped the curb and climbed a small hill and came safely to a stop. The police were called but no report was written. The contact injured his lower back but did not seek medical attention. The vehicle was towed to an independent mechanic and has not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11456807

Incident

Mar 11, 2022

Mileage

70,000 mi

The contact owns a 1999 Chrysler Concorde. The contact stated while driving at an undisclosed speed, there was a gasoline odor detected while the vehicle was parked. There was no visible fuel leak on the ground when the contact inspected the vehicle. The dealer was informed of the failure but informed the contact that the vehicle needed to be diagnosed. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact that the Vin was not under recall. The approximate failure mileage was 248,000.

NHTSA ID

11422559

Incident

Jun 1, 2021

Mileage

248,000 mi

TAKATA RECALL CAR CAUGHT FIRE IN THE FRONT OF THE CAR (DEFROST VENTS) I WENT INSIDE THE STORE WHILE MY CAR WAS PARKED ON THE STREET WHEN I CAME BAC MY CAR WAS SMOKING. FIRE DEPARTMENT SAID IT WAS CAUSED BY FAN MOTOR FAIL.

NHTSA ID

11078612

Incident

Mar 11, 2018

Mileage

150,000 mi

THERE IS A FUEL LEAK AT THE CONNECTION OF FUEL RAIL AND FUEL LINE 2.7L ENGINE VEHICLE WAS STAIONARY COLD OR HOT MOTOR 6/ 2/ 2017 . THERE WAS A RECALL EARLY 2000 YEAR FOR SAME PROBLEMS .

NHTSA ID

10993103

Incident

Jun 2, 2017

Mileage

161,000 mi

SINCE 2010, THE CAR HAS HAD MANY ELECTRICAL ISSUES THAT HAVE RESULTED IN OVER 5,000 DOLLARS IN REPAIRS AND THE PROBLEMS CONTINUE TO PERSIST. IN 2010, THE CAR BEGAN HAVING INTERMITTENT LIGHTING ISSUES AND FAILURE OF THE TRUNK LATCH OPENING MECHANISM. IN AUG 2010, THE BCM WAS FIXED/REPLACED. SINCE THEN, THE A/C HAS BECOME THE PROBLEM THAT HAS LED TO THOUSAND OF DOLLARS OF REPAIRS. THE PROBLEM IS THAT INTERMITTENTLY THE A/C WILL NOT RESPOND TO CHANGES IN THE TEMPERATURE CONTROLS AND ONLY 180 DEGREE AIR COMES OUT. THE DEALER HAS REPLACED ALMOST ALL MECHANICAL PARTS OF THE A/C AND THE ELECTRICAL CONTROLS WITH THE EXCEPTION OF THE BCM. THE PROBLEM CONTINUES AND NOW THE SO CALL NEW BCM IS NO LONGER UNDER WARRANTY. *TR

NHTSA ID

10630377

Incident

Aug 21, 2010

Mileage

100,636 mi

I FOUND FIVE RECALLS ON THE SAFECAR.GOV SITE, YET I HAVE NEVER BEEN NOTIFIED OF ANY OF THEM. IN APPROXIMATELY 2000-2001, I HAD A FAILURE OF THE DRIVER'S SEAT, WHILE TRYING TO MOVE THE SEAT BACK FOR MORE ROOM, WHERE THE BACK FELL ALL THE WAY DOWN TO A RECLINING POSITION. I WAS NOT ABLE TO MAKE IT STAY UP. THE DEALER AT THE TME REPAIRED IT AT AN APPROXIMATE COST OF $1,100.00. SOMETIME LATER, I READ IN THE NEWSPAPER LATER ABOUT A RECALL FOR THE SEATS, AND TOOK IT TO JOLIET DODGE, JOLIET, IL, WHO IS NOW OUT OF BUSINESS. THEY REFUSED TO DO ANYTHING, TELLING ME I HAD ALREADY HAD IT FIXED, AND REFUSING TO REIMBURSE ME FOR THE COST TO REPAIR. FAST FORWARD TO JULY 2014. WHEN TRYING TO MOVE THE SEAT BACK BY USING THE LEVER FOR THAT AND PUSHING BACK WITH MY BODY, THE SEAT BACK TOTALLY FAILED AGAIN. IT GOES ALL THE WAY DOWN, AND WILL NOT STAY UP. BECAUSE OF THE AGE OF THE CAR, AND THE FACT THAT I AM A RETIREE ON ONLY SOCIAL SECURITY FOR A VERY LIMITED INCOME, AND NOT BEING ABLE TO AFFORD THE COST TO REPAIR, I DID A HOME MADE FIX BY PUTTING MY LARGE PLASTIC COOLER ON THE FLOOR IN BACK OF THE SEAT TO HOLD IT UP. I AM LUCKY THIS HAPPENED WHILE THE CAR WAS IN PARK, NOT MOVING, ELSE I MIGHT HAVE HAD A TERRIBLE ACCIDENT. THE FIRST TIME IT OCCURRED, I WAS DRIVING, BUT HAD NO ACCIDENT.

NHTSA ID

10627733

Incident

Jul 7, 2014

Mileage

171,000 mi

THE MOLDING BETWEEN THE HOOD AND THE WINDSHIELD FLEW OFF AS I WAS DRIVING IN THE FREEWAY. I WAS DRIVING LIKE I NORMALLY DO ( APPROX. 65MPH), WHEN FWY IS CLEAR OF CARS; THIS IS NOT REASON ENOUGH FOR THIS CAR PART TO FLY OFF. LUCKILY, FWY WAS CLEAR, IF NOT, I COULD OF HAD AN ACCIDENT SINCE IT AFFECTED MY VISIBILITY WHILE DRIVING. ONCE I REPLACE THIS, I WONDER IF NEXT TIME... WILL I HAVE AN ACCIDENT? HOW TO ASK THEY INSTALL IT SO IT DOESN'T FLY OFF? DEALER SAYS THEY MUST INSTALL IT PER MANUFACTURER REQUIREMENTS BUT THE NORMAL WAY IT COMES FROM MANUFACTURER DOESN'T WORK CAUSE IT EVENTUALLY FLIES OFF. I NOTICED THERE ARE COUNTLESS COMPLAINTS REGARDING SAME ISSUE WITH NHTSA. HOW MANY COMPLAINTS ARE NECESSARY FOR IT TO BE RECALLED? *TR

NHTSA ID

10544491

Incident

Aug 8, 2013

Mileage

207,465 mi

YESTERDAY I HAD TO GO TO THE HOSPITAL BECAUSE THE TRUNK LID FELL ON MY NECK WHEN I WAS UNLOADING MY TRUNK. THIS CAR HAS AN ELECTRICAL TRUNK THAT OPENS AND THE TRUNK ALSO, HAS A SPRING AIR ROD THAT CONTROLS THE HOLD OF THE OPEN TRUNK. I KNOW THIS FAILED BECAUSE THE TRUNK JUST LOST ITS HOLD ALL OF A SUDDEN AND LANDED ON MY NECK. AS I TRIED TO LIFT IT FROM ABOVE ME (ITS VERY HEAVY- BIG TRUNK), MY LEFT HAND INDEX FINGER BROKE AND MY LEFT ARM AND HAND ARE IN PAIN. NOT TO MENTION, THE SEVERE PAIN I AM UNDERGOING WITH MY NECK. I ALSO BLED A LOT AND IMMEDIATELY WENT TO THE EMERGENCY ROOM. I BELIEVE THIS CAN BE A MANUFACTURING DEFECT DUE TO THE EXCESSIVE WEIGHT OF THIS TRUNK DOOR AND THE DEVICE BEING RELIED ON FOR THE CONTROL OF TRUNK. *TR

NHTSA ID

10544485

Incident

Sep 18, 2013

Mileage

208,992 mi

I WAS PARKING ON A PARKING LOT AND LOT HAD A STRUCTURED SMALL POST ON THE DRIVER SIDE; DUE TO VISIBILITY THAT THE VEHICLE LAMP OMITTED TO LIGHT PROPERLY, I DAMAGED THE FRONT RIGHT CORNER BUMPER. I HAVE NOTICED THAT THE CORNER LAMP ASSEMBLIES HAVE A PROBLEM WITH THE REFLECTORS. THIS LAMP DOESN'T HAVE THE REQUIRED AMBER SIDE REFLECTORS DON'T WORK WELL CAUSE I CAN BARELY SEE (NOT LIKE MY OTHER CARS). THERE IS A RECALL SET ALREADY FOR PART NUMBER CS114-U0BJ2 WHICH IS A COMBINATION CORNER AND LAMP ASSEMBLY FOR THIS VEHICLE. I AM ASKED TO CONTACT SABERSPORT WHO IS DOING THE RECALL (RECALL ID#09E012000 EXTERIOR LIGHTING); HOWEVER, THEIR NUMBER IS DISCONNECTED AND THEIR ONLINE CONTACT NUMBER IS A WRONG NUMBER. AT THIS POINT, I DON'T THINK ITS RIGHT THAT I HAVE TO PAY FOR THESE REPAIRS. EVEN UPON REPAIRS,I NEED THE VEHICLE WITH CORRECT LAMP ASSEMBLY SO IT DOESN'T HAPPEN AGAIN. NEXT TIME, COULD BE A WORSE ACCIDENT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10544482

Incident

Sep 3, 2013

Mileage

208,012 mi

TL* THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT STATED THAT THE PASSENGER AND DRIVER SIDE DOOR HANDLE BROKE; AS A RESULT SHE WAS UNABLE TO UNLOCK THE DOORS IN ORDER TO EXIT THE VEHICLE. THE CONTACT ALSO MENTIONED THAT THE AUTOMATIC LOCKS AND INTERIOR LIGHTS WOULD TURN ON AND OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DECIDED TO GLUE THE HANDLE BACK ON AS A TEMPORARY REMEDY. THE REMEDY FAILED TO REPAIRED THE PROBLEM SINCE THE HANDLE CAME OFF COMPLETELY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 85,000.

NHTSA ID

10435478

Incident

Dec 1, 2009

TL* THE CONTACT OWNS A 1999 CHRYSLER CONCORDE LX. THE CONTACT WAS DRIVING 40 MPH WHEN A CLICKING NOISE WAS HEARD FROM UNDER THE HOOD. THE CONTACT ALSO MENTIONED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 110,727.

NHTSA ID

10433859

Incident

Oct 31, 2011

Mileage

110,727 mi

TL* THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE WINDSHIELD WIPER COWL, A PART WHICH COVERED THE BASE OF THE WINDSHIELD WASHER, EJECTED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10372122

Incident

Dec 12, 2010

I HAVE A 1999 CHRYSLER CONCORDE WITH A TIMING CHAIN PROBLEM....THIS IS MY SECOND CONCORDE AFTER THE OTHER GOT STOLEN....AND AFTER I PAID $3800 TO REPAIR THE TIMING CHAIN ON IT....CAN ANYTHING BE DONE OF THIS PROBLEM....I CANT AFFORD IT AGAIN??? *TR

NHTSA ID

10336521

Incident

May 2, 2010

Mileage

180,000 mi

BLINKING ENGINE LIGHT, SMOKE FROM EXHAUST, ALL MECHANICS STATE THAT I NEED A NEW ENGINE,BUT NO SHAKING, RIDES SMOOTH, UNSURE WHY IT SMOKES, I HAVE USED SEALANT, CHECK GASKETS AND NO CHANGE.. I BOUGHT THE CAR IN 2008 FROM A PRIVATE OWNER AND IT PASSED SMOG, SHORTLY AFTER THE ENGINE LIGHT CAME ON AND IT WENT DOWNHILL FROM THERE DIAGNOSED ENGINE, REPAIRED OIL PAN. *TR

NHTSA ID

10331624

Incident

Jun 21, 2008

TL* THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT STATED WHILE DRIVING AT APPROXIMATE SPEEDS OF 55 MPH, THE FRONT DRIVERS SEAT WOULD RECLINE BACKWARD WITHOUT DRIVER INTENT DUE TO A BOLT SNAPPING. THE CONTACT RECEIVED NOTIFICATION OF A RECALL (NHTSA CAMPAIGN ID NUMBER: 03V035000: SEATS: FRONT ASSEMBLY: RECLINER) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. THE DEALER ADVISED THE RECALL REPAIR WAS PREVIOUSLY PERFORMED ON THE VEHICLE AND THE MANUFACTURER WOULD NOT COVER THE COST OF A SECOND REPAIR. THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 58,000.

NHTSA ID

10325827

Incident

Mar 14, 2010

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE LXI. WHILE DRIVING APPROXIMATELY 70 MPH ON NORMAL ROAD CONDITIONS THERE WAS PRESSURE APPLIED TO THE ACCELERATOR PEDAL AND UNEXPECTEDLY, THE SPEED RATE REDUCED TO 20 MPH. THE CONTACT WAS ABLE TO DRIVE ON THE EMERGENCY LANE WITH CAUTION AND SUDDENLY, THE SPEED RATE INCREASED TO 70 MPH. THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING; HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE IDENTICAL FAILURES OCCURRED ON FOUR SEPARATE OCCASIONS. AN INDEPENDENT MECHANIC ON TWO SEPARATE OCCASIONS RESET THE CRANK SHAFT SENSOR CODE. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR WAS MADE IN ADDITION, THE VEHICLE STALLED INTERMITTENTLY. THE CONTACT HAD CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 121,000.

NHTSA ID

10289177

Incident

Sep 28, 2009

Mileage

121,000 mi

2.7 ENGINE FAILURE DUE TO OIL SLUDGE ON 1999 CHRYSLER CONCORDE LX. *TR

NHTSA ID

10287399

Incident

Sep 30, 2009

Mileage

135,771 mi

WHEN I WAS IN MY CAR ONE DAY, I PARKED AND TRIED TO GET OUT. THE DOOR STUCK AND I THINK THIS WAS BECAUSE THE RUBBER STUCK TO THE DOOR.. IT TOOK ME FIFTEEN MINUTE TO GET OUT OF MY CAR. I HAD TO LIFT UP THE BOTTOM OF THE NOW DETACHED INSIDE PLASTIC FRAME IN ORDER TO GET OUT OF MY CAR. IN ABOUT A YEAR< THE SAME THING HAPPENED TO THE PASSENGER DOOR> MY DAUGHTER TRIED TO GET OUT OF THE VEHICLE AND THE DOOR GOT STUCK... SHE PUSHED THE DOOR AND THE PLASTIC INSIDE FRAME DETACHED FROM THE DOOR THE SAME WAY THE DRIVER'S SIDE DID. NOW WE MUST LIFT THAT DOOR TOO.. THIS HAPPENS ALMOST ALL OF THE TIME AND IF THERE IS AN EMERGENCY AND WE HAVE TO GET OUT, THIS IS A HUGE CONCERN. IF THERE WAS A FIRE OR CRASH.. I MET SOMEONE WITH THE EXACT YEAR AND MODEL CARE AND THEY HAVE THE SAME PROBLEM... PLEASE HELP ME! *TR

NHTSA ID

10266183

Incident

Sep 17, 2006

Mileage

98,000 mi

FRIDAY, I WAS DRIVING TO WORK, THE CAR FELT LIKE IT WAS GOING TO STALL OUT, I LUCKILY MADE IT TO WORK. IT MADE AN AWFUL SOUND LIKE SOMETHING BROKE. LATER THAT DAY, I TOOK IT TO A NEARBY GARAGE, THE MECHANIC SAID THE ENGINE HAD BLOWN & HIS SUGGESTION WAS TO TAKE IT TO A JUNK YARD & HOPE FOR A COUPLE HUNDRED DOLLARS, OTHER WISE, IT WOULD COST 2000.00 FOR A REMANUFACTURED MOTOR & 1000.00 FOR LABOR TO INSTALL THE MOTOR. HE ALSO STATED THAT THE CHRYSLER 2.7 MOTOR WAS NOTORIOUS FOR BROKEN TIMING BELTS & THE ENGINES LOCKING UP. *TR

NHTSA ID

10265022

Incident

Apr 10, 2009

ANOTHER CHRYSLER 2.7 LITRE CATASTROPHIC ENGINE FAILURE TIMING CHAINS FAILURE DEMOLISHED ENGINE AT HIGHWAY SPEED. *TR

NHTSA ID

10263571

Incident

Mar 28, 2009

Mileage

101,000 mi

WHILE DRIVING ON THE HIGHWAY; THE ENGINE OF MY 1999 CHRYSLER CONCORDE, HAD A CATASTROPHIC FAILURE. THERE WAS AN INCIDENT INVOLVING THE TIMING CHAIN THAT LED TO A GREAT MANY FAILURES, TOP SO BEING THE CRANKSHAFT, AS I WAS TOLD BY THE DEALERSHIP I HAD EVALUATE THE PROBLEM. THE ENGINE IS THE 2.7L DOHC V6 THAT COMES STOCK WITH THE 1999 CONCORDE. I CHANGED MY OIL REGULARLY AND NEVER EXPECTED THE MOTOR TO FAIL AT JUST OVER 42K MILES. I WAS 400 MILES FROM HOME WHEN THIS OCCURRED, AND HAD TO WAIT IN A SHOPPING CENTER FOR SEVERAL HOURS UNTIL WE COULD ARRANGE A WAY HOME FOR MYSELF, MY WIFE, AND AT THE TIME MY 5 MONTH OLD DAUGHTER. *TR

NHTSA ID

10257095

Incident

Nov 22, 2006

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT HEARD A LOUD NOISE COMING FROM THE ENGINE. THE VEHICLE STALLED INTERMITTENTLY AND THE CHECK OIL WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATOR REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT OIL SLUDGE CAUSED THE ENGINE FAILURE AND IT WAS RECOMMENDED THAT THE ENGINE BE REPLACED. THE VEHICLE IS CURRENTLY INOPERABLE AND HAS NOT BEEN REPAIRED. UPDATED 3/5/09 *CN UPDATED 03/10/09. *JB

NHTSA ID

10256704

Incident

Jan 21, 2009

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING 45 MPH, THE VEHICLE SHUT OFF AND STOPPED IN THE MIDDLE OF THE FREEWAY. THE CONTACT WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, ALTHOUGH THE BRAKES AND POWER STEERING FAILED. SOMEONE HAD TO ASSIST HER WITH STEERING THE VEHICLE TO THE SIDE OF THE ROAD. THE POLICE WAS CALLED AND THE VEHICLE WAS TOWED TO THE AUTO REPAIR SHOP. THERE HAD NOT BEEN ANY ENGINE FAILURE PRIOR TO THIS INCIDENT. THE AUTO SHOP STATED THAT ENGINE SLUDGE COATED THE ENGINE. IT WOULD COST $5,000 TO REPLACE THE ENGINE. THE FAILURE MILEAGE WAS 60,000. UPDATED 2/23/09 *CN THE PASSENGER SEAT BELT WAS DIFFICULT TO UNFASTEN AND THE REAR PASSENGER DOOR HAD TO BE OPENED FROM THE OUTSIDE. UPDATED 02/26/09. *JB

NHTSA ID

10251825

Incident

Dec 11, 2008

Mileage

60,000 mi

THE ENGINE IN OUR 1999 CHRYSLER CONCORD BLEW AT ONLY 38000 MILES, IT WAS THE FAMOUS FLAWED 2.7, CHRYSLER REFUSED TO REPLACE THE ENGINE - TOLD US WE MUST NOT HAVE CHANGED THE OIL OFTEN ENOUGH! MY HUSBAND IS A DISTRICT SUPERVISOR FOR A OIL CHANGE CHAIN HERE IN MICHIGAN, THE OIL WAS CHANGED RELIGIOUSLY WITH SYNTHETIC BLEND, AN OIL FAR SUPERIOR TO THE BASIC FACTORY RECOMMENDATIONS. WE REPLACED THE ENGINE OURSELVES AT OUR OWN EXPENSE WITH A 3.2 AT A COST OF $3000. CHRYSLER REFUSES TO ADMIT ANY DEFECTS IN THEIR 2.7 MOTORS, YET OTHER COMPANIES WHOM USED THIS ENGINE HAVE VOLUNTARILY RECALLED IT! *TR

NHTSA ID

10250812

Incident

Jul 30, 2005

Mileage

38,000 mi

HERE IS A COPY OF OUR SALES TICKET THAT EXPLAINS ALL OF THE UPDATES THAT WE PERFORM ON THIS ENGINE. HOPEFULLY THIS WILL HELP YOU. IF YOU HAVE ANY FURTHER QUESTIONS FEEL FREE TO CONTACT OUR CUSTOMER SERVICE DEPARTMENT AT 1-800-827-7450. --OIL STARVATION IS A PROBLEM WITH THIS ENGINE, SO JASPER INSTALLS THE NEWEST DESIGN OIL LINE WHICH HAS A LARGER DIAMETER PIPE TO ALLOW MORE OIL FLOW AND BETTER LUBRICATION. THE NEWER DESIGN PIPE HAS ONE GENTLE BEND OPPOSED TO THE ORIGINAL WHICH HAD TWO 90-DEGREE BENDS WHICH TENDS TO RESTRICT TO OIL FLOW. --TO PREVENT BEARING FAILURE JASPER INSTALLS ALUMINUM ROD & MAIN BEARINGS INSTEAD OF TRI-METAL BEARINGS. THE ALUMINUM BEARINGS CONFORM TO THE MATING SURFACE MORE COMPLETELY, WHICH PROVIDES MORE EXACT CLEARANCES. THE ALUMINUM BEARINGS ARE ALSO MORE CORROSION RESISTANT. THE ORIGINAL TRI-METAL BEARINGS WERE PRONE TO NOT CONFORM WELL, WHICH LED TO DIRT AND DEBRIS BECOMING LODGED IN THE BEARING DUE TO EXCESSIVE BEARING CLEARANCES. --WATER PUMPS ON THIS ENGINE HAVE BEEN KNOWN TO LEAK OR FAIL. ONE OF THE ISSUES LEADING UP TO THIS WAS DUE TO THE TIMING CHAIN TENSIONER. IT WOULD APPLY MORE TENSION TO THE CHAIN THEN WAS NEEDED, CAUSING STRESS ON THE WATER PUMP. JASPER INSTALLS A LATER DESIGN TENSIONER, WHICH APPLIES THE RIGHT AMOUNT OF TENSION ON THE TIMING CHAIN AND REDUCES THE STRESS ON THE WATER PUMP. JASPER INSTALLS THE NEWEST DESIGN OE WATER PUMP & WATER PUMP GASKET WHICH WILL SEAL TO THE BLOCK BETTER THAN THE ORIGINAL OE DESIGN. --WITH THE USE OF AN MLS GASKET, THE STANDARDS FOR MACHINING ON THE HEAD AND BLOCK HAVE BEEN INCREASED TO INSURE THAT THE GASKET CAN SEAL PROPERLY. THIS IS TO HELP PREVENT COOLANT FROM ENTERING THE OIL CAVITIES CAUSING DAMAGE TO THE ENGINE. ----JASPER DOES NOT INSTALL THE CAM GEAR BALANCER DUE TO A BULLETIN FROM CHRYSLER EFFECTIVE 12/14/01 STATING IT IS NOT NEEDED AND NOT SERVICED FROM THIS TIME FORWARD. --DO NOT REMOVE FROM CORE AND INSTALL ON JASPER'S ENGINE. --LIVE RUN TESTED OIL. *TR

NHTSA ID

10243380

Incident

Sep 11, 2008

Mileage

131,506 mi