2002 Chrysler Pt Cruiser Owner Complaints

The contact owns a 2002 Chrysler PT Cruiser. The contact stated that the rear quarter glass fasteners on both sides of the vehicle had started to separate from the vehicle. The contact stated that the windows were violently shaking while driving at various speeds. The contact was concerned that the windows might fall out while driving and cause injury to a pedestrian. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.

NHTSA ID

11595572

Incident

Jun 13, 2024

Mileage

70,000 mi

The contact owns a 2002 Chrysler PT Cruiser. The contact stated that while driving at 35 MPH, she could smell fuel in the interior of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who located a fuel leak on the fuel trail line. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 02V215000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 138,000.

NHTSA ID

11535544

Incident

Jul 20, 2023

Mileage

138,000 mi

Hello My name is [XXX]. I own a 2002 Chrysler Pt cruiser and for some reason the power steering went out while I was driving! I was able to make it home because I wasn’t far away! My power steering stopped out of no where and my fluid is full and my belt is attached I was also told my pump was in great condition! I’m really concerned because I had my 6 year old child in the car! I now can’t make appointments work or even take my child to school I’m in need for help! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11526442

Incident

Jun 11, 2023

Answers and explanations to all of the above questions: My power steering assembly is leaking pretty bad and is only getting worse. I have a bad shoulder that I had surgery on and if it goes completely out I am afraid i wont be able to turn the steering wheel & cause an accident. The rims on the vehicle are cracked/cracking & I believe one has a hole or 2 & another 1 is forming one. It's also scratching & ruining the rotors. Its not the pads they are fine but I need at least 1 new rotor & can't because the rims are defective causing it to happen again which can easily damage the calipers locking up the wheel causing a crash plus sometimes theres a loud crunching noise not grinding like the pads are bad cause they are not. I know the difference. The trac off & airbag lights are on then they go off then come back on again.The dashboard is cracked and it caused the vent to break where anything can get in it.The clear coat is peeling and yet the paint under it is in great shape.I also believe that the instrument cluster is causing the lights to come on the dashboard.The vehicle can be picked up when ever you have a spot open for it. I would like 48 hours notice due to work. This is a safety issue if the power steering goes while driving I cant steer it because I didn't know it was leaking it went out and I was stuck blocking traffic and couldn't turn it the passenger had to do it for me, If the rims get worse or hole bigger it can crack or break in half while I am driving. The defrost vent is open to particles that can get in there that shouldn't. The airbag light on could be a defect or the air bags defective. Nothing has been inspected on it since I just found out when looking up this make, year and model a price on power steering to find out there's a recall on it as well as other issues. There were no warnings and the only code that came up was the high fan relay switch. Since then the trac off light goes on and off as well as airbag light and now is currently on.

NHTSA ID

11441234

Incident

Nov 13, 2021

While driving the vehicle I could begin to smell a strong odor of gas them almost like the smell of plastic melting and the vehicle engine started running hot temperature so I immediately turned off the engine as I pulled over to the side of the road and as I stepped out of the car aflame began under the hood and ended up burning my entire engine. Fire department had to come and extinguish the car.

NHTSA ID

11426744

Incident

Jul 26, 2021

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE AIR BAG SENSOR WARNING LIGHT REMAINED ILLUMINATED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE BUT, NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 102,000.

NHTSA ID

11386397

Incident

Jan 2, 2021

Mileage

102,000 mi

DROVE THE VEHICLE 12 MILES TO GET HOME. (THE VEHICLE WAS STATIONARY) IMMEDIATELY TURNING OFF ENGINE AFTER MAKING IT HOME. POWER STEERING FLUID LEAKAGE (BIG LEAK) FROM HOSE AND SMOKE SMELL FROM UNDER HOOD. (ENGINE LOOKS CHARD)

NHTSA ID

11271512

Incident

Oct 20, 2019

Mileage

199,685 mi

MY CHECK ENGINE LIGHT GOES OFF AND ON. CRANKSHAFT AND CAMSHAFT SENSORS WERE READING AS THE ISSUE ACCORDING TO THE ODOMETER CODE SYSTEM.. MY CAR SHUTS OFF AT ANYTIME EVEN WHILE DRIVING IN THE MIDDLE OF THE ROAD. MY BATTERY TERMINAL SEEMS TO BE WEAK POSSIBLY HAVING SHORTAGE MOMENTS FROM TIME TO TIME. MY VEHICHLE WILL PULL ONE WAY OR THE OTHER. MY BREAKS FEEL LIKE THERE GOING TO GIVE OUT OR ARE BRAND KNEW . MY VEHICHLE MAKES A NOISE AS IF THE FRONT CV AXELS OR BALL JOINTS NEED TO BE GREASED. MY WIRING AND ENGINE IS MY MAIN CONCERN. MY AC DOESN'T WORK MY RADIATOR SEAL HAS BEEN REPLACED MY CAR WILL MAKE A GUZZLING NOICE DUE TO THE COOLANT . THE LIST GOES ON. I BOUGHT MY VEHICHLE APPROX. 4MONTHS AGO. THE ISSUES HAVE PROGRESSED OVER THE PAST MONTH.

NHTSA ID

11242425

Incident

Jun 21, 2019

Mileage

147,000 mi

UPON STARTING VEHICLE ALL WARNING TEST LIGHTS SUCH AS AIRBAG,OIL PRESSURE ETC. COME ON AS NORMAL,BUT OFTEN THE RED "AIRBAG" LIGHT STAYS ON INDEFINITELY OR GOES OFF THEN BELLS AND "AIRBAG" RED LIGHT REAPPEAR AND STAY ON 5 TO 10,SECONDS THEN GO OFF EVERY FEW MINUTES FOR SEVERAL SECONDS. THIS SEEMS TO OCCUR WHEN I AM IN 1000 TO 1500, LOW ROOMS LIKE WHEN I'M SLOWING TO MAKE A STOP.YESTERDAY, THE AIRBAG LIGHT STAYED ON THE ENTIRE 20 MINUTE TRIP. I TOOK CAR IN FOR REPAIR ON MY OWN $ BUT PROBLEM RETURNED. PROBLEM HAS OCCURRED AT ALL,HIGHWAY AND STREET SPEEDS BUT MOSTLY WITH DECELERATION TURNING THE AIRBAG OFF. VERY DANGEROUS. WHY HAVEN'T YOU PUT THE PT CRUISER ON THE AIRBAG RECALL LIST? I BOUGHT THE CAR NEW IN 2002 AND AM,THE SOLE OWNER.

NHTSA ID

11233840

Incident

Jan 1, 2018

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE HIGH BEAM HEAD LAMPS WOULD ILLUMINATE RANDOMLY DAY OR NIGHT. THE CONTACT STATED THAT THE FAILURE OCCURRED AT LEAST SIX TIMES IN ONE WEEK. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE MULTI-FUNCTION SWITCH THAT CONTROLLED THE HEADLIGHTS WAS REPLACED BY HIM. THE CONTACT NOTICED THAT THE PLASTIC CLIP HOLDING THE ELECTRICAL HARNESS TO THE SWITCH HAD BURNED. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.

NHTSA ID

11219448

Incident

Jun 11, 2019

Mileage

153,000 mi

I WAS INVOLVED IN AN ACCIDENT WITH MY WIFE AND I AND IT ALMOST TOOK OUR LIVES BUT I WAS ABLE TO GET OUT OF IT ALIVE AND THE INSURANCE AND THE ATTORNEYS GAVE ME SOME MONEY SO I WENT OUT AND BOUGHT ME A CHRYSLER PT CRUISER FOR $4, 700 FOR A 2002 CHRYSLER PT CRUISER FROM LARRY H MILLER HONDA I STARTED HAVING OVERHEATING ISSUES RIGHT AFTER I PURCHASED IT FROM THEM AND EVENTUALLY BLEW THE HEAD GASKET IN IT NOT KNOWING THAT THE WATER PUMP WAS ALSO GOING IN IT I HAD NOTHING BUT PROBLEMS FROM THE FIRST DAY I BOUGHT IT I SPENT MY WHOLE $4, 700 FROM MY SETTLEMENT TO GET THIS VEHICLE AND I HAVE NOTHING BUT PROBLEMS ON IT'S GOT 60, 000 MILES ON IT AND IT'S IT'S IN MY BACKYARD MY WIFE AND I DON'T HAVE A VEHICLE BECAUSE THIS OVERHEATED AND CAUSED IT TO BLOW THE HEAD GASKET I CHANGE THE WATER PUMP TIMING BELT EVERYTHING AND THEN IT BLEW A HEAD GASKET PLEASE HELP ME MY WIFE AND I ARE STUCK BECAUSE WE HAVE NO WAY TO GETTING AROUND AND I'M NOT ABLE TO WORK BECAUSE I DON'T HAVE A VEHICLE WE STRUGGLED SINCE OUR AUTO ACCIDENT AND THIS IS JUST BEEN ONE HURDLE THAT WE ARE NOT ABLE TO GET OVER IT PLEASE HELP ME

NHTSA ID

11195963

Incident

Dec 1, 2017

Mileage

55,000 mi

TAKATA RECALL THIS VEHICLE WAS INVOLVED IN A T-BONE ACCIDENT IN WHICH DRIVERS SIDE BACK SEAT TO REAR HATCH WAS T-BONED. BOTH FRONT AIRBAGS DEPLOYED AT IMPACT. THE PASSENGER SIDE AIRBAG WAS PRISTINE WHITE WITHOUT ANY FRAY WHEN DEFLATED. THE DRIVERS SIDE AIRBAG WAS FULL OF GUN SHOT RESIDUE AND BAG FRAYED. THE DRIVERS SEAT BELT WAS BURNED (BELT WAS CHARRED) ONTO DRIVERS CHEST AND THERE WAS AN APPARENT PUNCTURE WOUND LEFT OF CENTER CHEST AND MY SIGNIFICANT OTHER WAS DECEASED. THIS HAPPENED JAN 27, 2019. I'M WAITING ON CERTIFIED REPORTS FROM LA COUNTY CORONER AND CHP. DUE END MARCH, EARLY APRIL. *DSY

NHTSA ID

11187144

Incident

Jan 27, 2019

Mileage

150,000 mi

DOME LIGHTS DO NOT ALWAYS GO OUT WHEN DOORS ARE CLOSED. SOMETIMES DOME LIGHTS COME ON WHEN SIGNALS ARE USED. COULD RUN BATTERY DONE IF NOT NOTICED

NHTSA ID

11063389

Incident

Jun 1, 2007

Mileage

100,000 mi

MY LIGHTS SHUT OFF WHILE DRIVING. NOT ONLY DID MY HEADLIGHTS SHUT OFF BUT MY DASH BOARD LIGHTS AND THE LIGHTS ON MY GEAR SHIFT DID AS WELL. MY DOORS WILL NOT LOCK AS WELL.

NHTSA ID

11057044

Incident

Dec 22, 2017

Mileage

224,441 mi

VEHICLE RECALLED IN 2004 FOR POWER STEERING PRESSURE HOSE LEAK POTENTIAL. RECALL WAS COMPLETED. POWER STEERING PRESSURE HOSE IS NOW LEAKING. CHRYSLER WILL NOT HONOR A REPAIR.

NHTSA ID

11045674

Incident

Oct 17, 2017

Mileage

82,000 mi

TAKARA RECALL. WHILE CHANGING UPPER AND LOWER MOTOR MOUNT I NOTICED SUB FRAME ON THE PASSENGER'S SIDE WAS ROTTED AND AFTER I PUT MOUNTS IN THE CAR PULLS WHEN ACCELERATING

NHTSA ID

10995582

Incident

Jun 10, 2017

Mileage

170,311 mi

ON RETURNING HOME FROM AN EVENT IN THE EVENING I PARKED MY VEHICLE IN THE GARAGE. I TURNED OFF LIGHTS AND THEN THE IGNITION AND EVERYTHING SHUT DOWN EXCEPT THE FOG LIGHTS STAYED ON (THE VEHICLE WAS COMPLETELY SHUT OFF). I NEVER HAD THE FOG LIGHTS ON THAT EVENING. I TRIED VARIOUS A TEMPS I.E. PUSHING THE BUTTEN IN, TURNING THE VEHICLE ON AND THEN OFF AGAIN, ETC., BUT DID NOT HAVE ANY SUCCESS. MY WIFE WENT ONLINE AND FOUND (FROM MANY PEOPLE HAVING THE SAME PROBLEM WITH THEIR PT CRUSIERS) TO PUT THE LEFT TURN SIGNAL ON, SHUT OFF THE VEHICLE, THEN PUSH THE FOG LIGHT BUTTEN IN. THIS WORKED SO THAT I DIDN'T WAKE UP TO A DEAD BATTERY. IF YOU GO ONLINE YOU WILL FIND MANY PEOPLE WHO OWN PT CRUISERS WITH THE IDENTICAL PROBLEM INCLUDING SOME HAVING SMOKE COMING FROM THE MULTI FUNCTION SWITCH. I HOPE TO HEAR FROM SOMEONE SOON!!

NHTSA ID

10968457

Incident

Mar 24, 2017

Mileage

48,000 mi

TAKATA RECALL: I WAS DRIVING NORTH, TURNING RIGHT ON A 20 MPH CURVE, WHEN SOMEONE HEADING SOUTH, TURNED LEFT ON THE CURVE, WENT OVER THE LINE AND HIT ME HEAD ON. WHEN I CAME TO, I HEARD MYSELF SCREAMING THAT I WAS ON FIRE! ( BUT MY CAR WAS NOT ON FIRE.) THEN I DIDN'T REMEMBER ANYTHING UNTIL I WOKE UP IN THE HOSPITAL. I WAS COVERED IN THIS HOT POWDERY SUBSTANCE AND I HAD BURNS WHERE EVER MY SKIN WAS SHOWING. I HAD CUTS EVERYWHERE AND DARK MARKS IN MY SKIN FOR YEARS. I HAD CORNEAL SCRATCHES AND IRRITATED EYES TOO, ALONG WITH DISLOCATED JAW, SEAT BELT INJURIES AND A FEW OTHER INJURIES. MY TMJ SPECIALIST REALIZED I HAD METAL IN MY FACE, LOOKING AT MY MRI. A FEW DAYS AFTER THE MRI, MY FACE SWELLED UP ON THE RIGHT SIDE, MY RIGHT EYE WAS SWOLLEN SHUT AND MY FACE HAD A HUGE BUMP WHERE THE METAL FESTERED UP FROM THE MRI, THE ER LANCED IT OPEN, FOUND PARTICALS BUT DIDN'T DO A BIOPSY, JUST THREW IT AWAY. I NEVER HAD FACE SURGERY OR ANYTHING LIKE THAT AND IT WAS TOO HIGH ON MY CHEEK TO BE FROM DENTAL WORK. I HAVE DOCUMENTS ON ACCIDENT REPORTS, DRS DOCUMENTS, X RAYS, MRI'S SHOWING THE BLOOM OF METAL HIDING MY BROKEN JAW. I HAVE PICTURES TOO OF ME AND DEPLOYED AIRBAGS. ALTHOUGH I DON'T HAVE THEM HERE TO SCAN. HOPEFULLY I CAN COME BACK TO MY FORM AND UPDATE ANY INFORMATION THAT IS MISSING. THANK YOU. MY TMJ DR AND MY MAXIO FACIAL SPECIALIST SAID IT HAD TO BE SHRAPNEL AND THEY CANNOT MAKE ANY PROPER DIAGNOSIS OF MY TMJ OR BROKEN JAW. I STILL HAVE PAIN AND STILL HAVE SHRAPNEL THAT HAS BEEN COMING OUT OF MY EYE AREA AND FACE FOR SOME TIME. I KNEW OF ALL OF THIS PRIOR TO THE TAKATA ISSUES, I HAVEN'T BEEN WELL ENOUGH TO FOLLOW THROUGH WITH YOU UNTIL NOW. THANK YOU FOR YOUR TIME.

NHTSA ID

10958273

Incident

Feb 10, 2012

Mileage

90,000 mi

ENGINE CRADLE, OR FRONT SUBFRAME, IS RUSTED TO THE POINT I'VE STOPPED DRIVING THE CAR. I'M IN THE PROCESS OF FINDING A REPLACEMENT BUT CHRYSLER NO LONGER MAKES THE PART! NOTHING HAS HAPPENED TO THIS POINT BECAUSE OF MY CAUTION BUT THE FRONT END WAS STARTING TO MAKE POPPING NOISES WHEN I STARTED OUT FROM A DEAD STOP. THE PROBLEM IS ON THE FRONT PASSENGER SIDE. I UNDERSTAND FROM READING ARTICLES, MANY OTHER PTS HAVE THIS SAME PROBLEM. FOR YEARS, I HAVE TRIED TO PRIME AND SPRAY OIL ON THE PART TO EXTEND IT'S LIFE. TIME HAS COME.... *TR

NHTSA ID

10920082

Incident

Oct 30, 2016

Mileage

294,000 mi

TAKATA RECALL. I WAS DRIVING DOWN THE HIGHWAY AND MY HEADLIGHTS WENT OUT I PULLED OVER AND I DIDNT HAVE DOOR LOCKS TO UNLOCK THE DOORS. ALL THE FUSES ARE GOOD. I WAS RESEARCHING ONLINE AND ALOT OF PT CRUISERS ARE HAVING THE ISSUE IT SEEMS THAT THE CONNECTOR FOR THE FUSE BLOCK GOES BAD I HAVE BEEN DEALING WITH THIS FOR A FEW MONTHS NOW. I THINK ITS REDUNDANT THAT YPU HAVE TO PAY 150-250 DOLLARS EVERY TIME THIS HAPPENS. WHEN NO ONE REALLY HAS THAT KINDA MONEY

NHTSA ID

10919959

Incident

May 13, 2016

Mileage

135,000 mi

TL* THE CONTACT OWNED A 2002 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 40 MPH, ANOTHER VEHICLE RAN A RED LIGHT AND CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAG DEPLOYED AND METAL FRAGMENTS STRUCK THE CONTACT'S FACE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO THE CONTACT'S RESIDENCE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

NHTSA ID

10919006

Incident

Nov 12, 2014

Mileage

120,000 mi

..ON MY 2002 PT CRUISER THE FRONT SUSPENSION CROSS MEMBER HAS ROTTED SO BAD THAT IT BROKE IN A FEW PLACES CAUSING THE LOWER A ARM TO MOVE IN SUCH A WAY AS TO CAUSE THE STEERING WHEEL TO PULL OUT OF YOUR HANDS ALL THE WAY TO THE LEFT AND OR RIGHT,THE CAR COULD NOT BE DRIVEN MORE THEN 15 MPH,..AND THAT WAS WHILE HOLDING THE WHEEL TIGHTLY....IF THIS CROSS MEMBER WAS TO BREAK WHILE DRIVING 65 MPH THERE WOULD BE A VERY BAD CRASH,..I SUGGEST ANY ONE THAT HAS A PT CRUISE HAVE IT CHECKED FOR THE CROSS MEMBER ROTTING BEFORE A CRASH TAKES PLACE,,,I WAS ABLE TO BUY A NEW CROSS MEMBER AND THE CHEAPEST PRICE WAS $514 PLUS TAX AND SHIPPING,..NOW COMES THE COSTS TO INSTALL IT...WHAT IS ODD THE CROSS MEMBER ROTTED OUT ON THE PASSENGER SIDE ONLY,...I HAVE SOME PICS OF IT WITH THE A ARM OFF THE CROSS MEMBER..

NHTSA ID

10913849

Incident

Sep 28, 2016

Mileage

116,500 mi

STRUCTURE - NOTICED SLIGHT CLUNK FROM FRONT SUSPENSION ON BUMPS. ON MECHANIC'S LIFT, FOUND ALL SUSPENSION PARTS STILL GOOD OR RECENTLY REPLACED, BUT FRONT K-MEMBER SEVERELY RUSTED THROUGH. DECLARED UNSAFE AND UNFIXABLE, ALTHOUGH AT 112,000 MILES THE REST OF THE CAR IS STILL IN GREAT SHAPE.

NHTSA ID

10897162

Incident

Aug 18, 2016

Mileage

112,884 mi

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED, A WARNING LIGHT ILLUMINATED, AND AN ALARM SOUNDED. THE FAILURE RECURRED TEN TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ALARM SYSTEM NEEDED TO BE RESET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10875997

Incident

May 31, 2016

Mileage

130,000 mi

ENGINE STARTS AND RUNS, BUT AS SOON AS I PUT IT INTO ANY GEAR BUT PARK, THE CAR IMMEDIATELY DIES. IT WILL RESTART, BUT AGAIN DIES WHEN PLACED IN A GEAR. THE CHECK ENGINE LIGHT CAME ON SO I HAD MY MECHANIC LOOK AT IT. HE CHECKED FOR CODES AND THIS IS THE CODE THAT CAME UP (P0601). IT HAS 83500 MILES. HE SAYS IT NEED A NEW COMPUTER. THIS INITIALLY STARTED BACKING INTO TRAFFIC, THE CAR JUST QUIT. I STARTED IT BACK UP AND WENT TO PUT IT IN DRIVE AND IT AGAIN QUIT. THIS HAPPENS OVER AND OVER, UNTIL SOMEONE PUSHED ME OUT OF THE STREET. CAR IS NOW PARKED UNTIL IT IS REPAIRED.

NHTSA ID

10872620

Incident

Jun 2, 2016

Mileage

83,500 mi