2002 Chrysler Pt Cruiser Exterior lighting Problems

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE HIGH BEAM HEAD LAMPS WOULD ILLUMINATE RANDOMLY DAY OR NIGHT. THE CONTACT STATED THAT THE FAILURE OCCURRED AT LEAST SIX TIMES IN ONE WEEK. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE MULTI-FUNCTION SWITCH THAT CONTROLLED THE HEADLIGHTS WAS REPLACED BY HIM. THE CONTACT NOTICED THAT THE PLASTIC CLIP HOLDING THE ELECTRICAL HARNESS TO THE SWITCH HAD BURNED. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.

NHTSA ID

11219448

Incident

Jun 11, 2019

Mileage

153,000 mi

DOME LIGHTS DO NOT ALWAYS GO OUT WHEN DOORS ARE CLOSED. SOMETIMES DOME LIGHTS COME ON WHEN SIGNALS ARE USED. COULD RUN BATTERY DONE IF NOT NOTICED

NHTSA ID

11063389

Incident

Jun 1, 2007

Mileage

100,000 mi

MY LIGHTS SHUT OFF WHILE DRIVING. NOT ONLY DID MY HEADLIGHTS SHUT OFF BUT MY DASH BOARD LIGHTS AND THE LIGHTS ON MY GEAR SHIFT DID AS WELL. MY DOORS WILL NOT LOCK AS WELL.

NHTSA ID

11057044

Incident

Dec 22, 2017

Mileage

224,441 mi

ON RETURNING HOME FROM AN EVENT IN THE EVENING I PARKED MY VEHICLE IN THE GARAGE. I TURNED OFF LIGHTS AND THEN THE IGNITION AND EVERYTHING SHUT DOWN EXCEPT THE FOG LIGHTS STAYED ON (THE VEHICLE WAS COMPLETELY SHUT OFF). I NEVER HAD THE FOG LIGHTS ON THAT EVENING. I TRIED VARIOUS A TEMPS I.E. PUSHING THE BUTTEN IN, TURNING THE VEHICLE ON AND THEN OFF AGAIN, ETC., BUT DID NOT HAVE ANY SUCCESS. MY WIFE WENT ONLINE AND FOUND (FROM MANY PEOPLE HAVING THE SAME PROBLEM WITH THEIR PT CRUSIERS) TO PUT THE LEFT TURN SIGNAL ON, SHUT OFF THE VEHICLE, THEN PUSH THE FOG LIGHT BUTTEN IN. THIS WORKED SO THAT I DIDN'T WAKE UP TO A DEAD BATTERY. IF YOU GO ONLINE YOU WILL FIND MANY PEOPLE WHO OWN PT CRUISERS WITH THE IDENTICAL PROBLEM INCLUDING SOME HAVING SMOKE COMING FROM THE MULTI FUNCTION SWITCH. I HOPE TO HEAR FROM SOMEONE SOON!!

NHTSA ID

10968457

Incident

Mar 24, 2017

Mileage

48,000 mi

TAKATA RECALL. I WAS DRIVING DOWN THE HIGHWAY AND MY HEADLIGHTS WENT OUT I PULLED OVER AND I DIDNT HAVE DOOR LOCKS TO UNLOCK THE DOORS. ALL THE FUSES ARE GOOD. I WAS RESEARCHING ONLINE AND ALOT OF PT CRUISERS ARE HAVING THE ISSUE IT SEEMS THAT THE CONNECTOR FOR THE FUSE BLOCK GOES BAD I HAVE BEEN DEALING WITH THIS FOR A FEW MONTHS NOW. I THINK ITS REDUNDANT THAT YPU HAVE TO PAY 150-250 DOLLARS EVERY TIME THIS HAPPENS. WHEN NO ONE REALLY HAS THAT KINDA MONEY

NHTSA ID

10919959

Incident

May 13, 2016

Mileage

135,000 mi

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE FOG LIGHTS ILLUMINATED INDEPENDENTLY AND WOULD NOT TURN OFF. THE CONTACT ALSO STATED THAT THERE WAS AN ODOR AND EVIDENCE OF SMOKE COMING FROM THE STEERING WHEEL. AFTERWARDS, THE CONTACT WAS ABLE TO TURN THE FOG LIGHTS OFF AND THE ODOR DISSIPATED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

NHTSA ID

10861357

Incident

Apr 25, 2016

Mileage

180,000 mi

2002 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO VEHICLE HEADLIGHTS AND OTHER ELECTRICAL PROBLEMS. *SMD THE CONSUMER STATED HIS WIFE WENT TO TURN ON THE HEADLIGHTS, AND DISCOVERED THEY DID NOT WORK. THE CONSUMER'S SON CHECKED THE SWITCH ASSEMBLY AND FOUND A SHORTAGE IN THE ASSEMBLY. THE CONSUMER SON DISCOVERED SOME OF THE WIRING COMING FROM THE ASSEMBLY WAS BARE. *JB

NHTSA ID

10805823

Incident

Oct 1, 2015

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE ATTEMPTING TO START THE VEHICLE, ALL THE METERS, GAUGES, AND INSTRUMENT PANEL LIGHTING FAILED TO FUNCTION. IN ADDITION, THE INTERIOR LIGHTING ALSO FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

NHTSA ID

10712646

Incident

Apr 21, 2015

Mileage

135,000 mi

I HAD JUST PUT FUEL IN MY CAR AND WAS DRIVING ACROSS A PARKING LOT. I PROCEEDED TO PARK MY CAR AND NOTICED SMOKE RISING OUT OF MY STEERING WHEEL AND A BURNING SMELL. MY LOWER SET OF LIGHTS ( FOG LIGHTS) HAD TURNED ON BY THEMSELVES, WHICH IS ODD SINCE THEY HAVEN'T BEEN WORKING FOR AT LEAST TWO YEARS. IN ORDER TO STOP THE SMOKING IN THE STEERING WHEEL, I HAD TO REMOVE FUSE #8. SAME SET OF LIGHTS HAVE TURNED ON BEFORE A FEW YEARS BACK DRAINING MY BATTERY SINCE I COULDN'T TURN THEM OFF WITH THEIR SWITCH. IN ADDITION, MY HEADLIGHTS TURN OFF AUTOMATICALLY AT RANDOM WHILE I'M DRIVING AND MY CLOCK LIGHTS GO OUT FREQUENTLY. HEADLIGHTS HAVE GONE OUT ON ME 5 TIMES OVER THE PAST 3 YEARS. I TRY NOT TO DRIVE MUCH AT NIGHT AS A RESULT. *TR

NHTSA ID

10668604

Incident

Dec 23, 2014

Mileage

124,000 mi

FOG LIGHTS CAME ON BY THEMSELVES WHILE PARKED WITH NO KEY IN IGNITION (WHILE AT WORK). COMMON ISSUE FOUND ALL OVER THE INTERNET. CAUSE IS A DEFECTIVE MULTI-FUNCTION SWITCH. SMELLED A BURNING SMELL. REPAIR SHOP WAS UNABLE TO FIND ANY PROBLEMS THROUGH DIAGNOSTICS WHICH WAS BEFORE THE CAR HAD BEEN SEEN DURING THE DAY WITH IT'S RUNNING LIGHTS ON. THAT DRAINED THE BATTERY AND REQUIRED A JUMP START. HAPPENED SEVERAL TIMES. DUE TO OVERWHELMING NUMBER OF COMPLAINTS LISTED THROUGHOUT THE INTERNET FOR THIS SAME ISSUE WE FEEL A RECALL SHOULD BE ISSUED AS THIS IS A FIRE HAZARD. THE 15 AMP FUSE (NUMBER 8 ON INTERIOR FUSE PANEL) NEVER BLEW BUT WAS DISCOLORED FROM HEAT. *TR

NHTSA ID

10641402

Incident

Sep 26, 2014

Mileage

120,000 mi

FOG LIGHTS WON'T TURN OFF, STAYED ON LONG ENOUGH TO RUN DOWN BATTERY. NOT GOOD FOR SINGLE ELDERLY WOMAN VOLUNTEER STUCK IN A PARKING LOT ACROSS TOWN. UNDERSTAND THE PROBLEM HAS BEEN REPORTED IN MANY, MANY VEHICLES FOR AT LEAST 10 YEARS. DID I MISS A RECALL? I'M THE ORIGINAL OWNER. WHERE IN THE WORLD WILL I FIND A MULTIFUNCTION SWITCH AND SOMEONE TO INSTALL IT? WILL THE COMPANY COVER THE COST? ARE THEY ON A FIXED INCOME? *TR

NHTSA ID

10594932

Incident

May 29, 2014

Mileage

98,000 mi

MY WIFE'S CAR HAS HAD ISSUES SINCE WE GOT THE CAR. I HAVE HAD THE BATTERY REPLACED AND IT IS STILL NOT HOLDING A CHARGE. I FOUND THAT WHILE JUMP STARTING THE CAR, YOU GET SPARKS AS YOU ATTACH THE CABLES. THIS IS EVIDENCE OF A SHORT SOMEWHERE IN THE VEHICLE. THE ISSUES THAT I HAVE FOUND ARE NONFUNCTIONAL INTERIOR LIGHTS, MIRROR CONTROLS, DOOR LOCKS, AND RADIO. I HAVE FOUND RECALL INFORMATION ON VEHICLES WITH THIS SAME YEAR, MAKE, AND MODEL. UPON CALLING DAIMLER CHRYSLER I WAS INFORMED THAT THIS VEHICLE WAS NOT INVOLVED IN THIS RECALL. I MA HAVING THE SAME ISSUES AS VEHICLES IN THIS RECALL. *TR

NHTSA ID

10577641

Incident

Mar 3, 2014

Mileage

128,500 mi

THE ELECTRONIC DOOR LOCKS ON MY 2002 PT CRUISER LIMITED STARTED OPERATING BY THEMSELVES TWO YEARS AGO. I HAVE HAD THIS CAR SINCE IT WAS NEW AND HAD THE MULTIFUNCTION TURN SIGNAL SWITCH REPLACED ABOUT 3 YEARS AGO. THE DOOR LOCK PROBLEM SOMETIMES OCCURS WHEN YOU ARE DRIVING THE CAR AT LOW SPEED BUT IT WILL ALSO OCCUR WHEN THE CAR IS SETTING IN THE GARAGE WITH THE KEY OUT OF THE IGNITION. THE DOORS WILL LOCK AND UNLOCK SEVERAL TIMES ON THEIR OWN WHILE DRIVING OR WITHOUT ANYONE BEING IN THE CAR OR TOUCHING THE REMOTE KEYLESS ENTRY SYSTEM. THIS CAN PRESENT PROBLEMS IF THE CAR IS LOCKED AND IN A PUBLIC PARKING LOT. THE CARE SOMETIMES WILL UNLOCK ON ITS OWN. YOU CAN ALSO BE LOCKED OUT OF THE CAR IF YOU DON'T TAKE YOUR KEYS WITH YOU WHEN EXITING THE CAR. THIS SEEMS TO HAPPEN MORE DURING HOT SUMMER WEATHER THAN DURING COOLER WINTER MONTHS. I HAVE ALSO NOTED THAT THE EXTERNAL TEMPERATURE GAUGE AND COMPASS MOUNTED ABOVE THE FRONT WINDOW WILL ALSO GO OUT DURING HOT WEATHER. WHEN THE CAR COOLS DOWN WITH THE AIR CONDITIONER ON, THE EXTERNAL TEMPERATURE GAUGE WILL START OPERATING AGAIN. I HAVE TAKEN THE CAR TO THE DEALER THREE TIMES TO BE FIXED. THE FIRST TIME THEY CHARGED TO DIAGNOSE THE PROBLEM AND SAID NOTHING WAS WRONG, THE SECOND TIME THEY SAID THE BATTERY CABLE WAS CORRODED AND NEED REPLACED AT $300 AND IT NEEDED A NEW BATTERY. AFTER THIS WORK, I DROVE IT AROUND THE BLOCK AND THE DOOR LOCKS STARTED GOING WILD AGAIN. SO I WENT BACK TO THE SERVICE MANAGER AND HE SAID THEY WOULD HAVE TO HAVE THE CAR FOR SEVERAL DAYS AND THEY WOULD GET THE DISTRICT SERVICE MANAGER ON THE PHONE TO SEE IF HE MIGHT BE ABLE TO HELP THEM. AT THAT POINT WE WENT INTO WINTER AND IT WAS OK. IT IS DOING IT AGAIN THIS SPRING SO I WILL TRY AGAIN. *TR

NHTSA ID

10511597

Incident

Jun 3, 2011

Mileage

42,000 mi

THE PROBLEM I AM HAVING STARTED ABOUT 2 MONTHS AGO, MY BATTERY WAS SUDDENLY DRAINED AND I HAD NO IDEA WHY. I HAD TO BUY A NEW BATTERY FOR ABOUT $125. *TR WHEN MY FOG LIGHT INDICATOR BEGAN TO FLICKER ON AND OFF ON ITS OWN. I'D JUST PRESS THE END OF TURN SIGNAL ARM INWARD TOWARDS THE STEERING COLUMN AND THE INDICATOR LIGHT WENT OFF. GRADUALLY, THE PRESSING PROCESS DID NOT WORK ANYMORE AND I DISCOVERED THAT SHUTTING OFF THE CAR WITH THE LEFT HAND TURN SIGNAL PRESSED DOWN, AT LEAST TEMPORARILY SOLVED THE PROBLEM (SO I COULD DO SOME RESEARCH ON ITS SOLUTION). NOT KNOWING WHAT TO DO, I BROUGHT IT INTO THE DEALER AND FOR $65 THEY DIAGNOSED IT AT A NEED TO REPLACE THE MULTIFUNCTION SWITCH WHICH THEY SAID REQUIRED THE PULLING OF STEERING WHEEL AND OVER $600 MORE TO FIX. I OPTED OUT ON THAT, SINCE CAR HAS 112,000 MILES ON IT. THEN, WITH A WEEK OF VERY HOT 90 DEGREE TEMPERATURES, , I FOUND THAT BRAND NEW BATTERY TOTALLY DRAINED AND BEGAN READING THE INTERNET POSTS OF THE POSSIBILITY OF PULLING THE FUSE. OF COURSE BEING A USA CAR, THE MANUAL DIDN'T IDENTIFY THE FUSE FOR THE FOG LAMPS IN THE "UNDER THE HOOD" FUSE BOX. IT SEEMS THAT THE HEAT ALLOWS THE FOG LAMPS TO STILL TURN ON WHEN THE LEFT HAND SIGNAL ARM IS PRESSED DOWNWARDS. GOING FURTHER, I FOUND THAT FUSE #8 IN THE INTERIOR DASHBOARD FUSE BOX COULD BE PULLED AND SHOULD SOLVE THE PROBLEM WITHOUT FURTHER REPAIR. I FIND IT VERY INTERESTING THAT CHRYSLER DOES NOT EVEN SHOW YOU A SKETCH OF THE INTERIOR FUSE BOX IN THEIR OWNERS MANUAL.THIS APPROACH DOES MEAN THAT THE MANUFACTURER OF THE VEHICLE IS NOT ALLOWING THE BUYER (ME) TO FULLY ENJOY ALL THE FEATURES OF THE VEHICLE! SEEMS TO ME THAT CHRYSLER CORPORATION HAS NOT RECALLED THE DEFECTIVE CARS ON PURPOSE AND NEEDS TO HAVE A DEBACLE LIKE TOYOTA HAD BEFORE THEY WILL DO THE RIGHT THING AND FIX A BAD DESIGN. .

NHTSA ID

10470235

Incident

Aug 10, 2012

Mileage

112,000 mi

I UNLOCKED MY CAR DOORS WITH REMOTE, AND DROVE TO THE STORE, IT WAS DARK OUT SO I HAD MY HEAD LIGHTS ON. WHEN I CAME OUT OF THE STORE AND TRIED TO UNLOCK MY CAR, IT WOULD NOT WORK. SO I MANUALLY UNLOCKED THE DOORS WITH MY KEY. IT WAS VERY COLD WEATHER AT THAT TIME AND MY HEATER WOULD NOT WORK AS WELL THEN I TURNED ON MY CAR TO GO HOME, AND MY LIGHTS WOULD NOT COME ON. AND SO I WAS TOWED HOME. THE NEXT DAY I TOOK IT IN TO A CHRYSLER REPAIR SHOP AND THEY DID A QUICK CHECK ON IT AND SAID THAT IT MIGHT BE THE ELECTRICAL AND THEY WOULD HAVE TO GO THROUGH THE ENTIRE ELECTRICAL TO FIND THE PROBLEM. THEY CHECKED EVERYTHING OUT WITHOUT TEARING THE ENTIRE CAR APART AND SAID THAT THEY COULD NOT FIND A PROBLEM WITH IT. THERE WENT $100.00 OF MY MONEY TO FIND OUT THAT THEY COULD NOT FIND THE PROBLEM. I DON'T KNOW WHAT ELSE TO DO TO GET THE CAR REPAIRED WITH OUT HAVING TO SPEND $1,000.00 PLUS.... WHICH IS A QUOTE BY THE CHRYSLER REPAIR. I HAVE NOT BEEN ABLE TO DRIVE MY CAR AT NIGHT, DUE TO NO LIGHTS AND NOW THAT WE HAVE HOT 90 TO 101 DEGREE WEATHER, I CAN NOT DRIVE MY CAR DURING THIS PERIOD OF TIME DUE TO NOT BEING ABLE TO USE THE AIR CONDITIONER OR TO ROLL MY WINDOWS DOWN. I HAVE SPENT OVER $3,000.00 IN REPAIRS FOR MY CAR AND I HAVE ONLY HAD IT FOR JUST TWO YEARS. THERE IS ONE THING AFTER ANOTHER WITH MY CAR, THE PROBLEMS ARE HAVING TO REPLACE PARTS AND SOMETIMES HAVING TO REPLACE THOSE SAME PARTS A YEAR LATER WHEN THEY HAVE JUST RAN OUT OF THE WARRANTIES. I HAVE SERVICE RECORDS FOR ALL OF THESE PROBLEMS AND IT IS ALMOST 2 INCHES THICK. I AM ON DISABILITY AND IT TOOK ME OVER A YEAR TO SAVE THE ENOUGH MONEY TO BUY THIS CAR AND I HAVE NO MORE MONEY TO FIX IT AGAIN... AND I HAVE TO TAKE IT THROUGH DEQ HERE IN OREGON AND IT WILL NOT PASS THEIR TEST DUE TO EXHAUSTION PROBLEMS WITH THE EMISSIONS LEAKING AS WELL. *TR

NHTSA ID

10466957

Incident

Feb 7, 2012

Mileage

185,000 mi

10-18-2011 I JUST BOUGHT MY CAR LAST MONTH (09-26-2011) AND MY CONTROL ARMS AND BUSHING HAVE ALREADY WENT BAD. NOW 2 NIGHTS AGO (10-16-2011) MY HEADLIGHTS STOPPED WORKING. I TOOK IT INTO THE DEALERSHIP TO HAVE EVERYTHING CHECKED AND WAS TOLD THAT THE WIRING UNDER THE DASH IS MESSED UP. I SEE THAT THERE ARE A LOT OF RECALLS FOR THAT HAPPENING TO THE 2002 PT CRUISERS AND NOW THE DEALER I BOUGHT THE CAR FROM WILL NOT FIX IT (EVEN THOUGH I'M STILL WITHIN MY 30 DAY WARRANTY) I DO NOT UNDERSTAND WHY I SHOULD HAVE TO COME OUT OF POCKET TO FIX THIS PROBLEM. ALSO, THE DEALER I BOUGHT IT FROM WOULD NOT GIVE ME A CARFAX ON THE VEHICLE. ALSO, SOLD ME THE CAR WITH A RECALL ALREADY ON IT THAT WAS ISSUED WAY BACK IN 2004. (POWER STEERING PRESSURE HOSE) THAT I WAS TOLD COULD CAUSE A FIRE UNDER THE HOOD. *TR

NHTSA ID

10430685

Incident

Oct 16, 2011

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THE FOG LAMPS WOULD REMAINED ON AFTER THE VEHICLE WAS TURNED OFF. THE CONTACT HAD TO REMOVED THE FUSE IN ORDER TO TURN THE FOG LAMPS OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE SWITCH THAT OPERATED THE EXTERNAL LIGHTS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY OF THE RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

NHTSA ID

10420714

Incident

Jul 1, 2011

Mileage

103,000 mi

FOG LIGHTS AUTOMATICALLY TURNING ON BY THEMSELVES WITHOUT THE OWNERS KNOWLEDGE...LATER ON IN THE DAY IT WOULD CAUSE ISSUES WITH THE HEADLIGHTS NOT WANTING TO WORK OR THEM GOING OFF WHEN YOU NEED THEM WHICH COULD POTENTIALLY CAUSE AN ISSUE. PLEASE REVIEW THE FOLLOWING WEBSITE FOR OTHER POTENTIAL ISSUES WITH OTHER CONSUMERS: HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHRYSLER-PT-CRUISER/TF81KHBDLDVT92AH2/P7. *TR

NHTSA ID

10417027

Incident

Apr 15, 2011

Mileage

145,000 mi

TL* THE CONTACT OWNS 2002 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS PARKED AND THE ENGINE WAS TURNED OFF, THE FOG LIGHTS BEGAN TO ILLUMINATE WITHOUT INTENT. THERE WERE SEVERAL ATTEMPTS BEFORE THE FOG LIGHTS WOULD TURN OFF. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.

NHTSA ID

10411746

Incident

Jul 10, 2011

Mileage

32,000 mi

TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS PARKED THE FOG LIGHTS CAME ON AND CAUSED THE BATTERY TO FAIL. THE CONTROL SWITCH FOR THE FOG LIGHTS CONTINUED TO REMAIN ILLUMINATED ON THE STEERING COLUMN WHEN THE LIGHTS TURNED OFF. THE VEHICLE WAS NOT INSPECTED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 94,000.

NHTSA ID

10334304

Incident

May 30, 2010

Mileage

94,000 mi

TL*THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE DRIVING AT APPROXIMATELY 30 MPH WITH THE FOG LAMP ILLUMINATED, THE CONTACT NOTICED A BURNING SMELL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE A SWITCH IN THE STEERING COLUMN WAS REPLACED. SOME TIME LATER, THE CONTACT WAS UNABLE TO TURN OFF THE FOG LIGHTS. SHE CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 56,000. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000.

NHTSA ID

10326775

Incident

Apr 12, 2010

Mileage

28,000 mi

FOG LIGHTS WOULD NOT TURN OFF. BROUGHT INTO DEALERSHIP IN EL SEGUNDO, CA FOR REPAIR ON 03/29/06 WAS TOLD IT WAS AN INTERNAL SWITCH AND REPAIRED FOR $86.58. I THOUGHT THE PROBLEM WAS REPAIRED. THEN IN 2008 IT HAPPENED AGAIN AND I TOOK IT INTO ANOTHER DEALERSHIP IN W. LOS ANGELES, CA AND THEY TOLD ME IT WAS A SWITCH IN THE STEERING COLUMN SO IT HAD TO BE REPLACED AND THAT TOTALED APPROXIMATELY $340. NOW ON EASTER (04/04/10) ON MY WAY TO A BBQ TO MY PARENTS HOME, THE FOG LIGHTS CAME ON AGAIN ...AND WOULDN'T TURN OFF AGAIN. BUT THIS TIME IT CAUSED ME TO PANIC BECAUSE IT OVERHEATED AND SMOKE STARTED TO COME OUT OF THE HAZARD LIGHT SWITCH AND TURN SIGNAL SWITCH WHILE I WAS JUST GETTING OFF THE FREEWAY. I WAS LUCKY BECAUSE I WAS NOT TO FAR FROM MY PARENTS HOME WHERE MY BROTHER WHO WAS FORMALLY A MECHANIC HAD THE MIND TO PULL OUT THE FUSE TO THE FOG LIGHTS. THE FUSE WAS VERY HOT WHEN HE PULLED IT OUT AND THE SMOKING STOPPED. HE DID STATE THAT THE CAR COULD OF CAUGHT FIRE IF HE HAD NOT PULLED THE FUSE OUT IN TIME. I WAS LUCKY. I DO HAVE THE OLD PART AVAILABLE. *TR

NHTSA ID

10324085

Incident

Apr 4, 2010

Mileage

92,171 mi

THERE HAS BEEN NUMEROUS PROBLEMS WITH CHRYSLER PT CRUISER ELECTRICAL SYSTEMS, NAMELY THE MULTIFUNCTION CONTROL SWITCH SEEMS TO OVERHEAT AND CAUSE AN ELECTRICAL SHORT. THIS DEPLETES THE BATTERY, AND HAS LED A NUMBER OF PT CRUISER OWNERS TO REPLACE THE MULTIFUNCTION CONTROL SWITCH NUMEROUS TIMES OR REMOVE THE FUSES FOR LIGHTS, SUCH AS THE FOG LIGHTS. CHRYSLER KNOWS THAT THERE IS A SYSTEMATIC PROBLEM WITH THEIR VEHICLE BUT ARE NOT WILLING TO DO ANYTHING TO RESOLVE THE PROBLEM. INFORMATION ON SUCH EXPERIENCES CAN BE FOUND ON THE WEB AT FORUMS SUCH AS HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHRYSLER-PT-CRUISER/TF81KHBDLDVT92AH2 OR AT PTCRUISER.COM. *TR

NHTSA ID

10299029

Incident

Oct 15, 2009

Mileage

46,514 mi

MULTI-FUNCTION SWITCH CONNECTOR HOUSING DEGRADES DUE TO HEAT EXPOSURE OVER TIME WHICH CAN CAUSE SHORTING, LIGHT OR TURN SIGNAL FAILURE OR A SMOKE/FIRE HAZARD. THE FIRST INDICATION OF A PROBLEM WAS THAT THE FOG LAMPS WOULD TURN ON BY THEMSELVES. OTHER OWNERS HAVE REPORTED THE MAIN LIGHTS TURNING ON AND A FEW INSTANCES OF THE STEERING COLUMN BILLOWING SMOKE WHILE DRIVING. CHRYSLER HAS 2000+ MULTI-FUNCTION SWITCHES ON BACK ORDER AND REFUSES TO ACKNOWLEDGE THE ISSUE AFTER MANY OWNERS HAVE CALLED TO COMPLAIN ABOUT THE PROBLEM. *TR

NHTSA ID

10291682

Incident

Aug 14, 2009

Mileage

72,000 mi

THE MULTIFUNCTIONAL LIGHT SWITCH ON PT CRUISERS IS DEFECTIVE. OVER 500 PT CRUISER OWNERS HAVE REPORTED THAT SUDDENLY THE FRONT & BACK FOG LIGHTS COME ON & DO NOT SHUT OFF EVEN WHEN THE MOTOR & ALL OTHER SWITCHES ARE TURNED OFF. OBVIOUSLY THERE IS A SHORT IN THE SWITCH WHICH COULD RESULT IN HEAD LIGHTS SUDDENLY BEING TURNED OFF WHEN DRIVING AT NIGHT. THIS FAILURE HAS BEEN CONSTANT FORCING ME & OTHERS TO REMOVE THE FUSE CONTROLLING THE FOG LIGHTS SO THAT THE BATTERY DOES NOT DRAIN DOWN AFTER THE VEHICLE IS SHUT DOWN. I AND OTHERS HAVE ENCOUNTERED EXTREME DIFFICULTY IN OBTAINING A REPLACEMENT PART. *TR

NHTSA ID

10289723

Incident

Oct 6, 2009

Mileage

25,000 mi