2011 Chrysler Town And Country Body & structure Problems

The contact owns a 2011 Chrysler Town and Country. The contact stated that while her husband was driving at an undisclosed speed, the window glass fell into the door abruptly. A mechanic inspected the vehicle and determined that the failure occurred due to an internal door fracture. The vehicle was not repaired. The contact stated while driving and turning the steering wheel, the steering wheel made an abnormally loud squealing sound. Additionally, the contact stated that the vehicle had difficulty starting, and there was an abnormal amount of smoke coming out of the exhaust pipe. The check engine warning light and the electronic throttle control warning light were illuminated. An unknown dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 174,098.

NHTSA ID

11617463

Incident

May 1, 2021

Mileage

174,098 mi

Van was sitting in driveaway in front of my house. We noticed smoke coming from rear of the vehicle and then saw flames. Contacted 911. Fire department arrived to put out the fire. They said something appeared to have shorted or exploded inside the driver side rear wall panel. Just below the rear window vent in the area of the 3 row speakers and cup holders. It burned down the exterior of the van near the gas cap.

NHTSA ID

11582650

Incident

Apr 11, 2024

Rear sliding door lock actuator has failed and is stuck in locked position. It is impossible to open the door from inside or out using either manual or electric opener. This is dangerous as this door can no longer be used in case of emergency or accident. It is also not apparent anything is wrong. It just does not unlock or open.

NHTSA ID

11446143

Incident

Dec 1, 2021

THE ACTUATOR FAILED ON THE DRIVER SIDE SLIDING DOOR. THE DOOR IS COMPLETELY STUCK AND WILL NOT OPEN MANUALLY MAKING DRIVING A VERY DANGEROUS SITUATION.

NHTSA ID

11342730

Incident

Aug 1, 2020

Mileage

140,000 mi

LEFT SIDE PASSENGER AUTO SLIDING DOOR AUTO LOCKING SYSTEM. WHEN SYSTEM WOULD AUTO LOCK, IT WOULD NOT UNLOCK IN EITHER THE AUTO MODE, ELECTRICALLY BY FOB OR DOOR LOCK ELECTRIC SWITCH AND MOST DANGEROUS, UNABLE TO MANUALLY MOVE THE LOCK RELEASE TAB ON THE DOOR TO UNLOCK POSITION. RENDERS EGRESS FROM THIS DOOR TOTALLY IMPOSSIBLE. TROUBLESHOOT FOR 3 WEEKS. AFTER COUPLE DAYS WAS ABLE TO ELECTRICALLY UNLOCK DOOR AT WITCH TIME I TOTALLY DISCONNECTED DOOR POWER AND OPERATED THE LOCK AND DOOR IN MANUAL MODE NO PROBLEMS.. ONLY WHEN USING THE LOCK SOLENOID,,DID THE LOCK SYSTEM JAM. REPLACED DOOR LOCKING ASSMY AT PART COST OF $648 AND DOOR BACK TO NORMAL OPS. PART NUMBER FOR LOCK WAS DLA1306.

NHTSA ID

11310402

Incident

Feb 1, 2020

Mileage

199,000 mi

REAR PASSENGER SLIDING DOORS WILL NOT FULLY CLOSE AND LOCK WHEN PUSHING CLOSE BUTTON. DOORS HAVE TO BE MANUALLY PUSHED CLOSED FROM THE OUTSIDE TO CLOSE THE LAST QUARTER INCH AND TO HAVE THE DOOR CLOSE MECHANISM ENGAGE. THIS PRESENT A SAFETY RISK TO 2ND ROW PASSENGERS AS THE DOORS ARE NOT FULLY SECURED.

NHTSA ID

11309166

Incident

Jun 1, 2019

Mileage

115,000 mi

ON MY DRIVER SIDE THE SLIDING DOOR DOES NOT OPEN, NOT REMOTLEY OR MANUAL. THE LIGHT AT THE OVERHEAD BUTTON TO OPEN THE DOOR WITH COME ON SOMETIMES BUT WILL NOT OPEN THE DOOR EITHER. I CAN HEAR A CLICKING SOUND TRYING TO OPEN THE DOOR WITH THE REMOTE BUT IT STILL WILL NOT MOVE AT ALL.

NHTSA ID

11232813

Incident

Jul 17, 2019

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE SUDDENLY SHUT OFF. AFTER RESTARTING THE VEHICLE, THE TEMPERATURE GAUGE INCREASED AND DECREASED AND THE ENGINE WOULD CONTINUE TO SHUT OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. ALSO, THE CONTACT STATED THAT OTHER ELECTRICAL FAILURES PREVIOUSLY OCCURRED, SUCH AS THE PASSENGER SIDE SLIDING DOOR WOULD BUZZ AND THE WINDOWS MALFUNCTIONED. THE LOCAL DEALER (GOLLING CHRYSLER, 2405 S. TELEGRAPH RD., WEST BLOOMFIELD, MI) WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID

11123056

Incident

Aug 1, 2017

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT WHEN ATTEMPTING TO OPEN THE REAR DRIVER SIDE SLIDING DOOR WITH THE FOB, IT FAILED TO FUNCTION. THE CONTACT ATTEMPTED MANUALLY BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

NHTSA ID

10967985

Incident

Mar 23, 2017

Mileage

68,000 mi

MY 2011 CHRYSLER TOWN AND COUNTRY REAR LIFT GATE OPENS AND CLOSES AT WILL WHEN PARKED AND KEY IN NOT TURNED ON. I HAVE ALSO NOTED A FEW TIMES WHEN THE ENGINE HAS ALSO STARTED UP WITH OUT USING THE REMOTE. AND IN ONE INSTANCE WHILE DRIVING THE LCD SCREEN IN FRONT OF THE DRIVER KEPT JUMPING FROM ON THING TO ANOTHER. *TR

NHTSA ID

10916729

Incident

Oct 17, 2016

Mileage

40,000 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE REAR PASSENGER DOOR INDEPENDENTLY OPENED AND CLOSED AT RANDOM. THE CONTACT ALSO STATED THAT THE BLIND SPOT SENSOR SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE DETERMINED DUE TO THE COST. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

NHTSA ID

10904841

Incident

Jun 8, 2016

Mileage

60,000 mi

BLIND SPOT SENSING SYSTEM FAILS. MESSAGE TO SERVICE BLIND SPOT SYSTEM.

NHTSA ID

10854093

Incident

Mar 18, 2016

Mileage

33,000 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING APPROXIMATELY 55 MPH, THE TRUNK LID OPENED INDEPENDENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTACT WAS INFORMED THAT THE REMOTE MADE CONTACT WITH THE DOOR AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. UPDATED 1/21/16 LN THE CONSUMER STATED THE LID GOES UP AND DOWN ON ITS OWN. THE CONSUMER STATED HE WAS IN THE HEAD AND CAUSED A BUMP TO FOR ON THE CONSUMERS HEAD, WHEN THE LID CAME DOWN ON ITS OWN. UPDATED 03/30/16.*JB *TR

NHTSA ID

10789285

Incident

Oct 23, 2015

Mileage

20,000 mi

2011 CHRYSLER TOWN AND COUNTRY. THE SLIDING DOORS FAILED TO REMAIN OPEN AND IT AUTOMATICALLY CLOSED.THE DOOR REQUIRED EXCESSIVE FORCE TO AVOID CLOSING AND PREVENTING AN INJURY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED ON TWO SEPARATE OCCASIONS WHERE THEY FLASHED THE COMPUTER, BUT THE PROBLEM REOCCURS. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 65,000.

NHTSA ID

10780653

Incident

Oct 6, 2015

Mileage

30,000 mi

TURN SIGNAL LAMP ON BOTH MIRRORS DEFECTIVE. COVER COMES OFF EXPOSING THE ELECTRICAL BOARD WITH THE LIGHTS. BOTH SIDES NOT FUNCTIONING. THIS APPEARS TO BE A COMMON ISSUE ON THE INTERNET. WE HAVE A CHRYSLER MAXIMUM CARE PLAN WHICH IT THE BEST WARRANTY CHRYSLER OFFERS BUT THIS PART IS NOT COVERED. THIS ITEM IS FOR ADDED SAFETY BUT NOT FUNCTIONING AND I'M CONCERNED EXPOSED ELECTRICAL BOARDS TO THE WEATHER COULD CAUSE A SHORT OR FIRE.

NHTSA ID

10736041

Incident

Nov 15, 2013

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING APPROXIMATELY 20 MPH, THE FRONT PASSENGER SIDE DOOR OPENED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE STALLED AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN DIAGNOSED THAT THE BUMPER SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 42,000.

NHTSA ID

10660794

Incident

Oct 3, 2014

Mileage

42,000 mi

VEHICLE PARKED IN HOMEOWNER'S DRIVEWAY ERUPTED IN FLAMES AT APPROXIMATELY 12.45 AM ON SEPTEMBER 3RD. VEHICLE WAS SHUT OFF FOR OVER FOUR(4) HOURS. ENGINE WAS RELATIVELY COOL AS IT WAS ONLY DRIVEN FOR FIVE MINUTES PRIOR TO 8 PM ON THE 2ND OF SEPTEMBER. NEIGHBOR WHO CALLED THE FIRE DEPARTMENT REPORTED SEEING SPARKS EMANATING FROM UNDER THE HOOD BEFORE IT BURST INTO FLAMES WHICH DESTROYED THE CAR. THIS ALSO DAMAGED THE OTHER VEHICLE PARKED AHEAD OF THE TOWN AND COUNTRY. *TR

NHTSA ID

10637811

Incident

Sep 3, 2014

Mileage

21,000 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE DRIVER SIDE DOOR FAILED TO LOCK AND UNLOCK ELECTRONICALLY. THE WINDOW HAD TO BE OPENED IN ORDER TO UNLOCK AND LOCK THE DOOR. IN ADDITION, THE REAR DRIVER SIDE SLIDING DOOR CLOSED ABRUPTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.

NHTSA ID

10629108

Incident

Jul 31, 2014

Mileage

20,000 mi

THE AUTOMATIC SLIDING DOOR CLOSES ON IT OWN. WHEN YOU OPEN THE POWER SLIDING DOOR IN ANY OF THE 4 AVAILABLE WAYS, THE DRIVERS OVERHEAD BUTTON, DOOR POST BUTTON, PULLING AND RELEASING THE DOOR HANDLE OR WITH THE KEY FOB BUTTON THE PASSENGER SLIDING DOOR OPENS GOES ALL THE WAY TO THE FULL OPEN POSITION AND THEN CLOSES ON ITS OWN. THIS IS NOW HAPPENING EVERY TIME THE DOOR IS OPENED. *TR

NHTSA ID

10627348

Incident

Aug 11, 2014

Mileage

34,000 mi

SEVERAL WEEKS AGO THE BLIND-SPOT ALERT SYSTEM IN MY 2011 CHRYSLER TOWN AND COUNTRY MALFUNCTIONED. I BROUGHT THE VEHICLE TO MY LOCAL CHRYSLER DEALER. THE VEHICLE HAS OVER 50,000 MILES (AND LESS THAN 55,000 MILES, AT THAT TIME) SO THIS WAS NOT A WARRANTY ISSUE. WHEN THE BUMPER WAS REMOVED, IT CONTAINED A SIGNIFICANT AMOUNT OF ROAD DEBRIS AND ROAD SALT. THE LEFT SIDE BLIND-SPOT ALERT MODULE WAS CORRODED. THEY QUOTED REPLACING THAT MODULE AT ABOUT $1200. *JS AT THE DEALER I SAW A REAR BUMPER ASSEMBLY THAT HAS RELATIVELY SMALL OPENINGS THAT ALLOW DEBRIS TO ENTER WITHOUT A WAY FOR IT TO LEAVE. THIS MADE IT EASY FOR SALT AND DEBRIS TO ENTER AND DIFFICULT FOR IT TO LEAVE. THIS PROMOTED THE CORROSION. I CONTACTED CHRYSLER. THEIR POSITION WAS THEY DID NOT COVER CORROSION UNDER ANY CIRCUMSTANCES. I CAN FORWARD MY EMAIL EXCHANGE WITH CHRYSLER TO YOU. I VISITED A LOCAL COLLISION REPAIR SHOP. THEY REMOVED THE REAR BUMPER. WITH THEIR EXPERTISE, THEY WERE ABLE TO INFORM ME THAT THE OPENING THAT ALLOWED DEBRIS AND SALT TO ENTER WAS LOCATED WHERE THE REAR TIRES WOULD THROW ROAD DEBRIS AND ROAD SALT AT THE OPENING. CHRYSLER IS REPLACING BETWEEN 375 AND 400 OF THESE MODULES A WEEK ? AT OVER $1000 EACH, BEFORE LABOR TO INSTALL. *JS

NHTSA ID

10608944

Incident

May 15, 2014

Mileage

50,000 mi

MY 6 YEAR OLD SON HIT THE BUTTON TO OPEN THE AUTOMATIC DOOR THE SAME TIME I HIT THE IT CAUSING THE DOOR TO CLOSE ON HIS HEAD. IT CLOSED ON HIS HEAD WITH TREMENDOUS FORCE AND PRESSURE BEFORE RELEASING LEAVING HIM WITH A LARGE BUMP ON THE SIDE OF HIS HEAD AND SORE. IT TOOK A FEW SECONDS TO RELEASE. IT SHOULD HAVE NEVER CLOSED WITH THAT MUCH PRESSURE AS IT COULD HAVE BROKEN A BONE AND POTENTIALLY WORSE. THE DOOR SHOULD HAVE STOPPED AND RELEASED AS SOON AS IT TOUCHED MY SON. THE SAFETY MECHANISM OF THIS DOOR IS NOT SAFE AND CAN CAUSE SERIOUS HARM. THE DOOR NEEDS TO CLOSE SLOWER AND LIGHTER. AS SOON AS ANYTHING IS FELT IN THE WAY IT SHOULD RELEASE IMMEDIATELY AND NOT CONTINUE TO TRY TO CLOSE. *TR

NHTSA ID

10596535

Incident

Jun 5, 2014

Mileage

36,000 mi

BLIND SPOT MONITOR SENSOR AND BACKUP DETECTOR FAILURE. IMPORTANT SAFETY EQUIPMENT. UPDATED 06/10/14 *BF

NHTSA ID

10595273

Incident

May 2, 2014

Mileage

42,500 mi

WHILE DRIVING DOWN THE HIGHWAY, THE BLIND SPOT SENSORS STOPPED WORKING. THEY WHERE FIXED IN MARCH, BUT KNOW AT 64,000 MILES THEY HAVE STOPPED WORKING AGAIN. THE BLIND SPOT LIGHTS STAY ON IN THE SIDE VIEW MIRRORS AND A WARNING POPS UP " BLIND SPOT UNAVAILABLE OR SERVICE BLIND SPOT." *JS

NHTSA ID

10592133

Incident

Feb 19, 2014

Mileage

59,000 mi

PREMATURE FAILURE OF IMPORTANT SAFETY EQUIPMENT - REAR BLIND SPOT SENSORS. DIAGNOSED WITH INTERNAL FAILURE AND COST OF REPAIRS WAS VERBALLY ESTIMATED BY DEALER AT CLOSE TO $3,000. SAFETY EQUIPMENT LIKE THIS, ONE OF THE REASONS THIS VEHICLE WAS PURCHASED BY AN ELDERLY COUPLE, SHOULD NOT FAIL THIS EARLY AND AT THIS EXPENSE. *TR

NHTSA ID

10573409

Incident

Mar 3, 2014

Mileage

53,807 mi

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE PASSENGER'S SIDE SLIDING DOOR FAILED TO REMAIN OPEN AND WOULD INDEPENDENTLY CLOSE. ON ONE OCCASION, THE SLIDING DOOR AUTOMATICALLY CLOSED ON A CHILD'S HEAD. THE CHILD SUSTAINED MINOR EAR INJURIES AND WAS NOT TAKEN TO THE HOSPITAL. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE CONTACT STATED THAT THE FAILURE WAS RECURRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000 AND THE CURRENT MILEAGE WAS 41,000. UPDATED 5/13/14*CN *TR *TR

NHTSA ID

10568829

Incident

Nov 20, 2012

Mileage

22,000 mi