2000 Dodge Grand Caravan Electrical Problems

The contact owns a 2000 Dodge Grand Caravan. The contact stated that while driving at 55 MPH, there was an abnormal noise and noticed that the vehicle's windshield wiper and blinkers had become inoperable. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty wiper transmission linkage, a relay, and a switch. The relay and switch were replaced however, the wiper transmission linkage was not repaired due to parts not being available. The manufacturer was made aware of the failure and determined that parts were not available. The failure mileage was approximately 110.000

NHTSA ID

11550683

Incident

Sep 29, 2023

Mileage

110,000 mi

THE CHECK ENGINE LIGHT AND ABS LIGHT KEEP COMING ON AND THE LIGHT KEEP GOING OFF ON THE DASH BOARD FOR I BOUGHT THE VEHICLE WHILE DRIVING

NHTSA ID

11222611

Incident

Apr 22, 2016

Mileage

1,141 mi

FUEL GAGE DON'T WORK AFTER FUEL PUMP REPLACEMENT,,,,GASOLINE SPILLED ALL OVER ROAD

NHTSA ID

11021289

Incident

Jul 5, 2017

Mileage

170,000 mi

THE SERPENTINE BELT ON 96-2000 CHRYSLER MINIVANS SLIPPING OFF IS A KNOWN ISSUE AND HAS BEEN FOR YEARS. TIME AND TIME AGAIN CHRYSLER HAS REFUSED TO ISSUE A RECALL FOR IT. IT IS DUE TO A MANUFACTURING DEFECT IN ONE OF THE ENGINE MOUNTS CAUSING A PULLEY MISALIGNMENT. THE BELT SLIPPING OFF CAUSES LOSS OF POWER STEERING, WATER PUMP, AND ALTERNATOR. THE POWER STEERING LOSS CAN CAUSE A DRIVER TO NOT BE ABLE TO CORRECT IN TIME AND CAUSE AN ACCIDENT. THE LOSS OF THE WATER PUMP CAN CAUSE OVERHEATING RESULTING IN ENGINE DAMAGE. THE LOSS OF THE ALTERNATOR CAN CAUSE THE CAR TO EVENTUALLY STOP RUNNING WHEN THE BATTERY IS DRAINED, CAUSING MOTORISTS TO BE STRANDED. I LIVE IN ALASKA AND I'M NOT ALWAYS IN CELLULAR SIGNAL WHEN DRIVING AND TEMPERATURES IN THE WINTER GET DOWN TO -30 F AT TIMES. I CAN'T WAIT SOMETIMES SEVERAL HOURS FOR A TOW TRUCK TO GET TO ME WITHOUT RISKING HYPOTHERMIA AT THOSE TEMPERATURES. THIS NEEDS TO BE MADE INTO A RECALL SO IT CAN GET FIXED.

NHTSA ID

10957538

Incident

Feb 11, 2017

Mileage

290,000 mi

TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT 50 MPH, THE HORN AND CRUISE CONTROL FAILED TO FUNCTION AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.

NHTSA ID

10716674

Incident

May 15, 2014

Mileage

97,000 mi

HI I OWN A 2000 DODGE GRAND CARAVAN.HAVE BEEN HAVING PROBLEMS FOR ABOUT A YR. TRIED CONTACTING DODGE THEY SAID THEY COULDN'T HELP ME OR GIVE ME ANY SUGGESTIONS. THEY SAID BECAUSE THE VAN HAS A LOT OF MILES. I WENT ONLINE TO RESEARCH THE PROBLEM. APPARENTLY A LOT OF PEOPLE ARE HAVING THE SAME ISSUES AS ME.I DID HAVE MY MECHANIC CHK IT OUT. HE COULD NOT RESOLVE THE ISSUE AFTER 1WK. IT STARTED WITH A DEAD BATTERY,THE GAUGES ON THE DASHBOARD SOMETIMES NOT WORKING,THE AC IS BLOWING HOT AIR OR NOT WORKING AT ALL AND THE DRIVERS SIDE WINDOW NOT GOING DOWN.NOW NONE OF THE GAUGES WORK INCLUDING MY GAS GAUGES, SPEEDOMETER,AIR,WINDOW,CAR TEMP AND THE LIGHTS STAY ON WHEN I TURN THE CAR ON. I AM A SINGLE MOM I CANNOT PAY RIDICULOUS AMOUNTS OF MONEY FOR THEM TO FIGURE IT OUT. THERE ARE A LOT OF PEOPLE ON THE INTERNET THAT HAVE THE SAME ISSUES BUT HAVE NOT ADDRESSED THE ISSUE WITH DODGE. SOMEONE NEEDS TO DO SOMETHING ABOUT THIS ISSUE. THIS IS VERY DANGEROUS I HAVE RUN OUT OF GAS ON THE HIGHWAY AND ON A ROAD WHERE GAS IS NOT OFF THE EXIT. I AM A MOTHER OF TWO AND THAT'S NOT SAFE. PLEASE SEE IF YOU COULD HELP ME. THANK YOU *TR

NHTSA ID

10449661

Incident

Feb 29, 2012

TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THE VEHICLE WAS PARKED AND OFF WHEN IT CAUGHT ON FIRE. THE FIRE WAS EXTINGUISHED AND THE FIRE DEPARTMENT CONFIRMED THAT THE FIRE ORIGINATED FROM THE FUSE BOX. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

NHTSA ID

10427619

Incident

Sep 13, 2011

Mileage

100,000 mi

REPEATEDLY THE ENTIRE INSTRUMENT PANEL GOES DEAD-NO SPEEDOMETER, ODOMETER, OR OTHER GAUGES VISIBLE, ALSO THE GEARSHIFT INDICATOR LIGHTS GO DEAD. HAVE REPLACED ENTIRE COMPUTER AT HIGH EXPENSE, THEN HAD RECURRENCE OF PROBLEM. HAVE TAKEN VAN TO DODGE DEALER BUT WERE UNABLE TO ISOLATE PROBLEM. ON DODGE FORUM THIS IS A RECURRENT DEFECT IN THESE CARS-SEE LINK HTTP://WWW.TOPIX.COM/FORUM/AUTOS/DODGE-CARAVAN/T4AJES74F3AC3VOAB. *TR

NHTSA ID

10362434

Incident

Oct 26, 2010

Mileage

64,744 mi

REGARDING THE IGNITION PROBLEM WITH THE PROPER KEY BEING INSERTED AND NOT TURNING..I HAD THE SAME PROBLEM SEVERAL TIMES AND WAS ALSO STRANDED. I LEARNED IF YOU PUT THE KEY IN AND TAP THE END OF THE KEY (AS IF YOU'RE TRYING TO TAP IT FURTHER INTO THE IGNITION) WITH A RUBBER HANDLED SCREWDRIVER A COUPLE TIMES IT WILL THEN TURN AND START RIGHT UP. *TR

NHTSA ID

10234497

Incident

Feb 18, 2008

Mileage

65,000 mi

2000 GRAND CARAVAN.....INITIALLY, THE INSTRUMENTATION CLUSTER WOULD INTERMITTENTLY EXTINGUISH. HITTING A BUMP, IT WOULD COME BACK ON. MOST RECENTLY, THE VAN WILL NOT START. NO INSTRUMENTS, NO CLICK, NO NOTHING. IF YOU WHACK THE TOP OF THE DASH WITH YOUR FIST, ALL INSTRUMENTS COME ON, AND THE VAN STARTS. I HAVE NOT REPAIRED IT YET, BUT INTEND TO PULL THE DASH AND CHECK FOR BAD SOLDER CONNECTIONS. *TR

NHTSA ID

10218495

Incident

Feb 19, 2008

Mileage

150,000 mi

HEATING/AIRCONDITIONING FAN SWITCH WOULD NOT FUNCTION IN ONE POSITION, TRACED PROBLEM TO BURNED UP AND SHORT OUT CONNECTOR AND RESISITOR CONNECTOR IN ENGINE COMPARTMENT THAT OPERATED HEATING/AIR CONDITIONING FAN SPEED. REPLACED PARTS. POOR DESIGN, WILL NOT ACCEPT ELECTRICAL LOAD OVER EXTENDED OPERATION. OLD PARTS AVALIBLE. *AK

NHTSA ID

10191797

Incident

May 25, 2007

Mileage

59,000 mi

DT*: THE CONTACT STATED, THE AIR BAG WARNING LIGHT FAILED TO ILLUMINATE DURING AN EMISSIONS TEST PERFORMED ON 7/21/06. THE LIGHT WORKED UNTIL 6/23/2006, WHEN THE SERVICE DEALER PERFORMED RECALL #04V480000. THE SERVICE DEALER INFORMED THE CONTACT THE WARNING LIGHT WAS NOT PART OF THE RECALL.

NHTSA ID

10163392

Incident

Jul 21, 2001

Mileage

86,000 mi

LOCK CYLINDER ENGAGES COLUMN LOCK AND WILL NOT DISENGAGE. ONGOING PROBLEM THAT HAS GOTTEN INCREASING HARDER TO GET THE COLUMN TO RELEASE. PER DEALER TSB ON PROBLEM. WILL HAVE TO HAVE DRILLED OUT AND REPLACED. *NM

NHTSA ID

10157024

Incident

May 8, 2006

Mileage

120,000 mi

DT: THE CONTACT STATED THERE HAVE BEEN NUMEROUS ELECTRICAL PROBLEMS WHICH RESULTED IN THE DASHBOARD PANEL LIGHTS FLASHING ON AND OFF WHILE DRIVING. SHE TOOK THE VEHICLE TO A DEALER FOR MULTIPLE ATTEMPTS TO CORRECT THIS PROBLEM. ALSO, THERE WAS A LEAK WITHIN THE ROOF, RESULTING IN DAMAGE TO THE CARPETING. THERE IS A SLASHING SOUND WITHIN THE ROOF COMPARTMENT AFTER A HEAVY RAIN. THE CARPET HAS BEEN REPLACED FIVE TIMES, AND THE TELEVISION WAS REPLACED ONCE AS A RESULT OF THE LEAK. *AK. UPDATED 11/30/2005 - GLAZED SERPENTINE BELT CAUSED GRINDING NOISE WHEN TURNING. THE LEFT MIDDLE SEAT HEAD REST CAME LOOSE FROM THE GUIDE ROD. THE DOOR STICKS AND THE SIDING DOOR MAKES NOISE WHEN OPENING. THE REAR WINDOW RATTLES WHEN OPENED. THE FOG LIHJT ARE IONPERTIVE. THE HORN SPUNDED WEAK BECAUSE THE KEYLESS ENTRY REMOTE NEEDED TO BE REPROGRAMMED. THE TAIL LIGHT HAD MOISTURE IN IT. THE LOCKING GAS CAP WAS HARD TO OPEN. THE REAR TIRE HAD A SLOW LEAK. *NM

NHTSA ID

10141380

Incident

Dec 15, 1999

Mileage

5 mi

2000 PONTIAC GRAND AM SAFETY RECALL REGARDING CLOCKSPRING REPLACEMENT.*MR THE CLOCKSPRING RECALL WAS REPAIRED THE FUSE FOR THE BLOWER MOTOR, THE BACK UP LAMPS AND TURN SIGNAL BLEW OUT WHEN THE VEHICLE WAS PUT IN REVERSE. *NM

NHTSA ID

10135590

Incident

Jan 1, 1901

Mileage

89,552 mi

WHILE DRIVING VEHICLE SHUTS DOWN COMPLETLY IF KEY IS TURNED OFF VEHICLE WILL MOST TIMES RESTART,SEVERAL TIMES VEHICLE WOULD ONLY START AFTER WAITING SEVERAL HOURS THIS HAPPENS SPORATICALLY ABOUT ONCE A WEEK VEHICLE HAS LESS THAN 20,000 MILES FUEL FILTER REPLACED OLD FILTER UNAVAILABLE STARTER RELAY REPLACED OLD RELAY IS AVAILABLE

NHTSA ID

10127088

Incident

Jun 25, 2005

Mileage

18,000 mi

I PURCHASED MY VEHICLE 2 WEEKS AGO WHEN I WAS DRIVING DOWN THE FREEWAY, IT FELT LIKE I HIT SOMETHING BUT NOTHING WAS IN THE ROAD. I ASSUMED I HAD A BLOWOUT. WHEN I PULLED TO THE SIDE OF THE ROAD THE HOOD WAS SMOKING, AND THE TIRES WERE FINE. I THEN PROCEEDED TO OPEN THE HOOD TO FIND A FIRE. THE FIRE DEPARTMENT CAME TO PUT OUT THE FIRE AND SUGGESTED THAT IT WAS AN ELECTRICAL MALFUNCTION. I AM CURRENTLY IN THE PROCESS OF HAVING THE VEHICLE EVALUATED TO FIND OUT IF THIS IS TRUE. *JB

NHTSA ID

10109938

Incident

Feb 2, 2005

Mileage

103,000 mi

PROBLEMS WITH VEHICLE'S ALTERNATOR, BATTERY, BRAKES AND ELECTRICAL SYSTEM.*MR THE CONSUMER FEELS THAT THE ELECTRICAL PROBLEM CAUSED THEM THE REPLACE THE BATTERY THREE TIMES AND THE ALTERNATOR TWICE IN FOUR YEARS. THE SERPENTINE BELT BROKE AND LEFT THE DRIVER STRANDED IN RUSH HOUR TRAFFIC. THE BRAKES FAILED WHICH RESULTED IN AN ACCIDENTS. MULTIPLE BRAKE COMPONENTS HAD BEEN REPLACED PRIOR TO THIS ACCIDENT. THE CONSUMER BELIEVES THE VEHICLE IS UNSAFE AND REQUEST REIMBURSEMENT. *NM

NHTSA ID

10089541

Incident

Aug 1, 2004

THERE WAS A FIRE UNDER THE HOOD WHICH CAUSED 2 EXPLOSIONS. THE FIRST EXPLOSION APPEARS TO HAVE BEEN AN ELECTRICAL FIRE. THE SECOND EXPLOSION WAS IN THE GAS OR FUEL LINE. THE ENTIRE ENGINE AREA WAS BURNED AND THE FIRE CRACKED THE WINDSHIELD AND STARTED MOVING INTO THE FRONT OF THE CAR. NO ONE WAS HURT. THE CAR WAS DETERMINED TO BE A TOTAL LOSS. NO REPAIRS WERE MADE. THIS IS A CLAIM TO REPLACE OR REPAIR THE CAR. POLICE AND FIREMEN WERE CALLED TO THE FIRE. FIRE REPORT WAS MADE.*AK

NHTSA ID

10088198

Incident

Feb 8, 2004

Mileage

15,000 mi

I HAVE A 2000 DODGE GRAND CARAVAN. I AM QUITE CERTAIN MY CLOCKSPRING HAS BROKEN AND MY AIRBAG LIGHT STAYS LIT ALL THE TIME, AND MY HORN AND CRUISE CONTROL DOES NOT WORK.*AK I BELIEVE CHRYSLER HAS NOT ISSUED A RECALL FOR THE 2000 MODEL, BUT ONLY FOR THE 1996-1998 MODELS. YET SEARCHING THE WEB REVEALS MANY, MANY PROBLEMS WITH THE 2000 MODELS AS WELL. THIS IS A SAFEY ISSUE CAUSES BY CHRYSLER'S EQUIPPMENT AND SHOULD BE A PROVIDED FREE REPAIR. CHRYSLER DOES NOT OFFER TO REPAIR IT FOR FREE. I AM CURRENTLY OUT OF MY PRINTING CAREER AND AM HAVING DIFFICULTY FINDING WORK AGAIN, SO THE $250 PLUS TO HAVE THIS REPAIRED IS A HEAVY LOAD AT THIS TIME. CHRYSLER SHOULD TAKE CARE OF THIS FOR ALL THE 1999 AND 2000 MODELS AS WELL. I KNOW THE NHTSA IS INVESTIGATING THIS, BUT WITH HUNDREDS OF COMPLAINS ALREADY FILED, HOW MUCH MORE INFORMATION DOES IT NEED TO ACT? I DONT KNOW THE PROCESS, BUT WHAT SHOULD I DO NOW? THIS IS A SAFTEY ISSUE, AND THIS IS OUR FAMILIY VEHICLE. PLUS, THE ANNUAL INSPECTION IS COMING UP IN LESS THAN 4 MONTHS, AND IT WILL NOT PASS WITHOUT THE HORN AND CRUISE AND AIRBAG BROKEN. THANK YOU FOR ANY INFORMATION AND ADVICE YOU CAN GIVE ME. THANKS AGAIN! JOHN CALOGRIDES

NHTSA ID

10068263

Incident

Mar 10, 2004

Mileage

90,000 mi

I RECENTLY PURCHASED MY VAN USED, AND HAVE HAD THE FOLLOWING PROBLEMS WITH IT..THE AUTOMATIC DOOR LOOKS WORK WHEN THEY WANT TO. I HAVE HAD MY CHILDS CARE SEAT COME UNBUCKLED FROM THE MIDDLE BENCH SEAT BEFORE. MY BRAKE LIGHTS COME ON WHEN THEY WANT TO AND STAY ON, IN THE MIDDLE OF THE NIGHT YOU WILL GET UP AND FIND THE BRAKE LIGHTS HAVE COME ON FOR NO REASON. THE LASTEST PROBLEM IS WHEN YOU OPEN A DOOR ON THE VAN, THE OPEN DOOR LIGHT COMES ON AND MY LOW GAS LIGHT COMES ON AND MAKES ITS WARNING TONE AND MY FUEL GAUGE GOES TO EMPTY. WHEN YOU CLOSE THE DOOR AND THE WARNING LIGHTS GO OFF AND MY FUEL GAUGE RETURNS TO FULL.*AK

NHTSA ID

10058880

Incident

Feb 25, 2004

I LIKE TO FILE A COMPLAINT REGARDING 2000 DODGE GRAND CARAVAN. THIS VEHICLE HAS EXPERIENCED THE SAME PROBLEM OTHER OWNERS HAVE COMPLAINED ABOUT REGARDING THE HORN AND AIR BAG NOT FUNCTIONING DUE TO A DEFECTIVE CLOCKSPRING HARNESS. CHRYSLER HAS REFUSED TO RECALL THIS COMPONENT OR ACKNOWLEDGE THIS AS A SAFETY ISSUE OTHER THAN SAYING IT SHOULD BE FIXED. MOST MINI-VAN OWNERS TRANSPORT FAMILIES IN THESE VEHICLES AND IT IS A SHAME THAT CHRYSLER WON'T DO ANYTHING ABOUT IT. *LA

NHTSA ID

10052369

Incident

Dec 10, 2003

Mileage

61,800 mi

HORN BLOWING WHILE NO ONE IS IN THE VAN. *JB

NHTSA ID

10039322

Incident

Sep 21, 2003

Mileage

49,000 mi

ELECTRIAL SHORT THAT RENDER ALL DASHBOARD GAUGES TO CEASE FUNCTIONING.N ADDITION, ELECTRICAL SHORT DID NOT ALLOW TRANSMISSION TO PROPERLY SHIFT GEARS.LECTRICAL SHORT CAUSED ADDITIONAL DAMAGE TO CIRCUIT BOARD (SO THE DEALER CLAIMS)

NHTSA ID

10037181

Incident

Jul 31, 2003

Mileage

498,000 mi

MY INFINITY RADIO SYSTEM STARTED LOSING ITS TIME AND WHEN I SHUT THE CAR OFF IT SHUT THE RADIO AND THE NEXT THING I KNEW THE RADIO/CD/CASSETTE PLAYER WAS DEAD WITH A CD STILL IN IT. I BROUGHT IT TO MY MECHANIC WHO SAID WITH THIS MAKE/MODEL AND YEAR VAN THIS WAS VERY COMMON FOR THE RADIO TO DIE. HE SAID THEY HAD NUMOROUS PEOPLE COMPLAIN AND HAVE TO BUY NEW RADIOS. THIS IS A 3 YR OLD VAN I SHOULD NOT HAVE TO BE REPLACING THE RADIO IN IT. OF COURSE I CANNOT EVEN GET A COMPARABLE SYSTEM WITHOUT SPENDING AT LEAST $350.00 I THINK IF THIS IS HAPPENING TO DODGE GRAND CARAVANS A LOT THEN THERE SHOULD BE A RECALL AND THE MANUFACTURER SHOULD REPLACE THE SYSTEM.*AK

NHTSA ID

10033479

Incident

Aug 18, 2003