2000 Dodge Grand Caravan Powertrain (other) Problems

DT*: THE CONTACT STATED WHILE DRIVING 50MPH, A LOUD NOISE WAS HEARD COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS DRIVEN TO ITS DESTINATION AND WHEN THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE AGAIN, IT WOULD NOT GO INTO GEAR. THE VEHICLE WAS TOWED TO A DEALER, WHERE IT WAS DETERMINED THE DIFFERENTIAL CROSS PIN CAME LOOSE, LOGGED INTO THE SIDE OF THE TRANSMISSION CASE AND RESULTED IN A COMPLETE LOSS OF TRANSMISSION FLUID. THE ENTIRE TRANSMISSION NEEDS TO BE REPLACED.

NHTSA ID

10153599

Incident

Mar 22, 2006

Mileage

84,000 mi

WHILE DRIVING 50-55 MPH TRANSMISSION EXPLODED. BROKEN PIECES OF THE TRANSMISSION SPREAD OUT ONTO THE ROADWAY. VEHICLE WAS TOWED TO A REPAIR SHOP, AND MECHANIC STATED THAT THE CAUSE OF THIS PROBLEM WAS UNDETERMINED. THE DEALER WAS NOT NOTIFIED.*AK... LET CHRYSLER KNOW OF THE PROBLEM. WHEN TRANSMISSION WAS TAKEN OUT IT LOOKED LIKE A BUNCH OF HOLES SHOT INTO IT. THE MECHANIC SAID THE PIN CAME OUT OF THE DIFFERENTIAL. CONSUMER WAS LUCKY TO GET OFF THE ROAD. *AK

NHTSA ID

10113247

Incident

Mar 1, 2005

Mileage

36,000 mi

MAKE : DODGE MODEL : GRAND CARAVAN YEAR : 2000 MANUFACTURER : DAIMLERCHRYSLER CORPORATION CRASH : NO FIRE : NO NUMBER OF INJURIES: 0 ODI ID NUMBER : 10100418 DATE OF FAILURE: NOVEMBER 20, 2004. *JB VIN : NOT AVAILABLE COMPONENT: CV JOINT.AXLE PROBLEM SUMMARY: I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO THE DEALER FOR THE AIR BAG RECALL (CLOCKSPRING- WHICH BY THE WAY THE AIRBAG REALLY STAYS ON NOW, WHERE IT DID NOT BEFORE THE DEALER REPLACED/REPAIRED THE CLOCKSPRING) AND PLUS THE DEALER CALLED ME TO TELL ME THAT HAD FOUND A LEAK IN THE MASTER CYLINDER WHICH THEY WANTED TO FIX. I SAID YES (NOW I SEE THERE ARE SEVERAL COMPLAINTS ABOUT MASTER CYLINDER LEAKS) I PICKED UP MY VAN UP ON FRIDAY EVENING AFTER WORK. SATURDAY MORNING I RAN A COUPLE OF ERRANDS AROUND TOWN AND AT 12:30 P.M. BEGAN TO BACK OUT OF A PARKING SPOT AND HEARD A LOUD NOISE. I PROCEEDED OUT OF THE PARKING STRUCTURE AND ONLY MADE IT AS FAR AS THE STREET BEFORE COMING TO A COMPLETE STOP. I CALLED FOR A TOW. THE TOW TRUCK DRIVER SAID THAT MY WHEEL ON THE FRONT DRIVER'S SIDE DID NOT APPEAR TO BE COMPLETELY ATTACHED TO THE AXLE. HE TOWED IT TO THE DEALER. THE SERVICE DEPARTMENT ON MONDAY INFORMED ME THAT MY CV JOINT/AXLE HAD BROKEN. A BROKEN AXLE ON A 2000 THAT HAS 18,222 MILES ON IT. HOW DOES THIS HAPPEN UNDER NORMAL DRIVING CONDITIONS? MY KIDS AND I WERE LUCKY THAT I WAS NOT GOING FAST OR DRIVING DOWN A FREEWAY. NOW I SEE ON THE NEWS THIS MORNING THAT THERE IS A RECALL FOR DAKOTA TRUCKS AND DURANGOS, BUT NOT CARAVANS. WHAT'S UP WITH THAT? *JB

NHTSA ID

10102711

Incident

Nov 20, 2004

Mileage

18,222 mi

WHILE DRIVING, SUDDENLY THERE WAS A LOUD CLANGING NOISE FROM THE TRANSMISSION THEN THE VAN STOPPED ACCELERATING. THE VAN WAS TOWED TO A DEALERSHIP. THE DEALERSHIP INDICATED THAT THE DIFFERENTIAL PIN BROKE IN HALF AND WENT THROUGH THE TRANSMISSION AND CREATED A HOLE . THE CAUSE OF THE DIFFERENTIAL PIN BREAKING HAD NOT BEEN DETERMINED. *JB

NHTSA ID

10064774

Incident

Mar 9, 2004

Mileage

40,000 mi

TRANSAXLE PIN SLIPPED OUT OF POSITION AND RIPPED TRANSMISSION CASE OPEN. TRANSMISION WAS DESTROYED. FLUID DRAINED OUT IN LOCAL DRIVEWAY. EALERSHIP SAYS WILL COST $3,100 TO $3,400 TO REPLACE TRANSMISION WITH, NOT A NEW ONE, BUT A CHRYSLER REBUILT TRANSMISION.*AK ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ 3 YEARS OLD ... 71,000 MILES ... WHEN TRANNY BUSTED. DEALERSHIP PREFORMED $150.00 POWERFLUSH TO TRANSMISION 1 1/2 YEARS AGO WITH SUPERIOR FLUID THAT WAS AVERT ANY PROBLEMS DUE TO ORIGINAL EQUIPMENT FLUID NOT RECOMENDED BECAUSE OF NOT BEING GOOD ENOUGH. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ AMY WHITFORD STOPPED VAN IN THE MIDDLE OF THE ROAD WHEN SHE THOUGHT SHE HIT SOMETHING (THE NOISE OF THE TRANSMISION PIN BREAKING THROUGH THE CASE) AND GOT OUT IN TRAFFIC WALKING AROUND VEHICLE WITH 3 YOUNG CHILDREN INSIDE. SHE NOTICED FLUID ON GROUND AND PULLED INTO NEAREST DRIVEWAY, WHERE REMAINDER OF FLUID RAN OUT. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ I AM OUTRAGE TO FIND THAT THOUSANDS OF THESE EXACT FALURES HAPPEN WITH THESE CHRYSLER AUTOMATIC TRANSMISIONS AND CONTINUE. THE CONSUMER PAYS THE $3,300 PRICE FOR THESE KNOWN DEFECTS AFTER THEY TEAR THE TRANSMISION APART. THESE FAILURES ARE DANGEROUS AND ONLY IGNORED BECAUSE IT WILL COST THE MANUFACTURER INSTEAD OF ME. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ CHRYSLER HAS MADE A BLUNDER HERE AND WANTS ME TO PAY FOR IT. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ CAMERON R. WHITFORD ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ [email protected] PLEASE EMAIL WITH ANY ASSISTANCE. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ HOW DO I GET CHRYSLER TO OWN UP TO THIS CUSTOMER NIGHTMARE. I WILL DO ANYTHING!

NHTSA ID

10051221

Incident

Dec 22, 2003

Mileage

71,000 mi

AUTOMATIC TRANSAXLE: WITHIN THE FIRST 5, 000 MILES I COMPLAINED TO THE DEALER ABOUT A "JUMP" IN THE TRANMISSION. I WAS ADVISED BY THE SALESPERSON AND SERVICE DEPARTMENT THAT IS WAS NORMAL. AFTER DRIVING OTHER 2000 GRAND CARAVANS, I NOTICED IT TO BE THE SAME.WITHIN THE FOLLOWING 10, 000 MILES THE JUMP STILL EXISTED AND PROGRESSIVELY GOT WORSE. I AGAIN RETURNED TO THE DEALER AND AGAIN WAS ADVISED IT WAS NORMAL. AFTER A TOTAL OF 36, 000 MILES, THE TRANSMISSION DIED. I NOW HAVE TO PAY OUT OF POCKET FOR REAPIRS AND WANT OTHER CONSUMERS TO KNOW THAT THE TRANSMISSION SENSORS AND POWERTRAIN CONTROL MODULES (PCM) ARE FAULTY AND COULD CAUSE INJURIES IF NOT CHECKED OR REPLACED. A "JUMPY" TRANSMISSION COULD CAUSE A VEHICLE TO ACCEL OR DECEL OUT OF CONTROL. MY NEIGHBOR'S 2000 GRAND CARAVAN TRANSMISSION SENSOR POWERTRAIN CONTROL MODULE (PCM) WENT OUT AFTER 15, 000 MILES AND HAD TO GET IT REPLACED. IT WAS NOT UNDER WARRANTY. HE HAD TO PAY FOR THE REPAIR OUT OF POCKET.*AK

NHTSA ID

10025156

Incident

Aug 4, 2002

Mileage

15,000 mi

WHILE DRIVING THE CONSUMER HEARD A GRINDING NOISE AND PULLED OVER. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE LEFT FRONT AXLE HAD BROKEN. THE VAN HAS BEEN MODIFIED BY "BRAUN ENTERVAN" FOR DISABLED ACCESS. *NLM

NHTSA ID

10017782

Incident

Apr 28, 2003

THE CONSUMER HEARD A NOISE FROM THE UNDER CARRIAGE OF THE VEHICLE, WHEN THE CONSUMER DEPRESSED THE GAS PEDAL, THE RPMS INCREASED, BUT THE SPEED DID NOT. THE DEALER DIAGNOSED THE TRANSMISSION DIFFERENTIAL FAILED WHICH RESULTED IN A $3000 REPAIR. *JB

NHTSA ID

10015215

Incident

Apr 2, 2003

THE VEHICLE BEGAN TO MAKE A LOUD NOISE, CONSUMER PULLED OVER AND NOTICED TRANSMISSION FLUID ALL OVER THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER, AFTER THE VEHICLE WAS INSPECTED, IT WAS DETERMINED THE PINS WHICH WERE LOCATED INSIDE OF THE DIFFERENTRAL WAS BENT AND HAD SHOT OUT OF THE CASING. *JB

NHTSA ID

10009425

Incident

Feb 8, 2003

Mileage

47,000 mi

THE DIFFERENTIAL PIN POPPED OUT, WHICH CAUSED A NOISE WHEN THE VEHICLE COASTED. *JB THE DEALER STATED THAT IF THE VEHICLE CONTINUES TO BE DRIVEN, THE PIN WOULD PENETRATE THE TRANSMISSION, THEN SPILL FLUID AND BREAKDOWN. SCC

NHTSA ID

10009126

Incident

Feb 21, 2003

Mileage

69,000 mi

THE TRANSAXLE IN THE TRANSMISSION BLEW APART IN THE GEAR CASE AT 76,000 MILES ON OUR 2000 CARAVAN AND NINE DAYS AFTER THIS THE LEFT FRONT AXLE ASSEMBLE WAS SHOT AND HAD TO BE REPLACED.

NHTSA ID

10003064

Incident

Dec 24, 2002

Mileage

77,500 mi

CONSUMER STATED WHIEL DRIVING, THE TRANSAXLE FAILED, WHICH CAUSED THE TRANSMISSION FLUID TO LEAK.*JB

NHTSA ID

10002596

Incident

Jan 3, 2003

SPEEDOMETER ERRATIC WHILDE DRIVING FREEWAY SPEEDS. THE SPEEDOMETER WILL JUMP TO 120 CAUSING THE ENGINE TO STALL IF THE NEED IS NOT RELEASED. THIS HAPPEN ON THE FREEWAY AND HAD TO COAST OVER TO THE EMERGANCY LANE "IMEDIATLY" . THE CAUSE WAS THE RSS SPEED SENSOR (203 C 4800879 AND THE OUTPU RSS SPEED SENSOR 204 C) THIS IS A MAJOR SAFTY ISSUE WHEN IT STALL ON THE FREEWAY WITH MY FAMILY IN THE MINIVAN. THIS SHOULD NOT HAVE BEEN A REPAIR PAYED FOR BY THE CONSUMER FOR FAULTY DESIGN! *AK

NHTSA ID

758089

Incident

Feb 7, 2002

MY GRAND CARAVAN WAS HIT FROM BEHIND WITH SUCH FORCE THE REAR OF THE VAN LIFTED OFF THE GROUND. AT IMPACT MY DRIVERS SEAT BROKE, RECLINING ME, MAKING IT IMPOSSIBLE FOR ME TO REACH THE BRAKES TO STOP MY VAN. I HIT THE CENTER MEDIAN (FAST LANE) WITH THE LEFT FRONT FENDER, BLOWING THE TIRE AND BREAKING AXLE THE VAN THEN BOUNCED ACROSS LANES HITTING BRIDGE RAILING AND CEMENT WALL WITH RIGHT FRONT FENDER BLOWING THAT TIRE AND THEN BACK TO THE MEDIAN (FAST LANE), AND CAME TO A STOP AGAINST THE MEDIAN. I WAS TOLD BY THE INSURANCE INVESTAGATOR MY CARAVAN WAS BEYOND REPAIR DUE TO THE AMOUNT OF DAMAGE.*AK

NHTSA ID

745123

Incident

Jan 31, 2001