2004 Dodge Grand Caravan Fuel system Problems

HAIRLINE CRACKS IN FUEL PUMP OUTLET JUST BEFORE CONNECTING TO FUEL LINE LEADS TO STRONG FUEL SMELL AND FUEL VAPORS ALL AROUND VEHICLE. FUEL PUMP NEEDS REPLACEMENT TO REPAIR THIS DANGEROUS CONDITION. HIGHLY SUGGEST DIFFERENT FUEL PUMP DESIGN THAT IS NOT PRONE TO HAIRLINE CRACKS AND POTENTIAL FIRE HAZARD AS FUEL LEAK IS ABOUT ONE FOOT AWAY FROM A HOT MUFFLER AND A TOSSED CIGARETTE OR OTHER SPARK COULD CAUSE A FIRE OR EXPLOSION.

NHTSA ID

11253106

Incident

Aug 30, 2019

Mileage

260,000 mi

AFTER FILLING THE GAS TANK, WITHIN A FEW MILES THE VEHICLE WILL STALL. DODGE ALREADY HAS EXTENDED THE WARRANTY ON THE FUEL TANK OF VEHICLE BUILT AFTER SEPTEMBER 2003 BUT MINE WAS BUILT AUGUST 5 2003 SO IT IS OUTSIDE THEIR WINDOW. THIS IS A VERY DANGEROUS ISSUE BECAUSE IT HAS HAPPENED TO ME ON THE HIGHWAY AT 55 MILES AN HOUR AND I THEN HAVE NO POWER AND NEED TO GET OUT OF THE WAY OF TRAFFIC THAT IS GOING TO RUN ME OVER.

NHTSA ID

10924275

Incident

Nov 3, 2016

Mileage

115,000 mi

EVERY TIME WE FILL THE FUEL TANK THE CARAVAN CUTS OFF AND RIDES VERY ROUGH. THE RECALL ON THE DODGE CARAVAN WAS ON VANS BUILD STARTING ON 09/01/2003 MY CARAVAN WAS BUILT ON 09/29/2013.

NHTSA ID

10824863

Incident

Nov 1, 2014

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2004 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, IT STALLED WITHOUT WARNING. AFTER SEVERAL ATTEMPTS THE VEHICLE WAS ABLE TO RESTART BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10823476

Incident

Apr 20, 2012

Mileage

70,000 mi

ENGINE STALLS OUT 10 OR 15 SECONDS AFTER FILLING THE GAS TANK. USUALLY ON THE HIGHWAY YOU ARE TURNING ON TO. ITS BEEN DOING THIS FOR A COUPLE OF YEARS.

NHTSA ID

10819667

Incident

Jan 11, 2016

Mileage

160,000 mi

THE VEHICLE STALLS OUT AFTER FILLING AT THE GAS STATION. REPORTEDLY DUE TO AN ISSUE WITH THE CHECK VALVE AND REQUIRES THE ENTIRE FUEL TANK TO BE REPLACED.

NHTSA ID

10744730

Incident

May 25, 2013

Mileage

75,000 mi

TL* THE CONTACT OWNS A 2004 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE TEMPERATURE GAUGE ON THE INSTRUMENT PANEL STARTED GOING TO THE RED SIDE; INDICATING THAT THE VEHICLE WAS HAVING TROUBLE REGULATING THE ENGINE COOLING SYSTEM. THE CONTACT ALSO STATED THAT THERE WAS A STRONG ODOR OF FUEL ENTERING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND CARBON FILTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10731299

Incident

Jun 14, 2014

Mileage

100,000 mi

I WENT TO THE GAS STATION AND FILLED MY GAS TANK, NOT TOPPING IT OFF, AND AS SOON AS I TURNED OUT OF THE STATION ON A MAJOR ROAD THE VEHICLE STALLED AND ALMOST RESULTING IN AN ACCIDENT. AFTER A QUICK RESTART THE VAN RAN FINE AND I WAS ABLE TO DRIVE FROM NASHVILLE, TN TO ATLANTA, GA WITH NO PROBLEMS. BUT WHEN I FILLED UP AGAIN IN ATLANTA, RIGHT AFTER PULLING OUT OF THE GAS STATION THE VEHICLE STALLED AGAIN, IN THE MIDDLE OF A BUSY INTERSECTION. THIS PROBLEM IS WIDELY REPORTED ACROSS DODGE AND CHRYSLER VANS, WITH OVER 100 COMPLAINTS ON THIS WEBSITE. I'M HOPING THIS ISSUE WITH THE GAS TANK/SENSORS WILL BE ADDRESS. THANK YOU.

NHTSA ID

10722724

Incident

May 29, 2015

Mileage

115,000 mi

AFTER FUELING THE CHECK ENGINE LIGHT IS NOW ON AND INDICATES AN EMISSIONS LEAK WHICH CAUSES VAPORS TO NOW BUILD UP INSIDE THE VAN AFTER EVERY REFUELING. IF FILLED TO CAPACITY THE VEHICLE WILL ALSO STUTTER AND SOMETIMES COMPLETELY STALL SHORTLY AFTER FUELING.

NHTSA ID

10722552

Incident

May 1, 2015

Mileage

33,000 mi

EVERY TIME I FILL MY TANK (I DO NOT TOP OFF), WITHIN A FEW MINUTES OF LEAVING THE STATION, THE VAN DIES. IT NORMALLY RE-STARTS, BUT IT TAKES QUITE A LOT OF GAS PEDAL PUMPING. THIS IS DANGEROUS WHEN IT HAPPENS IN THE MIDDLE OF AN INTERSECTION. I HAD THE FUEL PUMP AND FILTER REPLACED AND THAT DID NOT SOLVE THE PROBLEM. NOW I UNDERSTAND THAT THE VALVE ON TOP OF THE TANK IS AT FAULT, BUT YOU HAVE TO REPLACE THE ENTIRE TANK. THIS IS A DESIGN FLAW AND NEEDS TO BE CORRECTED.

NHTSA ID

10716797

Incident

Aug 15, 2014

Mileage

109,000 mi

WHILE MAKING LEFT THE VEHICLE STALLED WHILE IN MOTION IN THE MIDDLE OF MAJOR INTERSECTION. AFTER A 20 OR SO SECONDS, THE VEHICLE ENGINE TURNED ON. ANOTHER INCIDENT, APPROXIMATELY A YEAR AGO, WHILE TRAVELING 60+ MILES ON MAJOR INTERSTATE, THE VEHICLE AGAIN SHUT DOWN WHILE IN MOTION. I HAD TO COAST THE VEHICLE, WITH LOSS OF POWER, TO MEDIAN ON THE INTERSTATE. AFTER ABOUT A MINUTE OR SO, THE VEHICLE TURNED ON. ALWAYS UPON FILLING THE GAS TANK, THE VEHICLE STALLS WHILE EXITING THE GAS STATION OR SHORTLY THEREAFTER. AFTER A MINUTE, THE VEHICLE IS ABLE TO TURN BACK ON. *TR

NHTSA ID

10713706

Incident

Apr 10, 2015

Mileage

108,000 mi

CAR SHUTS OFF AFTER FILLING THE GAS TANK. THIS HAS HAPPENED SEVERAL TIMES. ALWAYS ON THE ROAD AND IN TRAFFIC. *TR

NHTSA ID

10702901

Incident

Mar 30, 2015

Mileage

124,000 mi

AFTER FILLING MY '04 GRAND CARAVAN WITH FUEL AND ATTEMPTING TO LEAVE THE PUMP MY CARAVAN SHUTS OFF. THIS HAS BEEN ON AN ONGOING ISSUE FOR OVER 2 YEARS. AFTER SEVERAL REPAIR ATTEMPTS I WAS TOLD TODAY THAT THE VAPOR SEPARATOR VALVE LOCATED ON TOP OF THE GAS TANK IS FAULTY. A VALVE THAT DODGE DOES NOT MAKE AVAILABLE FOR REPAIR. THE ONLY "FIX" THAT IS OFFERED IS TO REPLACE THE ENTIRE TANK OF WHICH I WAS TOLD TODAY WOULD BE $1600. *TR

NHTSA ID

10683697

Incident

Jan 22, 2015

Mileage

150,000 mi

EVERY TIME I FILL UP THE VAN, AS SOON AS I PULL OUT OF THE GAS STATION IT WILL IDLE ROUGH, HESITATE, OR DIE ALL TOGETHER. I COULD HAVE 1/2 TANK AND ADD MAYBE 5 GAL OF GAS AND IT WILL DO THE SAME THING. I SAW ONLINE THAT I AM NOT THE ONLY ONE THAT HAD THIS ISSUE. IT RANGES FOR DIFFERENT YEARS AND COME TO FIND OUR IT HAS TO DO WITH A VALVE ABOVE THE TANK AND CANT BE REPLACED SINGLY BUT THE WHOLE TANK FOR $1600 PLUS LABOR. THIS IS A SAFETY ISSUE BECAUSE THIS THING HAS HAPPEN IN THE MIDDLE OF AN INTERSECTION WHILE TURNING. I CALLED MELLOY DODGE HERE IN ALBUQUERQUE NM AND THEY RIGHT SHOT ME DOWN ABOUT AS QUICK IT TOOK TO DIAL THE PHONE NUMBER. *TR

NHTSA ID

10668094

Incident

Nov 15, 2012

Mileage

80,000 mi

THE FUEL PUMP HAS HAIR LINE FRACTURES IN MULTIPLE PLACES OF FUEL PUMP IN AND IS LEAKING GAS LOOKS LIKE ITS BEEN THERE FOR AWHILE BUT I JUST NOTICED IT IN JULY IV BEEN READING UP ON IT AND THERE'S. BEEN ALOT OF PEOPLE WITH THE SAME PROBLEM WITH 04 DODGE GRANDCARE VANS SXT AND OTHERS MODELS ALSO...... THANKS. *TR

NHTSA ID

10667398

Incident

Jul 10, 2014

AFTER TAKING ON GAS, ENGINE WILL SOMETIMES STUMBLE AND MOST OF THE TIME QUIT RUNNING. TRIED NOT OVER FILLING IT AND IT STILL WILL JUST DIE SOMETIME AFTER TAKING ON GAS. ON TWO OCCASIONS, IT DID THIS AFTER HITTING HIGHWAY SPEEDS. IT WOULD SUDDENLY LOSE POWER AND YOU HAD TO PULL OFF THE ROAD. IT WOULD NORMALLY START BACK UP AND HAVE NO MORE PROBLEMS UNTIL NEXT FILL UP. BECAUSE OF THIS, WE DON'T FILL UP AND HIT THE ROAD. WE DRIVE AROUND BEFORE DRIVING AT HIGHWAY SPEEDS. ONCE, IT DIED IN FRONT OF SEVERAL CARS AND A BIG TRUCK HAD TO BRAKE HARD AND SWERVE OFF THE ROAD. SO FAR, THERE HAS NOT BEEN ANY KNOWN ACCIDENTS BUT FEEL IT IS A MATTER OF TIME BEFORE SOMEONE GETS HURT. THE MECHANIC SAID IT WAS SOMETHING WRONG WITH A VALVE IN GAS TANK AND THAT YOU CAN'T BUY THE PART. WE DON'T LOAN OUR VAN TO THE KIDS ANYMORE SINCE MY OLDEST DAUGHTER ALMOST CAUSED A WRECK AND ALMOST GOT HIT WHEN THE VAN LOST POWER. *TR

NHTSA ID

10638411

Incident

Oct 12, 2011

Mileage

75,000 mi

FOR THE PAST FOUR YEARS OR SO, ALMOST EVERY TIME AFTER FILLING UP THE GAS TANK, THE 2004 DODGE GRAND CARAVAN ANNIVERSARY EDITION STALLS. I CAN BE JUST PULLING AWAY FROM THE PUMP WHEN IT HAPPENS, OR STOPPED AT A STOP LIGHT WITHIN A FEW MINUTES FROM LEAVING THE GAS STATION. YOU CAN FEEL THE CAR 'JUMP' LIKE SOMEONE IS PRESSING THE GAS PEDAL QUICKLY AND IT JERKS THE VAN A BIT FORWARD. THEN IT STALLS. IT TAKES A FEW TURNS OF THE KEY AND PRESSING THE GAS PEDAL VERY QUICKLY AND FORCEFULLY TO GET IT STARTED AGAIN. I HAVE GOTTEN INTO THE HABIT OF DRIVING THE VAN AROUND A PARKING LOT FOR A FEW MINUTES UNTIL IT FEELS BACK TO NORMAL BEFORE PULLING OUT INTO TRAFFIC, AS I'M CONCERNED IT WILL STALL OUT IN THE MIDDLE OF TRAFFIC. THIS ONLY HAPPENS RIGHT AFTER FILLING UP THE GAS TANK. IT CONCERNS ME NOW MORE THAN EVER SINCE MY SON IS LEARNING HOW TO DRIVE AND I WANT HIM TO BE SAFE. *TR

NHTSA ID

10637669

Incident

Jun 1, 2010

Mileage

100,000 mi

ENGINE STARTED MISSING, VIBRATIONS FROM ENGINE. DIAGNOSIS ELECTRICAL FAULT. WIRING HARNESS BRITTLE FORM HARNESS BEING PLACED ON, OVER AND NEXT, SNAKED AROUND EXHAUST MANIFOLD, CAUSING PREMATURE WIRING FAILURE. FUEL INJECTOR WIRING HARNESS UNSHIELDED IN SIDE OF INTAKE MANIFOLD / PLENUM. WIRING HARNESS POORLY SHIELDED. THIS IS A DELIBERATE, INTENTIONAL DESIGN / ENGINEERING TO SNAKE WIRING HARNESS AROUND EXHAUST MANIFOLD. CAUSING WIRING HARNESS FAILURE. USING SUB-STANDARD WIRING COMPONENTS AND NOT USING SHIELDING TO CAUSE PRE-MATURE FAILURE. INSTALLING PCM (COMPUTER) IN WHEEL WELL FOR PRE-MATURE FAILURE EXPOSED TO SALT, ROAD DEBRIS, WATER, ETC. PCM INSTALLED IN OPEN AREA OF VEHICLE PRONE TO FAILURE. CONSEQUENTIAL SAFETY ISSUES. *TR

NHTSA ID

10633124

Incident

Sep 10, 2014

Mileage

176,000 mi

TL* THE CONTACT OWNS A 2004 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD STALL IMMEDIATELY AFTER REFUELING. THE CONTACT INDICATED THAT THE FAILURE HAD OCCURRED ON MULTIPLE OCCASIONS AND IN SOME INSTANCES THE VEHICLE WOULD STALL UP TO TWO TIMES BEFORE OPERATING AS NORMAL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 115,000.

NHTSA ID

10632542

Incident

Sep 2, 2010

Mileage

115,000 mi

NOTICED FUEL SMELL AND VEHICLE STALLING OR HESITATING AFTER FUELING, FOUND FUEL LEAK COMING FROM VERY SMALL CRACKS ON FUEL PUMP HOUSING TOP LOCATED ON THE PASSENGER SIDE OF THE VAN CLOSE TO THE EXHAUST SYSTEM. *TR

NHTSA ID

10593944

Incident

Aug 15, 2013

Mileage

180,000 mi

BEGINNING AROUND AUGUST 2012, MY 2004 DODGE GRAND CARAVAN ANNIVERSARY EDITION BEGAN TO SPUTTER AND STALL IF I EVER FILLED THE GAS TANK COMPLETELY. IF I DID NOT CONTINUE TO FEED GAS TO THE ENGINE, THE ENGINE WOULD STALL. AT STOPLIGHTS I WOULD NEED TO PUT THE CAR IN PARK AND REV THE GAS AND THEN SIT IN PARK UNTIL I WAS ABLE TO MOVE. THIS WOULD CONTINUE FOR APPROX 2-3 MILES. IN SUMMER 2013 IT BEGAN HAPPENING EVEN IF THE CAR WAS NOT FILLED TO CAPACITY. REPAIR SHOPS TELL ME IT'S THE TYPE OF GAS OR THERE IS WATER IN THE GAS LINE, BUT MY RESEARCH TELLS ME THIS IS A KNOWN CARAVAN ISSUE. MY REQUESTS FOR REPAIR INVESTIGATIONS ARE NOT TAKEN SERIOUSLY. SO MY SOLUTION IS TO NEVER FILL THE CAR BEYOND 3/4 TANK - SUPER INCONVENIENT. AS A RESULT, THE SPUTTERING DOES NOT HAPPEN AS MUCH ANY MORE, BUT THE SITUATION IS DANGEROUS AND SCARY. I AM JUST WAITING FOR THE ENGINE TO FAIL IN THE MIDDLE OF A BUSY ROAD SIMPLY BECAUSE I'VE GOTTEN FUEL. *TR

NHTSA ID

10549841

Incident

Aug 1, 2012

Mileage

100,000 mi

MY VAN LEFT SMALL FUEL MARKS IN DRIVEWAY, I INVESTIGATED IT PHYSICALLY AND FOUND FUEL TO BE LEAKING BY FUEL PUMP HOUSING NEAR A FUEL LINE, I ASSUMED IT WAS LEAKING FROM THE O-RINGS ON QUICK DISCONNECT LINE. I REPLACED O-RINGS AND THE PROBLEM STILL EXISTS. I GOOGLED THE ISSUE AND TO MY SURPRISE THERE ARE MANY SIMILAR ISSUES, PEOPLE EXPLAINING HOW THEIR VEHICLES WHERE LEAKING IN THE SAME LOCATION. AFTER BROWSING I FOUND A WEBSITE WHERE THERE WAS A PICTURE SHOWING FRACTURES ON THE HOUSING NEAR THE FUEL LINE THAT I HAD WORKED ON. SURE ENOUGH I RECHECKED MY VEHICLE AND THERE WERE THE FRACTURES. LEAKING FUEL. I JUST WANTED TO POST THIS ON THIS WEBSITE TO INFORM OTHER OWNERS, THAT IF THEY SMELL FUEL FROM THEIR VAN, THEY SHOULD GET THIS ISSUE CHECKED ASAP. THIS IS A REAL HAZARD, AND COULD BE REALLY DANGEROUS. *TR

NHTSA ID

10547850

Incident

Oct 1, 2013

Mileage

155,000 mi

THIS INCIDENT OCCURS EVERY TIME I FILL UP WITH FUEL. IT BEGAN AT APPROXIMATELY 35,000 MILES AND CONTINUES UNTIL THIS DAY AT ABOUT 116,000 MILES. INCIDENT DESCRIPTION: I ENTER THE GAS STATION. I FILL UP WITH FUEL UNTIL THE PUMP STOPS, NOT A "TOP-OFF". I START THE IGNITION AND BEGIN TO DRIVE AWAY. THE ENGINE STUTTERS AND SOMETIMES STALLS COMPLETELY. AFTER A SHORT DISTANCE, 3 MILES OR SO, IT RUNS NORMALLY. RECENTLY AFTER MY KNEE SURGERY, MY WIFE WAS DRIVING AND PULLED OUT INTO TRAFFIC, LEFT HAND TURN, AFTER A REFUEL. WE WERE TRYING HIGH-TEST ETHANOL FREE GASOLINE. WELL SHE MADE IT INTO THE CENTER TURNING LANE AND WAITED HER TURN. WHEN AN OPENING ARRIVED SHE PRESSED THE ACCELERATOR AND THE VAN STARTED AND FAILED COMPLETELY, LEAVING US HALF-WAY IN THE LANE FOR ONCOMING TRAFFIC. THANKFULLY THE ONCOMING TRAFFIC SLOWED AS THEY BLEW THEIR HORNS AND SHE WAS ABLE TO RESTART THE VAN AND BEGIN TO DRIVE. THIS WAS A MOST MISERABLE EXPERIENCE ESPECIALLY SINCE WE HAD ALL THREE OF OUR SMALL CHILDREN IN THE VAN WITH US. SOMETHING REALLY NEEDS TO BE DONE TO CORRECT THIS ONGOING AND DANGEROUS ISSUE. *TR

NHTSA ID

10520549

Incident

Sep 7, 2007

THE 3.8L ENGINE STALLS AFTER ALMOST EVERY FUEL FILL-UP AND BEGAN IN EARLY 2010. WITHIN 1-2 MILES AFTER A FUEL UP, THE VEHICLE WILL BUCK AND SPUTTER AND OFTEN TURN OFF COMPLETELY. IT GETS BETTER AFTER 3-5 MILES. IT APPARENTLY IS A KNOWN ISSUE WITH MANY DODGE OWNERS, NOT JUST MINIVANS. I HAD TWO 2006 DODGE CHARGERS (R/T AND SRT8) THAT BOTH DID THE SAME THING. I NO LONGER OWN THE CHARGERS BUT STILL HAVE THE 2004 CARAVAN. THIS A DANGEROUS AND UNPREDICTABLE ISSUE THAT HAS SOMETHING TO DO WITH THE TANK MOUNTED VAPOR SEPARATION VALVE AND THE VAPOR RETURN SYSTEM. THE VEHICLE IS NOT "TOPPED OFF" WHEN FUELING WHICH HAS BEEN KNOWN TO CREATE THE ISSUE. THANKS. *TR

NHTSA ID

10513147

Incident

May 7, 2010

Mileage

100,000 mi

ENGINE STALLS WITHIN A MILE OR SO AFTER FILLING FUEL TANK. ISSUE BEGAN AT 31,000 MILES AND VEHICLE CURRENTLY HAS 35,280 MILES. HAS OCCURRED EVERY TIME FUEL TANK IS FILLED SINCE THE FIRST INCIDENT AT 31,000 MILES. *TR

NHTSA ID

10504260

Incident

Oct 1, 2012

Mileage

31,000 mi